Delta Dual 800 Groundwater Series User manual
INSTALLATION GUIDE
Delta Dual 800 Groundwater
Packaged Pumping Stations
www.deltamembranes.com
INNOVATION | MANUFACTURER | DESIGN | SOLUTION
THIS MANUAL SHOULD BE KEPT WITH
THE PUMP STATION OR THE HOMEOWNER
Contents
DMS_IG_V800G 0123Delta Dual 800 Groundwater Packaged Pumping Station
1.1 Delta Dual 800 Groundwater Series packaged pumping stations overview
1.2 Example installation
For illustration purposes only.
A B C D F
E
K
O
G H I J
M
L N
A
B
C
D
E Vent
F
G
H
I
J
K
L
M
N
O
1.5 Pump specications
Pump specication V3 V4 V6
1.3 Parts included
•
•
•
•
•
•
1.4 Optional extras
•
•
•
•
0 2 4 6 8 10 12 14 16 18
0
2
4
6
8
10
12
14
0 1 2 3 4 5
Head (m)
Flow rate m³/h
Flow rate l/s
V3
V4
V6
Delta V3
Delta V4
Delta V6
DMS_IG_V800G 0123Delta Dual 800 Groundwater Packaged Pumping Station
1.6 Chamber specications
CAPACITY
(litres)
DEPTH OF INLET
(mm)
600
325
850
200
Ø800
Ø900
355 895
1250
Discharge face
600
450
850
325
CAPACITY
(litres)
DEPTH OF INLET
(mm)
355 250 895
1500
Ø800
Ø900
Discharge face
600
575
850
450
1100
325
CAPACITY
(litres)
DEPTH OF INLET
(mm)
Ø800
Ø900
355 250 250 895
1750
Discharge face
800.1250
800.1250
800.1500
800.1500
800.1750
800.1750
Chamber specication
Positioning connections
Discharge only
Inlet location allowed
Cable ducts and vents only
No drilling allowed
INVERT LEVEL
600
545
450
Discharge face
Ø900
Ø800
355 250 250 250
2000
895
700 600
575 850
450 1100
325 1350
CAPACITY
(litres)
DEPTH OF INLET
(mm)
800.2000
800.2000
DMS_IG_V800G 0123Delta Dual 800 Groundwater Packaged Pumping Station
2.1 Discharge pipework and ttings
Product DMS Code Qty req.
Please scan this order form and email to [email protected]
2.2 Spare parts
Part Description DMS Code
A
C
D
E
F
G
Part Description DMS Code
I
J
L
A
B
H
C
D
E
I
B
J
P
K
P
L
O
C
D
E
F
E
G
C
DMS_IG_V800G 0123Delta Dual 800 Groundwater Packaged Pumping Station
< 300 mm
> 300 mm
Less than 300 mm below FFL
More than 300 mm below FFL
4.1 Installation guidelines
4.2 Pump station location
4.3 Installation within a reinforced concrete sump
A structural and waterproong engineer must be consulted when designing the waterproof
reinforced concrete sump and backll to ensure that it can withstand the anticipated pressures,
and that they are not transferred onto the chamber.
Chamber A (mm) B (mm) C (mm)
C
A
B
Recommended RC sump dimensions
DMS_IG_V800G 0123Delta Dual 800 Groundwater Packaged Pumping Station
4.4 Cable duct guidance
4.4.1 CONSTRUCTING THE CABLE DUCT
4.4.2 CABLE EXTENSIONS
4.5 Vent duct guidance
not required
Pull a draw cord through
the cable duct as it is being
constructed, ensuring the
cord’s loose end cannot
slip back into the duct.
Swept bends allow the cables to
be pulled through the cable duct.
4.6 Installation procedure
ENSURE A DRAW CORD IS PULLED THROUGH THE CABLE DUCT AS THE CABLE DUCT IS BUILT.
PLEASE REFER TO SECTION 4.4.
TO PREVENT THE CHAMBER FROM FLOATING UP WHEN THE RC SUMP IS BACKFILLED, THE
CHAMBER MUST BE BALLASTED WITH WATER AT THE SAME RATE AS BACKFILLING. THE LEVEL
DIFFERENCE BETWEEN THE WATER AND BACKFILL MUST NOT EXCEED 300 mm AT ANY TIME.
DMS_IG_V800G 0123 Delta Dual 800 Groundwater Packaged Pumping Station
THE BALLAST WATER INSIDE THE CHAMBER SHOULD NOT BE REMOVED UNTIL THE BACKFILL
HAS FULLY SET.
FAILURE TO REMOVE SAND, SILT, RUBBLE AND ALL OTHER DEBRIS FROM THE CHAMBER WILL
INVALIDATE THE WARRANTY ON THE PUMPS.
A QUALIFIED ELECTRICIAN MUST CARRY OUT ALL ELECTRICAL CONNECTIONS.
•
•
•
•
•
•
If you require further advice contact Delta Membranes on 01992523523 between 8am and 5pm, Monday to Friday or by
email at [email protected] before attempting to lift the product.
These instructions must be followed to prevent injury to operatives or damage to the product.
DO NOT USE CHAINS USE A SPREADER BAR
4-HOOK LIFTING SPREADER BAR SUITABLE
FOR THE WIDTHS OF THE LIFTING EYES
LIFTING
EYES
LIFTING
EYES
LIFTING
EYES
LIFTING
EYES
✗✓
DMS_IG_V800G 0123 Delta Dual 800 Groundwater Packaged Pumping Station
6.1 Wiring diagram with Delta HLA
A B C
BREAKER SPECIFICATION
Description Device type Rating
A
B
C
DMS_IG_V800G 0123Delta Dual 800 Groundwater Packaged Pumping Station
6.3 Wiring diagram with Delta UPS V4/6
A B C
BREAKER SPECIFICATION
Description Device type Rating
A
B
C
DMS_IG_V800G 0123Delta Dual 800 Groundwater Packaged Pumping Station
•
•
•
•
•
•
•
Table of contents
Other Delta Water Pump manuals
Popular Water Pump manuals by other brands
EINHELL
EINHELL HW 900 Niro operating instructions
KSB
KSB Amarex Installation & operating manual
Wayne
Wayne CDU980E installation manual
Siccom
Siccom mini FLOWATCH 1 EVO manual
Grundfos
Grundfos Unilift AP12 Installation and operating instructions
Wilden
Wilden P25 Advanced Plastic Series Engineering, operation & maintenance
Zoeller
Zoeller X160 Series owner's manual
Pfeiffer Vacuum
Pfeiffer Vacuum ACP 120G installation instructions
Hitachi
Hitachi WT-P Series Operation manual
Altecnic
Altecnic Matrix Mini 130D Installation, operation & maintenance instructions
Espa
Espa NEPTUN FL instruction manual
Berkeley
Berkeley 10PDH11VT Installation, Operation & Parts Manual