dellonda DG104 User manual

Model No. DG104
Thank you for purchasing a Dellonda product. Manufactured to a high standard, this product will,
if used according to these instructions, and properly maintained, give you years of trouble free performance.
www.dellonda.co.uk
Dellonda Table Top Gas Powered Pizza Oven, Supplied with
Regulator, Hose & Cover
DG104 Issue:2 13/04/2021

2
Important Information
Please read these instructions carefully. Note the safe operational requirements, warnings & cautions. Use the product correctly and with care
for the purpose for which it is intended. Failure to do so may cause damage and/or personal injury and will invalidate the warranty. Keep these
instructions safe for future use.
Refer to
instruction
manual
Wear
Gloves
Warning:
Hot
Surface
ABOUT THE PRODUCT

keep an eye on your food without letting the heat out. Supplied with high quality, water resistant cover, Ø300mm pizza stone and regulator & hose
assembly for use with propane patio gas bottles.
SAFETY INSTRUCTIONS
• GENERAL SAFETY
• WARNING! The warnings, cautions and instructions in this manual cannot cover all possible conditions and situations that may occur. It must
be understood by the operator that common sense and caution are factors which cannot be built into this product, but must be applied by the
operator.
• WARNING
• WARNING
• WARNING! Accessible parts may be very hot. Keep young children and pets away. Take special care when children and elderly are present.
• WARNINGDO NOT operate any electrical appliances, check
for leaks as detailed in this manual. If odour persists, contact your Dellonda stockist.
• WARNING
• WARNING! The hood must always be open when lighting the burner.
• 
• Turn off the gas supply at the gas bottle after use.
• Use outdoors only, stand on a level surface, remember hot fat may drip out of the grease cup.
• Handle the hot items with the help of oven gloves.
• 
• Connect the regulator and hose onto the gas cylinder, close all the valves by turning the control knobs to the “OFF” (fully clockwise) position.
• Always do the gas leak check before you use the barbecue and after a cylinder change. Test the leakage on all the connections where gas passes
by.
• GAS LEAK CHECK Put soapy water on all the connections where the gas reaches. Open the gas cylinder valve and regulator. If bubbles are seen,
tighten the connection. If bubbles are still seen, close all valves, turn off the regulator and contact your Dellonda for help. Never use the pizza
oven with a leak.
• The gas cylinder can only be changed by a competent person.
• 
• Keep the gas supply hose away from any heated surfaces.
• Ensure the appliance has completely cooled before storing.
• Cylinders must be stored outdoors, upright and out of reach of children. Protect cylinder from high temperatures and replace the plastic port cap.
• This gas pizza oven is designed for outside use only.
• DO NOT use in high winds.
• DO NOT move the gas pizza oven whilst it is in operation.
• DO NOT operate if there is a gas leak.
• DO NOT
• DO NOT leave unattended, from being lit to fully cooled.
• DO NOT use this gas pizza oven in a garage or any enclosed area. Keep the surrounding area clear, at least 1.0m from any combustible materials
and 0.5m from a brick wall.
• DO NOT attempt any unauthorised interference of the main controls on this pizza oven, i.e. gas taps, injectors, valve etc.
• DO NOT attempt to use charcoal in this gas pizza oven.
• DO NOT position on a surface that may be damaged by hot fat or heat.
• DO NOT
• NEVER
• NEVER store a spare gas bottle or an empty/disconnected bottle near or under the pizza oven or near any other ignition or heat source.
• 
people in the vicinity of the area where the appliance is being used.
• NEVER use in any enclosed covered area.

3
CONTENTS
ASSEMBLY
• 
• 
• Then attach the cowl on top of the chimney, and attach the chimney assemb



NO Description Qty
1 Pizza stone 1
2 Pizza stone rack 1
3 Chimney cap 1
4 Chimney 1
5 Temperature gauge 1
6 Door glass 1
7 Door handle 1
8 Door 1
9 Base 1
10 Oven top 1
11 Grease cup 1
12 Control knob 1
13 Control knob bezel 1
14 Manifold 1
15 Burner 1
16 Flexible gas tube 1
17 Foot 4
DG10001 UK regulator & hose
(c/w knob) 37 mbar (not shown)
Ensure gas hose is fully engaged to stem
and the worm drive is fully
tightened.
Tap in Off position




CONNECTING GAS TO THE APPLIANCE
• Before connecting, please ensure there is no debris caught in the head of the gas cylinder, regulator, burner and burner parts.
• If the hose is replaced, it must be secured to the appliance and regulator connections.
• After connecting, GAS LEAKAGE CHECKING is a must. Please follow following method to check for gas leakage.
• Ensure the control valve is “OFF”.
• Connect the cylinder to the regulator, the regulator to hose and hose to the appliance, ensure the connections are secured then turn ON the gas.
• Brush the soapy water on the hose and all joints. If bubbles appear, it means there is leakage. You have to reconnect or replace the gas leaking
part or joint.
• 
• Turn OFF the gas at the cylinder after testing.
OPERATION
• 1. Open the front door and make sure the knob is on the OFF position.
• 2. Push down the knob and turn the knob anticlockwise fully to operate the piezo ignition if the burner does not light turn the knob to the off
position then repeat the process.
• 3. Adjust the heat by turning the knob to the High /Low position.
• OFF, turn the cylinder valve or regulator switch to the “OFF” position and then turn all of the control knobs on the barbecue
clockwise to the “OFF” position.
STORAGE
• When the appliance is not in use, storage of an appliance indoors is only permitted when the cylinder is disconnected and removed from the
appliance. When the appliance is not to be used for a period of time it should be stored in its original packaging and stored in a dry dust free
environment.
• Gas Cylinder
• The gas cylinder should not be dropped or handled roughly! If the appliance is not in use, the cylinder must be disconnected.
• Precaution need to be taken when changing the gas cylinder. This shall be carried out away from any source of ignition.
• Cylinders must be stored outdoors in an upright position and out of the reach of children. The cylinder must never be stored where temperatures
can reach over 50C. DO NOT
• THE APPLIANCE IS SUITABLE FOR USING WITH GAS CYLINDER 13KGS (HEIGHT 575MM) OR LESS.
REGULATOR AND HOSE
• The use of the wrong regulator or hose is unsafe; always check that you have the correct items before operating the oven.
• 
or damaged hose must be replaced. Ensure that the hose is not obstructed, kinked, or in contact with any part of the oven other than at its
connection. Change the hose when the national conditions require it and/or depending on it validity.
• The hose should not be twisted or kinked when attached to the regulator and outdoor gas oven.
• No part of the hose should touch any part of the appliance. So site the cylinder out to the left hand side of the appliance at the
permitted by the hose length.
Maintenance
• All cleaning and maintenance should be carried out when the appliance is cool and with the fuel supply turned OFF at the gas cylinder after each
time use.
• .




Environment Protection



liability is accepted for incorrect use of this product. Guarantee is 12 months from purchase date, proof of which is required for any claim.
Dellonda Limited
Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757575 suppor[email protected] www.dellonda.co.uk
• DO NOT mistake brown or black accumulation of grease, smoke for paint. Interiors of gas pizza ovens are not painted at the factory (and should
NEVER be painted). Apply a strong solution of detergent and water on insides of the pizza oven with a domestic scourer sponge. Carefully rinse
and allow to completely air dry.
• DO NOT apply a caustic grill/ oven cleaner to painted surfaces.
• DO NOT
• Plastic parts; wash with warm soapy water and wipe dry.
• Stainless steel surfaces; Stainless steel will get rusty if not maintained well. To maintain your pizza ovens high quality appearance, wash with
mild detergent and warm soapy water and wipe dry with a soft non-abrasive cloth after each use. Use food safe stainless steel protection liquid
on the surface to avoid rust.
• Pizza Stone rack Use a mild soapy water solution. Non-abrasive scouring power can be used on stubborn stains then rinse with water.
• PIZZA STONE (FIG.8):
• 1.DO NOT
• DO NOT place
frozen foods on a hot stone.
• 3. The stone is fragile and can break if bumped or dropped.
• 
after use. Please let it cool down completely before handling.
• 5. DO NOT try to cool the pizza stone with water when the pizza
stone is hot.
• 
stone with water, please dry the stone before use.
Cleaning the burner assembly
• Follow these instructions to clean
• 1. Turn gas off at control knobs and gas cylinder.
• 
• 
• 
• 5. Wire brush entire outer surface of burner to remove food residue
and dirt.
• 
• 
burner.
• 
• 
• 
• 

• To Clean Burner Tubes:
• DO NOT use a brass wire brush), run the brush through each burner tube and burner several
times.
• Wear eye protection: use an air hose to force air into the burner tube and out the air ports. Check each port to make sure air comes out each hole.
