Ecosoft MO11XLWE User manual
9001:2015
3
ENG
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
2
1 2
2 4
3 6
4 11
5 13
6 16
7 17
55
1 20
2 21
3 24
4 29
35
B 36
This appliance is not intended for use by persons (including children) with reduced
-
-
ance by a person responsible for their safety. Children should be supervised to
ensure that they do not play with the appliance.
4
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
CIP Clean-in-place
NC Normally closed
Reverse osmosis
Normally open
Total dissolved solids
Gallon per minute
Piping and instrumenta-
Liter per minute
PCB Printed circuit board
irreparable membrane failure, hardware failure, and also involves electrical and
-
salinity feed water. All parts of the system that are in contact with water have the necessary
pressure pump feeds the water into the membrane module or membrane array, in which feed
pressure pump, referred to as concentrate
to waste water
-
The system is operated with a process , which powers pump(s) and valves so as to carry
-
ing on these signals, it chooses to run in service, rinse membranes, go to standby, or go to fault
5
ENG
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
-
-
Perform a detailed laboratory analysis of your well water and consult a water treat-
pretreatment
LIMITATIONS2
8 °dH
none
6
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
SPECIFICATIONS MO-1 MO-1 MO-1 MO-1
1
5,5–7 8–10
Water use per rinse, L
7,5 7,5
0,9×0,95×2,0
500 700 850
feed water
permeate
concentrate
²
LPM
GPM 7–8
LPM 75–110 50–80 110–150
GPM
LPM 50–55
GPM
7
ENG
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
-
membrane.
It is strongly recommended to use short runs of pipe or hose the size of which
-
-
-
to the vessel. Remove the lid at the feed end of pressure vessel. First, remove spiral retaining
ring by pulling bent tab towards the center of circle. If the pressure vessel lid is retained by half
membrane adapter.
last. Central tube of the membrane has to mate with membrane adapter installed at the concen-
trate end of pressure vessel. If necessary, remove the lid at the concentrate end before installing
end. Couple the second membrane with the connector, then push it forward all the way in the
place. Put spiral retaining ring (or half rims) in the groove, fasten half rims with screws. Re-assem-
ble the RO system in reverse order.
outlet of the RO system and run it to drain pipe. Ensure air gap at the end of drain line to prevent
8
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
If the RO system has permeate rinse enabled, install the necessary piping. If using service
together on controller PCB. Then, run wire from microswitch inside the controller housing and
-
Run power to the RO system. Pull power cable inside power cabinet of the RO system through
supply. See pictures of the electrical panel.
9
ENG
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
-
-
START on controller front pan-
valve to bring it down.
-
Recovery
10
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
•
• -
•
• To provide access to the unit for maintenance and repair purposes, respect the following
above.
•
• -
•
• -
If power supply cord is damaged, it must be replaced by the manufacturer, its ser-
Operator of the unit must strictly follow these guidelines and general electrical safety pre-
and that power supply is clean and uninterrupted.
-
Change polypropylene cartridge when it has clogged. Pressure drop of 0,1 MPa or greater on
Perform CIP or another suitable chemical cleaning protocol when any of the following condi-
11
ENG
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
membrane.
perform any maintenance, repair, cleaning, moving the unit or ancillary
water supply.
The manufacturer shall not be held liable for any damages incurred by the owner
-
-
12
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
•
•
•
transport.
•
13
ENG
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
Remove electrical power and relieve pressure before proceeding with any diag-
electrician!
shining green light
No power
-
tem, power cable is properly connected and
not damaged
Power supply fault
The controller does not
power supply to the system
Loosened contact in screw
terminal
terminals of the PCB
Other
trips
Power supply does not meet
power surges
Other
High pressure pump is
controller has started up
Controller is in Standby mode
a valve
Controller is in Stop mode
conductor
Controller is in Service
14
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
Low feed pressure fault
supply
-
The system is connected to
hose or small size pipe
pipe. Avoid long runs of small size pipe
necessary
Other
High permeate
Water temperature is higher
than allowed
proper concentrate pressure
Write down readings on pressure gauges and
support
Fouled or damaged membranes Replace or chemical clean the membrane
Other
Water temperature is lower
than allowed
proper concentrate pressure
Write down readings on pressure gauges and
support
Fouled membranes
Carry out chemical cleaning, contact your
Other
15
ENG
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
-
•
• -
•
•
• -
The controller supports scheduled maintenance alerts and
reading is digitally corrected for temperature of permeate, while
Power
IP code
Ambient temperature
Weight
16
INSTRUCTION MANUAL ECOSOFT MO MIDI SYSTEMS
This manual is the intellectual property of Ecoso. Copying and reprinng is prohibited. © 2020
This manual suits for next models
6
Table of contents
Languages:
Other Ecosoft Industrial Equipment manuals
Popular Industrial Equipment manuals by other brands
Weidmüller
Weidmüller POWERSTRIPPER AM 12 operating manual
Full Spectrum Laser
Full Spectrum Laser MUSE MOPA user manual
ULB
ULB TLB-R1000-480-OS instruction manual
transnorm
transnorm TS 1200 operating instructions
ABB
ABB HT846302 Operation manual
schmersal
schmersal AZM300Z-ST-SD2P-A Instructions for operation
