dynarex 5606 User manual

PORTABLE COMPRESSOR
NEBULIZER
Guidebook & Manual
Reorder No. 5606
Please read this guidebook carefully before operating this unit.
Your Nebulizer is intended for use in the treatment of asthma,
COPD and other respiratory ailments in which an aerosolized
medication is required during therapy. Please consult with your
physician and/or pharmacist to determine if your prescription
medication is approved for use with this Nebulizer. This
Nebulizer is intended for single patient use.

2
PORTABLE COMPRESSOR NEBULIZER
INSTRUCTIONS
INDEX
1.Introduction..............................................................Page 2
2.ProductIdentication...............................................Page 3
3.Important Safeguards..............................................Page 3
4.Operating Your Compressor Nebulizer....................Page 4
5.Cleaning ..................................................................Page 5
6.Specications ..........................................................Page 7
7.Warranty & Registration Card..................................Page 8
1. INTRODUCTION
Thank you for purchasing the Dynarex Portable Compressor
Nebulizer. It is a compact medical device designed to
efficiently deliver physician prescribed medication to the
bronchial lung passages. With proper care and use, it will
provide you with many years of reliable treatment.
This product is developed for the successful treatment of
asthma, allergies and other respiratory disorders. It creates
a stream of air that travels through a clear tube to the
nebulizer. When air enters the nebulizer, it will convert the
prescribed medication into aerosol mist for easy inhalation.
Your Compressor Nebulizer should be used under the
supervision of a licensed physician and/or a respiratory
therapist. We encourage you to thoroughly read this
guidebook to learn about the features of this product. Any
use of this product other than its intended use should always
be avoided.

3
2. PRODUCT IDENTIFICATION
3. IMPORTANT SAFEGUARDS
Note: Read all instructions carefully before use.
The following basic cautions are needed when using an
electrical product:
Caution: Failure to read and observe all cautions could
result in personal injury or equipment damage.
Product cautions:
1. To avoid electrical shock: Keep the unit away from water
 •Donotimmersethepowercordortheunitinliquid
 •Donotusewhilebathing•Donotreachforaunitthat
has fallen into water - immediately unplug the unit.
2. Never operate the unit if it has any damaged parts
(including power cord), if it has been dropped or
submersed in water. Promptly send it to a service center
for examination and repair.
3. The unit should not be used where flammable gas,
oxygen or aerosol spray products are being used.

4
4. Disconnect the unit from the electrical outlet before
cleaning,llingandaftereachuse.
5. Do not use other attachments unless recommended by
manufacturer.
Operating Cautions:
1. Connect this product to an appropriate voltage outlet for
your model.
2. Do not run this product unattended.
3. Never operate if this unit has a damaged cord or plug, if it
has been dropped, or in any way, submerged into water, if
it does not work properly. Return it to a service center for
repair.
4. If any abnormality occurs, discontinue use immediately
until the unit has been examined and repaired.
5. Always unplug the product immediately after use.
6. Never block the air openings of the main unit or place it
where the air openings may be obstructed.
Storage Cautions:
1. Do not store the unit under direct sunlight, high
temperature or humidity.
2. Keep the unit out of reach of small children.
3. Always keep the unit unplugged while not in use.
Cleaning Cautions:
1. Do not immerse the unit in water. It may damage the unit.
2. Disconnect the unit from the electrical outlet before
cleaning.
3. Clean all necessary parts after each use as instructed in
this guidebook.
4. OPERATING YOUR COMPRESSOR NEBULIZER
Note: Prior to initial operation, the nebulizer should be
thoroughly cleaned.
1. Place your Compressor Nebulizer on a flat and stable

5
surface. Be sure that you can easily reach the controls
when you are seated.
2. Gently twist the top part of the nebulizer counter-
clockwise to disassemble the nebulizer.
3. Fill the bottom section of the nebulizer with the medication
prescribed by your physician. Be sure that the cone is put
inside the bottom section.
4. Gently twist the top part clockwise to reassemble the
nebulizer.Besurethetwosectionstwell.
5. Attach one end of air tube to the base of the nebulizer.
6. Attach the other end of air tube to the tube connector
located on the front of the compressor.
7. Attach mouthpiece or mask per your choice to the top
section of nebulizer.
8. Plug the power cord into an appropriate electrical outlet.
Make sure at this stage, the power switch is at "Off"
status.
9. Press power switch to begin your prescribed treatment.
Important:
The compressor motor has a thermal protector, which will
shut off the unit before the unit is overheated. When the
thermal protector shuts the unit off, please:
a. Switch off the unit.
b. Unplug the unit from the electrical outlet.
c. Wait 30 minutes for the motor to cool down before
another treatment. Make sure the air openings are not
obstructed.
10.Whentreatmentisnished,shutofftheunitandunplug
it from the electrical outlet.
5. CLEANING
It is recommended that the nebulizer, mouthpiece and mask
be thoroughly cleaned with hot water after each use and

6
cleaned with a mild detergent after the last treatment of the
day. If your physician or respiratory therapist specifies a
different cleaning procedure, follow their instructions.
Rinsing (after each treatment)
1. Disconnect the air tube, nebulizer, mouthpiece and mask.
2. Gently twist the nebulizer to open it.
3. Rinse the nebulizer, mouthpiece and mask with water.
4. Dry them with clean soft towel or let it air dry.
5. Reassemble the nebulizer when completely dry and store
in a dry area.
Disinfecting Unit:
Please follow the following steps to disinfect your nebulizer
unlessotherwisespeciedbyyourphysician.Itissuggested
that the unit is disinfected after the last treatment of the day.
1. Use one part white vinegar with three parts distilled water.
Make sure mixed solution is enough to submerge the
nebulizer, mouthpiece, and mask.
2. Complete Rinsing Steps 1-3.
3. Wash nebulizer, mouthpiece and mask in warm water and
a mild detergent. Then wash them in hot tap water.
4. Submerge these parts in the vinegar and water solution
for thirty minutes.
5. Complete Rinsing Steps 3-5.
Cleaning the compressor
1. Wipe daily with a damp cloth.
2. Do not use any powdered cleaners or soap pads, which
maydamagethenish.
Filter change
1. Do not use cotton or any other materials. Do not wash or
cleanthelter.Onlyuselterssuppliedbyyourdistributor.
Anddonotoperatewithoutalter.

7
2. Change the filter every 30 days or when the filter turns
gray.
3. Changing procedure:
A.Removetheltercover
B.Replacetheusedlterwithanewone.
C.Replacetheltercover.
6. SPECIFICATIONS
Power 120V 60Hz
Current 1.3A
Medication Capacity 6ml
Particle Size >75%0.5~5μm
MMAD 2.97μm
Sound Level Around 60 dBA
Maximum Medication capacity 13ml (cc)
Average Nebulization Rate Min 0.2ml/min
Compressor Pressure Range 30 to 50 Psi
(210 to 345KPa / 2.1 to 3.45 bar)
Operating Pressure Range 9.5 to 16 Psi
(65.5 to 100KPa / 0.65 to 1.0 bar)
Liter Flow Range 6 ~ 10 lpm
Operating Temperature Range 10°C to 40°C (50°F to 104°F)
Operating Humidity Range 10 to 95% RH
Storage Temperature Range -20°C to 70°C(-4°F to 158°F)
Storage Humidity Range 10 to 95 % RH
Dimension (L x W x H) 156 x 140 x 90mm
(6.1” x 5.5” x 3.5”)
Weight 1.2kg (2.7lbs)
Standard Accessories
Nebulizer Bottle, Air Tube,
Adult Mask, Child Mask,
Mouththpiece, Filters(5PCS)

8
Protection against electric shock:
- Class II Equipment
- Type BF applied parts:
-Mouthpiece,babypacierinhaler&mask.
7. WARRANTY & REGISTRATION CARD
The Compressor Nebulizer unit is
warranted for three years from date of
purchase against defects in manufacturing.
AC power cord is warranted for a period of two years from
the date of purchase against defects in manufacturing.
All warranties are based on typical usage and does not
apply to use in any clinical or commercial applications.
This warranty is voided if the Compressor Nebulizer product
is misused or abused in any manner.
If the Compressor Nebulizer fails to operate during the
warranty period, please consult the distributor where you
purchased the nebulizer unit for further details.




N/A
Black
xxxxxx AI CS6
CHINA
ARIAL
5606_Warranty card_d02_r0_xxxxxxAdded comma after Orangeburg.
Updated slug.
Dynarex Corporation
WARRANTY REGISTRATION
Serial No.:
Date of Purchase:
1. Is this the first Compressor Nebulizer you’ve ever purchased? Yes No
2. Why did you select this unit?
3. What distributor did you purchase the Compressor Nebulizer from?
4. What other medical supplies do you purchase?
Please tell us about yourself (please print):
Name:
Address:
City:
State: ZIP:
Email:
Place
Stamp
Here
Attn.: Marketing Department
DYNAREX CORPORATION
10 GLENSHAW STREET
ORANGEBURG, NY 10962
Reorder No. 5606
Print black is free
Portable
Compressor
Nebulizer
15 x 10cm
r1