Hugo Brennenstuhl ML CA 120 F IP54 User manual

6
DMobile rechargeable battery LED lamp
exible
ML CA 120 F IP54 / ML CA 130 F IP54
SAFETY INFORMATION:
• Pleasereadtheoperatinginstructionscarefullypriortouseanddonotthrowthemaway.
• Prior to every use, check the lamp and power adapter for damage. Never use the lamp or
power adapter if there isanydamage.Inthiscase, please contact an electricianorwrite to
theserviceaddressprovidedbythemanufacturer.
Non-compliance may result in risk to life due to electrical shock!
• Neveropenthedevice.Thelampdoesnotcontainanycomponentsthatrequiremaintenance.
TheLEDscannotbereplaced.
• Donotusetheworklampinexplosiveenvironmentsinwhichammableliquids,gasesordusts
arepresent.Risktolife!
• Whenthebatteryisproperlyinstalled,thelampisprotectedagainstspraywater.
 Neversubmergethelamporitsindividualcomponentsinwaterorotherliquids.
 Riskofexplosionandre!
• Keepchildrenawayfromthelamp.Childrencannotestimatetheriskofelectricshock.
• Onlyusetheincludedpoweradapterorcarchargertochargethebatteries.
 Usingotherpoweradapters or carcharger cables maydamagethebatteries orresultin an
explosion!
• Disconnectthe powersupply fromtheelectricityprior tocleaning andswitchthe lampo.
Cleanthelampregularlywithadry,lint-freecloth.Toremovedirt,adampclothcanbeused.
Donotuseanysolvents,causticcleaningagents,etc.
• Topreventblinding,donotlookdirectlyintothelight.
SETUP/ MOUNTNG THE LAMP:
Forset-up,thebattery-operatedlampcanbeunfoldedtoseveralsettings,but,atmost,tothe
“OPEN”marking.Donotforcethelampfurtheropensincethiswoulddamagethemechanism!
Thelampcanbehunguponahookontheframeusingthemountingopening(1)oronametial
surfaceusingthemagnets(2).Pleasemakesurethesurfaceisstableinordertoavoiddamageto
theproductorinjuriestopersons!
2
2
2
2
1
Mobile Akku Chip LED-Leuchte flexible 0487256_V7.indd 6 09.10.15 13:47

7
D
Mobile rechargeable battery LED lamp exible Operating Instructions
SWITCHING THE LAMP ON AND OFF:
Pressthe(B)buttontoturnonthelamp.Bypressingthe(A)button,thebrightnesscanbesetto
100%or50%.
Whenselecting50%,theservicelifeofthelampextendsincomparisontothe100%settingasit
consumeslessenergy.
Pressthe(B)buttonagaintoturnthelampo.
BATTERY STATUS DISPLAY C:
Displaysthecurrentchargingstatusofthebattery,or,howmuchenergyisstillavailable.Ifall
4LEDsarelit,thebatteryisfullycharged.Ifthebatteryisnearlyempty,theLEDblinks5times
andthebattery status indicator blinks continuously.Then the lampwillremainlitforapprox.
5-10minutes,beforethedeepdischargeprotectionshutsthelampo.Thisprovidessucient
timetoreplacethebatteryorstopworking.
CHARGING DEVICES WITH A USB CHARGING CABLE E.G.SMARTPHONES:
Suitable for products with a charging current of max. 2000 mA. To charge the depleted unit,
connectaUSBchargingcabletotheUSBchargingport(D)underthecoveronthebattery.
Aftercharging,putthecoverbackon.
CHARGING THE BATTERY:
• Toensureoptimumfunctionality,weensurecompletelydischargingthebatteryduringinitial
useandthenfullychargingit.
• Thechargingsocket(E)isunderthecoveronthebattery.
• Thebatterychargingstatuscanbedeterminedbyreadingthebatterystatus(seedescription
above).Ifall4LEDsarelit,thebatteryisfullycharged.
• Thelampcanbeoperatedwhilecharging,however,itisnotpossibletousetheUSBoutputwhile
chargingthebattery.Inordertochargethebattery,thelampisonlyoperatedwithreduced
illuminancewhilecharging.Thetimerequiredtochargethebatteryincreasessignicantlyin
thisoperatingmode.
• Thebatterycanalsobechargedseparatelyfromthelamp,seealsothe"Replacingthebattery"
section.
• Ifthelampisnotinuseforlongerperiodsoftime,chargethebatteryapproximatelyevery
3monthstoensurealongbatterylife.
• Aftercharging,makesuretoclosethechargingportwiththecap.
D
E
50%
100%
ON
OFF
50%
100%
ON
OFF
B A C
Mobile Akku Chip LED-Leuchte flexible 0487256_V7.indd 7 09.10.15 13:47

8
D
Operating Instructions Mobile rechargeable battery LED lamp exible
REPLACING THE BATTERY:
Thebatterycanbeeasilyandquicklyreplaced.Pressthelock(F)forwardandthenslidethe
batteryupandout,seedrawing.Itisthereforepossibletochargeonebatteryandcontinue
workingwithaseparatelyavailablereplacementbattery.
TECHNICAL SPECIFICATIONS:
Type description ML CA 120 F IP54 ML CA 130 F IP54
Output 20W 30W
Batteries Li-Ion7.4V,7800mAh Li-Ion7.4V,10400mAh
PoweradapterInputpower 100-240VAC,50/60Hz,0.8A 100-240VAC,50/60Hz,0.8A
PoweradapterOutputpower 12VDC1500mA 12VDC2000mA
Carcharger 12VDC/max.2A 12VDC/max.2A
Operatingtime approx.3.5h(100%)
resp.7h(50%)
approx.2.5h(100%)
resp.5h(50%)
Chargingtime approx.4.5h approx.4.5h
USBoutput 5V,max.2000mA 5V,max.2000mA
Protectionclass IP54* IP54*
Temperaturerange -5°C–+40°C -5°C–+40°C
*onlyifthebatterypackisinstalledcorrectly,notduringthechargingprocessorwhenusingtheUSBoutput.
Mobile Akku Chip LED-Leuchte flexible 0487256_V7.indd 8 09.10.15 13:47

9
D
Mobile rechargeable battery LED lamp exible Operating Instructions
Disposal
Do not dispose of electrical appliances with the household rubbish!
InaccordancewithDirective2012/19/EConwasteelectricalandelectronicequipmentand
thecorrespondingnationallaw,used electricalequipmentmustbe separatedfromthe
rubbishandreusedorrecycledinanenvironmentallyresponsiblemanner.Pleasecontact
yourlocalauthoritiesforavailabledisposaloptionsforyouruseddevice.
Incorrectdisposal ofbatteriesandrechargeablebatteriescanharmtheenvironment!
Batteriesandrechargeablebatteriesdonotbelonginthehouseholdwaste.
Theycancontainpoisonousheavymetalsandaresubjecttotreatmentashazardouswastes.
Takeyourusedbatteriestoamunicipalcollectionsite.
Manufacturer
HugoBrennenstuhlGmbH&Co.KG
Seestraße1–3·D-72074Tübingen
H.BrennenstuhlS.A.S.
4ruedeBruxelles∙F-67170Bernolsheim
lectra-tag
Blegistrasse13·CH-6340Baar
PleasevisittheService/FAQsectionofourhomepage,www.brennenstuhl.com,
formoreinformation.
Mobile Akku Chip LED-Leuchte flexible 0487256_V7.indd 9 09.10.15 13:47