Hussmann SI1N Instruction Manual

Serial Plate
P/N 0492444_A
®
SI1N
Technical Data Sheet
P/N 0492444_A
NSF®Certified
April 2007
©2007 HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM
We reserve the right to change or revise specifications
and product design in connection with any feature of
our products. Such changes do not entitle the buyer to
corresponding changes, improvements, additions or
replacements for equipment previously sold or shipped.
Item Part # Description Wiring Item #
FAN ASSEMBLIES AND THERMOSTATS
8 Ft, 10 Ft, 12 Ft,14 Ft & 16 Ft
A. 12W Standard Fan Assembly (1)
0047000 Fan Motor, Evaporator
(MO.4410103)
0407532 Fan Blade (FB.4780619)
embossing toward motor
12W Energy Efficient Fan Assembly (1)
0477655 Fan Motor, Evaporator
(MO.4410546)
0407532 Fan Blade (FB.4780619)
B. Optional Adjustable Refrigeration Thermostat (2)
0448347 (CT.4481631)
Item Part # Description Wiring Item #
HEATERS
C. Anti-Sweat Heater (3)
0447688 (HE.4850682)
LAMPS AND BALLASTS
D. Ballast, Electronic (4)
0447683 (BA.4440811)
E. Fluorescent Lamp (5)
Replace with like fixtures

2 of 6 SI1N Technical Data Sheet
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
SI1N Island
A
B
Electrical Service
Drains
Refrigeration
& Coil Stubout
26 1 /2
(673)
27
(686)
7
(178)
49
(1242)
51 /2
(140)
91 /2
(241)
22
(559)
60
(1524)
31
(788)
14 1 /2
(368)
Engineering
Plan Views
06-2003
Front
8 ft 10 ft 12 ft 14 ft 16 ft
General
(A) Base Length 77 (1956) 101 7/8 (2588) 125 7/8 (3198) 149 1/2 (3798) 173 (4396)
Overall Case Length 96 (2438) 120 (3048) 144 (3658) 168 (4267) 192 (4876)
Maximum O/S dimension of case back to front
(includes bumper) 60 (1524) 60 (1524) 60 (1524) 60 (1524) 60 (1524)
Front of splashguard to O/S edge of front base rail 1 5/8 (41) 1 5/8 (41) 1 5/8 (41) 1 5/8 (41) 1 5/8 (41)
Front of case to O/S edge of front base rail 13 1/8 (333) 13 1/8 (333) 13 1/8 (333) 13 1/8 (333) 13 1/8 (333)
Back of case to O/S edge of front base rail 58 7/8 (1495) 58 7/8 (1495) 58 7/8 (1495) 58 7/8 (1495) 58 7/8 (1495)
Width of base rail 1 7/8 (48) 1 7/8 (48) 1 7/8 (48) 1 7/8 (48) 1 7/8 (48)
Electrical Service (Electrical Field Wiring connection point)
Center of Electrical service to O/S edge of front base rail 46 1/2 (1181) 46 1/2 (1181) 46 1/2 (1181) 46 1/2 (1181) 46 1/2 (1181)
Right end of case to center of knockout 27 (686) 27 (686) 27 (686) 27 (686) 27 (686)
Left end of case to center of knockout 69 (1753) 93 (2362) 117 (2972) 141 (3581) 165 (4191)
Waste Outlets
(B) LH End of case to the center of waste outlet 48 (1219) 78 (1981) 102 (2591) 84 (2134) 96 (2439)
Center of front waste outlet to outside of front base rail 8 (203) 8 (203) 8 (203) 8 (203) 8 (203)
Center of back waste outlet to outside of front base rail 39 1/4 (997) 39 1/4 (997) 39 1/4 (997) 39 1/4 (997) 39 1/4 (997)
Schedule 40 PVC drip pipe 1 1/4 (32) 1 1/4 (32) 1 1/4 (32) 1 1/4 (32) 1 1/4 (32)
Refrigeration Outlet
LH end of case to center of refrigeration outlet 22 (559) 22 (559) 22 (559) 22 (559) 22 (559)
RH end of case to center of refrigeration outlet 74 (1880) 98 (2489) 122 (3098) 146 (3708) 170 (4318)
Serial Plate
End

3 of 6P/N 0492444_A HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. • WWW.HUSSMANN.COM
6(152)
27 1/16
(276)
57/8(149)
13 5/8
(346)
3(76)
2313/16
(605)
87/ 8
(225)
49
(1245)
60
(1524)
5
1/ 2
(140)
3
1/ 4
(83)
44 3/8
(1127)
27
(686)
4(102)
10
1/ 4
(260)
5
1/ 2
(140)
Dimensions shown as in. and (mm).
NSF Certification
These merchandisers are manufactured to meet ANSI /National Sanitation
Foundation (NSF ®) Standard #7 requirements.
Single Deck Island, 1 Display Levels, Narrow Footprint
SI1N
SI1N
Single Deck Island
Optional High Plex
with 6 in. (152 mm)
Product Depth
SI1N
Load Limit Load Limit
3 in. Space Required
Load Limit Profile
Air flow between the shelves, from the CAD to the return, must be maintained at all times
for optimum operating efficiency and to prolong product shelf life. At no time should
merchandisers be stocked beyond the load limits indicated.
Cases may not function properly if they are loaded above load limits.
REFRIGERATION DATA
Note: This data is based on store tempera-
ture and humidity that does not exceed
75°F and 55% R.H.
SI1
Discharge Air (°F) 27
Evaporator (°F) 15
Unit Sizing (°F) 13
Btu/hr/ft
SI1
Parallel 1260
Conventional 1375
DEFROST DATA
SI1
Frequency (hr) 4
Defrost Water (lb/ft/day) 9
(± 15% based on case configuration and
product loading).
OFFTIME SI1
Time Terminated (minutes) 20
ELECTRIC OR GAS Not Recommended
CONVENTIONAL CONTROLS
Low Pressure Backup Control
CI/CO*SI1
8°F / -2°F
Indoor Unit Only, Pressure Defrost
Termination* 48°F
*Use a Temperature Pressure Chart to
determine PSIG conversions.
PHYSICAL DATA
Merchandiser Drip Pipe (in.) 1 1/2
Merchandiser Liquid Line (in.) 3/8
Merchandiser Suction Line (in.) 5/8
Estimated Charge (lb)**
8 ft 1.7
10 ft 2.1
12 ft 2.5
14 ft 3.1
16 ft 3.7
**This is an average for all refrigerant types.
Actual refrigerant charge may vary
by approximately half a pound.

4 of 6 SI1N Technical Data Sheet
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
SI1N
Single Deck Island
Electrical Data
8 ft 10 ft 12 ft 14 ft 16 ft
Number of Fans – 12W 4 6 8 10 12
Amperes Watts
8 ft 10 ft 12 ft 14 ft 16 ft 8 ft 10 ft 12 ft 14 ft 16 ft
Evaporator Fan
120V 60Hz Standard 2.60 3.90 5.20 6.50 7.80 200 300 400 500 600
120V 50Hz Standard 3.00 4.50 6.00 7.50 9.00 228 342 456 570 684
230V 60Hz Export NA NA NA NA NA NA NA NA NA NA
230V 50Hz Export NA NA NA NA NA NA NA NA NA NA
120V 60Hz Energy Efficient 1.20 1.80 2.40 3.00 3.60 72 108 144 180 216
230V 60Hz Energy Efficient NA NA NA NA NA NA NA NA NA NA
Anti-sweat Heaters †
120V 50/60Hz Standard 1.00 1.00 1.33 1.67 2.00 120 120 160 200 240
230V 50/60Hz Export 0.52 0.52 0.70 0.87 1.04 120 120 160 200 240
Minimum Circuit Ampacity (MCA) †
120V 60Hz Standard 3.80 5.10 6.73 8.37 10.00
120V 50Hz Standard 3.72 5.22 6.90 8.57 10.24
230V 60Hz Export NA NA NA NA NA
230V 50Hz Export NA NA NA NA NA
120V 60Hz Energy Efficient 1.92 2.52 3.30 4.07 4.84
230V 60Hz Energy Efficient NA NA NA NA NA
Maximum Over Current Protection 120V 20 20 20 20 20
Maximum Over Current Protection 230V 15 15 15 15 15
Standard Lighting
1 Row Canopy 0.80 0.80 1.20 1.60 2.00 96 96 144 192 240
Optional Lighting
1 Row of Ledge 1.67 2.00 2.33 2.67 3.00 200 240 280 320 360
Optional Shelf Lighting
None
115V Lighting Circuit Total = Standard Lighting + Total Optional Lighting + Optional Shelf Lighting
230V Lighting Circuit Total = Multiply 115V Lighting Circuit Total by 0.52does not

5 of 6P/N 0492444_A
Light Blue
2
To
Condensing Unit
}
Refrigeration Thermostat
1
3
Anti-sweat Heaters
BROWN BAND
Fans
BROWN BAND
120V POWER
1
BROWN BAND
BROWN BAND
120V NEUTRAL
R = Red Y = Yellow G = Green BL = Blue B = Black W = White
= 120V POWER = 120V NEUTRAL = Field GROUND = Case GROUND
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS
8 ft
10 ft
12 ft
14 ft
16 ft
4, 6, 8, 10 & 12 Fans Fan Wiring
Offtime Defrost
HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. • WWW.HUSSMANN.COM

6 of 6 SI1N Technical Data Sheet
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
4
55
120V N EUTRAL
ORANGE OR TAN BAND
W
Light
Switch
120V P OWER
ORANGE OR TAN
BAND
B
R
R
BL
BL
R
BL
GG
G
G
5
Light Circuits
= 120V POWER = 120V NEUTRAL = Field GROUND = Case GROUND
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
Circled Numbers = Parts List Item Numbers
R = Red G = Green BL = Blue B = Black W = White
W
BG
R
R
BL
BL
R
BL
BL
GGG
4
55 5
Optional Ledge Light Circuit