Esco miniLIFT CLASSIC User manual
Equipment Supply Company
Instruction Manual
miniLIFT CLASSIC
MODEL 92050
2
miniLIFT - Mobile Lift System - MODEL #92050
MANUFACTURER’S INTRODUCTION
ESCO
miniLIFT CLASSIC [Model 92050]
ESCO
ESCO
ESCO
INDEX
2
2
3
3
4
5
6
6
6
6
7
7
7
7
8
9
10
11
11
11
12
12
12
13
miniLIFT - Mobile Lift System - MODEL #92050
3
GENERAL CHARACTERISTICS
miniLIFT
(equivilant to 2.500 KG noted on the unit)
ESCO
DESTINATION OF USE
. If any work is carried out on the
underside of the vehicle when using the lift additional means of support such as, the use of 2 axle stands
is compulsory to ensure the health and safety of the operative.
NOTE
4
miniLIFT - Mobile Lift System - MODEL #92050
Technical characteristics and dimensions table
miniLIFT
DIMENSION UNIT VALUE
Maximum load capacity Lbs.
Maximum height above the ground In.
Minimum height above the ground In.
Width of platform In.
Length of platform In.
Weight of unit with accessories Lbs.
Required PSI Min-Max
Rise time sec.
Descent time sec.
Measures support arm In.
Chart of machine dimensions
miniLIFT - Mobile Lift System - MODEL #92050
5
PACKAGING AND TRANSPORT
miniLIFT
INSTALLATION AND CONNECTIONS
miniLIFT
WARNING
ESCO
Diagram shows
installation of the operation han-
dle. Make sure to tighten screws
completely to ensure handle
does not come off the unit.
6
miniLIFT - Mobile Lift System - MODEL #92050
Pneumatic circuit connection
FREE SAFETY ZONE
PERSONAL PROTECTION
INSTALLATION AND SET UP
miniLIFT
Install Air Nipple (1/4 INCH NPT) into handle
using teon tape (or equivalent). Properly
tighten air nipple onto the handle and test for
any leakes in the connection and/or the air
hose. DO NOT operate miniLIFT with dam-
aged or leaking air hose and/or input nipple.
miniLIFT - Mobile Lift System - MODEL #92050
7
IMPLEMENTATION AND VERIFICATION
LIFTING OPERATION OF MINILIFT
LOWERING OPERATION OF MINILIFT
miniLIFT Classic
RAISING THE MINILIFT
WARNING: Before raising the vehicle be sure that the handbrake is not
activated and the vehicle is in the neutral gear position.
STOP
8
miniLIFT - Mobile Lift System - MODEL #92050
miniLIFT
NOTE: Make sure the lift is in position underneath the
vehicle straight and not at an angle. This will cause for an
unstable lifting of the vehicle and could damage the vehicle.
ESCO is not liable for any damage made to the vehicle due
to the improper use of this lift.
NOTE: Wheel the unit under the vehicle completely attened
down and not in the lifting position. This could cause for the
lift to damage the vehicle.
miniLIFT can lift the vehicle from one end or the
other. the minilift is NOT a full vehicle lift system on
its own.
To lift the entire vehicle, use (2) miniLIFT systems.
DO NOT attempt to lift vehicle using only (1) miniLIFT.
This could result in damage to the vehicle or even
worse serious injury or death.
NOTE: If at any time the back wheels of the miniLIFT begin
to lift off of the ground while the lift is in use STOP IMME-
DIATELY. Slowly release the air from the miniLIFT until the
wheels are back on the ground safely.
REMINDER: miniLIFT must lift on a solid at foundation.
miniLIFT - Mobile Lift System - MODEL #92050
9
WORKING POSITION
DOWN LOAD
SECURITIES
miniLIFT
ESCO
10
miniLIFT - Mobile Lift System - MODEL #92050
PROPER INSTALLATION OF SUPPORT STANDS
All loads MUST BE SUPPORTED by an appropriate support system. The miniLIFT is NOT a support
system It is designed to lift the load, NOT maintain the weight. The proper use of support
stands MUST be applied to the load for proper usage of the miniLIFT system. The miniLIFT system
comes with (2) 2,750 lb. capacity per support stand [5,500 lb. total capacity for (2)] that attach to the
miniLIFT unit for appropriate and safe support of the load while lifted. ESCO recommends using the
provided support stands with the miniLIFT.
NOTE
INSTALLATION:
NOTE: Before installing support
stands, make sure vehicle height
is high enough to manuever stand
under vehicle.
1. Insert the open end of the sup-
port stand into the opening on the
end of the miniLIFT as pictured in
Figure 1 to the left.
2. Once the support stand is in
alignment with the miniLIFT, put the
support stand pin through the hole,
connecting the
support stand to the miniLIFT. Ref-
ere to Figure 2 on the right.
Repeat steps 1. & 2. for the support
stand on the other side of the
vehicle and miniLIFT.
Once the support stands have been properly attached to the miniLIFT
system, slowly lower the lift down until the support stands hit the ground.
Support stands MUST be on a at even surface. Be sure that both support
stands are completely at on the ground and the load has been support-
ed by the stands (See Figure 3 for example).
Once both support stands are securly positioned and the load is no lon-
ger on the miniLIFT, but now on the support stands, the service process
may begin.
miniLIFT - Mobile Lift System - MODEL #92050
11
CORRECT INCORRECT
MINILIFT SAFETY MEASURES
miniLIFT Classic
LIFT INSPECTION AND CARE
CLEANING
12
miniLIFT - Mobile Lift System - MODEL #92050
WARRANTY
miniLIFT
ESCO
ESCO
ESCO
DESTRUCTION
JOURNAL OF THE MACHINE
miniLIFT - Mobile Lift System - MODEL #92050
Available Optional Accessories:
LIFT
MODEL #92050 & MODEL 92055
MODEL #92057
SUV Conversion Set
MODEL #92057
miniLIFT.
LOW
MODEL #92055
Compact Mobile Lift with Lift &
Move System!
This manual suits for next models
1
Table of contents
Popular Lifting System manuals by other brands
Stryker
Stryker 6390 Operation & maintenance manual
Zepro
Zepro ZDK 250 135 installation instructions
Forward Lift
Forward Lift CR4T installation instructions
ERS
ERS RopeFix 40 Translated instruction manual
Tractel
Tractel Davitrac Installation, operating and maintenance manual
Grainger
Grainger LumaPro 24K343B operating instructions
stellar labs
stellar labs SHUTTLE 120-15-13 G Assembly and installation manual
TMG
TMG TMG-ALS61 product manual
JLG
JLG 10msp Service and maintenance manual
WIRTH
WIRTH OKTOPUS GL-K800 operating instructions
MoJack
MoJack WorkBench Instructions for assembly and operation
APlusLift
APlusLift HW-10KBP Installation manual & operation instructions
MELCHOR GABILONDO
MELCHOR GABILONDO MEGA GCB-2 Operation and maintenance instructions
Terex
Terex Genie GS-1532 Service and repair manual
Space
Space SF 5505 IF manual
Pittsburgh
Pittsburgh 63273 owner's manual
Genie
Genie Runabout GR-8 Service manual
PFlow Industries
PFlow Industries 21 Series installation manual