Daewoo DG-M12D1P-SA User manual

S/M No. : DGM12D1002
Service Manual
MODEL:
DG-M12D1P-SA
DG-M22D1P-SA
DG-M12D1P-HA
DG-M22D1P-HA
DG-M22D1S-CA
DG-M22D1S-HA
DG-M22D1D-HA/E
DG-M22D1D-HA/I
DG-M22D1D-HA/B
DG-M12D1D-HA/E
DG-M12D1D-HA/I
DG-M12D1D-HA/B
HDMI MODEL:
DG-M22D2D-AA
DG-M23D2D-FB
DG-M23D2D-FB/I
DG-M23D2D-PB/I
DG-M22D2P-AR/F
DG-M22D2D-AQ/Q
DG-M23D2D-AQ/Q
DG-M13D2D-FQ/Q
DG-M23D2D-FQ/Q
DG-M34D2D-FB/I
DG-M33D2S-FA/W
DG-M33D2D-FB/I
Oct. 2006
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` Ø mac001 1200DPI 80LPI

1
SPECIFICATIONS..............................................................................................................................................2
SCHEMATIC DIAGRAM ..................................................................................................................................11
TROUBLE SHOOTING....................................................................................................................................29
OPTION TABLE ...............................................................................................................................................37
PCB CIRCUIT BOARD ....................................................................................................................................38
DISASSEMBLY................................................................................................................................................49
ELECTRICAL PARTSLIST ..............................................................................................................................57
CONTENTS
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` 1 mac001 1200DPI 80LPI

2
SPECIFICATIONS
SECTION 1st Model REMARK
MODEL For Europe
DAEWOO Model DG-M21D1D-HB
Description DVD Recorder + HDD
Target Area For Europe
Mass Production 05.11
GENERAL
Power Plug 3-Pin type ( For EUROPE)
Set Size (WxHxD)
- wihtout leg 435 x 55 x 343 mm
- with leg 435 x 60 x 343 mm
Safety Regulation CE
Set Weight (Net/Gross) 4.3Kg / 5.6Kg
Power Print on Rear Panel 200~240V, 50/60Hz
Operation temperature 35 ¡C
Power Consumption
- Maximum 57 W
- Operate 40 W
- Stand-By(power off) 4.5 W
Power Failure Compensation 1 Min.
Stuffing Quantity
- 20 ft 879 EA
- 40 ft 1839 EA
- 40 ft (HQ) 2069 EA
DVD MODULE Spec.
Manufactruer of FEM (Front End Module) Lite On / Daewoo
Interface ATA (IDE bus) Interface
Opitical P/U SANYO & SONY
FE Chip MT1818, MT1816
BE chip type Numbers DMN-8652
HDD Spec.
Drive interface ATA (IDE bus) Interface
Capacity 160 GB (1platter) - 80, 160, 250G
RPM 7200 RPM
Start time 8 sec ( 15 sec max )
Stop time 12 sec ( 20 sec max )
PLAYABLE DISC TYPE
DVD Type :
DVD-ROM / DVD+R / DVD+RW / DVD-R / DVD-RW / DVD-RAM Yes to All (Except DVD-RAM) - DVD+R/-R After finalize
- DVD-R/-RW (Video Format)
CD Type : CD-ROM / CD-R / CD-RW Yes to All
Video Format : DVD / VCD / SVCD / MPEG 4 /
JPEG / Kodak picture CD / DviX Yes to All (Except MPEG4, Kodak Picture CD) - DviX : For Europe Only
Audio Format : DVD-Audio / SACD / HDCD /
CDDA / MP3 / WMA / MP3 Pro CDDA / MP3 - WMA is Hidden
Disc size 8cm/12cm
Regional Code 2
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` 2 mac001 1200DPI 80LPI

3
SPECIFICATIONS
SECTION 1st Model REMARK
MODEL For Europe
PLAYBACK FEATURES
Disc access time ( play ready time from drawer close press) Less than 20 sec.
Fast Scan Motion (FWD / REV) ; DVD (ROM/-VIDEO/-VR) (O/O) : x2, x4, x8, x16, x32
Fast Scan Motion (FWD / REV) ; HDD (With Time Shifting) (O/O) : x2, x4, x8, x16, x32(except REV x2)
Fast Scan Motion (FWD / REV) ; VCD (O/O) : x2, x4, x8, x16, x32
Fast Scan Motion (FWD / REV) ; CDDA,MP3 (O/O) : x2
Fast Scan Motion (FWD / REV) ; DivX (O/O) : x2, x4, x8
Slow Motion (FWD / REV) ; DVD (ROM/-VIDEO/-VR) (O/O) : x1/2, x1/4, x 1/8
Slow Motion (FWD / REV) ; HDD (O/O) : x1/2, x1/4, x 1/8
Slow Motion (FWD / REV) ; VCD (O/X) : x1/2, x1/4, x 1/8
Slow Motion (FWD / REV) ; CDDA,MP3 (X/X)
Slow Motion (FWD / REV) ; DivX (X/X)
Next, Previous O
Resume play O (DVD Only)
Frame-by-Frame Playback (FWD / REV) (O/X) : DVD, HDD, VCD DVD-R/RW After finalized,
DVD Video format HDD OK
Search Title / Chapter / Track / Time DVD : Title & Chapter
HDD : Title & Chapter
VCD : Track CDDA/MP3 : X
Zoom (In Playback or Pause state) O (x2, x4)
Subtitle O (DVD-ROM Only)
Multi-angle playback O (DVD-ROM Only) - Only in case that DVD-Video disk
supports multi-angle scenes
Random Playback X
Program Playback X
Repeat DVD : Chapter-> Title -> Disc->
Shuffle ->Scan ->Off
HDD : Chapter -> Title -> Disc -> Off
VCD : Track-> Disc -> Off
CDDA/MP3 : Track -> All -> Off
Repeat A-B DVD,HDD,VCD
Yes DVD X
Clear Play X
Auto Play X
x2 Audio X
Combination Playback : JPG + MP3 Only O
SYSTEM
Language 15 languages - >English, German, French,
E/G/F/S/I/D/Nr/Sw/Pr/H/R/Po/Da/Fi/Cz Spanish, Italian, Dutch,
Norwegian,Swedish, Portuguese,
Hungarian, Russian,Polish, Danish,
Finnish, Czech
intial Language ENGLISH
On-screen display on/off-user selectable X
Disk Type displayed OSD / Front Panel Display O/X
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` 3 mac001 1200DPI 80LPI

SECTION 1st Model REMARK
MODEL For Europe
SYSTEM
Company LOGO DAEWOO
Screen Saver X
PBC for VCD 2.0 or SVCD O
Parental lock O
Child Lock O (Pushing PWR Key 5sec.)
TV Aspect Ratio (16x9, Pan Scan, letterbox) O
Upgradeable Flash Memory Capability by CD O
Video Output Format PAL
Information On HDD Size & Available Space O
Erase all program on HDD O
Auto Chapter Making (5Min, 10Min, 15Min, Off) O
Closed Caption X
Menu Language Change O
Subtitle Laguage Select O
Audio Language Select O
Network DVD (Digital 5) X
Up Scalar Analog Video Out (720p / 1080i) X
HDMI Option
AV LINK X
CM Skip X
Time Shift Mode O (Buffering 60Min.)
PIP X
DV Camcorder Control X
File Management & Editing
Rename O
Erase Disc O - Erase all titles on the disc
Overwrite disc O - Record a new title to
beginning of the title list
Lock O
Protect O
Edit
- Append X
- Split O (Title / Chapter)
- Delet O (Title / Chapter)
- Delet All O (Chapter)
Menu Display
Thumbnail (Title) O
Thumbnail Change O
Manual Chapter Making / Delete Chapter Mark X/X
Chapter Hide / Unhide O
Edit Title Name O
4
SPECIFICATIONS
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` 4 mac001 1200DPI 80LPI

5
SPECIFICATIONS
SECTION 1st Model REMARK
MODEL For Europe
RECORDING
Dual Format X
Video Recording Format DVD + VR Format (Dual Media)
Video Recording Compress Format MPEG II
DVD Type DVD+R / DVD+RW / DVD-R / DVD-RW - DVD-R/-RW Dual Media
Format (+VR Format)
Disk Recording Rate (Mbps) & Recording Hour with 4.7 GB HQ : 9.5 Mbps, 60min
SP : 5.1 Mbps, 120min
EP : 2.5 Mbps, 240min
SLP : 1.7 Mbps, 360min
HDD Recording Capacity (160GB) HQ : 9.5 Mbps, 32Hr
SP : 5.1 Mbps, 66Hr
EP : 2.5 Mbps, 128Hr
SLP : 1.7 Mbps, 195Hr
DVD data full
- Record (Include T.REC, & OTR) Stop - Warning message such as
DISC FULL
HDD data full
- Record (Include T.REC, & OTR) Stop - Manual Space Management
(Default)
- Auto Space Management
(oldest title erase)
Initialize DVD+R / DVD+RW / DVD-R / DVD-RW
Finalize DVD+R / DVD-R / DVD-RW
Time Shifting REC O
HDD Recording and DVD Playback O
DVD Recording and HDD Playback O
REC Bit Rate Selection O - By GUI & RCU key
Transrating DVD<->HDD ( REC Speed ) X
HDD <->DVD copy Disc Writing speed O - X 2.4
HDD <->DVD copy O ( MP3, JPG, JPEG, DivX)
TIMER
Date Recognized Period 2005~2104
Number of Timer Recording 8 Events / 1 Year
Clock display method 24 Hour
Manual Clock Setting O
Auto Clock Setting O
Timer Recording System
- General O
- ShowView (VideoPlus+) O
- VPS / PDC O
- EPG X
One Touch Recording O
- Recording Time Display Method Recording Hours (Unit of 15Min) HDD ; Max (10 Hours / 15Min in any Mode)
Once Recording O
Daily Recording O
Weekly Recording O
Weekend Recording O
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` 5 mac001 1200DPI 80LPI

6
SPECIFICATIONS
SECTION 1st Model REMARK
MODEL For Europe
TIMER
Timer Recording Contents Display O
Method to Timer Recording O Auto Start when Power-
OffWarning&Selection when
Power-ON
Timer Recording Start Timing On Time - Set turns on eariler than
Recording time
Priority on Overlap Timer Recording X - Conflict message will show
up on TV
Broadcasting Tuner
Broadcasting System PAL-B/G, PAL-I/I, SECAM-L, DK
Channel Selection Method Programmable F/S
Band
- PAL-B/G,I/I V-L, V-H, UHF
- PAL/SECAM-L V-L/L , V-H, UHF
Total Channel Number
- PAL BG 116 CH( CH 02-69, 74-80, CC 01-41)
- PAL I/I 116 CH( CH 01-13, 21-69, CC 01-54)
- PAL D/K 119 CH( CH01-12, 21-69, CC 01-58)
- SECAM L 99 CH( CH 02-10, 21-69, CC 01-41)
Position Memory Number 99CH
Auto Channel Setting
- Auto Search & Memory O
- Auto Channel Sorting Option License (Royalty)
- Auto Station Name Display O
Manual Channel Setting
- CH Direct Input O
- Manual Search & Memory O
- Manual Channel Clear O
- Manual Channel Align O
Manual Fine Tuning
- Memory Available O
- E2PROM O
RF Modulation Out X - 21 pin Scart Cable Accessory
VIDEO <PAL/SECAM>
Horizontal Resolution ( line input ) HQ/SP : 500 Lines (DVD+R/RW)
EP/SLP : 250 Lines (DVD+R/RW)
<PAL/SECAM>
Screen size(MPEG encoder) HQ/SP: 720x576 (DVD+R/RW)
LP/EP : 352x576 (DVD+R/RW)
SLP : 352x288 (DVD+R/RW)
Video DAC 8bit
PAL
Progressive Scanning O - 576p By Setup menu & RCU key
Component / RGB Select O (OSD)
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` 6 mac001 1200DPI 80LPI

7
SECTION 1st Model REMARK
MODEL For Europe
AUDIO
Audio Recording Format MPEG I Layer II
Sampling Rate 48 KHz
Audio ADC/DAC 24bit
S/N Ratio ( line input ) 65 dB weighted
Dynamic range ( line input ) 75 dB
Digital output DTS, AC3, MPEG2
Audio Digital-to-analog converter 96kHz/24bit
Dolby Digital Down Mix (5.1ch to LtRt out) O
Dolby Digital Passthrough O
DTS Digital Passthrough O
MPEG-2 Audio Passthrough O
Dolby Digital 5.1-Ch decoding O
DTS Digital 5.1-Ch decoding X
Open MP3 Compatible (pre recorded MP3 Discs) O
AC-3/PCM data Conversion O - Down Mixing
3D Surround O
Dynamic range control O
Front Panel
Front Panel Key 11 KeyOpen/Close, Play, Stop,
REC, NEXT, PREV , DVD/HDD,
Menu, Standby/ON, PR+ , PR-
LED Indicator X
Front A/V jacks 2EA FOR AUDIO (R/L) 1EA FOR VIDEO
IEEE 1394 DV Input Option
S-VIDEO Input O
USB Input Option
Memory Card Slot X
PCMCIA X
Front Panel DISPLAY
Device LED Array
Display Size 62(W) x 18(H) mm
Display Color RED / YELLOW
Language English
Clock / Counter Change
- On DVD Out Clock
- On DVD In Clock
Clock Display Method 24 Hour
Counter Display Method Real Time
Dimmer at Power Off O
Rear Panel
Analog Audio In (L/R RCA Jack) X
Analog Audio Out (L/R RCA Jack) X
S-video Out 1 EA
Composite Video In (Yellow RCA Jack) X
SPECIFICATIONS
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` 7 mac001 1200DPI 80LPI

SECTION 1st Model REMARK
MODEL For Europe
Rear Panel
Composite Video Out (Yellow RCA Jack) X
Component Out (Y/Pb/Pr RCA Jack) 1 EA
Component Pair Analog Audio Out (L/R RCA Jack) 1 EA
EURO AV (SCART 1) : Composite / RGB Switchable O
EURO AV (SCART 2) : Decoder O
DVI X
HDMI Option
Digital Audio In / Out Output Only
- Coaxial O
- Optical O
Power cord Type Polarized
- Cord Holder O
Spec & Serial Number Label O (DEC s spec)
Antenna Jack Type F type : 1 Pair
- Antenna Jack Layout In : Up , Out : Down
REMOTE CONTROL
Tool VR-FA3
Multi-brand TV Control X
Code type DAEWOO - Mitsubishi format
IR (Infra-Red) Response O
Back-lit remote X
Joy Stick X
Jog / Shuttle on Remote X
Accessories
RMC O
Batteris O
Bundle Disc X
Power Cord X
RF cable O
Composite A/V Cable X
Component Video Cable X
S-video cable (4 pin mini DIN) - 6 X
Scart Cable O
Coaxial, Optical Cable X
IB/Safety Tips O
IB, Number of Books / Language TBD
IB, Color / Size B,W / B5
Safety Sheet / Product Registration Card TBD
POP Material X
Advertisement Material O
Sensormatic Tag TBD
DivX Spec.
Playable format
Market Region
Support DRM stream(DRM ID) Playback DRM streams (DRM ID)
Bit rate Upto 4Mbps
8
SPECIFICATIONS
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` 8 mac001 1200DPI 80LPI

9
A file encod
available.
XVID forma
option is no
SECTION 1st Model REMARK
MODEL For Europe
Playable format
Market Region
Support DRM stream(DRM ID) Playback DRM streams (DRM ID)
Bit rate Upto 4Mbps
Frame / sec 30,24, 12, 8 and 25 frames/s
Playable Codec Format DivX5.1, DivX5.05, DivX5.02, option is not available.
DivX4.1.2,DivX3.11, Dr.Divx1.02, XVID format encoded with GMC
MPEG4 SP, MPEG4 ASP option is not avaiable.
Playable Audio Format MP3, MPEG2 Audio, PCM, AC-3,
AAC, DTS, Ogg
Playable DivX File .avi, .divx
File System ISO9660,UDF
Sub title
Language support All Occidental languages : Refer to setup menu
Eng/Fre/Spa/Ger/Ita/Dut
File type (SMI, TXT, SUB, SRT, PAB, ASS, SSA) MicroDVD.sub, SubViewer.sub,SAMI.smi File over 128kB is not
available (LSI spec)
Selection of subtitle (Auto/Manual) O/O (on Application level) Auto Subtitle On, if the same
titled subtitle file is in the same
folder with DiVX file.
Color of text White only
Video
Transparency on sub title area O
Max resolution (frame rate) 720X480(NTSC) and 720X576(PAL)
Playback function
Time Search O Display menu during playback,
excpet a file without time
information.
Change the text size X
Transparency on sub title area X LSI : black back/white font
Repeat O
A-B Repeat X
FF / FR O / O (2, 4, 8, 16)
SLOW FW / BW X / X
STEP FW / BW X / X
File Browser
Program play X
Type of browser Type of browser Folder and file names
Display full name of file O (32 characters/ line) If title is too long, title name will
be shrunk to distinguish title
file to asubtitle file.
Popup listing on playing X
Preview on browser X
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` 9 mac001 1200DPI 80LPI

10
SPECIFICATIONS
SECTION 1st Model REMARK
MODEL For EuropeKey Action
KEY ACTION
Numeric key on file browser X LSI : Act just on STOP
Numeric key on playing X LSI : use for Time Search
Display key on file browser X
Display key on Playing O
Display information O Current track / total track
O Audio Mode(Left,Right,Stereo)
O Internal Audio ( current / total )
O Internal Subtitle ( current / total )
O External Subtitle Name, Time
Search(Present time display)
Next Key on playing
Single file Display prohibit mark
Last file Display prohibit mark
Multi file Go to next file
Prev Key on playing
Single file Display prohibit mark
First file Display prohibit mark
Multi file Go to previous file
Next /Prev key on file browser Go to Next/Prev page.
Subtitle key in Playing Change Subtitle Onlyforinternalsubtitleisavailable.
Subtitle key on File Browser No Prohibition Mark
Audio Key in playing Change Audio
Others
Repeat Key Change Repeat Mode Repeat A-B is not available
Search Key O
Zoom X
Bookmark X
Out of CoDec support Guide message
Over spec. of resolution Guide message
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:15 AM ˘ ` 10 mac001 1200DPI 80LPI

11
SCHEMATIC DIAGRAM
A
A
B
B
C
C
D
D
E
E
4 4
3 3
2 2
1 1
LSI 8652
MSP
R/L
AUDIO DAC
AUDIO IN SCART1
VFD DRIVER
IIC
AUDIO FROM FRONT
IIS
IIC
ISP
MM1443
S-Video TO JACK
CCIR656 VCLK
COMPOSITE
OUT TO
CANAL
MM1443
R/L
VIDEO
SWITCH
AND
BUFFER
RESET
VIDEO IN FROM FRONT S-Video
PSCAN
COMPONENT OUT
DVD RECORDER
LOADER ATAPI
1
BUFFER
LC74793
DECODER
IIC
RESET
VIDEO IN FROM TUNER
MPEG2
IIS
MUX
IIC
IC CANAL+
RESET
SAA7115
FLASH 32M BYTE
CCIR656 VCLK
IIS
IC CANAL+
DATA
VIDEO IN FROM SCART1
MSP3417
RGB OUT TO SCART
CCIR656[7..0]
COMPOSITE
OUT TO
CANAL
TSB41AB1
RGB OUT TO SCART
VIDEO IN FROM SCART2
VFD/KEY
PSCAN COMPONENT OUT
VPS PDC
ATAPI
ADR/CTL
M3777
AUDIO ADC
DDRAM(256M BIT)
IIS
IIC
MASTER
TUNER
OPTION
VIDEO SWITCH
VIDEO
IIC
LA73053
VIDEO FROM FRONT
ADR/CTL
IIC
SLAVE
R/L
AUDIO
RESET
AUDIO OUT TO
MM1443
CCIR656[7..0]
DATA
CODEC
IIC
MICOM
ISP
LPF SWITCH
DV 1394 INPUT
S-Video TO JACK
REMOCON
RECEIVER
ATAPI
HDD ATAPI2
RESET
HDMI
HDMI
CS 5340
CS4344
VIDEO BLOCK DIAGRAM
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:16 AM ˘ ` A mac001 1200DPI 80LPI

12
SCHEMATIC DIAGRAM
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:16 AM ˘ ` C mac001 1200DPI 80LPI

13
SCHEMATIC DIAGRAM
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:16 AM ˘ ` E mac001 1200DPI 80LPI

14
SCHEMATIC DIAGRAM
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:16 AM ˘ ` G mac001 1200DPI 80LPI

15
SCHEMATIC DIAGRAM
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:16 AM ˘ ` I mac001 1200DPI 80LPI

16
SCHEMATIC DIAGRAM
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:16 AM ˘ ` K mac001 1200DPI 80LPI

17
SCHEMATIC DIAGRAM
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:16 AM ˘ ` M mac001 1200DPI 80LPI

18
SCHEMATIC DIAGRAM
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:17 AM ˘ ` O mac001 1200DPI 80LPI

19
SCHEMATIC DIAGRAM
DG-M21D1D-HA HDMI_SVC 2006.10.13 11:17 AM ˘ ` Q mac001 1200DPI 80LPI