England's Stove Works Smartstove 15-SSW01 User manual

15‐SSW01,50‐SHSSW01, 50‐TRSSW01 
INSTALLATION&OPERATION
MANUAL 
Manufactured
By: 
England’sStoveWorks, Inc.

POBox 206 
Monroe,VA 24574
 www.heatredefined.com
(800) 245‐6489
Rev.1/2021
CAUTION 
Pleasereadthisentiremanualbeforeinstallationanduseofthiswood
fuel‐
burningappliance.Keepchildren,furniture,fixturesandallcombustibles away
fromanyheating appliance. 
SAVETHESEINSTRUCTIONS
SAFETY NOTICE 
Failuretofollowtheseinstructionscanresultinpropertydamage,bodily
injury

orevendeath.Foryoursafetyandprotection,followthe
installation
instructionsoutlinedinthismanual.Contactyourlocalbuildingorfire officials
aboutrestrictionsandinstallationinspectionrequirements(including permits)
inyour area.
Laversionfrançaisedecemanuelsuitlaversionanglaise.

IMPORTANT:IFYOUHAVEAPROBLEMWITHTHISUNIT,DO
NOTRETURNITTOTHEDEALER.CONTACTTECHNICAL
SUPPORT@1‐800‐245‐6489
MobileHomeUse(ApprovedforUSAonly):
Thisfreestandingwoodunitisapprovedformobilehomeor
doublewideinstallationwiththeoutsidecombustionairhook‐
up.Seethe“Installation”sectionofthismanualfordetails
pertainingtomobilehomeinstallations.Mobilehome
installationmustbeinaccordancewiththeManufactured
HomeandSafetyStandard(HUD),CFR3280,Part24.
Retainforyour files

Model
Number
Date of Purchase
Date ofManufacture
Serial Number
*Thisinformationcanbefoundonthesafetytagattachedtotherearoftheunit.
Havethisinformationonhandifyouphonethefactoryoryourdealerregardingthis
product.
• Keepchildrenaway.
CAUTION
• Supervisechildreninthesameroomasthisappliance.
• Alertchildrenandadultstothehazardsofhightemperatures.
• DoNOToperatewithprotectivebarriersopenorremoved.
• Hotwhileinoperation!Keepclothing,furniture,draperiesandother
combustiblesaway.Contactmaycauseskinburns!
• InstallationMUSTcomplywithlocal,regional,stateandnationalcodesand
regulations.
• Consultlocalbuilding,fireofficialsorauthoritieshavingjurisdictionabout
restrictions,installationinspection,andpermits.
2

IMPORTANT NOTE: The ash pan on this wood stove must be installed
correctly before operation.
The locking lip on the bottom of the ash pan must be slid INSIDE the stove
pedestal so that it can lock the ash pan in place, flush against the pedestal.
Tilt the ash pan up toward you as you slide it into the opening to do this.
If the locking lip is on the outside of the stove pedestal, it is incorrectly
installed.
CORRECTINSTALLATION
LOCKINGLIP
INCORRECTINSTALLATION
*DAILY‐‐Inspectthefireboxforashaccumulation;removeexcessashandfollowinstructionsinyour
owner’smanualregardingdisposal.Ashshouldnotbeallowedtoaccumulateinthestovetothe
pointthatitcoversthedogboxhole.Theashdumppluginthefireboxmayberemovedandashes
rakedintotheashpanbelowfortemporarystorage.Remembertoreplacetheashdumpplug.
AshDump
DogBox
SeeBelow*
3


WELCOME!


Introduction
• ThankYou!…...............................5

Specifications
• HeatingSpecifications..................6
• Dimensions...................................6
• EPACompliance...........................6

Installation
• Installation Overview ...................7
• ClearancestoCombustibles.........8
• VentingIntroduction....................9
• VentingGuidelines.......................9
• AdditionalVenting Information ..10
• Wall Pass ‐Throughs.....................11
• ApprovedVentingMethods
o ThroughtheWall...........12
o ThroughtheCeiling........13
o MasonryChimney...........14
o MasonryFireplace..........15
• MobileHomeInstallation...........16
• OutsideAir Hook‐Up ...................16
• FloorProtection.........................17

Operation
• Break‐InFires.............................18
• ContinuousOperation...........18‐19
• Safety Notes ...............................20

Maintenance
• StoveMaintenance....................22
• Inspecting Gaskets ......................23
• Finish..........................................23

Replacing Components
• Glass...........................................24
• BurnerTubes..............................25
• CeramicFiberboards...................25
• DoorHinges................................25
• HeatShield&BackPanel...........25
• OtherComponents.....................26

Optional Accessories
• AC‐16/AC‐30 Blower ..................26
• SideHeatShield  ……...................26

Troubleshooting Guide
• Troubleshooting.........................27

Illustrated Parts Detail
• PartsList.....................................28
• ExplodedPartsDiagram.............29
• BrickLayout................................30

Warranty
• SampleTag..................................31
• Warranty Details ........................32
• ImportantNo tice ........................33
• WarrantyregistrationForm.......34
*EPAAddendumfollowsWarrantySection


NOTE:CLEARANCESMAYONLYBEREDUCEDBYMEANSAPPROVEDBYTHEREGULATORYAUTHORITY
HAVINGJURISDICTION
DONOTCONNECTTOANYAIRDISTRIBUTIONDUCTORSYSTEM.

DONOTBURNGARBAGEORFLAMMABLEFLUIDSSUCHASGASOLINE,NAPHTHAOR
ENGINEOIL.

DONOTUSECHEMICALSORFLUIDSTOSTARTTHEFIRE.
4


Thank you for purchasing this fine product from England’s Stove
Works!
England's Stove Works was started, and is still owned by, a family that
believes strongly in a "Do It Yourself" spirit – that’s one reason you
found this product at your favorite “Do It Yourself” store.
We intentionally design and build our stoves so that any homeowner
can maintain his or her unit with basic tools, and we're always more
than happy to show you how to do the job as easily and as
inexpensively as possible.
From our free, downloadable service sheets to our "wizard-style," click-
through Troubleshooting guide on our web site, we have always tried to
help our customers stay "heat-ready," especially when oil and
electricity prices continue to skyrocket.
Please look at our vast Help section on our web site and call our
Technical Support department at [phone] if you need any help
with your unit. We are nearly always able to help “walk you through”
any repairs, problems or questions you may have.
PLEASE NOTE: While information obtained on our web site and
through our 800 number is always free of charge, there will be a service
charge incurred with any “on-site” repairs or maintenance that we may
arrange.
Wishing you years of efficient, quality and “comfy” heating,
England’s Stove Works
Technical Support Department
www.HeatRedefined.com
[phone]

This manual is available for free download on the manufacturer’s web site. It is a copyrighted document and resale
is strictly prohibited. The manufacturer may update this manual occasionally and cannot be responsible for
problems including injuries or damages resulting from the use of information found in any manual from
unauthorized sources.
PLEASE NOTE: If you purchased this model from certain stores, their model number may end in “L” “LC” “H”
“CT”
,
etc. This manual does a
pp
l
y
to those models as well.
CAUTION:Stoveisheavy.
Inaddition,whenhandlinganysheetmetalproducts,beawarethattheremaybesharpedgesorburrs.
Althoughwemakeeveryefforttoeliminateanysharpedges,pleaseusecautionwhenhandlinganymetalparts.
Remembertodisconnect(unplug)thestovefromthepowersourceandallowittocompletelycooldown
before
p
erformin
g
an
y
maintenance.
5


SPECIFICATIONS 


Heating Specifications 
• MaximumBurnTime** ................................................................................. 6‐8hours
• ApproximateSquareFootageHeated*** .................................................... 2000sq.ft.
• Firebox Capacity............................................................................................35 pounds
• FlueCollar .................................................................................................. 6.0in.round

Dimensions(Inches)
EPAandSafetyComplianceSpecifications
EPAComplianceStatus…….......Certifiedtocomplywith2020particulateemission
standardsusingcribwoodfuel.
U.S.TestStandard:USEPA40CFRPart60,Subpart60.536
ParticulateEmissions……………………………1.956grams/hr
COEmissions……………………………………….1.659grams/min
HeatOutputRange……………………………..11,129–24,369Btu/hr
Efficiency……………………………………………73.77%(HHV)
 TestedToEPATestMethod28A,ASTME2780,ASTME2515, UL1482‐2011(R2015)andULC‐S627‐
00(R2016).
Notes for this unit: Product may vary slightly from diagram. Clearances are the minimum
for this unit and may need to be increased in the rear to have proper vent clearances. Follow all
venting manufacturer clearances and local codes.
***‐Themaximumheatingcapacityofthisunitcanvarygreatlybasedonclimate,constructionstyle,insulationandamyriadofotherfactors.
UsethisinformationinconjunctionwithaBTUlosscalculationforyourhometodetermineifthisunitwillbesufficientforyourneeds.
6


INSTALLATION 

Installation Overview

Whenchoosingalocationforyournewstove,thereareamultitudeoffactorsthat
shouldbetakenintoaccountbeforebeginningtheinstallation.

1.TrafficPatterns–Tohelppreventaccidents,thestoveshouldbeplacedinalocation
whereitisoutofthewayofnormaltravelthroughthehome.

2.HeatFlow–Whendecidingonalocationforthestove,considerthewayheatmoves
throughoutyourhome.Installthestovewhereyouneedtheheat;basement
installationsoftendonotallowsufficientheattoflowtotheupperfloorsandatop
floorinstallationwillnotallowanyheattoreachthefloorsbelow.Alwaysconsider
thatheatrisesandwilltakethepathofleastresistancewhileitisstillhot.

3.ExhaustLocation–Theenginewhichdrivesawoodstoveisthechimneysystem,so
itisimportanttoconsiderpreciselyhowthechimneysystemwillbeintegratedinto
thestoveinstallation.Ideally,awoodstovechimneywillruncompletelyvertical
fromthefluecollaroftheunitallthewaytotheterminationpointabovetheroof
line.Keepingtheentirechimneysysteminsidetheheatedenvelopeofthehome
willensureastrong,easytoinitiatedraftinthechimney.Althoughexteriorchimney
systemsoftenfunctionproperly,theyaremorelikelytosufferfromcolddowndrafts
atstartuporprovideweakdrafttotheunit.Also,considerthecross‐sectionalarea
ofthechimney;althoughexistingmasonrychimneyscanoftenbeused,alarge
externalmasonrychimneywillresultinaunitthatisdifficultorimpossibleto
operateproperly.Inthatcase,aninsulatedchimneylinerwilloftenberequiredto
supplythenecessarydraft.

4.WallConstruction–Locatingthestovesothattheexhaustsystemcanpassbetween
studswillsimplifytheinstallationandeliminatetheneedtoreframeanysectionsof
thewallorceilingtoaccommodatethewallthimbleorceilingbox.

WARNING
• Donotstoreorusegasolineorotherflammablevaporsandliquidsinthe
vicinityofthisoranyotherappliance.
• DoNotOver‐fire–Ifanyexternalpartstartstoglow,youareover‐firing.
Reduceintakeairsupply.Over‐firingwillvoidyourwarranty.
• Complywithallminimumclearancestocombustiblesasspecified.
Failuretocomplymayresultinahousefire.
• Testedandapprovedforcordwoodonly.Burninganyotherfuelwill
voidyourwarranty.
7


INSTALLATION 
Clearances to Combustibles




















Parallel 
Wall Installation 
CornerInstallation

WARNING‐INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER





Unitto Side 
Wall
*
Chimney
Connector
to Side
Wall
Chimney
Connector to
Rear Wall
Unit to 
Rear
Wall
Unitto
Corner
Chimney
Connector
to Corner
A B C D E F
in.(mm.) in.(mm.) in.(mm.) in.(mm.) in.(mm.) in.(mm.)
SingleWall Chimney
Connector Unprotected
Surface

21.5
(546.1)

29
(736.6)

12
(304.8)

7.5
(190.5)

9.5
(241.3)

19
(482.6)
DoubleWall Chimney
Connector Unprotected
Surface

N/A

N/A

N/A

N/A

N/A

N/A
SingleWall Chimney
Connector Unprotected
Surfacewithside shields.
17.5
(445.5)
25
(635)
12
(304.8)
7.5
(190.5)
5.5
(139.7)
15
(381)
DoubleWall Chimney
Connector Unprotected
Surfacewithside shields.

N/A

N/A

N/A

N/A

N/A

N/A
Notesforthisunit:Theproductmaydifferslightlyfromthediagrams.Theclearancesarethe
minimumforthisunitandmayneedtobeincreasedtohaveproperventilationclearances.
Observeallventilationmanufacturerclearancesandlocalcodes.
8


Venting Introduction
INSTALLATION
Venting Guidelines

Thiswoodstoveoperatesona
naturaldraftsystem,inwhichthechimney
systempullsairthroughthestove.Thisunit
mustbeinstalledinaccordancewiththe
followingdetaileddescriptionsofventing
techniques;notinstallingthestovein
accordancewiththedetailslistedherecan
resultinpoorstoveperformance,property
damage,bodilyinjuryordeath.Avoid
make‐shiftcompromiseswheninstallingthe
ventingsystem.England’sStoveWorksis
notresponsibleforanydamageincurred
duetoapoororunsafeinstallation.
Becertainthatallaspectsofthe
ventingsystemareinstalledtotheventing
manufacturer’sinstructions,particularlythe
requiredclearancestocombustibles.Also,
becertaintouseanatticradiationshieldto
preventinsulationfromcontactinga
chimneywhichpassesthroughanattic.
Thechimneysystemisthe“engine”
whichdrivesawoodstove,soitis
imperativeforproperunitfunctionthatthe
ventingsystembeinstalledexactlyas
describedinthefollowingsection.
Ifquestionsarisepertainingtothe
safeinstallationofthestove,ourTechnical
Supportline(800‐245‐6489)isavailable.
Contactyourlocalcodeofficialtobecertain
yourinstallationmeetslocalandnational
firecodes,andifyou’reuncertainabout
howtosafelyinstallthestove,westrongly
recommendcontactingalocalNFIcertified
installertoperformtheinstallation.

• ALWAYSinstallventpipeinstrict
adherencetotheinstructionsand
clearancesincludedwithyour
ventingsystem.
• DONOTCONNECTTHISWOOD
STOVETOACHIMNEYFLUEWHICH
ALSOSERVESANOTHERAPPLIANCE.
• DONOTinstallafluepipedamper
oranyotherrestrictivedeviceinthe
exhaustventingsystemofthisunit.
• USEanapprovedwallthimblewhen
passingthroughawallandaceiling
support/firestopwhenpassing
throughaceiling.
• INSTALLthreesheetmetalscrewsat
everychimneyconnectorjoint.
• AVOIDexcessivehorizontalrunsand
elbows,asbothwillreducethedraft
oftheventingsystemandwillresult
inpoorstoveperformance.
• INSPECTyourventingsystemoften,
tobecertainitisclearofcreosote,
fly‐ashandotherrestrictions.
• CLEANtheventingsystemas
detailedinthemaintenancesection
ofthismanual.
• ADHEREtothe10‐3‐2ruleregarding
chimneyterminations.
• INSTALLsinglewallchimney
connectorwiththemaleenddown
topreventcreosoteleakage.Follow
doublewallchimneyconnector
manufacturer’sinstructions
regardingproperpipeinstallation.





WARNING:VentingsystemsurfacesgetHOT,andcancauseburnsif
touched.Noncombustibleshieldingorguardsmayberequired.
9


FlueGasDirection


Additional Venting Information
INSTALLATION
• Donotmixandmatchcomponentsfromdifferentpipemanufacturerswhenassembling
yourventingsystem(i.e.DoNOTuseventingpipefromonemanufacturerandathimble
fromanother).

• Werequireaminimumchimneyheightof15.0ft.Chimneysystemsshorterthanthis
maynotcreatetheamountofdraftwhichisrequiredtooperatethiswoodburningunit.

• Donotusemakeshiftcompromiseswheninstallingtheventingsystem;haveexisting
chimneysystemsinspectedbeforeuseandbecertainallnewchimneysystemsare
installedtothemanufacturer’sspecificationsandwithonlyULlistedcomponents(ULCif
Canada).

• PrefabricatedventingsystemsusedforthisstovemustbelistedtoULCS629(Canada)
andUL103HT(US).

• Neverinstalladraftinduceroranyothersystemwhichincreasesthenaturaldraftofthe
chimney;similarly,donotinstallabarometricorstovepipedamperwiththisunit.

• Neverusesinglewallordoublechimneyconnectorasachimneysystem;neverpass
eithertypeofchimneyconnectorthroughacombustiblewallwithoutcarefullyfollowing
themanufacturer’sinstructionsandthoselistedinthefollowingpageonWallPass‐
Throughs.NEVERpasschimneyconnectorthroughanattic,floor,closetorroof.
• Onlyuse24gaugeMSGblacksinglewallchimneyconnectororULListed(ULCifCanada)
doublewallchimneyconnector.

Single Wall Chimney Connector Installation




Themaleendofsinglewall
chimneyconnectoris
installedfacingdownsothat
anyliquidcreosoteinthe
fluewillrunintotheunit
insteadofontotheoutside
ofthepipe(thenaturaldraft
inthechimneysystemwill
preventsmokeleakageat
thejoints).


Crimpedormaleendof
singlewallchimney
connectormustfacedown.




Fasteneachsinglewall
chimneyconnectorjoint
withthreesheetmetal
screws.

WARNING

• INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER.
• HOT!Donottouch!Severeburnsorclothingignitionmayresult.
• Glassandothersurfacesarehotduringoperation.
10

INSTALLATION
Wall Pass-Throughs
In Canada ,the installation must conform to CAN/CSA-8365 when passing through combustible construction.

11

18.0in.2.0ft.
3.0ft.
INSTALLATION 
Approved Venting Method 1:ThroughtheWallFactoryBuiltChimney



10 ft. 
TerminationCap




StormCollar



RoofFlashing
The 10‐3‐2Rule:Thechimneysystem
mustterminate3.0ft.abovethepoint
whereitscenterlinepassesthroughthe
roofANDthechimneymustterminate
2.0ft.aboveanypartofthedwelling
withina10ft.radiusofthechimney.





WallThimble
ClassAChimneySystem


ChimneyConnector
(SingleorDoubleWall)
TeeandTeeSupport





• PrefabricatedchimneysystemsmustconformtoUL‐103HT(2100°F)fortheU.S.andULC‐S629(650°C)for
Canada.
• Thiswoodburningunitisonlylistedforinstallationwith6.0”diameterchimneyconnectorandchimneysystems.
Installingthisunitonprefabricatedchimneyslargerthan6.0”diameterwillresultindecreaseddraftandthe
potentialforpoorunitperformance.
• Followallventingsystemmanufacturer’sinstallationrequirementsandrequiredclearances.
• Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s
recommendationswhendoublewallchimneyconnectorisused).
• Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal
screws(holesshouldbepre‐drilledinfluecollarfromfactory).
• Properlyattachtheprefabricatedchimneysystemtothehomeinstrictaccordancewiththeprefabricated
chimneysystemmanufacturer’sinstructions.
• Avoidnumerouselbowsandexcessivehorizontalrunsasbothwillleadtopoordraftandincreasedcreosote
accumulation. Horizontalrunsofchimneyconnectormustneverexceed4.0ft.andtheoveralllengthofthe
chimneyconnectormustnotexceed8.0ft.withsinglewallblackconnectorpipe.Ifnecessarytorunlonger
than8.0ft.ofchimneyconnectorpipe,doublewallblackchimneyconnectorpipemustbeused.
• Specialadaptersandslipconnectorsareavailabletoeliminatetheneedtocutsinglewallchimneyconnector.
Doublewallchimneyconnectormustbeusedwiththeseslipconnectors,asitcannotbetrimmedtolength.

Please Note:Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplans
foreachindividualinstallation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancesto
combustibles,andfollowalllocalcodes.

12

2.0ft.
3.0ft.
3ft.
2ft.
INSTALLATION 


Approved Venting Method 2:ThroughtheCeiling

10 ft. 


TerminationCap












StormCollar
The 10‐3‐2Rule:Thechimneysystem
mustterminate3.0ft.abovethepoint
whereitscenterlinepassesthroughthe
roofANDthechimneymustterminate
2.0ft.aboveanypartofthedwelling
withina10ft.radiusofthechimney.


RoofFlashingClassAChimneySystem



CeilingSupportBox
ChimneyConnector
(SingleorDoubleWall)





• PrefabricatedchimneysystemsmustconformtoUL‐103HT(2100°F)fortheU.S.andULC‐S629(650°C)for
Canada.
• Thiswoodburningunitisonlylistedforinstallationwith6.0”diameterchimneyconnectorandchimneysystems.
Installingthisunitonprefabricatedchimneyslargerthan6.0”diameterwillresultindecreaseddraftandthe
potentialforpoorunitperformance.
• Followallventingsystemmanufacturer’sinstallationrequirementsandrequiredclearances.
• Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s
recommendationswhendoublewallchimneyconnectorisused).
• Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal
screws(holesshouldbepre‐drilledinfluecollarfromfactory).
• Properlyattachtheprefabricatedchimneysystemtothehomeinstrictaccordancewiththeprefabricated
chimneysystemmanufacturer’sinstructions.
• Theoveralllengthofthechimneyconnectormustnotexceed8.0ft.Inthecaseofcathedralceilings,the
prefabricatedchimneysystemshouldextendto8.0ft.fromthetopoftheunitifusingsinglewall
chimneyconnectorpipe.Ifnecessarytorunlongerthan8.0ft.ofchimneyconnectorpipe,doublewall
blackchimneyconnectorpipemustbeused.
• Specialadaptersandslipconnectorsareavailabletoeliminatetheneedtocutsinglewallchimneyconnector.
Doublewallchimneyconnectormustbeusedwiththeseslipconnectors,asitcannotbetrimmedtolength.
Please Note:Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplans
foreachindividualinstallation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancesto
combustibles,andfollowalllocalcodes.
13

2.0ft.
18.0in.
3.0ft.
INSTALLATION 


Approved Venting Method 3:InternalorExternalMasonryChimneySystem

10 ft. 







Chimneylinercross‐sectional
area(LengthxWidth)must be
nolargerthantwicethecross‐
sectionalareaofthefluecollar
(2x28.27in2=56.55in2).If
chimneylinerislargerthan
56.55in2,reliningwitha5.5”
or6.0”linerisrequired
The10‐3‐2Rule:Thechimneysystem
mustterminate3.0ft.abovethepoint
whereitscenterlinepassesthroughthe
roofANDthechimneymustterminate
2.0ft.aboveanypartofthedwelling
withina10ft.radiusofthechimney.



ChimneyConnector
(SingleorDoubleWall)


MasonryThimblewith
properclearanceto
combustibles

AshCleanoutsmust
haveanairtightsealto
preventweakdraft.

• Followtheruleslistedaboveconcerningmaximumpermissiblefluelinersize;installingthisunitonmasonry
chimneysexceeding56.55in2incross‐sectionalareawillresultindecreaseddraftandthepotentialforpoorunit
performance.
• Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s
recommendationswhendoublewallchimneyconnectorisused).
• Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal
screws(holesshouldbepre‐drilledinfluecollarfromfactory).
• Avoidnumerouselbowsandexcessivehorizontalrunsasbothwillleadtopoordraftandincreasedcreosote
accumulation. Horizontalrunsofchimneyconnectormustneverexceed4.0ft.andtheoveralllengthofthe
chimneyconnectormustnotexceed8.0ft.withsinglewallblackconnectorpipe.Ifnecessarytorunlonger
than8.0ft.ofchimneyconnectorpipe,doublewallblackchimneyconnectorpipemustbeused.
• Atightsealatthethimbleiscrucialforproperunitperformanceandtocreateasafeinstallation.Usetheproper
adapterdesignedforconnectingsingleordoublewallchimneyconnectortoamasonrythimble.
• Haveexistingmasonrychimneysinspectedforsafetyandproperclearancestocombustiblesbeforeputtingthem
intoservice;aqualifiedchimneysweepcanperformthisinspection.
• Externalmasonrychimneysoftensuffercolddowndraftsandpoordraftperformanceevenwhentheymeetthe
cross‐sectionalarearules.Inthiscase,a6.0”insulatedlinermaybenecessary.


Please Note:Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplans
foreachindividualinstallation.Pleasefollowallventingsystemrequirements,maintaintherequiredclearancesto
combustibles,andfollowalllocalcodes.

 
14

The10‐3‐2Rule:Thechimneysystemmustterminate3.0ft.abovethe
pointwhereitscenterlinepassesthroughtheroofANDthechimney
mustterminate2.0ft.aboveanypartofthedwellingwithina10ft.
radiusofthechimney.
INSTALLATION 
INSTALLATION INTO A MASONRY FIREPLACE
Preparation
Measure your hearth to ensure it is large
enough to accept the unit.
Unit must have a 36” clearance from the top of
the stove to a mantel in accordance with NFPA
211.
For the USA: Hearth must extend at least 16
in. from the front of the fuel opening.
For Canada: Hearth must extend at least 18 in
(450.0 mm) from the front of the fuel opening.
Keep in mind that this type of installation
will make it difficult to change speeds on
the blower frequently. We recommend
picking a blower speed and sticking with it,
since adjusting the blower will be difficult
because of the tight installation.
WARNING: DO NOT ATTEMPT TO ADJUST
BLOWER DURING OPERATION. SKIN
BURNS MAY OCCUR WHEN MAKING
CONTACT WITH THE UNIT. WAIT FOR UNIT
TO COMPLETELY COOL BEFORE
ATTEMPTING TO ADJUST BLOWER.
Inspect your hearth to be sure it is constructed
of a noncombustible material such as brick or
stone. Do not install this stove on a hearth that
is constructed of wood framework that is
covered by brick or stone and do not install
this unit in a zero (0) clearance fireplace.
The manufacturer will not be held responsible
for an accident resulting from this stove being
installed on a hearth constructed of a
combustible material.
Inspect your fireplace to ensure it is in proper
working order and free of any obstructions.
Prior to installation, remove the existing
damper or wire it to fasten it open.
Venting Your Stove - Direct Connect
When this unit is direct connected it will require six inch (6”) diameter 24 gauge pipe from the stove through the
damper opening. (NOTE: The chimney connector must be attached to the appliance
with a minimum of three (3) screws, and 3 screws should be used to attach each adjoining section.)
We highly recommend having the chimney fully lined with a 6 inch liner to ensure proper draft. This will make it
necessary to block off the open area on both sides of the pipe that passes through the damper opening, which
can be done with sheet metal or by packing flame retardant fiberglass insulation in the open areas (no paper or
combustibles). You must be sure the draft from the chimney is being pulled through the stove, and not around
the connector pipe.
We highly recommend you have this done by a professional. You should also contact your local authorities to
be sure you are following all codes.
36in.(91.4cm)minimum
Stovetoptomantel
Seehearthrequirements
Removeorwire
damperopen
6in.(15.24cm)liner
highlyrecommended
Connector
Pipe
15

INSTALLATION 

WARNING 
DONOTINSTALLINASLEEPINGROOM.
CAUTION 
THESTRUCTURALINTEGRITYOFTHE
MANUFACTUREDHOMEFLOOR,WALL AND
CEILING/ROOFMUSTBE MAINTAINE D.
Caution

NEVERdrawoutsidecombustionair from:
Wall,floororceilingcavity or 
enclosedspacesuchasanattic,garageor
crawl
space.
Mobile Home Installation(USAONLY,NOTAPPROVEDFORCANADIANMOBILEHOMEINSTALLATION)

• ThewoodstoveMUSTbesecuredtothefloorofthemobilehomeusinglagboltsandtheholes
providedinthebottomoftheunitforthis
purpose.Usea#8copperwiretoground
stovetoframeofmobilehome.

• Thewoodstovemustbeconnectedtothe
chimneysystemwithdoublewallchimney
connectorwhichisULlistedforusein
mobileandmanufacturedhomes.

• Carefullyfollowallclearanceslistedinthe
appropriatesectionofthismanualANDfollow
theventingmanufacturer’s
minimum
clearance
requirements.Similarly,becertain
theventingsystemusedisapproved
formobile 
homeuse.

• Installationmustbeinaccordancewith
ManufacturersHome&SafetyStandard

ChimneyCap/SparkArrestor


ClassAChimneySystem


RoofFlashingandStormCollar


JoistShield/Firestop


MobileHomeApprovedDouble
WallChimney
Connector 

Usesiliconetocreateavapor
barrierwherethechimneypasses
throughtoexterior.
(HUD)CFR3280,Part24aswellasanyapplicablelocalcodes.
Outside Combustion Air
• Theuseofoutsidecombustionairismandatorywheninstallingthiswoodstoveinamobileor
manufacturedhome.

• Theoutsideairconnectionpipeprotrudesfromthebottomcenterofthestove;akitisavailable
fromEngland’sStoveWorks,Inc.designedforconnectingthisunittooutsidecombustionair.[Part
No.AC‐OAK3]

• IfitisnotfeasibletousetheAC‐OAK3outsideairhookupkitinyourstoveinstallation,other
materialsmaybeused,providedthefollowingrulesarefollowed:

o Thepipeusedforoutsideairhookupmustbemetal,withaminimumthicknessof.0209in.
(25gaugemildsteel)orgreaterandaninsidediameterofapproximately2.75in.

o Keeppiperunsshortanduseamechanicalfastenerateachpipejoint.

o Ascreenorotherprotectiondevicemustbefittedovertheoutsideairterminationpointto
preventrain,debrisandnuisanceanimalsfromenteringthepipingsystem.Inspectthe
outsidecombustionairinletforblockanddebrismonthly.
16

FLOORPROTECTION

• ThiswoodstoverequiresaULlistedtype1sparkandemberfloorprotectorifthestoveistobe
installedonacombustiblefloor.Ifthefloorthestoveistobeinstalledonisalready
non‐combustible(i.e.aconcretefloorinabasement),nofloorprotectionisneeded(althougha
decorativefloorprotectorcanstillbeusedforaestheticreasons).

• WhenusinganyULlistedtype1sparkandemberfloorprotector,considerthatthisstoveisnotonly
heavybutwillinduceheatingandcoolingcyclesonthefloorprotectorwhichcandamagetileand
loosenmortarandgroutjointslocatednearthestove.

• ThesparkandemberfloorprotectorshouldbeULapprovedorequivalent(ULCifCanada)andmust
benoncombustible.Sincethemajorityoftheheatfromthisunitisradiant,thefloorprotectoronly
servestokeepashesandsparksfromlandingoncombustibleflooringneartheunit.Ahearthrugis
NOTanapprovedsubstituteforaproperhearthpad.NoRValueisnecessary.

• FortheUS:Thefloorprotectormustextendatleast16in.fromthefrontofthefuelopening,8in.
fromthesidesofthedooropeningand8in.fromtherearoftheunit.

• ForCanada:Thefloorprotectormustextendatleast450.0mmfromthefrontofthefuel opening, 
200.0mmfromthesidesofthedooropeningand200.0mmfromtherearoftheunit.

• Thesparkandemberfloorprotectormustextend2in.(50.8mm.)oneithersideofanyhorizontal
ventingrunsandextenddirectlyunderneathanyverticalventingpipe.

CAUTION 
NEVERUSEGASOLINE,GASOLINE‐TYPELANTERNFUEL,KEROSENE,CHARCOALLIGHTER FLUID,
ORSIMILARLIQUIDSTOSTARTOR“FRESHENUP”AFIREINTHISHEATER.KEEPALL SUCH
LIQUIDSWELLAWAYFROMTHEHEATERWHILEINUSE.ADDITIONALLY,NEVERAPPLY FIRE‐
STARTERTOANYHOTSURFACEOREMBERSINTHE STOVE. 


38½in
47in
17

FirstFire‐Remembertoopenadoor
and/orwindowtoventilatethearea.
Youmayfinditnecessarytoopen
severaldoorsorwindowsforplentyof
ventilation.
OPERATION 

Break‐In Fires

• Thiswoodburningunitisconstructedofheavygaugesteelandcastironandisbuilttolastalong
time.However,inordertoensurenoexcessivethermalstressesareinducedonthe
metal
during
thefirstfire,threebreak‐infiresshouldbeburned,eachoneslightlyhotterthanthelast.
Thesebreak‐infireswillnotonlyhelpthestovebodyacclimatetothehightemperaturesofthe
fire,butwillalsoslowlycurethehightemperaturestovepaint,whichwillensurethehigh
qualityfinishlastsforyears.Remembertoopenadoorand/orwindowtoventilatethearea.

• Thisstovehasasingleaircontrolrodwhichregulatesthewoodburnrate;whentheprimaryair
controlslideispulledallthewayoutoftheunit,thestovewillburnmoreslowlyandputout
heatoveralongertimeperiod.Conversely,whentheaircontrolslideispushedallthewayin,
theunitwillburnmorequicklyandputoutalargeramountofheatoverarelativelyshorter
time 
period.Donotattempttomodifytherangeofaircontroladjustmentforanyreason.

• Thefirstbreak‐infireshouldbejustalargekindlingfire,gettingthestovetoabout300°F .Once 
thistemperaturehasbeenreached,allowthefiretodieoutwiththeaircontrolopen.The
secondandthirdbreak‐infiresshouldbeabitlarger,withsomesmalldrysplitsaddedtothe
kindlingload.Thetemperaturegoalduringthesefiresisabout350°F–450°F;don’tletthefire
gethotterthanthat.

Continuous Operation

• Afterthebreak‐infiresarecomplete,thisunitisreadyforcontinuousoperation.Whenburning
thestovecontinuously,donotallowashandcoalstoaccumulatehigherthantheairholeinthe
dogbox.Excessivecoalingisoftenaresultofburningwoodattoohighaburnrate,andthecoal
bedshouldbeallowedtoburndownbeforereloadingthestovewithfreshwood.

• Combustionairisdeliveredtothestoveattwolocations:Themajorityoftheprimarycombustion
airentersthefireboxviatheair‐washsystemwhichkeepstheglasscleanandfeedstheprimary
combustionflamesonthetopsurfacesofthewood;someprimarycombustionairisfeedintothe
coalbedviathedogboxholeinthebottom,frontboxofthestove.(Thisairissuppliedfrom
undertheunit.)Everyeffortmustbetakentomaintaintheareainfrontofthisholefreeofash.

• Whenloadingthestoveforalongtermburn,itismostusefultorakea“v”inthecenterofthe
coalbed,toallowtheprimaryairbleedholetopushairallthewaytotherearoftheunit.

• Afterloadingthestovewithafullfireboxoffreshwood,itisimportanttooperatetheunitwith
theaircontrolinthefullopenpositiontoproperlycharthewoodloadanddriveofftheinitial
moistureinthefreshwood.Oncethewoodhasbeenproperlycharredandiscompletely
ignited,theaircontrolcanthenbesettothedesiredheatoutputlevel.

• Thisunitalsooffersanewfeature.Whenloadingthestoveforalonglowburn,youcansetthe
aircontroldampertoallowtheunittoheatupandgetagoodburngoingbeforetheairis
closed 
offtothelowposition.Simplypulltherodouttolowandturnitcounter‐clockwiseuntil
youhearaslight“click”(aboutaquarterofaturn). Whenitisreadythedamperwillshutitself.
Thiswillworkforlowandmediumlowsettings.
18

age | 18
OPERATION 


• Theoptionalroomairconvectionblowerwasdesignedtoextractthemaximumamountofheat
fromthestove,forthehighestpossibleheattransferintotheroom.Sincetheblowerisso
efficientatremovingheatfromtheunit,itisveryimportanttoonlyoperatetheroomairblower
afterafreshwoodloadhasbeenallowedtoburnforatleastthirty(30)minutes.Allowingafresh
loadofwoodtoburnwithoutthebloweronensuresthattheentireunitreachesproper
operationtemperaturesandthatthesecondarycombustionsystemisfunctioningproperly.
Additionally,followtheguidelinesbelowforacceptableblowerspeeds.

• Whenusingtheoptionalroomairconvectionblower(PartNo.AC‐16,oryoucanupgradetothe
AC‐30),theblowershouldbeoperatedasfollowsdependingonheatoutputlevel:

Burn
Rate High MediumHigh Medium MediumLow Low
BlowerSpeedAC‐16 High High Low Low Low
BlowerSpeedAC‐30 High MediumHigh Medium MediumLow Low
Creosote –Formation and Need for Removal 
Whenwoodisburnedslowly,itproducestarandotherorganicvapors, which

combinewithexpelledmoisturetoformcreosote.Thecreosote
vapors
condenseintherelativelycoolchimneyflueofaslow‐burningfire.Asa result,
creosoteresidueaccumulatesonthefluelining.Whenignited,this creosote
makesanextremelyhotfire.Thechimneyandchimneyconnectorshould be
inspectedatleastonceeverytwomonthsduringtheheatingseason to
determineifacreosotebuilduphasoccurred.Ifcreosotehasaccumulated, it
shouldberemovedtoreducetheriskofchimney fire.
DONOTUSEGRATEORELEVATEFIRE–BUILDWOODFIREDIRECTLYON HEARTH 
DONOTOPERATEWITHTHEMAINDOOROPEN–OPERATINGTHESTOVEWITHTHE MAIN
DOOROPENWILLCREATEANOVER‐ FIRE
Intheeventofacreosoteorsootfire(chimneyfire),closetheaircontrolonthe stove,
contactthelocalfiredepartmentandgetout!Donotthrowwateronthefire! Contact
yourlocalfireauthorityformoreinformationonhowtohandleachimneyfire and 
P
developasafeevacuationplanforyouandyourfamilyintheeventofachimneyfire.
19


OPERATION
Additional Safety Guidelines

CAUTION:Whenaddingfueltothestove,theblowermustbeturnedOFF.

• Theinstallationofsmokedetectorsishighlyrecommendedwheninstallingthisoranyothersolid
fuelburningappliance.Smokedetectorsshouldbelocatednearorineveryroomofthehome,
particularlysleepingrooms.

• Asmokedetectorcanbeinstalledinthesameroomasthiscordwoodburningunit;installingthe
smokedetectortooclosetotheunitcanleadtonuisancealarmsduetoslightwispsofsmokeemitted
duringthefirestartingorreloadingprocess.Duetothis,thesmokedetectorinthe
sameroomastheunitwillbemostusefulifitislocatedasfarfromtheunitastheroomwill
permit.

• Thisstoveisdesignedtoburnnaturalwoodonly.Higherefficienciesandloweremissionsgenerally
resultwhenburningairdried,seasonedhardwoods,ascomparedtosoftwoodsortogreenor
freshly‐cuthardwoods.DONOTBURNgarbage,lawnclippingsoryardwaste,materialscontaining
rubber,includingtires;Materialscontainingplastic:Wasterpetroleumproducts,paintsorpaint
thinners,orasphaltproducts;Materialscontainingasbestos;Constructionordemolitiondebris;
Railroadtiesorpressure‐treatedwood;Manureoranimalremains;Saltwaterdriftwoodor
previouslysaltwatersaturatedmaterials;Paperproducts,cardboard,plywood,orparticleboard.
Theprohibitionagainstburningthesematerialsdoesnotprohibittheuseoffirestartersmade
frompaper,cardboard,sawdust,waxandsimilarsubstancesforthepurposeofstartingafirein
anaffectedwoodheater.Burningthesematerialsmayresultinreleaseoftoxicfumesorrender
theheaterineffectiveandcausesmoke.

• Burningfuelsotherthancordwood,particularlycoalandcharcoal,canresultinhazardous
concentrationsofcarbonmonoxidebeingemittedintothedwelling.Forthesereasons,NEVER
burncoalorcharcoalinthiscordwoodstove.Installingacarbonmonoxidedetectorandbeing
awareofthesymptomsofcarbonmonoxidepoisoningcanhelpreducetheriskofcarbonmonoxide
relatedissues. 

• Thisunitwasdesignedforoperationonlywiththeloadingdoorclosedandtightlylatched.
Operatingthisunitwiththeloadingdoorlatchedlooselyoropenwillallowexcessivecombustionair
toreachthefireandwillresultindangerouslyhighunittemperatures.Highunittemperaturescan
damagetheunit,voidthewarrantyorignitecreosotedepositedinthechimneysystembyprevious,
slowburningfires.

• Thenaturaldraftthatpullsairthroughthisunitandallowsthefiretoburnusestheindoorairofthe
dwellingforcombustion,unlesstheunitisconnectedtoanoutsidecombustionairsource.Kitchen
rangeventhoods,furnacesandotherairmovementappliancesinthehomeareoftenalsoremoving
airfromthedwelling;iftheamountofairfiltrationorleakagebackintothehomeisexceededbythe
airbeingremoved,negativepressuremaybecreatedinthehome.

• Sincethisisanaturaldraftappliance,itwilloftenbethefirstappliancetohaveproblemsrelatedto
negativepressure.Ifsmokeisforcedoutthechimneyconnectorjointsoroutoftheairinduction
systemoftheunit,theunitislikelyfightingnegativepressureinthedwelling.
Crackingawindowordoorneartheappliancecanhelpequalizethenegativepressure;
ultimately,anunrestrictedsourceofoutsidecombustionmaybenecessaryforproperunit
DONOTSTOREFUELCLOSERTHANSPECIFIEDCLEARANCESTOCOMBUSTIBLESOR
WITHINTHESPACENEEDEDFORLOADINGTHESTO
V
EANDFORASHREMO
V
AL.
20