FMI (V)KC36N series Quick start guide

DIRECT-VENT FIREPLACE
OWNER’S OPERATION AND INSTALLATION MANUAL
NATURAL GAS MODELS (V)KC36N SERIES
PROPANE/LP GAS MODELS (V)KC36P SERIES
Patent Pending
For more information, visit www.fmiproducts.com
WARNING: If the information in this manual is not
IROORZHGH[DFWO\D¿UHRUH[SORVLRQPD\UHVXOWFDXVLQJ
SURSHUW\GDPDJHSHUVRQDOLQMXU\RUORVVRIOLIH
² 'R QRW VWRUH RU XVH JDVROLQH RU RWKHU ÀDPPDEOH
YDSRUVDQGOLTXLGVLQWKHYLFLQLW\RIWKLVRUDQ\RWKHU
DSSOLDQFH
— WHAT TO DO IF YOU SMELL GAS
 'RQRWWU\WROLJKWDQ\DSSOLDQFH
 'RQRWWRXFKDQ\HOHFWULFDOVZLWFKGRQRWXVHDQ\
SKRQHLQ\RXUEXLOGLQJ
 ,PPHGLDWHO\FDOO\RXUJDVVXSSOLHUIURPDQHLJKERU¶V
SKRQH)ROORZWKHJDVVXSSOLHU¶VLQVWUXFWLRQV
 ,I\RXFDQQRWUHDFK\RXUJDVVXSSOLHUFDOOWKH¿UH
GHSDUWPHQW
² ,QVWDOODWLRQDQGVHUYLFHPXVWEHSHUIRUPHGE\DTXDOL-
¿HGLQVWDOOHUVHUYLFHDJHQF\RUWKHJDVVXSSOLHU
,167$//(5/HDYHWKLVPDQXDOZLWKWKHDSSOLDQFH
&21680(55HWDLQWKLVPDQXDOIRUIXWXUHUHIHUHQFH
PFS
®
US
All manuals and user guides at all-guides.com
all-guides.com

www.fmiproducts.com 116226-01L2
SAFETY
 :$51,1* ,PSURSHU
LQVWDOODWLRQ DGMXVWPHQW
alteration, service or
maintenance can cause
LQMXU\ RU SURSHUW\ GDP-
DJH5HIHUWRWKLVPDQXDO
for correct installation
DQG RSHUDWLRQDO SURFH-
GXUHV )RU DVVLVWDQFH RU
additional information
FRQVXOW D TXDOLILHG LQ-
staller, service agency or
WKHJDVVXSSOLHU
7KLVDSSOLDQFHPD\EHLQ-
stalled in an aftermarket,*
SHUPDQHQWO\ ORFDWHG
PDQXIDFWXUHG PRELOH
KRPHZKHUHQRWSURKLE-
LWHGE\ORFDOFRGHV
7KLVDSSOLDQFHLVRQO\IRU
XVH ZLWK WKH W\SH RI JDV
indicated on the rating
SODWH 7KLV DSSOLDQFH LV
QRW FRQYHUWLEOH IRU XVH
with other gases, unless
DFHUWL¿HGNLWLVXVHG
$IWHUPDUNHW&RPSOHWLRQRIVDOHQRWIRU
SXUSRVHRIUHVDOHIURPWKHPDQXIDFWXUHU
State of Massachusetts:
7KH LQVWDOODWLRQ PXVW EH
PDGHE\DOLFHQVHGSOXPEHU
RUJDV¿WWHULQWKH&RPPRQ-
ZHDOWKRI0DVVDFKXVHWWV
 :$51,1* 7KLV SURGXFW
contains and/or generates
chemicals known to the State
of California to cause cancer or
ELUWKGHIHFWVRURWKHUUHSURGXF-
WLYHKDUP
,03257$175HDGWKLVRZQHU¶V
PDQXDOFDUHIXOO\DQGFRPSOHWHO\
EHIRUH WU\LQJ WR DVVHPEOH RS-
HUDWH RU VHUYLFH WKLV ORJ VHW
,PSURSHUXVHRIWKLVORJVHWFDQ
FDXVH VHULRXV LQMXU\ RU GHDWK
IURP EXUQV ILUH H[SORVLRQ
HOHFWULFDO VKRFN DQG FDUERQ
PRQR[LGHSRLVRQLQJ
'$1*(5&DUERQPRQR[LGH
SRLVRQLQJPD\OHDGWRGHDWK
7KLV¿UHSODFHPXVWEHLQVWDOOHGE\DTXDOL¿HG
FHUWL¿HGRUOLFHQVHGVHUYLFHSHUVRQ,WKDV
DVHDOHGJDVFRPEXVWLRQFKDPEHUWKDWXVHV
DFRD[LDOSLSHSLSHZLWKLQDSLSHDQGKDYLQJ
WKHVDPHFHQWHUYHQWLQJV\VWHP,WEULQJVLQ
IUHVKDLUIRUFRPEXVWLRQWKURXJKWKHRXWHUSLSH
DQGFRPEXVWLRQJDVHVDUHH[KDXVWHGWKURXJK
WKHLQQHUSLSH,IWKHJODVVGRRUDVVHPEO\DQG
YHQWLQJ SLSH DUH QRW SURSHUO\ VHDWHG FRQ-
QHFWHGDQGVHDOHGFDUERQPRQR[LGHOHDNDJH
VSLOODJHFDQRFFXU
TABLE OF CONTENTS
6DIHW\ 2
3URGXFW,GHQWL¿FDWLRQ 4
/RFDO&RGHV 5
3URGXFW)HDWXUHV 5
3UH,QVWDOODWLRQ3UHSDUDWLRQ 5
/RFDWLRQRI7HUPLQDWLRQ&DS 8
9HQWLQJ,QVWDOODWLRQ 9
)LUHSODFH,QVWDOODWLRQ 19
2SHUDWLRQ 27
,QVSHFWLQJ%XUQHUV 30
&OHDQLQJDQG0DLQWHQDQFH 31
7URXEOHVKRRWLQJ 33
6SHFL¿FDWLRQV 37
5HSODFHPHQW3DUWV 37
6HUYLFH+LQWV 37
7HFKQLFDO6HUYLFH 37
3DUWV 38
$FFHVVRULHV 42
:DUUDQW\%DFN&RYHU
All manuals and user guides at all-guides.com

www.fmiproducts.com
116226-01L 3
&DUERQ 0RQR[LGH 3RLVRQLQJ (DUO\ VLJQV
RIFDUERQPRQR[LGHSRLVRQLQJUHVHPEOHWKH
ÀXZLWKKHDGDFKHVGL]]LQHVVRUQDXVHD,I
\RXKDYHWKHVHVLJQVWKH¿UHSODFHPD\QRW
EHZRUNLQJSURSHUO\*HWIUHVKDLUDWRQFH
+DYH ¿UHSODFH VHUYLFHG 6RPH SHRSOH DUH
PRUHDIIHFWHGE\FDUERQPRQR[LGHWKDQRWK-
HUV7KHVHLQFOXGHSUHJQDQWZRPHQSHRSOH
ZLWKKHDUWRUOXQJGLVHDVHRUDQHPLDWKRVH
XQGHUWKH LQÀXHQFHRI DOFRKRODQGWKRVHDW
KLJKDOWLWXGHV
1DWXUDODQG3URSDQH/3*DV1DWXUDODQG
SURSDQH/3JDVDUHRGRUOHVV$QRGRUPDNLQJ
DJHQWLVDGGHGWRWKHJDV7KHRGRUKHOSV\RX
GHWHFWDJDVOHDN+RZHYHUWKHRGRUDGGHGWR
WKHJDVFDQIDGH*DVPD\EHSUHVHQWHYHQ
WKRXJKQRRGRUH[LVWV
0DNH FHUWDLQ \RX UHDG DQG XQGHUVWDQG DOO
ZDUQLQJV.HHSWKLVPDQXDOIRUUHIHUHQFH,W
LV\RXUJXLGHWRVDIHDQGSURSHURSHUDWLRQRI
WKLV¿UHSODFH
WARNING: Any change to
WKLV¿UHSODFHRULW¶VFRQWUROVFDQ
EH GDQJHURXV 'R QRW PRGLI\
WKLV¿UHSODFHXQGHUDQ\FLUFXP-
VWDQFHV$Q\SDUWVUHPRYHGIRU
VHUYLFLQJPXVWEHUHSODFHGSULRU
WRRSHUDWLQJ¿UHSODFH
WARNING: Do not use a
EORZHU LQVHUW KHDW H[FKDQJHU
insert or other accessory not
DSSURYHGIRUXVHZLWKWKLV¿UH-
SODFH
 :$51,1* 7KLV DSSOLDQFH
LVRQO\IRUXVHZLWKWKHW\SHRI
JDVLQGLFDWHGRQWKHUDWLQJSODWH
7KLVDSSOLDQFHLVQRWFRQYHUWLEOH
for use with other gases unless
DFHUWL¿HGNLWLVXVHG
SAFETY
Continued
WARNING: Do not allow fans
WREORZGLUHFWO\LQWRWKH¿UHSODFH
$YRLGDQ\GUDIWVWKDWDOWHUEXUQHU
ÀDPHSDWWHUQV
'XH WR KLJK WHPSHUDWXUHV WKH
DSSOLDQFHVKRXOGEHORFDWHGRXW
RIWUDI¿FDQGDZD\IURPIXUQLWXUH
DQGGUDSHULHV
'RQRW SODFH FORWKLQJRU RWKHU
ÀDPPDEOH PDWHULDO RQ RU QHDU
WKHDSSOLDQFH1HYHUSODFHDQ\
REMHFWVRQWKHDSSOLDQFH
'RQRWXVHWKLV¿UHSODFHWRFRRN
IRRGRUEXUQSDSHURURWKHUÀDP-
PDEOHPDWHULDO
7KLV¿UHSODFHUHDFKHVKLJKWHP-
SHUDWXUHV .HHS FKLOGUHQ DQG
adults away from hot surface to
DYRLGEXUQVRUFORWKLQJLJQLWLRQ
)LUHSODFH ZLOO UHPDLQ KRW IRU D
WLPHDIWHUVKXWGRZQ$OORZVXU-
IDFHWRFRROEHIRUHWRXFKLQJ
&DUHIXOO\VXSHUYLVH\RXQJFKLO-
dren when they are in the room
ZLWK¿UHSODFH
.HHS WKH DUHD DURXQG \RXU
¿UHSODFH FOHDU RI FRPEXVWLEOH
materials, gasoline and other
ÀDPPDEOHYDSRURUOLTXLGV'R
QRW UXQ ¿UHSODFH ZKHUH WKHVH
DUHXVHGRUVWRUHG
 )RU SURSDQH/3 ¿UHSODFH GR QRW SODFH
SURSDQH/3 VXSSO\ WDQNV LQVLGH DQ\
VWUXFWXUH /RFDWH SURSDQH/3 VXSSO\
WDQNVRXWGRRUV7RSUHYHQWSHUIRUPDQFH
SUREOHPVGRQRWXVHSURSDQH/3IXHOWDQN
RIOHVVWKDQOEVFDSDFLW\
All manuals and user guides at all-guides.com

www.fmiproducts.com 116226-01L4
 ,I\RXVPHOOJDV
 VKXWRIIJDVVXSSO\
 GRQRWWU\WROLJKWDQ\DSSOLDQFH
 GRQRWWRXFKDQ\HOHFWULFDOVZLWFKGR
QRWXVHDQ\SKRQHLQ\RXUEXLOGLQJ
 LPPHGLDWHO\FDOO\RXUJDVVXSSOLHUIURP
D QHLJKERU¶V SKRQH )ROORZ WKH JDV
VXSSOLHUVLQVWUXFWLRQV
 LI\RXFDQQRWUHDFK\RX JDVVXSSOLHU
FDOOWKH¿UHGHSDUWPHQW
 1HYHULQVWDOOWKH¿UHSODFH
 LQDUHFUHDWLRQDOYHKLFOH
 LQZLQG\RUGUDIW\DUHDVZKHUHFXUWDLQV
RU RWKHU FRPEXVWLEOH IODPPDEOH
REMHFWV FDQ PDNH FRQWDFW ZLWK WKH
¿UHSODFHIURQW
 LQKLJKWUDI¿FDUHDV
 7XUQ ILUHSODFH RII DQG OHW FRRO EHIRUH
VHUYLFLQJ LQVWDOOLQJ RU UHSDLULQJ 2QO\ D
TXDOL¿HG VHUYLFH SHUVRQ VKRXOG LQVWDOO
VHUYLFHRUUHSDLUWKLV¿UHSODFH+DYH¿UH-
SODFH LQVSHFWHG DQQXDOO\ E\ D TXDOL¿HG
VHUYLFHSHUVRQ
 <RX PXVW NHHS FRQWURO FRPSDUWPHQWV
EXUQHUV DQG FLUFXODWLQJ DLU SDVVDJHV
FOHDQ 0RUH IUHTXHQW FOHDQLQJ PD\ EH
QHHGHG GXH WR H[FHVVLYH OLQW DQG GXVW
SAFETY
Continued
IURP FDUSHWLQJ EHGGLQJ PDWHULDO HWF
7XUQRIIWKHJDVYDOYHDQGSLORWOLJKWEHIRUH
FOHDQLQJ¿UHSODFH
 +DYHYHQWLQJV\VWHPLQVSHFWHGDQQXDOO\E\
DTXDOL¿HGVHUYLFHSHUVRQ,IQHHGHGKDYH
YHQWLQJV\VWHPFOHDQHGRUUHSDLUHG6HH
Cleaning and MaintenanceSDJH
 'RQRWXVH DQ\VROLG IXHOV ZRRGFRDO
SDSHU FDUGERDUG HWF LQ WKLV ¿UHSODFH
8VHRQO\WKHJDVW\SHLQGLFDWHGRQ¿UH-
SODFHQDPHSODWH
 7KLVDSSOLDQFHZKHQLQVWDOOHGPXVWEH
HOHFWULFDOO\JURXQGHGLQDFFRUGDQFHZLWK
ORFDO FRGHV RU LQ WKH DEVHQFH RI ORFDO
FRGHVZLWKWKHNational Electrical Code,
ANSI/NFPA 70.
 'RQRWXVH¿UHSODFHLIDQ\SDUWKDVEHHQ
H[SRVHGWRRUXQGHUZDWHU,PPHGLDWHO\
FDOODTXDOL¿HGVHUYLFHSHUVRQWRDUUDQJH
IRUUHSODFHPHQWRIWKHXQLW
'R QRW RSHUDWH ¿UHSODFH LI DQ\ ORJ LV
EURNHQ
'RQRWRSHUDWH¿UHSODFHZLWKJODVVGRRU
UHPRYHGFUDFNHGRUEURNHQ
3URYLGHDGHTXDWHFOHDUDQFHVDURXQGDLU
RSHQLQJV
Figure 1 - Direct-Vent Fireplace with Millivolt Ignition
*ODVV'RRU
$VVHPEO\
6ZLWFK%UDFNHWIRU2SWLRQDO
5HPRWHDQG%ORZHU
&RQWURO9DOYH
ZLWK3LH]R,JQLWRU
/RJ6HW
/DYD
5RFN
*ORZLQJ
(PEHUV
8SSHU/RXYHU3DQHO
/RZHU
/RXYHU
3DQHO
)OXH&ROODU
1DLOLQJ
)ODQJH
%XUQHU
$VVHPEO\
$QGLURQ
$VVHPEO\
PRODUCT IDENTIFICATION
All manuals and user guides at all-guides.com

www.fmiproducts.com
116226-01L 5
PRODUCT FEATURES
Figure 2 - Common Fireplace Locations
)OXVKZLWKDZDOO
7KURXJKH[WHULRUZDOO
HQFORVHGLQDFKDVH
&RUQHU
LQVWDOODWLRQ
Figure 3 - Fireplace Bottom Dimensions
D
RW
FW
21 18"
29"
41"
LOCATION AND SPACE
REQUIREMENTS
'HWHUPLQHWKHVDIHVWDQGPRVWHI¿FLHQWORFD-
WLRQIRU\RXU)0,352'8&76//&GLUHFWYHQW
¿UHSODFH 0DNH VXUH WKDW UDIWHUV DQG ZDOO
VWXGVDUHQRWLQWKHZD\RIWKHYHQWLQJV\VWHP
&KRRVHDORFDWLRQZKHUHWKHKHDWRXWSXWLV
QRWDIIHFWHGE\GUDIWVDLUFRQGLWLRQLQJGXFWV
ZLQGRZVRUGRRUV)LJXUHVKRZVVRPHFRP-
PRQORFDWLRQV%HDZDUHRIDOOUHVWULFWLRQVDQG
SUHFDXWLRQVEHIRUHGHFLGLQJWKHH[DFWORFDWLRQ
IRU\RXU¿UHSODFHDQGWHUPLQDWLRQFDS
:KHQGHFLGLQJWKHORFDWLRQRI\RXU¿UHSODFH
IROORZWKHVHUXOHV
 'RQRWFRQQHFWWKLV¿UHSODFHYHQWLQJWRD
FKLPQH\ÀXHVHUYLQJDVHSDUDWHVROLGIXHO
EXUQLQJ¿UHSODFHRUDSSOLDQFH
 'XHWRKLJKWHPSHUDWXUHVGRQRWORFDWHWKLV
¿UHSODFHLQKLJKWUDI¿FDUHDVZLQG\RUGUDIW\
DUHDVRUQHDUIXUQLWXUHRUGUDSHULHV
 3URSHUFOHDUDQFHVPXVWEHPDLQWDLQHG
LOCAL CODES
7KHVHDUHDIHZIDFWVWKDWFDQKHOS\RXXQGHU-
VWDQGDQGHQMR\\RXUGLUHFWYHQW¿UHSODFH
 7KHYHQWLQJV\VWHPPD\EHURXWHGWRWKH
RXWVLGH RI \RXU KRPH LQ VHYHUDO ZD\V ,W
PD\ YHQW WKURXJK WKH URRI YHUWLFDO RU LW
PD\YHQWWRDQRXWVLGHH[WHULRUZDOOKRUL-
]RQWDO7KH YHQWSLSHLQVWDOODWLRQ LV YHU\
LPSRUWDQW WR DOORZ IRU SURSHU RSHUDWLRQ
<RX PXVW IROORZ WKH YHQWLQJ LQVWUXFWLRQV
YHU\FDUHIXOO\IRUHLWKHUYHUWLFDORUKRUL]RQWDO
DSSOLFDWLRQV
 7KLV¿UHSODFHPD\EHLQVWDOOHGLQDQ\URRP
RI\RXUKRXVHSURYLGHGDOOORFDOFRGHVDQG
WKHVHLQVWDOODWLRQLQVWUXFWLRQVDUHIROORZHG
 7KLV¿UHSODFHUHTXLUHVDZDOOVZLWFKKDQG
KHOGUHPRWHRUZDOOWKHUPRVWDWPLOOLYROWIRU
RSHUDWLRQVHHAccessoriesSDJH
 7KLV¿UHSODFHGRHV QRWUHTXLUHHOHFWULFLW\
WRRSHUDWH
 2QO\ WKH EORZHU UHTXLUHV HOHFWULFLW\ LI LQ-
VWDOOHGDQGLI\RXSODQWRLQVWDOOWKHEORZHUDW
DODWHUGDWHGRQRWIRUJHWWRZLUHWKHRXWOHWDW
WKHERWWRPRIWKH¿UHSODFHZKHQIUDPLQJ
 $SLH]RLJQLWRUDQGFHUDPLFHOHFWURGHFUH-
DWHVSDUNWRLJQLWHWKHSLORWOLJKW,WGRHVQRW
UHTXLUHDQ\PDWFKHVEDWWHULHVRUDQ\RWKHU
VRXUFHVRILJQLWLRQWROLJKWWKHSLORW
 (DFKWLPH\RXWXUQRQ\RXU¿UHSODFH\RX
PD\QRWLFHVRPHDPRXQWRIFRQGHQVDWLRQ
RQ WKH LQVLGH RI WKH ¿UHSODFH JODVV 7KLV
LV QRUPDO DQG ZLOO GLVDSSHDU DIWHU 
PLQXWHVRIRSHUDWLRQ
 <RXU GLUHFWYHQW JDV ILUHSODFH V\VWHP
¿UHSODFHDQGYHQWLQJLVDEDODQFHGDQG
VHDOHGJDVRSHUDWLQJXQLW,WUHTXLUHVDS-
SUR[LPDWHO\  PLQXWHV RI RSHUDWLQJ
WLPHEHIRUHWKHÀDPHSDWWHUQVWDELOL]HV
 )LUHSODFHVZLWKWKHVXI¿[RI+$KDYHEHHQ
GHVLJQHG WR RSHUDWH DW DOWLWXGHV RI 
IHHWDQGDERYH
PRE-INSTALLATION PREPARATION
,QVWDOODQGXVH¿UHSODFHZLWKFDUH)ROORZDOO
ORFDOFRGHV,Q WKHDEVHQFHWR ORFDO FRGHV
XVHWKHFXUUHQWNational Fuel Gas Code ANSI
Z223.1/NFPA 54*
$YDLODEOHIURP
$PHULFDQ1DWLRQDO6WDQGDUGV,QVWLWXWH,QF
%URDGZD\
1HZ<RUN1<
1DWLRQDO)LUH3URWHFWLRQ$VVRFLDWLRQ,QF
%DWWHU\PDUFK3DUN
4XLQF\0$
All manuals and user guides at all-guides.com

www.fmiproducts.com 116226-01L6
 ,I\RXU¿UHSODFHLVWREHLQVWDOOHGGLUHFWO\RQ
FDUSHWLQJYLQ\OWLOHRUDQ\FRPEXVWLEOHPD-
WHULDORWKHUWKDQZRRGLWPXVWEHLQVWDOOHG
RQDPHWDORUZRRGSDQHOH[WHQGLQJWKHIXOO
ZLGWKDQGGHSWKRIWKH¿UHSODFH6HH)LJXUH
SDJH
 <RXU ¿UHSODFH LV GHVLJQHG WR EH XVHG LQ
]HURFOHDUDQFHLQVWDOODWLRQV:DOORUIUDPLQJ
PDWHULDOFDQEHSODFHGGLUHFWO\DJDLQVWDQ\
H[WHULRUVXUIDFHRQWKHEDFNVLGHVRUWRSRI
\RXU¿UHSODFHH[FHSWZKHUHVWDQGRIIVSDF-
HUVDUHLQWHJUDOO\DWWDFKHG,IVWDQGRIIVSDF-
HUV DUH DWWDFKHG WR \RXU ¿UHSODFH WKHVH
VSDFHUVFDQEHSODFHGGLUHFWO\DJDLQVWZDOO
RUIUDPLQJPDWHULDO6HHIUDPLQJGHWDLOVRQ
SDJH
 ,I \RX SODQ RQ LQVWDOOLQJ D WHOHYLVLRQ RU
HQWHUWDLQPHQW FHQWHU UHFHVVHG DERYH
\RXU¿UHSODFHLWLVUHFRPPHQGHGWKDW\RX
PDLQWDLQDPLQLPXPDERYHWRSRIORXYHU
RSHQLQJ
 :KHQORFDWLQJWHUPLQDWLRQFDSLWLVLPSRU-
WDQW WR REVHUYH WKH PLQLPXP FOHDUDQFHV
VKRZQLQ)LJXUHSDJH
 ,IUHFHVVLQJLQWRDZDOO\RXFDQDYRLGH[WUD
IUDPLQJE\SRVLWLRQLQJ\RXU¿UHSODFHDJDLQVW
DQDOUHDG\H[LVWLQJIUDPLQJPHPEHU
 'RQRWUHFHVVWHUPLQDWLRQFDSLQWRDZDOO
RUVLGLQJ
 <RX PD\ SDLQW WKH WHUPLQDWLRQ FDS ZLWK
 )  & KHDWUHVLVWDQW SDLQW WR
FRRUGLQDWHZLWKWKHH[WHULRU¿QLVK
 7KHUH PXVW QRW EH DQ\ REVWUXFWLRQ VXFK
DV EXVKHV JDUGHQ VKHGV IHQFHV GHFNV
RUXWLOLW\EXLOGLQJVZLWKLQIURPWKHIURQW
RIWKHWHUPLQDWLRQFDS
 'RQRWORFDWHWHUPLQDWLRQFDSZKHUHH[FHV-
VLYHVQRZRULFHEXLOGXSPD\RFFXU%HVXUH
WRFOHDUYHQWWHUPLQDWLRQDUHDDIWHUVQRZIDOOV
WR SUHYHQW DFFLGHQWDO EORFNDJH RI YHQWLQJ
V\VWHP:KHQXVLQJVQRZEORZHUVGRQRW
GLUHFWVQRZWRZDUGVYHQWWHUPLQDWLRQDUHD
 )RU KRUL]RQWDO LQVWDOODWLRQV DERYH 
IHHWLWLVUHFRPPHQGHGWKDWDH[WHQVLRQ
SLSHEHDGGHGEHIRUHVWDUWHUHOERZDQGD
URXQGKRUL]RQWDOWHUPLQDWLRQEHXVHGVHH
High Altitude InstallationSDJH
PRE-INSTALLATION PREPARATION
Continued
CLEARANCES
0LQLPXPFOHDUDQFHVWRFRPEXVWLEOHVIRUWKH
¿UHSODFHDUHDVIROORZV
%DFNDQGVLGHV FP
3HUSHQGLFXODUZDOOV FP
)ORRU FP
&HLOLQJWRORXYHURSHQLQJ FP
)URQW FP
7RSRI6WDQGRIIV FP
9HQW 6HHYHQWLQJLQVWUXFWLRQV
IRUVSHFL¿FYHQWLQJFOHDU-
DQFHV
&RPEXVWLEOHPDWHULDOZLWKDPD[LPXPWKLFN-
QHVVRIPD\EHÀXVKZLWKWKHWRSIURQW
RI¿UHSODFH
)RUEDFNDQGVLGHVRI¿UHSODFHGRQRWSDFN
ZLWK LQVXODWLRQ RU RWKHU PDWHULDOV  FOHDU-
DQFHWRFRPEXVWLEOHPDWHULDOVDUHIRUIUDPLQJ
SXUSRVHRQO\
127,&( 7KLV ¿UHSODFH LV LQ-
WHQGHGIRUXVHDVVXSSOHPHQWDO
KHDW 8VH WKLV ¿UHSODFH DORQJ
ZLWK\RXUSULPDU\KHDWLQJV\V-
WHP'RQRWLQVWDOOWKLV¿UHSODFH
DV \RXU SULPDU\ KHDW VRXUFH
If you have a central heating
V\VWHP\RXPD\UXQV\VWHP¶V
FLUFXODWLQJ EORZHU ZKLOH XVLQJ
¿UHSODFH7KLVZLOOKHOSFLUFXODWH
WKHKHDWWKURXJKRXWWKHKRXVH
,QWKHHYHQWRIDSRZHURXWDJH
\RXFDQXVHWKLV¿UHSODFHDVD
KHDWVRXUFH
FRAMING AND FINISHING
)LJXUH  VKRZV W\SLFDO IUDPLQJ RI WKLV ¿UH-
SODFH )LJXUH  SDJH  VKRZV IUDPLQJ IRU
FRUQHU LQVWDOODWLRQ$OO PLQLPXP FOHDUDQFHV
PXVWEHPHW
)RU DYDLODEOH DFFHVVRULHV IRU WKLV ¿UHSODFH
VHHAccessoriesRQSDJH,I\RXDUHXVLQJ
DVHSDUDWHFRPEXVWLEOHPDQWHOSLHFHUHIHUWR
)LJXUHIRUSURSHULQVWDOODWLRQKHLJKW<RXFDQ
LQVWDOOQRQFRPEXVWLEOHPDQWHOVDWDQ\KHLJKW
DERYHWKH¿UHSODFH
Note: Noncombustible mantels may dis-
color!
All manuals and user guides at all-guides.com
all-guides.com

www.fmiproducts.com
116226-01L 7
Figure 4 - Framing Clearances for
Installation Against an Exterior Wall
C
B
A
DE
FG
Top of Louver
Opening
3
2
1
4
5
6
7
Wall
Figure 5 - Framing Clearances for Corner
Installation
5HI 0DQWHO'HSWK 5HI
0DQWHOIURP
7RSRI/RXYHU
2SHQLQJ
1FP A FP
2FP % FP
3FP & FP
4FP ' FP
5FP E FP
6FP ) FP
7FP * FP
Figure 6 - Clearances for Combustible
Mantels
PRE-INSTALLATION PREPARATION
Continued
36 18"
41 14"
+RUL]RQWDO9HQW
24 129HUWLFDO9HQW
A
B
E
F
G
H
DC
Nailing Tabs
41"
41 14"
35 34"
49 58"
13 34"
68 12"
1038"
1DLOLQJ
7DEV
15"
All manuals and user guides at all-guides.com

www.fmiproducts.com 116226-01L8
Fixed
Closed OpenableFixed
Closed
V
V
V
V
VV
V
V
X
X
VX
G
G
J
F
B
B
K
N
H
I
A
N
E
L
D
B
M
A
C
B
V
V
A
G
G
B
TERMINATION CAP AIR SUPPLY INLET GAS METERRESTRICTED AREA
(TERMINATION PROHIBITED)
A = clearance above grade, veranda, porch, deck, or
balcony [*12" (30.5 cm) minimum]
B = clearance to window or door that may be opened
[6" (15 cm) min. for 10,000 Btu or less; 9" (23 cm) in US
if between 10,000 and 50,000, 12" (30 cm) in Canada
if between 10,000 and 100,000; 12" (30 cm) in US if
greater than 50,000, 36" (91 cm) in Canada if greater
than 100,000]
C = clearance to permanently closed window
[minimum 12" (30.5 cm) recommended to prevent
condensation on window]
D = vertical clearance to ventilated soffit located above the
terminal within a horizontal distance of 24" (61 cm) from
the center-line of the terminal [18" (45.7 cm) minimum]
E = clearance to unventilated soffit [12" (30.5 cm) minimum]
F = clearance to outside corner (see below)
G = clearance to inside corner (see below)
H = *not to be installed above a meter/regulator assembly
within 36" (91.4 cm) horizontally from the center line
of the regulator
I = clearance to service regulator vent outlet [*72" (182.9 cm)
minimum]
J = clearance to non-mechanical air supply inlet to building
or the combustion air inlet to any other fireplace
[6" (15 cm) min. for 10,000 Btu or less; 9" (23 cm) in US
if between 10,000 and 50,000, 12" (30 cm) in Canada
if between 10,000 and 100,000; 12" (30 cm) in US if
greater than 50,000, 36" (91 cm) in Canada if greater
than 100,000]
K = clearance to a mechanical air supply inlet [*In Canada,
6 ft. (1.83m) minimum; In US 3 ft. (91 cm) above if within
10 ft. (3 m) horizontally]
L = † clearance above paved side-walk or a paved driveway
located on public property [*84" (213.3 cm) minimum]
M = clearance under veranda, porch, deck
[*12" (30.5 cm) minimum ‡]
N = clearance above a roof shall extend a minimum of
24" (61 cm) above the highest point when it passes
through the roof surface and any other obstruction within
a horizontal distance of 18" (45.7 cm)
† vent shall not terminate directly above a side-walk or paved driveway which is located between two
single family dwellings and serves both dwellings*
‡ only permitted if veranda, porch, deck or balconey is fully open on a minimum of 2 sides beneath the floor*
* as specified in CAN/CSA B149 (.1 or .2) Installation Codes (1991) for Canada and U.S.A.
Note: Local codes or regulations may require different clearances
A = 6" (15.2 cm)
Inside Corner
V
B
E
V
B = 6" (15.2 cm)
C = Maximum depth of 48" (121.9 cm)
for recessed location
D = Minimum width for back wall of
recessed location -
Combustible - 38" (965 mm)
Noncombustible - 24" (61 cm)
E = Clearance from corner in
recessed location-
Combustible - 6" (15.2 cm)
Noncombustible - 2" (5.1 cm)
Outside Corner Recessed Location
G
H
G = 12" (30.5 cm) minimum clearance
Balcony with No Side Wall
V
J
Combustible &
Noncombustible
H = 24" (61 cm)
J = 20" (50.8 cm)
Balcony with Perpendicular Side Wall
C
D
C
Termination Clearances for Buildings with Combustible and Noncombustible Exteriors
Openable
Figure 7 - Minimum Clearances for Termination Cap
LOCATION OF TERMINATION CAP
All manuals and user guides at all-guides.com

www.fmiproducts.com
116226-01L 9
VENTING INSTALLATION
NOTICE:Failure tofollowthese in-
VWUXFWLRQVZLOOYRLGWKHZDUUDQW\
NOTICE: Do not seal termination
FDSWRYHQWSLSH&DSPXVWEH
UHPRYDEOH IRU YHQW LQVSHFWLRQ
DQGPDLQWHQDQFH
INSTALLATION PRECAUTIONS
 :HDUJORYHVDQGVDIHW\JODVVHVIRUSURWHF-
WLRQ
 8VHH[WUHPHFDXWLRQZKHQXVLQJODGGHUV
RUZKHQRQURRIWRSV
 %H DZDUH RI HOHFWULFDO ZLULQJ ORFDWLRQV LQ
ZDOOVDQGFHLOLQJV
7KHIROORZLQJDFWLRQV ZLOO YRLGWKHZDUUDQW\
RQ\RXUYHQWLQJV\VWHP
 ,QVWDOODWLRQRIDQ\GDPDJHGYHQWLQJFRP-
SRQHQW
 8QDXWKRUL]HG PRGL¿FDWLRQ RI WKH YHQWLQJ
V\VWHP 'R QRW FXW RU DOWHU YHQW FRPSR-
QHQWV
 ,QVWDOODWLRQ RI DQ\ FRPSRQHQW SDUW QRW
PDQXIDFWXUHGRUDSSURYHGE\)0,352'-
8&76//&
 ,QVWDOODWLRQ RWKHU WKDQ DV LQVWUXFWHG E\
WKHVHLQVWUXFWLRQV
:$51,1*7KLVJDV¿UHSODFH
DQG YHQW DVVHPEO\ PXVW EH
YHQWHG GLUHFWO\ WR WKH RXWVLGH
TheventingsystemmustNEVER
EHDWWDFKHGWRDFKLPQH\VHUY-
LQJDVHSDUDWHVROLGIXHOEXUQLQJ
DSSOLDQFH(DFKGLUHFWYHQWJDV
DSSOLDQFHPXVWXVHDVHSDUDWH
YHQW V\VWHP 'R QRW XVH FRP-
PRQYHQWV\VWHPV
 :$51,1* 9HQW SLSH DLU
VSDFH FOHDUDQFHV WR FRPEXV-
WLEOHVDUHRQDOOVLGHVH[FHSW
on the horizontal sections,
ZKLFK UHTXLUH  FOHDUDQFHV
IURPWKHWRSRIWKHSLSH:KHUH
WKHWHUPLQDWLRQFDSSHQHWUDWHV
DFRPEXVWLEOHZDOODLUVSDFH
FOHDUDQFHLVUHTXLUHG
NOTICE: Read these instruc-
WLRQVFRPSOHWHO\EHIRUHDWWHPSW-
LQJLQVWDOODWLRQ
7KHVH PRGHOV DUH WHVWHG DQG DSSURYHG IRU
XVHZLWK)0,352'8&76//&GLUHFWYHQW
SLSHFRPSRQHQWVDQGWHUPLQDWLRQV
7KHYHQWLQJV\VWHPPXVWWHUPLQDWHRQWKHRXW-
VLGHRIWKHVWUXFWXUHDQGFDQQRWEHDWWDFKHG
WRDFKLPQH\RUÀXHV\VWHPVHUYLQJDVHSDUDWH
VROLGIXHORUJDVEXUQLQJDSSOLDQFH$GLUHFWYHQW
DSSOLDQFHPXVWKDYHLWVRZQYHQWLQJV\VWHP
'2127FRPPRQYHQWWKLVDSSOLDQFH
7KHVH PRGHOV DUH DSSURYHG WR EH YHQWHG
HLWKHUKRUL]RQWDOO\WKURXJKDQRXWVLGHZDOORU
YHUWLFDOO\WKURXJKDURRIRUFKDVHHQFORVXUH
XVLQJWKHIROORZLQJJXLGHOLQHV
 :KHQYHQWLQJV\VWHPWHUPLQDWHVKRUL]RQ-
WDOO\ RQ DQ RXWVLGH ZDOO \RX PD\ LQVWDOO
D VWDQGRII LI WKH WHUPLQDWLRQ FDS LV WR EH
LQVWDOOHG GLUHFWO\ RQ D FRPEXVWLEOH ¿QLVK
VXFKDVYLQ\OZRRGVWXFFRHWF
 1HYHUUXQWKHYHQWGRZQZDUGDVWKLVPD\
FDXVHH[FHVVLYHWHPSHUDWXUHVZKLFKFRXOG
FDXVHD¿UH
 9HQW SLSH DLU VSDFH FOHDUDQFHV WR FRP-
EXVWLEOHVDUHRQDOOVLGHVH[FHSWRQWKH
KRUL]RQWDOVHFWLRQVZKLFKUHTXLUHVFOHDU-
DQFHIURPWKHWRSRIWKHSLSH:KHUHWKH
WHUPLQDWLRQFDSSHQHWUDWHVDFRPEXVWLEOH
ZDOODLUVSDFHFOHDUDQFHLVUHTXLUHG
 6QRUNHO WHUPLQDWLRQV DUH UHTXLUHG ZKHQ
PLQLPXP FOHDUDQFH WR JUDGH FDQQRW EH
PHWVHH)LJXUHRQSDJH
 +DYH¿UHSODFHDQGVHOHFWHGYHQWFRPSR-
QHQWVRQKDQGWRKHOSGHWHUPLQHWKHH[DFW
PHDVXUHPHQWVZKHQHOERZLQJRURIIVHWWLQJ
$OZD\VXVHZDOO¿UHVWRSVZKHQSHQHWUDWLQJ
ZDOOVDQG¿UHVWRSVZKHQSHQHWUDWLQJFHLO-
LQJVRUDWWLFVSDFHV
 ,I XVLQJ D YHQWLQJ FRQ¿JXUDWLRQ RI RQO\
KRUL]RQWDO YHQWLQJ ZLWK QR YHUWLFDO UXQ D
 ULVH IRU HYHU\  RI UXQ WRZDUG WKH
WHUPLQDWLRQLVUHTXLUHG
 )RULQVWDOODWLRQRI¿UHSODFHDWHOHYDWLRQVRI
IHHWRUJUHDWHUSD\VSHFLDODWWHQWLRQ
WRYHQWLQJUHTXLUHPHQWUHFRPPHQGDWLRQV
WARNING:Readallinstructions
FRPSOHWHO\DQGWKRURXJKO\EHIRUH
DWWHPSWLQJ LQVWDOODWLRQ )DLOXUH WR
GRVRFRXOGUHVXOWLQVHULRXVLQMXU\
SURSHUW\GDPDJHRUORVVRIOLIH
All manuals and user guides at all-guides.com

www.fmiproducts.com 116226-01L10
INSTALLATION PLANNING
7KHUH DUH WZR EDVLF W\SHV RI GLUHFWYHQW
LQVWDOODWLRQ
 +RUL]RQWDO7HUPLQDWLRQ
 9HUWLFDO7HUPLQDWLRQ
Horizontal Termination Installation
IMPORTANT+RUL]RQWDOVTXDUHWHUPLQDWLRQV
UHTXLUHRQO\LQQHUSRUWLRQRIZDOO¿UHVWRS+RUL-
]RQWDO LQVWDOODWLRQV XVLQJ URXQG WHUPLQDWLRQ
UHTXLUHH[WHULRU SRUWLRQRI ZDOO¿UHVWRS VHH
)LJXUHSDJH
 6HW ¿UHSODFH LQ LWV GHVLUHG ORFDWLRQ DQG
GHWHUPLQH URXWH \RXU KRUL]RQWDO YHQWLQJ
ZLOOWDNH'RQRWVHFXUH¿UHSODFHXQWLODOO
YHQWLQJKDVEHHQLQVWDOOHG6RPHLQVWDO-
ODWLRQVUHTXLUHVOLGLQJ¿UHSODFHLQDQGRXW
RISRVLWLRQWRPDNH¿QDOYHQWLQJFRQQHF-
WLRQV)LJXUHVWKURXJKRQSDJHV
WKURXJKVKRZGLIIHUHQWFRQ¿JXUDWLRQV
IRUYHQWLQJZLWKKRUL]RQWDOWHUPLQDWLRQWKDW
ZLOOKHOS\RXGHFLGHZKLFKDSSOLFDWLRQEHVW
VXLWV\RXULQVWDOODWLRQ&KHFNWRVHHLIZDOO
VWXGVRUURRIUDIWHUVDUHLQWKHSDWKRI\RXU
GHVLUHGYHQWLQJURXWH,IWKH\DUH\RXPD\
ZDQWWRDGMXVWORFDWLRQRI¿UHSODFH
 'LUHFWYHQWSLSHVHFWLRQVDQGFRPSRQHQWV
DUHGHVLJQHGZLWKVSHFLDOWZLVWORFNFRQ-
QHFWLRQV
Twist-Lock Procedure:)HPDOHHQGVRI
SLSHV KDYH ORFNLQJ OXJV LQGHQWDWLRQV
7KHVHOXJVZLOOVOLGHVWUDLJKWLQWRPDWFK-
LQJVORWVRQPDOHHQGVRIDGMDFHQWSLSHV
3XVK SLSH VHFWLRQV WRJHWKHU DQG WZLVW
RQHVHFWLRQFORFNZLVHDSSUR[LPDWHO\RQH
TXDUWHUWXUQXQWLOVHFWLRQVDUHIXOO\ORFNHG
VHH)LJXUHNote: Horizontal runs of
vent must be supported every three feet.
Use wall straps for this purpose.
 8VHDHOERZWRFRQQHFWYHQWLQJV\V-
WHPWR¿UHSODFHÀXHFROODU7KHHOERZLV
GHVLJQHGWREHWZLVWORFNHGRQWRÀXHFROODU
DVGHVFULEHGLQVWHSIMPORTANT:'R
QRWDWWHPSWWRDOWHUFRQ¿JXUDWLRQRIHOERZ
E\FXWWLQJWZLVWLQJEHQGLQJHWF
 $VVHPEOH GHVLUHG FRPELQDWLRQ RI SLSH
DQGHOERZVWR¿UHSODFHÀXHFROODU,IWKHUH
DUHORQJSRUWLRQVRIYHQWLQJUXQSUHDV-
VHPEOHGSLSHVHFWLRQVPD\EHLQVWDOOHG
DVVXEDVVHPEOLHVIRUFRQYHQLHQFH
VENTING INSTALLATION
Continued
Figure 8 - Vent Pipe Connections
)HPDOH/RFNLQJ/XJV
0DOH6ORWV
(Framing
Detail)
11
1
/ 2 "
(29.2 cm)
11
1
/ 2 " Inside Framing
(29.2 cm)
11
1
/ 2 "
(29.2 cm)
8
1
/ 2 "
(21.6 cm)
Vent
O
pening
Combustible Wall
Vent Opening
Noncombustible Wall
Figure 9 - Vent Opening Requirements
&HQWHURI
+ROH
 &DUHIXOO\GHWHUPLQHORFDWLRQZKHUHYHQW
SLSH DVVHPEO\ ZLOO SHQHWUDWH RXWVLGH
ZDOO&HQWHURIKROHVKRXOGOLQHXSZLWK
FHQWHUOLQHRIKRUL]RQWDOYHQWSLSH0DUN
ZDOO IRU D  12 [  12 VTXDUH KROH
&XW DQG IUDPH VTXDUH KROH LQ H[WHULRU
ZDOOZKHUHYHQWZLOOEHWHUPLQDWHG,IZDOO
EHLQJSHQHWUDWHGLVFRQVWUXFWHGRIQRQ-
FRPEXVWLEOHPDWHULDOVXFKDVPDVRQU\
EORFNRUFRQFUHWHD12KROHZLWK]HUR
FOHDUDQFHLVDFFHSWDEOHVHH)LJXUH
All manuals and user guides at all-guides.com

www.fmiproducts.com
116226-01L 11
VENTING INSTALLATION
Continued
WARNING: Do not recess
YHQWWHUPLQDWLRQ LQWR DQ\ZDOO
7KLVZLOOFDXVHD¿UHKD]DUG
 1RQFRPEXVWLEOH ([WHULRU :DOO 3RVL-
WLRQKRUL]RQWDOYHQWFDSLQFHQWHURIWKH
12URXQGKROHDQGDWWDFKWRH[WHULRUZDOO
ZLWKIRXUZRRGVFUHZVSURYLGHG%HIRUH
DWWDFKLQJYHQWFDSWRH[WHULRUZDOOUXQD
EHDG RI QRQKDUGHQLQJ PDVWLF SOLDEOH
VHDODQWDURXQGRXWVLGHHGJHVWRPDNHD
VHDOEHWZHHQLWDQGRXWVLGHZDOO
Note: Four wood screws provided should
be replaced with appropriate fasteners for
stucco, brick, concrete or other types of
sidings.
&RPEXVWLEOH ([WHULRU :DOO )RU YLQ\O
VLGLQJVWXFFRRUZRRGH[WHULRUVDVLGLQJ
VWDQGRII PD\ EH LQVWDOOHG EHWZHHQ YHQW
FDS DQG H[WHULRU ZDOO 6LGLQJ VWDQGRII
SUHYHQWVH[FHVVLYHKHDWIURPGDPDJLQJ
VLGLQJPDWHULDOV6LGLQJPDWHULDOPXVWEH
FXW WR DFFRPPRGDWH VWDQGRII %ROW YHQW
FDS WR VWDQGRII$SSO\ QRQKDUGHQLQJ
PDVWLFDURXQGRXWVLGHHGJHRIVWDQGRII
3RVLWLRQVWDQGRIIFDSDVVHPEO\LQFHQWHU
RI12VTXDUHKROHDQGDWWDFKWRH[WH-
ULRUZDOOZLWKZRRGVFUHZVSURYLGHGVHH
)LJXUH6LGLQJVWDQGRIIPXVWVLWÀXVK
DJDLQVWH[WHULRUIDVFLDPDWHULDO
 &RQQHFWLQJ9HQW&DSZLWK+RUL]RQWDO
9HQW3LSH6OLGHZDOO¿UHVWRS RYHUYHQW
SLSHEHIRUHFRQQHFWLQJKRUL]RQWDOUXQWR
YHQWFDSVHH)LJXUH
&DUHIXOO\ PRYH ¿UHSODFH ZLWK YHQW DV-
VHPEO\DWWDFKHGWRZDUGZDOODQGLQVHUW
YHQWSLSHLQWRKRUL]RQWDOWHUPLQDWLRQ3LSH
RYHUODSVKRXOGEHDPLQLPXPRI14VHH
)LJXUHSDJH
 6OLGH ZDOO ¿UHVWRS DJDLQVW LQWHULRU ZDOO
VXUIDFHDQGDWWDFKZLWKVFUHZVSURYLGHG
6HH )LJXUH  SDJH  IRU KRUL]RQWDO
WHUPLQDWLRQGHWDLOV
 3ODFH¿UHSODFHLQWRSRVLWLRQDQGVKLPZLWK
QRQFRPEXVWLEOHPDWHULDOLIQHHGHG1DLORU
VFUHZVLGHÀDQJHVWRIUDPLQJWRVHFXUH
XQLWLQSODFHIMPORTANT:0DNHVXUH¿UH-
SODFHLVOHYHOEHIRUHVHFXULQJ,I¿UHSODFH
LVQRWOHYHOLWZLOOQRWZRUNSURSHUO\
Figure 10 - Installing Horizontal Vent Cap
(Noncombustible Exterior)
:RRG6FUHZ
9HQW&DS
Figure 11 - Installing Siding Standoff
(Combustible Exterior Wall)
&XW6LGLQJ$ZD\
WR)LW6WDQGRII
:RRG
6FUHZ
6FUHZV
6WDQGRII
9HQW
&DS
$SSO\0DVWLFWR
$OO)RXU6LGHV
9HQW&DS
+RUL]RQWDO
7HUPLQDWLRQ
,QWHULRU:DOO
6XUIDFH
:DOO)LUHVWRS
+RUL]RQWDO
9HQW3LSH
Figure 12 - Connecting Vent Cap with
Horizontal Vent Pipe
6FUHZ
$SSO\0DVWLFWR
$OO)RXU6LGHV
All manuals and user guides at all-guides.com
all-guides.com

www.fmiproducts.com 116226-01L12
VENTING INSTALLATION
Continued
Figure 13 - Typical Horizontal
Termination Cap Mounting with
Additional Siding Standoff Installed
6LGLQJ6WDQGRII
6FUHZV
+LJK:LQG
7HUPLQDWLRQ
$SSO\
0DVWLFWR
2XWVLGH
(GJHRI
6WDQGRII
([WHULRU:DOOZLWK9LQ\O6LGLQJ
11 12[12"
)UDPHG2SHQLQJ
0DLQWDLQ
0LQLPXP$LU
6SDFH$URXQG
2XWHU3LSH:KHQ
3HQHWUDWLQJD:DOO
0LQLPXP3LSH
2YHUODS14"
:DOO
)LUHVWRS
'LUHFW9HQW
3LSH
+RUL]RQWDO7HUPLQDWLRQ&RQ¿JXUDWLRQV
)LJXUHV  WKURXJK  VKRZ GLIIHUHQW FRQ-
¿JXUDWLRQV DQG DOWHUQDWLYHV IRU YHQWLQJ ZLWK
KRUL]RQWDOWHUPLQDWLRQ(DFK ¿JXUH LQFOXGHV
DFKDUWZLWKFULWLFDOPLQLPXPDQGPD[LPXP
GLPHQVLRQV ZKLFK 0867 EH PHW IMPOR-
TANT,IXVLQJDYHQWLQJFRQ¿JXUDWLRQRIRQO\
KRUL]RQWDOYHQWLQJZLWKQRYHUWLFDOUXQD
ULVHIRUHYHU\RIUXQWRZDUGWKHWHUPLQD-
WLRQLVUHTXLUHG
NOTICE: Do not seal termination
FDSWRYHQWSLSH&DSPXVWEH
UHPRYDEOH IRU YHQW LQVSHFWLRQ
DQGPDLQWHQDQFH
WARNING: Never run vent
downward as this may cause
H[FHVVLYH WHPSHUDWXUHV ZKLFK
FRXOGFDXVHD¿UH2SHUDWLRQRI
LPSURSHUO\LQVWDOOHGDQGPDLQ-
tained venting system could
UHVXOWLQVHULRXVLQMXU\SURSHUW\
GDPDJHRUORVVRIOLIH
GROUND FLOOR INSTALLATION
5HFRPPHQGHG$SSOLFDWLRQV
 ,QVWDOODWLRQXVLQJFDELQHWVXUURXQGV
 7KURXJKWKHZDOOXVLQJURXQGRUVTXDUH
WHUPLQDWLRQXSWRDGMXVWDEOHSLSH
 127)25&251(5,167$//$7,21
+RUL]RQWDO
+LJK:LQG
6TXDUH
7HUPLQDWLRQ
:DOO)LUHVWRS
(OERZ
Figure 14 - Horizontal Termination
&RQ¿JXUDWLRQIRU6TXDUHRU5RXQG
Terminations
(OERZ
:DOO
)LUHVWRS
+RUL]RQWDO
5RXQG
7HUPLQDWLRQ
([WHULRU3RUWLRQRI
:DOO)LUHVWRS5RXQG
7HUPLQDWLRQ2QO\
$GMXVWDEOH
3LSH0D[
Round
Termination
,ILQVWDOOLQJWKLV¿UHSODFHDWDOWLWXGHVRI
IHHW DQG DERYH LW LV UHFRPPHQGHG WKDW DQ
DGGLWLRQDO YHUWLFDO KHLJKW RI  EH DGGHG WR
WKHYHQWV\VWHP
6TXDUH7HUPLQDWLRQ
9HUWLFDO9 +RUL]RQWDO+
32 34PLQ PD[
All manuals and user guides at all-guides.com

www.fmiproducts.com
116226-01L 13
CORNER INSTALLATION
5HFRPPHQGHG$SSOLFDWLRQV
 &RUQHUJURXQGÀRRULQVWDOODWLRQ
 *URXQGÀRRULQVWDOODWLRQZKHUHSLSHYHQWV
KRUL]RQWDOO\WKURXJKZDOORYHUKRUL]RQ-
WDOSLSH
 %DVHPHQWLQVWDOODWLRQZKHUHRQHIRRWFOHDU-
DQFHIURPJURXQGWRWHUPLQDWLRQLVSRVVLEOH
VENTING INSTALLATION
Continued
)LJXUH+RUL]RQWDO7HUPLQDWLRQ&RQ¿JXUDWLRQIRU&RUQHU,QVWDOODWLRQ8VLQJ2QH
90° Elbow
6TXDUH
7HUPLQDWLRQ
:DOO
)LUHVWRS
1RWWR([FHHG+/LPLWV
$V5HTXLUHG
IRU96HH
&KDUWIRU
3LSH6HFWLRQ
5HTXLUHG
(OERZ
(OERZ
(OERZ
6TXDUH
7HUPLQDWLRQ
:DOO
)LUHVWRS
(OERZ
0LQ
1RWWR([FHHG
+/LPLWV
6125.(/7(50,1$7,21,167$//$7,21
5HFRPPHQGHG$SSOLFDWLRQV
 ,QVWDOODWLRQVUHTXLULQJDYHUWLFDOULVHRQEXLOGLQJH[WHULRU
 $Q\LQVWDOODWLRQXVLQJVQRUNHOWHUPLQDWLRQWRDFKLHYHRQHIRRWDERYHJURXQG
6QRUNHOWHUPLQDWLRQVDUHDYDLODEOHIRULQVWDOODWLRQVUHTXLULQJDYHUWLFDOULVHRQWKHH[WHULRURI
WKHEXLOGLQJ,ILQVWDOOLQJVQRUNHOWHUPLQDWLRQEHORZJUDGH\RXPXVWSURYLGHSURSHUGUDLQDJH
WRSUHYHQWZDWHUIURPHQWHULQJVQRUNHOWHUPLQDWLRQVHH)LJXUH'RQRWEDFN¿OODURXQG
VQRUNHOWHUPLQDWLRQ
6QRUNHO7HUPLQDWLRQ
12"
0LQ
6QRUNHO7HUPLQDWLRQ
:DOO
)LUHVWRS
(OERZ
(OERZ
)LJXUH6QRUNHO7HUPLQDWLRQ&RQ¿JXUDWLRQVIRU%HORZ*URXQG,QVWDOODWLRQ
6QRUNHO7HUPLQDWLRQ
$GHTXDWH
'UDLQDJH
0LQ
0LQ
5HTXLUHG
9HUWLFDO9 9HUWLFDO3LSH +RUL]RQWDO+
*43 12PLQ 1RQH PD[
54 12PLQ IW PD[
66 12PLQ IW PD[
78 12PLQ IW PD[
90 12PLQ IW PD[
*URXQG)ORRU&RUQHU9HQWLQJ
All manuals and user guides at all-guides.com

www.fmiproducts.com 116226-01L14
VENTING INSTALLATION
Continued
)LJXUH+RUL]RQWDO7HUPLQDWLRQ&RQ¿JXUDWLRQIRU9HQWLQJ8VLQJ7ZR(OERZV
(OERZ
HORIZONTAL SYSTEM INSTALLATION USING TWO 90° ELBOWS
7KHIROORZLQJFRQ¿JXUDWLRQVVKRZWKHPLQLPXPYHUWLFDOULVHUHTXLUHPHQWV
IRUDKRUL]RQWDOV\VWHPXVLQJWZRHOERZV
)LJXUH+RUL]RQWDO7HUPLQDWLRQ&RQ¿JXUDWLRQIRU9HQWLQJ8VLQJ7ZR(OERZV
with Termination at 90° with Fireplace
(OERZ
9HQWLQJZLWK7ZR(OERZV
9HUWLFDO9 Horizontal (H
Horizontal (H
PLQ PD[
PLQ PD[
PLQ PD[
PLQ PD[
PD[ PD[
9HQWLQJZLWK7ZR(OERZV
9HUWLFDO9 Horizontal (H
Horizontal (H
Horizontal (H
PLQ PD[ PD[
PLQ PD[ PD[
PLQ PD[ PD[
PLQ PD[ PD[
PD[ PD[ PD[
All manuals and user guides at all-guides.com

www.fmiproducts.com
116226-01L 15
INSTALLATION FOR VERTICAL
TERMINATION
Note: Vertical restrictor must be installed in
all vertical installations.
 'HWHUPLQH URXWH \RXU YHUWLFDO YHQWLQJ
ZLOO WDNH ,I FHLOLQJ MRLVWV URRI UDIWHUV RU
RWKHUIUDPLQJZLOOREVWUXFWYHQWLQJV\VWHP
FRQVLGHUDQRIIVHWVHH)LJXUHWRDYRLG
FXWWLQJORDGEHDULQJPHPEHUVNote: Pay
special attention to these installation
instructions for required clearances (air
space) to combustibles when passing
through ceilings, walls, roofs, enclosures,
attic rafters, etc. Do not pack air spaces
with insulation. Also note maximum
vertical rise of venting system and any
maximum horizontal offset limitations.
 6HW¿UHSODFHLQGHVLUHGORFDWLRQ'URSD
SOXPEOLQHGRZQIURPFHLOLQJWRSRVLWLRQ
RI ¿UHSODFH H[LW ÀXH 0DUN FHQWHU SRLQW
ZKHUHYHQWZLOOSHQHWUDWHFHLOLQJ'ULOOD
VPDOOORFDWLQJKROHDWWKLVSRLQW
 'URSDSOXPEOLQHIURPLQVLGHRIURRIWR
ORFDWLQJKROHLQFHLOLQJ0DUNFHQWHUSRLQW
ZKHUHYHQWZLOOSHQHWUDWHURRI'ULOODVPDOO
ORFDWLQJKROHDWWKLVSRLQW
Flat Ceiling Installation
 &XW D  12VTXDUHKROHLQFHLOLQJ XVLQJ
ORFDWLQJ KROH DV D FHQWHU SRLQW 2SHQLQJ
VKRXOGEHIUDPHGWR12[12PP
[PPLQVLGHGLPHQVLRQVDVVKRZQLQ
)LJXUHRQSDJHXVLQJIUDPLQJOXPEHU
WKHVDPHVL]HDVFHLOLQJMRLVWV,IDUHDDERYH
FHLOLQJLVDQLQVXODWHGFHLOLQJRUDQDWWLFQDLO
¿UHVWRSIURPWRSVLGH7KLVSUHYHQWVORRVH
LQVXODWLRQ IURP IDOOLQJ LQWR UHTXLUHG FOHDU-
DQFHVSDFH,IDUHDDERYHFHLOLQJLVDOLYLQJ
VSDFH LQVWDOO¿UHVWRSEHORZIUDPHG KROH
)LUHVWRS VKRXOG EH LQVWDOOHG ZLWK QR OHVV
WKDQWKUHHQDLOVSHUVLGHVHH)LJXUH
 $VVHPEOHWKHGHVLUHGOHQJWKVRISLSHDQG
HOERZVQHFHVVDU\WRUHDFKIURP¿UHSODFH
ÀXHXSWKURXJK¿UHVWRS%HVXUHDOOSLSH
DQG HOERZ FRQQHFWLRQV DUH IXOO\ WZLVW
ORFNHGVHH)LJXUHSDJH
 &XWDKROHLQURRIXVLQJORFDWLQJKROHDV
DFHQWHUSRLQW&RYHUDQ\H[SRVHGRSHQ
YHQWSLSHVEHIRUHFXWWLQJKROHLQURRI7KH
11 12 [12 KROH PXVWEHPHDVXUHG
RQ WKH KRUL]RQWDO DFWXDO OHQJWK PD\ EH
ODUJHUGHSHQGLQJRQSLWFKRIURRI7KHUH
PXVWEHDFOHDUDQFHIURPYHQWSLSHWR
FRPEXVWLEOHPDWHULDOV)UDPHRSHQLQJDV
VKRZQLQ)LJXUHSDJH
 &RQQHFWDVHFWLRQRISLSHDQGH[WHQGXS
WKURXJKKROH
Note: If an offset is needed to avoid
obstructions, you must support vent pipe
every 3 feet. Use wall straps for this pur-
pose (see Figure 19). Whenever possible,
use 45° elbows instead of 90° elbows. A
HOERZRIIHUVOHVVUHVWULFWLRQWRWKHÀRZ
RIÀXHJDVHVDQGLQWDNHDLU
VENTING INSTALLATION
Continued
Figure 19 - Offset with Wall Strap and 45°
Elbows
(OERZ
:DOO6WUDS
5RRI)ODVKLQJ
&HLOLQJ)LUHVWRS
Figure 20 - Installing Firestop
,IDUHDDERYHLVDOLYLQJVSDFHLQVWDOO
¿UHVWRSEHORZIUDPHGKROH
,IDUHDDERYHLVDQDWWLFRULQVXODWHGDUHD
LQVWDOO¿UHVWRSDERYHIUDPHGKROH
All manuals and user guides at all-guides.com

www.fmiproducts.com 116226-01L16
 3ODFH ÀDVKLQJ RYHU SLSH VHFWLRQV H[-
WHQGLQJ WKURXJK URRI 6HFXUH EDVH RI
ÀDVKLQJWRURRIDQGIUDPLQJZLWKURR¿QJ
QDLOV %H VXUH URR¿QJ PDWHULDO RYHUODSV
WRSHGJHRIÀDVKLQJDVVKRZQLQ)LJXUH
SDJH7KHUHPXVWEHDFOHDUDQFH
IURPYHQWSLSHWRFRPEXVWLEOHPDWHULDOV
 &RQWLQXHWRDGGSLSHVHFWLRQVXQWLOKHLJKW
RIYHQWFDSPHHWVWKHPLQLPXPEXLOGLQJ
FRGHUHTXLUHPHQWVGHVFULEHGLQ)LJXUH
RQSDJH
Note: You must increase vent height for
steep roof pitches. Nearby trees, adjoining
URRÀLQHV VWHHS SLWFKHG URRIV DQG RWKHU
VENTING INSTALLATION
Continued
Figure 21 - Vertical Venting
&RQ¿JXUDWLRQ8VLQJ7ZR(OERZV
with Two Horizontal Runs (Vertical
Round High Wind Termination Shown)
Note: Install restrictor
into inner collar of
¿UHSODFHDVVKRZQ
(OERZ
Figure 22 - Vertical Venting
&RQ¿JXUDWLRQ8VLQJ2QH(OERZ
(Vertical Round High Wind Termination
Shown)
(OERZ
Note: Install restrictor
into inner collar of
¿UHSODFHDVVKRZQ
similar factors may cause poor draft or
down-drafting in high winds. Increasing
vent height may solve this problem.
 7ZLVWORFN YHQW FDS RQWR ODVW VHFWLRQ RI
YHQWSLSH
Note: If vent pipe passes through any occu-
SLHGDUHDVDERYH¿UVWÀRRULQFOXGLQJVWRUDJH
spaces and closets, you must enclose pipe.
You may frame and sheetrock enclosure with
standard construction material. Make sure
and meet minimum allowable clearances
WRFRPEXVWLEOHV'RQRW¿OODQ\UHTXLUHGDLU
spaces with insulation.
9HUWLFDO7HUPLQDWLRQ&RQ¿JXUDWLRQV
)LJXUHV  WKURXJK  VKRZ IRXU GLIIHUHQW
FRQ¿JXUDWLRQVIRUYHUWLFDOWHUPLQDWLRQ
9HQWLQJZLWK7ZR(OERZV
9HUWLFDO9
Horizontal (H
Horizontal (H
PLQ PD[
PLQ PD[
PLQ PD[
PLQ PD[
PD[ PD[
9HQWLQJZLWK2QH(OERZ
9HUWLFDO9 +RUL]RQWDO+
PLQ PD[
PLQ PD[
PLQ PD[
PLQ PD[
PD[ PD[
All manuals and user guides at all-guides.com
all-guides.com

www.fmiproducts.com
116226-01L 17
VENTING INSTALLATION
Continued
Note: Install
restrictor into inner
FROODURI¿UHSODFH
as shown.
9HQWLQJZLWK7ZR(OERZV
Vertical (V +RUL]RQWDO+
PLQ PD[
PLQ PD[
PLQ PD[
PLQ PD[
Note: Vertical (V1) + Vertical (V2) = 40' max.
Figure 23 - Vertical Venting
&RQ¿JXUDWLRQ8VLQJ7ZR(OERZV
(Vertical Round High Wind Termination
Shown)
(OERZ
Vertical Venting
9 PD[
)LJXUH9HUWLFDO9HQWLQJ&RQ¿JXUDWLRQ
With No Horizontal Run (Vertical Round
High Wind Termination Shown)
Note: Install
restrictor into
inner collar of
¿UHSODFHDV
shown.
(OERZ
HIGH ALTITUDE INSTALLATION
<RXU )0, 352'8&76 //& GLUHFWYHQW
¿UHSODFHKDVEHHQWHVWHGDQGDSSURYHGIRU
HOHYDWLRQVIURPIHHW
)LUHSODFHVIRU +LJK$OWLWXGHPRGHOVHQGLQJ
LQ +$ DUH IRU LQVWDOODWLRQ DERYH  IHHW
RQO\7KHVH¿UHSODFHVDUHHTXLSSHGZLWKSDUWV
VSHFL¿FIRUKLJKHUDOWLWXGHV
:KHQLQVWDOOLQJDQRQKLJKDOWLWXGH¿UHSODFHDW
DQHOHYDWLRQDERYHIHHW\RXPD\QHHG
WRGHFUHDVHWKHLQSXWUDWLQJE\FKDQJLQJWKH
H[LVWLQJEXUQHURUL¿FHWRDVPDOOHUVL]H5H-
GXFHLQSXWIRUHDFKIHHWDERYHVHD
OHYHO&KHFNZLWK\RXUORFDOJDVFRPSDQ\IRU
SURSHURUL¿FHVL]HLGHQWL¿FDWLRQ
IMPORTANT: For horizontal installations
DERYHIHHWLWLVUHFRPPHQGHGWKDWD
H[WHQVLRQSLSHEHDGGHGEHIRUHVWDUWHU
HOERZVHH)LJXUHSDJHDQGDURXQG
KRUL]RQWDOWHUPLQDWLRQEHXVHG
All manuals and user guides at all-guides.com

www.fmiproducts.com 116226-01L18
3$576/,67)259(17,1*.,76
AND COMPONENTS
)0,352'8&76//&3LSH9HQW.LWV
1XPEHU 'HVFULSWLRQ
3 6HFWLRQ'RXEOH:DOO3LSH
*DOYDQL]HG
3 6HFWLRQ'RXEOH:DOO3LSH
*DOYDQL]HG
3 6HFWLRQ'RXEOH:DOO3LSH
*DOYDQL]HG
3 6HFWLRQ'RXEOH:DOO3LSH
*DOYDQL]HG
3 6HFWLRQ'RXEOH:DOO3LSH
*DOYDQL]HG
3$ $GMXVWDEOH6HFWLRQ'RXEOH
:DOO3LSH*DOYDQL]HG
( (OERZ*DOYDQL]HG
( (OERZ*DOYDQL]HG
9.* *URXQG)ORRU9HQW.LW
*DOYDQL]HG,QFOXGHV(OERZ
$GMXVWDEOH3LSH:DOO
)LUHVWRS+RUL]RQWDO6TXDUH
7HUPLQDWLRQ6FUHZV
9.% %DVHPHQW9HQW.LW*DOYDQL]HG
,QFOXGHV(OERZ
$GMXVWDEOH3LSH:DOO)LUHVWRS
+RUL]RQWDO6TXDUH7HUPLQDWLRQ
3LSH(OERZ6FUHZV
9.6 6QRUNHO9HQW.LW*DOYDQL]HG
,QFOXGHV(OERZ
$GMXVWDEOH3LSH:DOO)LUHVWRS
6QRUNHO7HUPLQDWLRQ3LSH
3LSH(OERZ6FUHZV
VENTING INSTALLATION
Continued
1XPEHU 'HVFULSWLRQ
9.5 5RRI9HQW.LW*DOYDQL]HG
,QFOXGHV(OERZ
$GMXVWDEOH3LSH)OXH5HVWULFWRU
9HUWLFDO+LJK:LQG7HUPLQDWLRQ
3LSH3LSH:DOO)LUHVWRS
6WRUP&ROODU5RRI)ODVKLQJ
>@6FUHZV
9.& &RUQHU9HQW.LW*DOYDQL]HG
,QFOXGHV(OERZ
$GMXVWDEOH3LSH:DOO)LUHVWRS
+RUL]RQWDO7HUPLQDWLRQ3LSH
(OERZ6FUHZV
++7. +LJK:LQG5RXQG+RUL]RQWDO
7HUPLQDWLRQ.LW,QFOXGHV5RXQG
7HUPLQDWLRQ:DOO)LUHVWRS
(OERZ
++7 +LJK:LQG5RXQG+RUL]RQWDO
 7HUPLQDWLRQ.LW*DOYDQL]HG
+76 +RUL]RQWDO6TXDUH7HUPLQDWLRQ
*DOYDQL]HG
+7.6 +RUL]RQWDO6TXDUH7HUPLQDWLRQ
.LW,QFOXGHV6TXDUH
7HUPLQDWLRQ:DOO)LUHVWRS
(OERZ
97 9HUWLFDO5RXQG7HUPLQDWLRQ
*DOYDQL]HG
67 6QRUNHO7HUPLQDWLRQ
*DOYDQL]HG
67 6QRUNHO7HUPLQDWLRQ
*DOYDQL]HG
6& 6WRUP&ROODU*DOYDQL]HG
:) :DOO)LUHVWRS*DOYDQL]HG
5) 5RRI)ODVKLQJWR3LWFK
*DOYDQL]HG
5) 5RRI)ODVKLQJWR
3LWFK*DOYDQL]HG
95 9HUWLFDO5HVWULFWRU*DOYDQL]HG
6 9LQ\O6LGLQJ6WDQGRII*DOYDQL]HG
:6 :DOO6WUDS
&6 &DWKHGUDO&HLOLQJ6XSSRUW
)3 )LUHVWRS3ODWH
6) 6WXFFR)ODVKLQJ)RUXVHZLWK
+76
5) )ODW5RRI)ODVKLQJ
3) )OH[3LSH6HFWLRQWR
3) )OH[3LSH6HFWLRQWR
3) )OH[3LSH6HFWLRQWR
9.) )OH[.LW,QFOXGHV)OH[3LSHO6HF-
WLRQWR:DOO)LUHVWRSDQG
+RUL]RQWDO6TXDUH7HUPLQDWLRQ
Figure 25 - Recommended 12" Extension
for High Altitude Installation
6WDUWHU
(OERZ
12"
([WHQVLRQ
All manuals and user guides at all-guides.com

www.fmiproducts.com
116226-01L 19
FIREPLACE
INSTALLATION
&+(&.*$67<3(
8VHSURSHUJDVW\SHIRUWKH¿UHSODFHXQLW\RX
DUHLQVWDOOLQJ,I\RXKDYHFRQÀLFWLQJJDVW\SHV
GRQRWLQVWDOO¿UHSODFH6HHUHWDLOHUZKHUH\RX
SXUFKDVHGWKH ¿UHSODFHIRUSURSHU¿UHSODFH
DFFRUGLQJWR\RXUJDVW\SHRUWRSXUFKDVHJDV
FRQYHUVLRQNLWVHHAccessoriesSDJH
INSTALLING OPTIONAL BLOWER
ACCESSORIES
127,&(,I LQVWDOOLQJ EORZHULQ
DQ H[LVWLQJ ¿UHSODFH ZLWK JDV
FRQQHFWLRQVVKXWRIIJDVVXS-
SO\DQGGLVFRQQHFWKHDWHUIURP
JDVVXSSO\&RQWDFWDTXDOL¿HG
VHUYLFHSHUVRQWRGRWKLV
:$51,1*,IWKHUHLVDGXSOH[
electrical outlet installed in the
ULJKWVLGHRIWKHERWWRPRIWKH
¿UHSODFHEDVHDUHDEHVXUHWKDW
WKHHOHFWULFDOSRZHUWRWKHRXWOHW
LVWXUQHGRIIEHIRUHSURFHHGLQJ
ZLWKEORZHULQVWDOODWLRQ)DLOXUH
to do this may result in serious
LQMXU\
0RGHO%.,QVWDOODWLRQ
)ROORZ DOO LQVWUXFWLRQV SURYLGHG LQ EORZHU
DFFHVVRU\NLW
 $WWDFK SRZHU FRUG WR EORZHU PRWRU E\
¿UPO\SXVKLQJWZRIHPDOHWHUPLQDOVDWHQG
RISRZHUFRUGRQWRWZRVSDGHWHUPLQDOV
RQEORZHUPRWRUVHH)LJXUH
 $WWDFK JUHHQ JURXQG ZLUH IURP SRZHU
FRUGWREORZHUKRXVLQJXVLQJVFUHZSUR-
YLGHG VHH )LJXUH  7LJKWHQ VFUHZV
VHFXUHO\
 3ODFH EORZHU DJDLQVW ORZHU UHDU ZDOO RI
¿UHER[ RXWHU ZUDSSHU ZLWK H[KDXVW SRUW
GLUHFWHGXSZDUG%ORZHUZLOO¿WLQVLGHEDFN
RSHQLQJDQGEHKHOGLQSRVLWLRQDJDLQVW
EDFNZDOOE\PDJQHWVVHH)LJXUH
 %H FHUWDLQ WKDW DOO ZLUH WHUPLQDOV DUH
VHFXUHO\DWWDFKHGWRWHUPLQDOVRQEORZHU
PRWRU DQG WKDW VFUHZ UHWDLQLQJ JUHHQ
JURXQGZLUHLVWLJKW
%ORZHU/RFDWLRQ
6LGH9LHZ
Figure 26 - Blower Model BK
0DJQHWLF
6WULSV
([KDXVW3RUW
6FUHZ
*UHHQ
*URXQG
:LUH
6SDGH
7HUPLQDOV
/RZHU)LUHER[
&DYLW\
 0RXQWVSHHGFRQWUROER[WRVZLWFKEUDFNHW
E\ SODFLQJ SODVWLF FRQWURO VKDIW IRUZDUG
WKURXJKURXQGRSHQLQJLQVZLWFKEUDFNHW
VHH)LJXUH
 :KLOH VXSSRUWLQJ VSHHG FRQWURO VHFXUH
FRQWURO VKDIW ZLWK ORFN QXW E\ SXVKLQJ
DQGWXUQLQJORFNQXWZLWKSOLHUVFORFNZLVH
XQWLOLWLVWLJKWDJDLQVWIURQWSDQHO3ODFH
SURYLGHGFRQWURONQRERQVKDIW
 7XUQRQSRZHUWRGXSOH[RXWOHWLISUHYLRXVO\
WXUQHGRIISHUZDUQLQJLQFROXPQ
 3OXJLQEORZHUSRZHUFRUG
D,I \RXU ¿UHER[ LV LQVWDOOHG DV D IUHH-
VWDQGLQJXQLWZLWKDQDFFHVVRU\PDQWHO
GHWHUPLQHZKHWKHUSRZHUFRUGZLOOH[LW
OHIWVLGHRUULJKWVLGHRI¿UHER[5RXWH
SRZHUFRUGWKURXJKH[LWKROHDQGSOXJ
SRZHUFRUGLQWRDZDOOUHFHSWDFOHQHDU
¿UHER[
E,I\RXU¿UHER[LQVWDOODWLRQLVUHFHVVHG
DQGRUSUHZLUHGSOXJSRZHUFRUGLQWR
GXSOH[ RXWOHW SURYLGHG 5HIHU WR \RXU
¿UHER[RZQHU¶VPDQXDOIRULQVWUXFWLRQV
RQZLULQJGXSOH[RXWOHW
Figure 27 - Attaching Speed Control to
Firebox
6SHHG&RQWURO &RQWURO6KDIW
/RFNQXW
&RQWURO
.QRE
6ZLWFK
%UDFNHW
%ORZHU
3OXJ,Q
'XSOH[2XWOHW/RFDWHG
EHQHDWK¿UHER[ÀRRU
DJDLQVWORZHUULJKW
RXWVLGHZDOO
All manuals and user guides at all-guides.com

www.fmiproducts.com 116226-01L20
CAUTION: Never touch the
EORZHUZKHHOZKLOHLQRSHUDWLRQ
 &KHFNWRPDNHVXUH WKDW SRZHU FRUG LV
FRPSOHWHO\ FOHDU RI EORZHU ZKHHO DQG
WKDWWKHUHDUHQRIRUHLJQREMHFWVLQEORZHU
ZKHHO7XUQEORZHURQDQGFKHFNIRURS-
HUDWLRQ7XUQEORZHURIIE\WXUQLQJNQRE
IXOO\FRXQWHUFORFNZLVHEHIRUHFRQWLQXLQJ
3HHORIIEDFNLQJSDSHUDQGVWLFNVXSSOLHG
ZLULQJ GLDJUDP GHFDO RQ ¿UHER[ ERWWRP
DSSUR[LPDWHO\LQIURQWRIEORZHUVHH
)LJXUH
Variable
FanSwitch
White
White
Black
Green
On
110/115
V.A.C.
Blower
Motor
Black
Black
Black
Off
Figure 28 - Location of Wiring Diagram
Decal (Model May Vary From Illustration)
:LULQJ'LDJUDP'HFDO
LQ)URQWRI%ORZHU
FIREPLACE INSTALLATION
Continued
0RGHO%.7,QVWDOODWLRQ
Note: When installing BKT thermostati-
FDOO\FRQWUROOHGEORZHU\RXPXVW¿UVWVHFXUH
thermal switch bracket to blower if it has not
already been factory installed.
 3ODFHJUHHQJURXQGZLUHZLWKULQJWHUPLQDO
EHWZHHQERWWRPKROH RQWKHUPDO VZLWFK
EUDFNHWDQGWRSHDU KROH RQ EORZHUDV-
VHPEO\,QVHUWWKH3KLOOLSVVFUHZLQWRDOO
WKUHH SLHFHV DQG WLJKWHQ VHFXUHO\ VHH
)LJXUH
 &RQQHFW ZLUH KDUQHVV DQG SRZHU FRUG
WHUPLQDOV &RQQHFW EOXH MXPSHU ZLUH
WR EORZHU PRWRU WHUPLQDO DQG ULJKW VLGH
WHUPLQDORIWKHUPDOVZLWFK&RQQHFWEODFN
ZLUHWROHIWVLGHRIWKHWKHUPDOVZLWFKDQG
ZKLWHZLUHWRRWKHUUHPDLQLQJEORZHUPRWRU
WHUPLQDO
Note: Power cord outer insulation sleeve may
have to be stripped slightly to allow enough
wire length to reach and make all connec-
tions. DO NOT trim excessive length away.
Enable just enough to make all connections
securely.
 3ODFH EORZHU DJDLQVW ORZHU UHDU ZDOO RI
¿UHER[RXWHUZUDSSHUZLWKH[KDXVWSRUWGL-
UHFWHGXSZDUGDQGWKHUPRGLVFSRVLWLRQHG
XS QHDU ILUHSODFH ERWWRP7KHUPRGLVF
PXVW EH RULHQWHG QHDU ¿UHSODFH ERWWRP
DVVKRZQLQ)LJXUHLQRUGHUWRVHQVH
WHPSHUDWXUHDQGSURSHUO\RSHUDWH%ORZHU
ZLOOEHKHOGLQSRVLWLRQDJDLQVWEDFNZDOO
E\PDJQHWVLQFRUSRUDWHGRQWRWKHEORZHU
KRXVLQJVHH)LJXUH
 %H FHUWDLQ WKDW DOO ZLUH WHUPLQDOV DUH
VHFXUHO\DWWDFKHGWRWHUPLQDOVRQEORZHU
PRWRUDQGWKHUPDOVZLWFKDQGWKDWVFUHZ
IRUWKHUPRGLVFEUDFNHWDQGJUHHQJURXQG
ZLUHLVWLJKW
 0RXQWVSHHGFRQWUROER[DJDLQVWPRXQW-
LQJ SODWH SURYLGHG LQ ORZHU ILUHSODFH
FDYLW\ E\ SODFLQJ SODVWLF FRQWURO VKDIW
IRUZDUGWKURXJKURXQGKROHVHH)LJXUH
SDJH
 :KLOH VXSSRUWLQJ VSHHG FRQWURO VHFXUH
FRQWUROVKDIWZLWKORFNQXWE\SXVKLQJDQG
WXUQLQJORFNQXWZLWKSOLHUVFORFNZLVHXQWLO
LW LV WLJKW DJDLQVW PRXQWLQJ SODWH 3ODFH
SURYLGHGFRQWURONQRERQVKDIWVHH)LJXUH
SDJH
7KHUPRGLVF
Figure 29 - Blower Model BKT
$LU)ORZ'LUHFWLRQ
5RXWH%.7%ORZHU
7KURXJK7KLV$UHD 0DJQHWV
%ORZHU
/RFDWLRQ
6LGH9LHZ)LUHER[%RWWRP
%ODFN
:LUH
3KLOOLSV
6FUHZ
%OXH:LUH
5LQJ7HUPLQDO
RQ*UHHQ:LUH
:KLWH:LUH
7KHUPDO
6ZLWFK
7KHUPDO
6ZLWFK
%UDFNHW
3RZHU&RUG
$LU)ORZ
'LUHFWLRQ
0DJQHWLF
6WULSV
All manuals and user guides at all-guides.com