Forever Redwood DEL NORTE User manual

Del Norte Outdoor Kitchen Pavilions www.foreverredwood.com
______________________________________________________
866.332.2403 (Toll Free); 8am-5pm Pacific Time, Monday-Friday
Assembly instructions for:
DEL NORTE OUTDOOR KITCHEN PAVILIONS

Del Norte Outdoor Kitchen Pavilions www.foreverredwood.com
CONTENT OF BOXES
QUANTITY
DESCRIPTION
DRAWING
4
Posts
4
Main Knee Braces (strengthen
union between posts and dual
support timbers)
4
Secondary Knee Braces
(strengthens union between
posts and rafters)
4
Dual Support Beams (usually ship
in 2 parts that include blocking
timber(s) attached to one of the 2
dual supports)
Quantity will vary
depending on
size
Rafters
Quantity will
vary depending
on size
Roof Panels
4
Trim pieces for
bottom of posts
Depending on
size
Hardware: Bolts and deck screws
Deck Screws Bolts, washers and nuts
2
(if you ordered)
Anchors (U brackets, Gale Wind
or hurricane anchors)
Hurricane anchors
1
(if chosen)
Ceiling Fan base
U
brackets
Gale
Wind

Del Norte Outdoor Kitchen Pavilions www.foreverredwood.com
ASSEMBLY INSTRUCTIONS
All Pavilions are completely erected in the shop prior to crating for shipping. All hardware is included. All parts are
fully sanded, routered, notched, drilled and numbered for ease of reassembly. The parts that go together have the
same numbers/letters written next to the predrilled holes they attach to.
All Pavilions parts are notched into the part they connect to. You'll find the numbers next to the notches and/or
drill holes. Before beginning re-assembly, place the parts that go together on the ground with one another so you
don't have to be searching around in the middle of the reassembly. Most pavilions take less than one day to
reassemble with one helper. Very large pergolas (6 posts or larger) usually require a second day to finish up.
Note: print the drawings that you approved before start the construction, they are needed to see the distances
between the posts.
Step 1.Attach the post to the ground. There are different ways to do it. Please see the How to anchor your
pergola document.

Del Norte Outdoor Kitchen Pavilions www.foreverredwood.com
Step 2. Attach dual support beam to posts with four bolts (6 ” x 3/8”) washers & nuts. (Match numbers). Tap
the bolt all the way into the wood to set it, then add a washer and nut and lightly tighten.
Repeat this step with the other dual support beam.
One the 2 supports have one large beam already attached or a few 18” pieces depending on size, this add support
and strength to the structure. This beam must be in the interior of the support and bolted after you attach the
supports to posts as shown below:
Beam between the
supports
Attach with carriage bolts, washers
and nuts. The quantity of bolts
depends on supports length.

Del Norte Outdoor Kitchen Pavilions www.foreverredwood.com
Step 3. Attach corner rafter to posts with one bolt per post (6 ” x 3/8”) washer & nut and use deck screws to
attach the other rafters. (Match numbers).Tap the bolt all the way into the wood to set it, then add a washer and
nut and lightly tighten.
Repeat this step in the other side (Rafter and Posts).
Step 4. Attach Secondary Knee Braces to post & rafter with two bolts, washers & nuts. (Match numbers).Tap
the bolt all the way into the wood to set it, then add a washer and nut and lightly tighten. Repeat this step with the
other end arch.
8”x 3/8” Bolt,
washers & nut.
6”x 3/8” Bolt, washers & nut.
Bolts
Deck
Screws

Del Norte Outdoor Kitchen Pavilions www.foreverredwood.com
Step 5. Attach main knee brace to post & dual support beams with two bolts, washers & nuts. (Match
numbers).Tap the bolt all the way into the wood to set it, then add a washer and nut and lightly tighten. Repeat this
step with the other main knee brace.
Step 6. Attach roof panels to rafters with post (6 ” x 3/8”) washers & nuts .Tap the bolt all the way into the
wood to set it, then add a washer and nut and lightly tighten. The panels are all notched identically.
Bolt 8”x 3/8”,
washer & nut.
Bolt 6 ”x 3/8”, washer & nut.

Del Norte Outdoor Kitchen Pavilions www.foreverredwood.com
This completes the pavilion assembly. Hope you enjoy your set for many decades. If you ever have a problem or a
question, don't hesitate to call us (866 332 2403) or email us. We are here to support you.