GE Appliances C2S985 How to use

GE Appliances
General Electric Company
Louisville, Kentucky 40225
31-9224
GE Gas Ranges
C2S985
CGS985
CGS990
JGB870
P2B930
PGB900
PGB910
PGB915
PGB930
PGB935
PGB980
PGB995
Technical Service Guide
March 2012
GE Appliances
2345
1
78910
6
Double Oven
2345
Start
Cooking
Time
Convection
Bake
Oven
O
Convection
Bake
Delay
Start
Delay
Start
Warm
R
EAR
U
PPER
O
VEN
Warm
Bake Clock
Kitchen
Time
Check
Kitchen
Time
Check
TIMECONTROLS
LOWER OVEN
Clean
O
78910
6
1
F
RONT
O
VEN
H
EATING
F
RONT
O
VEN
R
EAR

– 2 –
IMPORTANT SAFETY NOTICE
Theinformationinthisserviceguideisintendedforusebyindividualspossessing
adequatebackgroundsofelectrical,electronic,andmechanicalexperience.Any
attempt to repair a major appliance may result in personal injury and property
damage.Themanufacturerorsellercannotberesponsiblefortheinterpretation
of this information, nor can it assume any liability in connection with its use.
WARNING
If the information in this manual is not followed exactly, fire or explosion may
result causing property damage, personal injury or death. If you smell gas:
– Do not try to light any appliance.
– Do not touch any electrical switch; do not use any phone in the
building.
– Immediately call the gas supplier from a neighbor’s phone. Follow the
gas supplier’s instructions.
– If you cannot reach the gas supplier, call thefire department.
WARNING
To avoid personal injury, disconnect power before servicing this product. If
electricalpowerisrequiredfordiagnosisortestpurposes,disconnectthepower
immediately after performing the necessary checks.
RECONNECT ALL GROUNDING DEVICES
If grounding wires, screws, straps, clips, nuts, or washers used to complete a
path to ground are removed for service, they must be returned to their original
position and properly fastened.
GE Appliances
Technical Service Guide
Copyright © 2011
All rights reserved. This service guide may not be reproduced in whole or in part in any
form without written permission from the General Electric Company.

– 3 –
Table of Contents
(Continued next page)
Bake and Broil Burner Flame Adjustments...........................................................................................................59
Bake Burners and Glow Bar Igniters........................................................................................................................56
Broil Burner and Glow Bar Igniter.............................................................................................................................55
Bake Assist...........................................................................................................................................................................56
Burner Output Ratings...................................................................................................................................................72
Burner Valves......................................................................................................................................................................36
Cavity Thermal Cut Out (TCO)......................................................................................................................................51
Component Locator Views...........................................................................................................................................19
Control Features................................................................................................................................................................ 9
Control Panel Assembly ................................................................................................................................................26
Convection Fan Cover....................................................................................................................................................61
Convection Fan Motor....................................................................................................................................................61
Converting the Cooktop Burners...............................................................................................................................69
Converting the Oven Burners.....................................................................................................................................70
Converting the Pressure Regulator..........................................................................................................................69
Cooktop.................................................................................................................................................................................31
Cooling Fan..........................................................................................................................................................................52
Diagnostics and Service Information .....................................................................................................................68
Door Lock Assembly........................................................................................................................................................38
Door Switch.........................................................................................................................................................................53
Electronic Range Control (ERC) Pin Locator..........................................................................................................29
Electronic Range Control (ERC) Failure Codes.....................................................................................................73
Fan Apparent Device.......................................................................................................................................................38
Glow Bar Igniter.................................................................................................................................................................54
Igniter Switch Assembly................................................................................................................................................34
Installation........................................................................................................................................................................... 7
Introduction......................................................................................................................................................................... 5
Lockout Relay.....................................................................................................................................................................51
Lockout Valve.....................................................................................................................................................................49
Lower Oven Door Hinge Receiver.............................................................................................................................52

– 4 –
Lower Oven Gas Valve....................................................................................................................................................66
Low Flame Simmer Adjustment.................................................................................................................................30
LP Conversion Instructions...........................................................................................................................................69
Maintop Burner Alignment...........................................................................................................................................30
Manifold Panel....................................................................................................................................................................33
Meat Probe Outlet.............................................................................................................................................................62
Motorized Door Lock Circuit Information..............................................................................................................41
Nomenclature.................................................................................................................................................................... 6
Oven Burner Ignition System......................................................................................................................................54
Oven Components...........................................................................................................................................................54
Oven Door Assembly......................................................................................................................................................43
Oven Door Removal.........................................................................................................................................................42
Oven Gaskets......................................................................................................................................................................52
Oven Light Assemblies...................................................................................................................................................67
Range Components ........................................................................................................................................................42
Range Top Components ...............................................................................................................................................30
Rear Cover............................................................................................................................................................................47
Regulator..............................................................................................................................................................................46
Relay Contacts Operation Test and Control Voltage Check.........................................................................71
Schematics and Wiring Diagrams............................................................................................................................74
Side Panel.............................................................................................................................................................................47
Spark Module......................................................................................................................................................................37
Surface Burner Igniters..................................................................................................................................................31
Temperature Sensor........................................................................................................................................................63
Testing the Flame Stability...........................................................................................................................................30
Thermostat..........................................................................................................................................................................64
Touch Panel and Electronic Range Control (ERC)...............................................................................................26
Tri-Burner Igniter...............................................................................................................................................................33
Upper Oven Door Hinge................................................................................................................................................53
Upper Oven Gas Valve....................................................................................................................................................65
Warranty..............................................................................................................................................................................76

– 5 –
Introduction
The Café, Profile, and GE gas ranges have some of
the following features:
• Gas convection oven – Circulates air
throughout the oven cavity ensuring better
baking and roasting results.
• Self-clean oven – Conveniently cleans the oven
cavity without the need for scrubbing.
• 17,000-BTU PowerBoil™ burner – Delivers
intense heat for rapid boiling.
• 20,000-BTU tri-ring burner – Three-in-one
burner is designed for accelerated boiling and
gentle simmering.
• Deep-recessed cooktop – Designed with a
recessed surface to help contain spills and
make cleaning easy.
• Precise simmer burner – Allows for low, even
heat distribution that is ideal for delicate foods
and sauces.
• Center oval burner – Oval fifth burner in the
center of the cooktop is large to accommodate
odd-sized cookware or griddles.
• 5.4-cu. ft. oven capacity – Enough room to
cook an entire meal at once.
• Baking drawer – Offers an additional 1.0 cu. ft.
of capacity for convenient baking from 140°F
to 450°F.
• Nonstick griddle – Provides a flat, nonstick
surface for cooking and warming all types of
foods.
• Reversible cast-iron griddle/grill – Provides the
flexibility to sear meats on the grill and cook
delicate meals on the griddle.

– 6 –
Serial Number
The first two characters of the serial number
identify the month and year of manufacture.
Example: FZ123456S = March, 2012
F– MAR
G – APR
H – MAY
L – JUN
M – JUL
R – AUG
S – SEP
T – OCT
V – NOV
Z – DEC
A – JAN
D – FEB
2012 – Z
2011 – V
2010 – T
2009 – S
2008 – R
2007 – M
2006 – L
2005 – H
2004 – G
2003 – F
2002 – D
2001 – A
The letter designating
the year repeats every
12 years.
Example:
Z - 2012
Z - 2000
Z - 1988
The mini-manual is taped to the back of the
range on GE and Profile units and located in
the rear, top, left corner on Café models.
The nomenclature tag is on the bottom, left
side of the lower oven front frame.
Brand
P = Profile
C = Café
J = GE
P G B 9 9 5 D E T 1 S S
Nomenclature
Model Number
Profile model shown
Feature Pack
Designates features–the higher
the number, the more features
Product Color
SS = Stainless steel
Indicator for Engineering and
Product Service Only
Model Year Designator
Ignition System
E = Electronic pilotless ignition
Configuration
B = 30-in. Range
S = Slide-in
Gas
G = Gas
Single or Double Oven
D = Double oven
Nomenclature
Mini-Manual
(Café) Mini-Manual
(Profile and GE)

– 7 –
Installation
(Continued next page)
Installation information is for reference only. See the
installation instructions shipped with the product
for complete details and before attempting to install
the range.
Power Supply
This appliance features pilotless electronic ignition
for energy savings and reliability. It must be
supplied with 120V, 60 Hertz, properly grounded
dedicated circuit protected by a 15-amp or 20-amp
circuit breaker or time-delay fuse as noted on the
rating plate.
Wiring must conform to the National Electrical
Codes.
Grounding Specifications
Ground Path Resistance 0.10 Max.
Insulation Resistance 250 KMin.
When checking for proper operation of the
regulator, the inlet pressure must be at least 1 inch
greater than the operating (manifold) pressure as
given above.
The pressure regulator located at the inlet of the
range manifold must remain in the supply line
regardless of whether natural or LP gas is being
used.
A flexible metal appliance connector used to
connect the range to the gas supply line should
have an I.D. of 1/2 in. and be 5 feet in length for ease
of installation. In Canada, flexible connectors must
be single wall metal connectors no longer than 6
feet in length.
WARNING: To reduce the risk of tipping the range,
the range must be secured by a properly installed
anti-tip bracket. Follow the instructions packaged
with the bracket.
To check if the bracket is installed and engaged
properly, look underneath the range to see that the
rear leveling leg is engaged in the bracket. On some
models, the storage drawer or kick panel can be
removed for easy inspection. If visual inspection is
not possible, slide the range forward, confirm the
anti-tip bracket is securely attached to the floor or
wall, and slide the range back so the rear leveling
leg is under the anti-tip bracket.
Anti-Tip Device
Gas Supply
This range is designed to operate at a pressure
of 5 inches of water column on natural gas or, if
designed for LP gas (propane or butane), 10 inches
of water column.
Make sure you are supplying this range with the
type of gas for which it is designed.
This range is convertible for use with natural or
propane gas. If you are installing this range for
use with LP gas, conversion must be made by a
qualified LP installer before attempting to operate
the range on that gas.
For proper operation, the pressure of natural gas
supplied to the regulator must be between 5 inches
and 13 inches of water column. For LP gas, the
pressure supplied must be between 10 inches and
13 inches of water column.

– 8 –
Minimum Clearances
7RFDELQHWVEHORZ
FRRNWRSDQGDW
WKHUDQJHEDFN
7RFDELQHWV
EHORZ
FRRNWRSDQG
DWWKHUDQJH
EDFN
µ
µ
µ
0LQLPXP
µ
0LQLPXP
FOHDUDQFHWR
ULJKWZDOO
0D[LPXP
GHSWKIRU
FDELQHWVDERYH
FRXQWHUWRSV
)URQWHGJHRI
WKHUDQJHVLGH
SDQHOIRUZDUG
IURPFDELQHW
µ
µ
µ
0LQLPXPWR
FDELQHWVRQ
HLWKHUVLGH
RIWKHUDQJH
µ
µ
0LQLPXP
FOHDUDQFH
WROHIWZDOO
µ
0RGHOV3*%
3*%3*%
3*%DQG3*%
UHTXLUHRQO\
PLQLPXPFOHDUDQFH
WROHIWZDOO
**43-3/4”
48”
*29-3/4”
36-1/2”
30”
30 3/4”
* Dimension includes handle with doors closed.
**Dimension are referenced from the point at
the back of the range that will contact the rear wall first.
Max dimension should be considered between the upper
and lower doors.

 

'HSWKZLWKGRRURSHQ
+HLJKWWREDFNJXDUGEDVHGRQ&DIpVW\OHEDFNJXDUGNLWLQVWDOOHG

µ
'HSWKZLWKGRRUFORVHGLQFOXGHVGRRUKDQGOH
'HSWKYDULHVGHSHQGLQJRQPRGHO
6HHVSHFLILFDWLRQVVKHHWIRU\RXUPRGHO
µ
µ
'HSWKZLWKGRRURSHQ
µ
µ
+HLJKW
µ
øµ
'HSWKZLWKGRRUFORVHG
LQFOXGHVGRRUKDQGOH
µ
øµ
øµ
'HSWKZLWKGRRURSHQ
øµ
+HLJKWWREDFNJXDUGEDVHGRQ
&DIpVW\OHEDFNJXDUGNLWLQVWDOOHG

– 9 –
Control Features
7KURXJKRXWWKLVPDQXDOIHDWXUHVDQGDSSHDUDQFHPD\YDU\IURP\RXUPRGHO
+RZWR/LJKWD*DV6XUIDFH%XUQHU
:$51,1*
%XUQHUIODPHVWKDW
DUHQRWFRYHUHGE\FRRNZDUHPD\SUHVHQWDULVN
RIILUHRUFORWKLQJLJQLWLRQ7KHJULGGOHEXUQHU
VKRXOGRQO\EHXVHGZLWKWKHJULGGOHLQSODFH
)DLOXUHWRGRVRPD\UHVXOWLQVHULRXVLQMXU\
0DNHVXUHDOOWKHVXUIDFHEXUQHUVDUHSODFHGLQ
WKHLUUHVSHFWLYHSRVLWLRQV
3XVKWKHFRQWURONQRELQDQGWXUQLWWRWKH/,7(
SRVLWLRQ
<RXZLOOKHDUDOLWWOHFOLFNLQJ QRLVH³WKHVRXQG
RIWKHHOHFWULFVSDUNLJQLWLQJWKHEXUQHU
7XUQWKHNQREWRDGMXVWWKHIODPHVL]H,IWKH
NQREVWD\VDW/,7( LWZLOOFRQWLQXHWRFOLFN
:KHQRQHEXUQHULVWXUQHGWR/,7( DOOWKH
EXUQHUVVSDUN'RQRWDWWHPSWWRGLVDVVHPEOH
RUFOHDQDURXQGDQ\EXUQHUZKLOHDQRWKHU
EXUQHULVRQ$QHOHFWULFVKRFNPD\UHVXOWZKLFK
FRXOGFDXVH\RXWRNQRFNRYHUKRWFRRNZDUH
3XVKWKHFRQWURONQRELQDQGWXUQ
LWWRWKH/,7(SRVLWLRQ
%HIRUH/LJKWLQJD*DV%XUQHU
0DNHVXUHDOOEXUQHUVDUHLQSODFH
0DNHVXUHDOOJUDWHVRQWKHUDQJHDUH
SURSHUO\SODFHGEHIRUHXVLQJDQ\EXUQHU
,I\RXUUDQJHKDVWKH*DV&RQWURO/RFNRXW
IHDWXUHPDNHVXUHLWLVGLVDEOHGEHIRUH
DWWHPSWLQJWROLJKWWKHVXUIDFHEXUQHUV
$IWHU/LJKWLQJD*DV%XUQHU
'RQRWRSHUDWHWKHEXUQHUIRUDQH[WHQGHG
SHULRGRIWLPHZLWKRXWFRRNZDUHRQWKH
JUDWH7KHILQLVKRQWKHJUDWHPD\FKLS
ZLWKRXWFRRNZDUHWRDEVRUEWKHKHDW
%HVXUHWKHEXUQHUVDQGJUDWHVDUHFRRO
EHIRUH\RXSODFH\RXUKDQGDSRWKROGHU
FOHDQLQJFORWKVRURWKHUPDWHULDOVRQWKHP
6HDOHG*DV%XUQHUV
<RXUJDVUDQJHFRRNWRSKDVVHDOHGJDV
EXUQHUV7KH\RIIHUFRQYHQLHQFHFOHDQDELOLW\
DQGIOH[LELOLW\WREHXVHGLQDZLGHUDQJHRI
FRRNLQJDSSOLFDWLRQV
7KHVPDOOHVWEXUQHULQWKHULJKWUHDUSRVLWLRQ
LVWKHVLPPHUEXUQHU2QVRPHPRGHOVWKH
ULJKWIURQWSRVLWLRQWULSOHIODPHEXUQHUZLOOEH
WKHVLPPHUEXUQHU7KLVEXUQHUFDQEHWXUQHG
GRZQWR6,0IRUDYHU\ORZVLPPHUVHWWLQJ
,WSURYLGHVSUHFLVHFRRNLQJSHUIRUPDQFHIRU
GHOLFDWHIRRGVVXFKDVVDXFHVRUIRRGVWKDW
UHTXLUHORZKHDWIRUDORQJFRRNLQJWLPH
7KHPHGLXPOHIWUHDUDQGWKHODUJHOHIW
IURQWEXUQHUVDUHWKHSULPDU\EXUQHUV
IRUPRVWFRRNLQJ7KHVHJHQHUDOSXUSRVH
EXUQHUVFDQEHWXUQHGGRZQIURP+,WR/2WR
VXLWDZLGHUDQJHRIFRRNLQJQHHGV
7KHH[WUDODUJHEXUQHUULJKWIURQWWULSOHIODPH
EXUQHURUOHIWIURQWEXUQHURQVRPHPRGHOVDUH
WKHPD[LPXPRXWSXWEXUQHUV/LNHWKHRWKHU
IRXUEXUQHUVLWFDQEHWXUQHGGRZQIURP+,WR
6,0IRUDZLGHUDQJHRIFRRNLQJDSSOLFDWLRQV
7KHVHEXUQHUVDUHGHVLJQHGWRTXLFNO\EULQJ
ODUJHDPRXQWVRIOLTXLGWRDERLO7KH\KDYH
DVSHFLDO32:(5%2,/VHWWLQJGHVLJQHGWR
EHXVHGZLWKFRRNZDUHLQFKHVRUODUJHULQ
GLDPHWHUIRUWKHH[WUDODUJHDQGLQFKHVRU
ODUJHUIRUWKHWULSOHIODPHEXUQHU
7KHFHQWHURYDOEXUQHURQVRPHPRGHOVLVIRU
ODUJHSRWVSDQVRUIRUXVHZLWKWKHJULGGOH
8VLQJWKHJDVVXUIDFHEXUQHUV
+RZWR/LJKW%ULGJH%XUQHUIRU0RGHO3*%
0HGLXP 6PDOO
/DUJH &HQWHURYDO
RQVRPH
PRGHOV
([WUD/DUJH
([WUD
/DUJH
RQ
VRPH
PRGHOV 7ULULQJ
EXUQHURQ
VRPHPRGHOV
%ULGJHEXUQHU
RQVRPH
PRGHOV
)RUH[WUDODUJHEXUQHUVRQO\
)RUWULULQJEXUQHUVRQO\
)RU5HDU%XUQHUDQG%ULGJH
%XUQHU&RPER2QO\
Griddle Burner
9 8 7 6 5 4 3 2 1
Griddle Burner Hi Med Lo
)RU)URQW*ULGGOH%XUQHU2QO\
:$51,1*%XUQHUIODPHV
WKDWDUHQRWFRYHUHGE\FRRNZDUHPD\
SUHVHQWDULVNRIILUHRUFORWKLQJLJQLWLRQ7KH
JULGGOHEXUQHUVKRXOGRQO\EHXVHGZLWKWKH
JULGGOHLQSODFH)DLOXUHWRGRVRPD\UHVXOWLQ
VHULRXVLQMXW\
/LJKWUHDUEXUQHUIXOO\DWWKH/LWHSRVLWLRQ
7XUQWKHVDPHUHDUEXUQHUNQREWRWKH
*ULGGOH%XUQHU+LVHWWLQJWROLJKWWKHEULGJH
 %HVXUHIURQWJULGGOHEXUQHUVHWWLQJLVWKHVDPH
DVUHDUEXUQHUDQGEULGJHEXUQHUFRPER

(Continued next page)

– 10 –
+RZWR6HOHFW)ODPH6L]H
:$51,1*)ODPHVWKDWDUH
QRWFRYHUHGE\FRRNZDUHPD\SUHVHQWDULVN
RIEXUQVRUFORWKLQJLJQLWLRQ1HYHUOHWIODPHV
H[WHQGEH\RQGWKHVLGHVRIWKHFRRNZDUH
:DWFKWKHIODPHQRWWKHNQREDV\RXDGMXVW
KHDW:KHQIDVWKHDWLQJLVGHVLUHGWKHIODPH
VL]HRQDJDVEXUQHUVKRXOGPDWFKWKH
FRRNZDUH\RXDUHXVLQJ
)ODPHVODUJHUWKDQWKHERWWRPRIWKHFRRNZDUH
ZLOOQRWUHVXOWLQIDVWHUKHDWLQJDQGPD\EH
KD]DUGRXV
,Q&DVHRI3RZHU)DLOXUH
,QFDVHRIDSRZHUIDLOXUH\RXFDQOLJKWWKH
JDVVXUIDFHEXUQHUVRQ\RXUUDQJHZLWKD
PDWFK+ROGDOLWPDWFKWRWKHEXUQHUWKHQ
SXVKLQDQGWXUQWKHFRQWURONQREWRWKH/,7(
SRVLWLRQ8VHH[WUHPHFDXWLRQZKHQOLJKWLQJ
EXUQHUVWKLVZD\
6XUIDFHEXUQHUVLQXVHZKHQDQHOHFWULFDO
SRZHUIDLOXUHRFFXUVZLOOFRQWLQXHWRRSHUDWH
QRUPDOO\
127(,I*DV&RQWURO/RFNRXWLVLQXVHDWWKH
WLPHRIDSRZHUIDLOXUHWKHVXUIDFHEXUQHUV
FDQQRWEHOLW
*($SSOLDQFHVFRP
:RN7KLV:D\
:HUHFRPPHQGWKDW\RXXVHDLQFKRU
VPDOOHUIODWERWWRPHGZRN0DNHVXUHWKHZRN
ERWWRPVLWVIODWRQWKHJUDWH7KH\DUHDYDLODEOH
DW\RXUORFDOUHWDLOVWRUH
2QO\DIODWERWWRPHGZRNVKRXOGEHXVHG
'RQRWXVHDZRNVXSSRUWULQJ3ODFLQJWKH
ULQJRYHUWKHEXUQHURUJUDWHPD\FDXVHWKH
EXUQHUWRZRUNLPSURSHUO\UHVXOWLQJLQFDUERQ
PRQR[LGHOHYHOVDERYHDOORZDEOHVWDQGDUGV
7KLVFRXOGEHGDQJHURXVWR\RXUKHDOWK
8VHDIODWERWWRPHGZRN
6WRYH7RS*ULOOV
'RQRWXVHVWRYHWRSJULOOVRQ\RXUVHDOHGJDV
EXUQHUV,I\RXXVHWKHVWRYHWRSJULOORQWKH
VHDOHGJDVEXUQHULWZLOOFDXVHLQFRPSOHWH
FRPEXVWLRQDQGFDQUHVXOWLQH[SRVXUHWR
FDUERQPRQR[LGHOHYHOVDERYHDOORZDEOH
FXUUHQWVWDQGDUGV
7KLVFDQEHKD]DUGRXVWR\RXUKHDOWK
7RSRI5DQJH&RRNZDUH
$OXPLQXP0HGLXPZHLJKWFRRNZDUHLV
UHFRPPHQGHGEHFDXVHLWKHDWVTXLFNO\
DQGHYHQO\0RVWIRRGVEURZQHYHQO\LQDQ
DOXPLQXPVNLOOHW8VHVDXFHSDQVZLWKWLJKW
ILWWLQJOLGVZKHQFRRNLQJZLWKPLQLPXP
DPRXQWVRIZDWHU
&DVW,URQ,IKHDWHGVORZO\PRVWVNLOOHWVZLOO
JLYHVDWLVIDFWRU\UHVXOWV
(QDPHOZDUH8QGHUVRPHFRQGLWLRQVWKH
HQDPHORIVRPHFRRNZDUHPD\PHOW)ROORZ
FRRNZDUHPDQXIDFWXUHU·VUHFRPPHQGDWLRQV
IRUFRRNLQJPHWKRGV
*ODVV7KHUHDUHWZRW\SHVRIJODVV
FRRNZDUH³WKRVHIRURYHQXVHRQO\DQG
WKRVHIRUWRSRIUDQJHFRRNLQJVDXFHSDQV
FRIIHHDQGWHDSRWV*ODVVFRQGXFWVKHDW
YHU\VORZO\
+HDWSURRI*ODVV&HUDPLF&DQEHXVHGIRU
HLWKHUVXUIDFHRURYHQFRRNLQJ,WFRQGXFWV
KHDWYHU\VORZO\DQGFRROVYHU\VORZO\&KHFN
FRRNZDUHPDQXIDFWXUHU·VGLUHFWLRQVWREH
VXUHLWFDQEHXVHGRQJDVUDQJHV
6WDLQOHVV6WHHO7KLVPHWDODORQHKDVSRRU
KHDWLQJSURSHUWLHVDQGLVXVXDOO\FRPELQHG
ZLWKFRSSHUDOXPLQXPRURWKHUPHWDOVIRU
LPSURYHGKHDWGLVWULEXWLRQ&RPELQDWLRQ
PHWDOVNLOOHWVXVXDOO\ZRUNVDWLVIDFWRULO\
LIWKH\DUHXVHGZLWKPHGLXPKHDWDVWKH
PDQXIDFWXUHUUHFRPPHQGV

(Continued next page)

– 11 –
<RXUQRQVWLFNFRDWHGJULGGOHRUSUHVHDVRQHG
JULGGOHRQVRPHPRGHOVSURYLGHVDQ
H[WUDODUJHFRRNLQJVXUIDFHIRUPHDWV
SDQFDNHVRURWKHUIRRGXVXDOO\SUHSDUHGLQD
IU\LQJSDQRUVNLOOHW
127(<RXUJULGGOHZLOOGLVFRORURYHUWLPHDVLW
EHFRPHVVHDVRQHGZLWKXVH
+RZWR,QVHUWWKH*ULGGOH
8VLQJWKHJULGGOHRQVRPHPRGHOV
&$87,213ODFHDQGUHPRYH
WKHJULGGOHRQO\ZKHQDOOJUDWHVDQGJULGGOH
DUHFRRODQGDOOVXUIDFHXQLWVDUHWXUQHG2))
7KHJULGGOHFDQRQO\EHXVHGZLWKWKHFHQWHU
EXUQHU7RLQVHUWWKHJULGGOHUHPRYHFHQWHU
JUDWHDQGUHSODFHZLWKJULGGOH
127('RQRWFOHDQWKHJULGGOHLQWKHVHOI
FOHDQLQJRYHQ
<RXUQRQVWLFNFRDWHGJULGGOHRUSUHVHDVRQHG
JULGGOHRQVRPHPRGHOVSURYLGHVDQH[WUDODUJH
FRRNLQJVXUIDFHIRUPHDWVSDQFDNHVRURWKHU
IRRGXVXDOO\SUHSDUHGLQDIU\LQJSDQRUVNLOOHW
127(<RXUJULGGOHZLOOGLVFRORURYHUWLPH
DVLWEHFRPHVVHDVRQHGZLWKXVH
+RZWR,QVHUWWKH&KHI·V*ULGGOH
7KLVJULGGOHFDQRQO\EHXVHGZLWKWKHOHIWUHDU
IURQWDQGEULGJHEXUQHUV7RLQVHUWWKHJULGGOH
SODFHRQWRSRIWKHJUDWHVVRWKDWWKHIHHW
RQWKHERWWRPRIWKHJULGGOHVHWEHWZHHQWKH
ILQJHUVRQWKHJUDWHV
127('RQRWFOHDQWKHJULGGOHLQWKHVHOIFOHDQLQJ
RYHQ
(Continued next page)

– 12 –
8VLQJWKHRYHQFRQWUROV
7KURXJKRXWWKLVPDQXDOIHDWXUHVDQGDSSHDUDQFHPD\YDU\IURP\RXUPRGHO*($SSOLDQFHVFRP
%DNH3DG
7RXFKWRVHOHFWWKHEDNHIXQFWLRQ
%URLO+L/R3DG
7RXFKWRVHOHFWWKHEURLOIXQFWLRQ
&RQYHFWLRQ%DNH3DG
7RXFKWRVHOHFWEDNLQJZLWKWKHFRQYHFWLRQ
IXQFWLRQ
&RQYHFWLRQ5RDVW3DG
7RXFKWRVHOHFWURDVWLQJZLWKWKHFRQYHFWLRQ
IXQFWLRQ
6WDUW3DG
0XVWEHWRXFKHGWRVWDUWDQ\FRRNLQJRUFOHDQLQJ
IXQFWLRQ
'LVSOD\
6KRZVWKHWLPHRIGD\RYHQWHPSHUDWXUHZKHWKHU
WKHRYHQLVLQWKHEDNHEURLORUVHOIFOHDQLQJPRGH
WKHWLPHVVHWIRUWKHWLPHURUDXWRPDWLFRYHQ
RSHUDWLRQVDQGLIWKHUDQJHLVORFNHG
,I´)²DQGDQXPEHURUOHWWHUµIODVKLQWKHGLVSOD\DQG
WKHRYHQFRQWUROVLJQDOVWKLVLQGLFDWHVDIXQFWLRQHUURU
FRGH7RXFKWKH&OHDU2IISDG$OORZWKHRYHQWRFRROIRU
RQHKRXU3XWWKHRYHQEDFNLQWRRSHUDWLRQ,IWKHIXQFWLRQ
HUURUFRGHUHSHDWVGLVFRQQHFWWKHSRZHUWRWKHRYHQDQG
FDOOIRUVHUYLFH
,I\RXURYHQZDVVHWIRUDWLPHGRYHQRSHUDWLRQDQGD
SRZHURXWDJHRFFXUUHGWKHFORFNDQGDOOSURJUDPPHG
IXQFWLRQVPXVWEHUHVHW
7KHWLPHRIGD\ZLOOIODVKLQWKHGLVSOD\ZKHQWKHUHKDV
EHHQDSRZHURXWDJH
6HOI&OHDQ3DG
7RXFKWRVHOHFWVHOIFOHDQLQJIXQFWLRQ6HHWKH
8VLQJWKHVHOIFOHDQLQJRYHQVHFWLRQ
2YHQ/LJKW2Q2II3DG
7RXFKWRWXUQWKHRYHQOLJKWRQRURII
'HOD\6WDUW3DG
8VHDORQJZLWK&22.,1*7,0(RU6(/)
&/($1SDGVWRVHWWKHRYHQWRVWDUWDQGVWRS
DXWRPDWLFDOO\DWDWLPH\RXVHW
&RRNLQJ7LPH3DG
 7RXFKDQGWKHQWRXFKWKHQXPEHUSDGVWRVHWWKH
DPRXQWRIWLPH\RXZDQW\RXUIRRGWRFRRN7KH
RYHQZLOOVKXWRIIZKHQWKHFRRNLQJWLPHKDVUXQRXW
&OHDU2II3DG
7RXFKWRFDQFHO$//RYHQRSHUDWLRQVH[FHSWWKH
FORFNWLPHUDQG*DV&RQWURO/RFNRXWRU&RQWURO
/RFNRXWGHSHQGLQJRQPRGHO
&ORFN3DG
7RXFKEHIRUHVHWWLQJWKHFORFN
1XPEHU3DGV
8VHWRVHWDQ\IXQFWLRQUHTXLULQJQXPEHUVVXFK
DVWKHWLPHRIGD\RQWKHFORFNWKHWLPHUWKHRYHQ
WHPSHUDWXUHWKHLQWHUQDOIRRGWHPSHUDWXUHWKH
VWDUWWLPHDQGOHQJWKRIRSHUDWLRQIRUWLPHGEDNLQJ
DQGVHOIFOHDQLQJ
.LWFKHQ7LPHU2Q2II3DG
7RXFKWRVHOHFWWKHWLPHUIHDWXUH
3UREH3DG
7RXFKZKHQXVLQJWKHSUREHWRFRRNIRRG
*DV&RQWURO/RFNRXWRQVRPHPRGHOV
7RXFKDQGKROGWKH*DV&RQWURO/RFNRXWSDGIRU
VHFRQGVWRORFNXQORFNWKHVXUIDFHEXUQHUV
RYHQEXUQHUVDQGFRQWUROSDQHOVRWKH\FDQQRWEH
DFWLYDWHG
2YHQ&RQWURO&ORFN7LPHUDQG)HDWXUHV&*60RGHOV
)HDWXUHVDSSHDUDQFHDQGSDGORFDWLRQVPD\YDU\

(Continued next page)

– 13 – (Continued next page)

– 14 – (Continued next page)
HOLD 3 SEC
JGB870, PGB995,
JGB870, PGB995,
CGS990 Models
CGS990 Models

– 15 – (Continued next page)

– 16 –
G AS/ C ONTROL
L
OCKOUT
(Continued next page)

– 17 –
K
(Continued next page)

– 18 –
<RXPD\ILQGWKDW\RXUQHZRYHQFRRNVGLIIHUHQWO\WKDQWKHRQHLWUHSODFHG8VH\RXUQHZRYHQIRUDIHZZHHNVWREHFRPH
PRUHIDPLOLDUZLWKLW,I\RXVWLOOWKLQN\RXUQHZRYHQLVWRRKRWRUWRRFROG\RXFDQDGMXVWWKHWKHUPRVWDW\RXUVHOI
'RQRWXVHWKHUPRPHWHUVVXFKDVWKRVHIRXQGLQJURFHU\VWRUHVWRFKHFNWKHWHPSHUDWXUHVHWWLQJRI\RXURYHQ
7KHVHWKHUPRPHWHUVPD\YDU\²GHJUHHV
127(7KLVDGMXVWPHQWZLOOQRWDIIHFWWKHEURLOLQJRUWKHVHOIFOHDQLQJWHPSHUDWXUHV7KHDGMXVWPHQWZLOOEHUHWDLQHGLQ
PHPRU\DIWHUDSRZHUIDLOXUH
7R$GMXVWWKH/RZHU7KHUPRVWDW
7R$GMXVWWKH8SSHU7KHUPRVWDW
7RXFKWKH%DNHDQG:DUP SDGVDWWKH
VDPHWLPHIRUVHFRQGVXQWLOWKHGLVSOD\
VKRZV6)
7RXFKWKH%DNHSDG$WZRGLJLWQXPEHU
VKRZVLQWKHGLVSOD\
7RXFK%DNH RQFHWRGHFUHDVHWKHRYHQ
WHPSHUDWXUHRUWZLFHWRLQFUHDVH
7KHRYHQWHPSHUDWXUHFDQEHDGMXVWHGXS
DVPXFKDV)RUGRZQDVPXFKDV
)7RXFKWKHQXPEHUSDGVWKHVDPH
ZD\\RXUHDGWKHP)RUH[DPSOHWR
FKDQJHWKHRYHQWHPSHUDWXUH)WRXFK
DQG
:KHQ\RXKDYHPDGHWKHDGMXVWPHQW
WRXFKWKH6WDUW SDGWRJREDFNWRWKH
WLPHRIGD\GLVSOD\8VH\RXURYHQDV\RX
ZRXOGQRUPDOO\
127(7KHWKHUPRVWDWDGMXVWPHQWIRU%DNLQJ
ZLOODOVRDIIHFW&RQYHFWLRQ%DNLQJRU&RQYHFWLRQ
5RDVWLQJ
3XOOWKH29(1&21752/NQRERIIWKH
UDQJHDQGORRNDWWKHEDFNVLGH7RPDNH
DQDGMXVWPHQWORRVHQDSSUR[LPDWHO\RQH
WXUQEXWGRQRWFRPSOHWHO\UHPRYHWKH
WZRVFUHZVRQWKHEDFNRIWKHNQRE
:LWKWKHEDFNRIWKHNQREIDFLQJ\RXKROG
WKHRXWHUHGJHRIWKHNQREZLWKRQHKDQG
DQGWXUQWKHIURQWRIWKHNQREZLWKWKH
RWKHUKDQG7RUDLVHWKHRYHQWHPSHUDWXUH
PRYHWKHWRSVFUHZWRZDUGWKHULJKW<RX·OO
KHDUDFOLFNIRUHDFKQRWFK\RXPRYHWKH
NQRE7RORZHUWKHWHPSHUDWXUHPRYHWKH
WRSVFUHZWRZDUGWKHOHIW
(DFKFOLFNZLOOFKDQJHWKHRYHQ
WHPSHUDWXUHDSSUR[LPDWHO\)5DQJHLV
)IURPWKHDUURZ:HVXJJHVWWKDW
\RXPDNHWKHDGMXVWPHQWRQHFOLFNIURP
WKHRULJLQDOVHWWLQJDQGFKHFNRYHQ
SHUIRUPDQFHEHIRUHPDNLQJDQ\DGGLWLRQDO
DGMXVWPHQWV
$IWHUWKHDGMXVWPHQWLVPDGHUHWLJKWHQ
VFUHZVVRWKH\DUHVQXJEXWEHFDUHIXO
QRWWRRYHUWLJKWHQ
5HLQVWDOONQRERQUDQJHDQGFKHFN
SHUIRUPDQFH
$GMXVWWKHORZHUDQGXSSHURYHQ
WKHUPRVWDWV³'RLW\RXUVHOI
T
O
M
A
K
E
O
V
E
N
C
O
O
L
E
R
T
U
R
N
D
I
S
K
A
P
P
R
O
X
.
1
0
˚
F
P
E
R
N
O
T
C
H
T
O
M
A
K
E
O
V
E
N
H
O
T
T
E
R
T
U
R
N
D
I
S
K
T
O
A
D
J
U
S
T
O
V
E
N
T
E
M
P
E
R
A
T
U
R
E
L
O
O
S
E
N
S
C
R
E
W
S
A
N
D
R
O
T
A
T
E

– 19 –
Touch Panel and ERC
Manifold Panel
(Continued next page)
Component Locator Views
Top View (Profile and GE models)
Top View (Café models)
Touch Panel and ERC

– 20 – (Continued next page)
Burner Assembly
Rangetop Burner Assembly
(Shown with Grates Removed)
Burner Orifice
Burner Head
Assembly
Burner Cap
Igniter (Electrode)