Dyaco XE515SD-YE005 User manual

XE515SD-YE005
Elliptical
Service Manual

-----------------------------------------Table of Content-----------------------------------------------
1. Elliptical Outlines
2. Electronic Parts
2.1 Upper Controllers
2.2 Lower Controller and Driver
3. Electrical Configurations
4. Elliptical Operation
5. Elliptical Unit Block Diagrams
6. Elliptical Basic Connections and Wiring
6.1 Display Board Wire Connections
6.2 Display Board PCB Component Locations
6.3 The Console Interface Board Wire Connections
6.4 Amplifier Board Wire Connections
6.5 Driver Board Wire Connections
6.6 Driver Board PCB Component Locations
6.7 Driver Board LED Indicator Locations
6.8 Controller Indicator LED Debugging
6.9 Driver Board Function
6.10 Tension Motor Connector Definition Function
7. Product Safety Instructions
7.1 Important Safety Instructions
7.2 Important Electrical Instructions
7.3 Important Grounding Instructions
8. Elliptical Error Messages and Troubleshooting for electronic Issues
8.1 Error Message: E1
8.2 Error Message: E2
8.3 Error Message: INCLINE E3
8.4 Circuit Diagram
8.5 Calibration Procedure
8.6 Fuse Replacement
8.7 Troubleshooting Procedure Matrix for Electronic Issues
9. Troubleshooting
9.1 Console Problem
9.2 Side Case & Round Disk Problem
9.3 Flywheel Problem
9.4 Poly-V Belt Problem
9.5 Swing Arm Problem
9.6 Connecting Arm and Slide Wheel Problem
9.7 Controller & Incline Motor Problem

S
Se er rv vi ic ce e M Ma an nu ua al l
9.8 Tension Motor Problem
10. Q & A
10.1 Noise
10.2 Slip Problem
10.3 Shaking Problem
10.4 Smooth Problem
11. Disassembling and Assembling of Parts
11.1 Console Replacement
11.2 Swing Arm Replacement
11.3 Connecting Arm Replacement
11.4 Pedal Arm Replacement
11.5 Console Mast Replacement
11.6 Side Case Replacement
11.7 Cross Bar Replacement
11.8 Idler Wheel Replacement
11.9 Flywheel & Poly-V Belt Replacement
11.10 Rear Frame Replacement
11.11 Rail & Incline Motor Replacement

1. Elliptical Outlines

(1)Plastic parts
Front & back handlebar cover (R)
Rear cover(1)
Rear cover(2)
Middle cover
Pedal(R)
Slide wheel cover(R)
Bottom cover
Pedal arm cover(R)
Round disk cover
Round disk
Right side case
Swing Arm Bushing
ConsoleSwing Arm Bushing
Left side case
Console mast cover
Pedal(L)
Front & back handlebar cover (L)

S
Se er rv vi ic ce e M Ma an nu ua al l
結構件 Steel parts
Main frame
Flywheel
Bushing Housing, Pedal Arm
Cross Bar
Pedal arm (R)
Drive Pulley
Incline motor
Rail assembly
Connecting arm (L)
Pedal arm (L)
Connecting arm (R)
Lower Swing arm (L)
upper Swing arm (L) upper Swing arm (R)
Console mast
Lower Swing arm (R)
Rear frame

2. Electronic Parts

S
Se er rv vi ic ce e M Ma an nu ua al l
2.1 Upper Controllers
DISPLAY
Cooling FAN
THUMB SWITCH
Speaker

2.2. Lower Controller and Driver
SPEED SENSOR
MOTOR CONTROLLER
INCLINE MOTOR
TENSION MOTOR

S
Se er rv vi ic ce e M Ma an nu ua al l
3. Electrical Configurations