Hussmann IMPACT CW2-EGE Instruction Manual

B
C
DE
A
P/N 0399452_C
Merchandisers
®
Note: Changed items have been underlined.
Item Part # Description Wiring Item #
FAN ASSEMBLIES AND THERMOSTATS
A. 9W End Compartment Fan Assembly (1)
0441749 Fan Motor, Standard (MO.4410575)
0377253 Fan Blade (FB.4780616)
embossing away from motor
B. 0398558 Standard Non-Adjustable (2)
Defrost Thermostat (CT.4481088)
Item Part # Description Wiring Item #
LAMPS AND BALLASTS
C. 0135966 Ballast, Electronic (3)
1 lamp (BA.4480883)
D. 0039764 Lamp Starter (EP.4481081) (4)
E. Fluorescent Lamp (5)
Replace with like fixtures
CW2-EGE
Technical Data Sheet
P/N 0399452_C
NSF®Certified
July 2007
©2007 HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM
We reserve the right to change or revise specifications
and product design in connection with any feature of
our products. Such changes do not entitle the buyer to
corresponding changes, improvements, additions or
replacements for equipment previously sold or shipped.

CW2-EGE
General
Maximum O/S dimension of case back to front (includes bumper) 40 3/4 (1035)
Total width of case 81 1/2 (2070)
Width at front of case 28 (711)
Front of case to O/S edge of front base rail 12 3/8(314)
Back of case to O/S edge of front base rail 28 3/8 (721)
RH edge of case to O/S edge of LH base rail 69 1/2 (1765)
LH edge of case to O/S edge of LH base rail 12 (305)
Rear to front of canopy 10 3/4 (273)
Width of canopy 25 1/2 (648)
Width of base rail 2 1/8 (54)
Access area between front base rail and splashguard 8 1/8 (206)
Electrical Service (Electrical Field Wiring connection point)
Center of Electrical service to O/S edge of front base rail 7 (178)
RH edge of case to center of knockout 46 7/8(1191)
Length of electrical raceway 21 3/8 (543)
Waste Outlet
Front RH edge of case to the center of waste outlet 11 7/8 (301)
Center of waste outlet to outside of front base rail 3 7/8 (98)
Water Seal
Center of case to center of pipe connection 32 (813)
Outside diameter of the drip pipe 1 1/4 (32)
Water seal outlet must clear front skid rail.
CW2-EGE Technical Data Sheet
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
2 of 6
C
L
Front of
Case
81 1/2(2070)
69 1/2(1765)
25 1/2
(648)
32 (813)
12
(305)
Waste Outlet
& Water Seal
46 7/8
(1191)
Access Area
32
(813) 35 1/8
(892)
40 3/4
(1035)
11 7/8
(301)
28
(711)
CW2-EGE
29 1/2
(749)
28 1/2
(724)
Convertible Island End
05-2003
Engineering
Plan Views
Dimensions shown as inches and (mm).

REFRIGERATION DATA
Note: This data is based on store temperature
and humidity that does not exceed 75°F and
55% R.H.
CW2-EGE
Discharge Air (°F) 28
Evaporator (°F) 21
Unit Sizing (°F) 19
Btu/hr/case CW2-EGE
Parallel 4600
Conventional 5100
DEFROST DATA
CW2-EGE
Frequency (hr) 6
Defrost Water (lb/case/day) 8
(± 15% based on a case configuration and
product loading).
OFFTIME CW2-EGE
Temp Term (°F) 48°
Failsafe (minutes) 45
ELECTRIC OR GAS Not Recommended
Standard Defrost Thermostat
Close on rise: close 48°F — open 33°F
CONVENTIONAL CONTROLS
Low Pressure Backup Control
CW2-EGE
CI/CO (Temp °F)*17°/ 7°
Indoor Unit Only, Pressure Defrost
Termination (Temp °F)* 48°
*Use a Temperature Pressure Chart to
determine PSIG conversions.
PHYSICAL DATA
Merchandiser Drip Pipe (in.) 1 1/4
Liquid Line (in.) 3/8
Suction Line (in.) 7/8
Estimated Charge (lb)** CW2-EGE
1.7
**This is an average for all refrigerant types.
Actual refrigerant charge may vary by
approximately half a pound.
Length Added to Lineup by:
Each End/Partition (in.) 1 1/2
3 of 6P/N 0399452_C
48
(1219)
Front
of
Case
16 in. Shelf
12 in. Shelf
10 3/4
(273)
5
(127) 32 (813)
6 3/8(162)
26
(660)
7
(178)
3 7/8
(98)
8 1/2
(216)
12 3/8
(314)
28 3/8
(721)
40 3/4
(1035)
FAN
COIL
30 1/8(765)
5 (127)
21
(533)
9 (229)
Dimensions shown as inches and (mm).
Convertible Island End, 2 Display Levels
Impact CW2-EGE
Convertible Island End
CW2-EGE
HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. • WWW.HUSSMANN.COM
NSF Certification
This merchandiser model is manufactured to meet ANSI/NSF
(National Sanitation Foundation) Standard #7 requirements for
construction, materials & cleanability.

CW2-EGE Technical Data Sheet
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
4 of 6
Electrical Data
Number of Fans CW2-EGE
Refrigeration – 9W 2
Merchandiser Amperes Watts
Fans (Refrigeration)
Standard (120V 60Hz) 0.76 50
Energy Efficient (120V 60Hz) (See Note 1 below)
Cycling Anti-sweat Heaters NA NA
Minimum Circuit Ampacity
With Standard Fans (120V 60Hz) 0.96 NA
With Energy Efficient Fans (120V 60Hz) (See Note 1 below)
Maximum Over Current Protection 120V 20
Electric Defrost Heaters (208V) NA NA
Standard Lighting
1 Row Canopy 0.80 40
Optional Lighting
2 Rows Canopy (See Note 2 below)
Optional Shelf Lighting
1 Row of Shelves 0.80 40
2 Rows of Shelves 1.60 80
Note 1: All CW2 end compartments are equipped with energy efficient fan motors as standard.
Note 2: CW2 end compartments are not available with 2 row canopy lighting due to space constraints.
Impact C2W-EGE
Convertible Island End

5 of 6P/N 0399452_C HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. • WWW.HUSSMANN.COM
Grayed components in 12 foot models only.
R = Red Y = Yellow G = Green BL = Blue B = Black W = White
= 120V POWER = 120V NEUTRAL = Field GROUND
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS
Fan Wiring
Offtime Defrost
= Case GROUND
2
Defrost
Termination
Thermostat
Refrigeration
Thermostat
Dark Blue To
Condensing
Unit
}
Light Blue
3
2 Fans 120V NEUTRAL
BROWN BAND
120V POWER
Fans 1
BROWN BAND

CW2-EGE Technical Data Sheet
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
6 of 6
5
55
5
5
5
3
3
3
Light Circuits
CW2-EGE END COMPARTMENT
LIGHTING SCHEMATIC
(Standard canopy lighting and
optional shelf lighting are shown)
4
4
44
4
4
= 120V POWER = 120V NEUTRAL
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
Grayed components in 12 ft models only.
R = Red Y = Yellow G = Green BL = Blue B = Black W = White
CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS