Gotrax EBE4 User manual
EBE4
USER MANUAL
ELECTRIC BIKE
Don’t Ride Until You Read This:
ALWAYS wear a helmet when riding your electric bike.
Make sure your electric bike has a full battery before taking it out to ride.
Always be aware of local road laws, and follow them.
Do not ride the bike under the inuence of drugs or alcohol.
Always respect pedestrians.
Do not ride under wet conditions. The electric bike may slide from under your
feet causing injury. Wet conditions may damage the electronics and void the
warranty.
1. Avoid water - The electric bike is not waterproof. The electronics may be damaged
due to water and water damage is not covered by our warranty. Riding in wet
conditions is also very dangerous and may result in injury.
2. Avoid prolonged exposure to sun or rain and avoid storage in places with high
temperatures or corrosive gas.
3. Abuse - We do not cover physical damage due to negligent care and extreme riding.
4. Whenever you ride the GOTRAX Electric Bike, you risk severe injury or even death
from loss of control, collisions, and falls. Use caution and ride at your own risk.
5. Do not modify the product from the manufacturers original design.
6. Do not exceed the posted speed limit and obey all trac laws.
7. Avoid touching the charging port directly and do not let it make contact with a
metal object.
8. Keep hands and all body parts away from moving parts while operating the
electric bike.
9. Before riding - be sure to check the electric bike over and make sure the electric
bike is operating correctly before each use.
10. Before riding - be sure to check that the braking system is functioning properly;
also be sure to check that all safety labels are in place and you understand the
safety warnings.
11. Before riding - be sure that any and all axle guards, chain guards, or other covers
or guards supplied by the manufacturer are in place and in serviceable condition.
12. Before riding - be sure to check that the tires are in good condition, inated
properly, and have sucient tread remaining.
Warning Message
13. Never exceed the 264 lb (120 kg) maximum load rating.
14. The electric bike should never be used by children under the age of 16.
15. Maximum Speed - Your electric bike goes the maximum speed of 20 mph.
16. Make note that additional insurance may be required to cover situations you
encounter while riding an electric bike. It is recommended that you contact an
insurance company or broker for advice and consultation.
17. To conserve electricity, use assist mode and avoid zero starting, frequent braking,
driving against the wind, carrying heavy loads including other people and riding with
insucient air pressure.
Remove all packaging material, then inspect each item for any accidental damage
that may have occurred during shipping. You should nd each of these items in
your box:
Unpacking and Product Specs
13
2
ELECTRIC BIKE TOOLS: (1) LARGE WRENCH, (3)
ALLEN WRENCHES,
(1) SCREWDRIVER
BATTERY CHARGER
ITEM SPECIFICATIONS
Model EBE4
Unfolded Dimensions 173x58x120 (cm)
Folded Dimensions 94x53x78 (cm)
Package Dimensions 141x28x67 (cm)
Max Load 264 lbs (120 kg)
Package Weight 77 lbs (35 kg)
E Bike Weight 66 lbs (30 kg)
Max Speed 20 mph
Battery 48V10AH
Pedal-Assist Mode Approx 43-50 miles (70-80 km)
Pure Electric Mode Approx 22-24 miles (36-40 km)
Max Angle of Climb 14 degrees
Charging Time 5-6 hours
Tire Pressure 30 PSI
Charging Port 5V1A
Crankset 1/2*3/32*48T*165MM ED
Seat Adjustable
IP Level IPx4
Get To Know Your E-Bike
Saddle
Seat Post
Motor
Wheel Chain
Crankset
Pedal
Removable
Battery
Tire
Disc Brake
Suspension
Front Fork
Front Light
Stem
LCD Display
Adjust the saddle tube and crank, loosen
the saddle tube clamp with quick release.
Insert the saddle tube down to the bottom
and lock the saddle tube clamp with quick
release. Adjust the crank angle to 9 o’clock
and fold the pedals at the same time.
Open the folding frame with the safety
clasp. Fold the left and right sides of the
frame.
Open the frame, make the wheel fold
parallel to the rear wheel and nish folding
the bike.
1
3
2
Folding the Electric Bike
Open the folder of
standpipe
1
Adjust Handlebar and Standpipes
2 3
4 5 6
Fold handlebars to the left When installing the stem,
make sure handlebars
are properly aligned and
tightened
Fold the handlebars
perpendicular to the
ground
Open the folder of the
handlebar and adjust
After adjusting the handle,
lock the folder and nish
the install
1
Mounting Pedal
2
This bike provides convenient
accessories, please check the L and R
marks on the pedals
Take wrench from the toolbox
34
R means it should be installed on the
right side, L means it should be installed
on the left side
Tighten the nut counterclockwise
Push the saddle
down
1
Adjust saddle and seat tube
2 3
Open the folding
mechanism on the
seat tube
Adjust and rotate
the seat
4
Lock the folding
mechanism
Open the folding
mechanism
1
Removing the battery
2 3
Loosen the folder Insert the key to
the battery lock
4
Remove the battery
Before using the electric bike, you must fully charge the battery.
Charge Your E-Bike: Method 1
1. Locate the charging port on the left side of the frame near the folding mechanism
2. Plug the charger into a power supply
3. A red light indicates the battery is charging, green indicates the battery is full
4. Charging Time: 5-6 hours
Charging
Port
Charge Your E-Bike: Method 2
Remove the battery charger from the e-bike
(as detailed on page 11)
Locate the charging port near the top of the
battery.
A red light indicates the battery is
charging, green indicates the battery is full
1
3
2
E-Bike Console Functions
Casing Material: ABS
Display Material: High hardness acrylic (the same hardness value as tempered glass)
Display Includes: Speed, battery, error indication and mileage
Control and Settings: Power switch, wheel diameter, idle time for auto-hibernation,
back light brightness setting, start mode setting, drive mode setting, voltage level setting,
controller current limit setting
Communications Protocol: UART
Light
Battery Level
Multi-function:
• Total Mileage
• Trip Mileage
• Error Code
• Power (WATT)
• Maintenance
Strong Power Mode
Max Speed/Average Speed
6 KM/H Booster Assist Constant Speed Service
Electric Assisted Mode Battery LED
Brake Indicator Controller Failure
Motor Failure Throttle Failure
OVERVIEW OF KEYS
1. Long press "M" to turn on the panel. Short press "M" to switch the interface in ODO/
TRIP/VOL/CUR/TIME mode when the panel is on.
2. Long press "M" to turn o the panel when it's on. Short press the up key + to increase
the PAS level, short press the down key - to decrease the PAS level.
3. Long press the up + key to adjust the parameter. In the setting interface, short press
"M" to switch parameters, and long press MODE to add ("A" on the left side)/minus ("D"
on the left side) the value.
4. After the charge, short press "M" to switch to the next parameter and save the last
parameter, or long press MODE and the parameter will stop blinking and be saved.
Long press "M" + MODE to exit the parameter setting interface, or wait for 10 seconds
and automatically exit the mode.
5. The throttle is used to adjust the motor rotational speed. Turn it from top down and
the motor will accelerate, release the lever and the motor will decelerate.
Troubleshooting & Warranty
We frequently update our user manuals at GOTRAX.com, and reserve the rights to
update and change manuals online.
Please contact our customer service team if you are experiencing problems or need more
detailed information. They can be reached at GOTRAX.com
1. Users should operate in accordance with the product manual. In case of any
performance fault caused by production quality, the company shall perform the
obligations of the three guarantees in accordance with the provisions of relevant laws
and regulations of the state.
2. The company is still responsible for the after-sales service of the faults beyond three
guarantees and the major components in the three guarantees, but there will be a
cost for repair.
3. If the battery replacement is over the warranty time, our company will supply the
battery at factory price. To ensure safety, and avoid pollution.
For additional warranty information, please visit GOTRAX.com.
Other manuals for EBE4
1
Table of contents
Other Gotrax Bicycle manuals
