Hussmann IMPACT ED1C-ICE User manual

HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A. P/N 0454041
Item Part # Description Wiring Item #
FAN ASSEMBLIES, AND THERMOSTATS
A. 4W Fan Assemblies (1)
0404551 Fan Motor, Ambient
Merchandisers
®
B
C
A
Item Part # Description Wiring Item #
LAMPS AND BALLASTS
B. 0355398 Ledge Lamps (2)
Electronic 3-Lamp
Ballast (Optional)
C. Fluorescent Lamp (3)
Replace with like fixtures
ED1C-ICE
Data Sheet Set
P/N 0454041
July, 2003
Note: Changed items have been underlined.

ED1C-ICE Data Sheet
2 of 5 HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
Engineering
PlanViews
Delicatessen
Curved Glass
Models
07-2003
C
L
(See Note**)
25 5/8
(651)
Legs
Front
Refrigeration
Outlet
Water Seal
Waste Outlet
Leg Center Lines
Electrical
3
5/8
(92)
(See Note***)
ED1C-ICE
A
DCB
25
5
/
8
(651) 28
3
/
4
(730) 33
3
/
8
(849) 44
5
/
8
(1133)
46
(1168)
E
Dimensions shown as inches and (mm).
6 ft 8 ft 12 ft
General
(A) Length of Case* 72 1/4(1835) 96 1/4(2444) 144 1/2(3670)
*Each End and Partition adds 1 1/2inches (38 mm.) to the length of the lineup.
Maximum outside dimensions of case back to front 46 (1333) 46 (1168) 46 (1168)
(includes bumper and Rear Sill)
Back of case to front of splashguard 33 3/8(848) 33 3/8(848) 33 3/8(848)
Center of rear legs to center of front legs 25 5/8(651) 25 5/8(651) 25 5/8(651)
Electrical Service
(B) Righthand end of case to right edge of electrical raceway 7 (178) 7 (178) 7 (178)
(C) Righthand end of case to left edge of electrical raceway 44 1/2(1131) 44 1/2(1131) 44 1/2(1131)
Back outside of case to center of knockout 3 5/8(92) 3 5/8(92) 3 5/8(92)
**Note: Electrical Field Wiring Connection Point
Waste Outlet
(D) Right end of case to center of waste outlet 24 (611) 24 (611) 72 1/4(1835)
Left end of case to center of waste outlet 48 1/4(1835) 72 1/4(1835) 72 1/4(1835)
Back outside of case to center of waste outlet 25 5/8(652) 25 5/8(652) 25 5/8(652)
Water Seal
Edge of water seal to center of waste outlet 4 (102) 4 (102) 4 (102)
Outside diameter of drip pipe lines 1 1/2(38) 1 1/2(38) 1 1/2(38)
***Note: Field installed water seal outlets, tees, and connectors are shipped with the merchandiser.
Refrigeration Outlet
(E) Right end of case to center of refrigeration outlet 9 3/8(238) 9 3/8(238) 9 3/8(238)
Back of case to center of refrigeration outlet 28 3/4(730) 28 3/4(730) 28 3/4(730)
Outside diameter of the liquid line 3/8(9.5) 3/8(9.5) 3/8(9.5)
Outside diameter of the suction line 5/8(16) 5/8(16) 5/8(16)

ED1C-ICE
Refrigeration
Outlet Electrical
FAN
DAO
18
(457)
22 1/2
(572)
113/8(289)
35/8
(92) 133/4
(349)
34
(864)
25 5/8(651)
28 3/4(730)
33 3/8(849)
44 5/8(1133)
46(1168)
341/2
(875)
7 3/4(196)
Impact ED1C-ICE
Delicatessen
Dimensions shown in inches & (mm).
REFRIGERATION DATA
Note: This data is based on store
temperature and humidity that does not
exceed 75°F and 55% R.H. ED1C
Discharge Air (°F) 24
Evaporator(°F) 22
Unit Sizing (°F) 20
Btu/hr/ft* ED1C
Parallel 150
Conventional 155
*For all refrigeration equipment other
than Hussmann, use conventional Btu
values.
DEFROST DATA ED1C
Frequency (hr) 24
Defrost Water (lb/ft/day) NA
(± 15% based on case configuration and
product loading).
OFFTIME ED1C
Temp Term (°F) 70°F
Failsafe minutes 90
ELECTRIC OR GAS Not Recommended
Standard Defrost Thermostat N/A
CONVENTIONALCONTROLS
Low Pressure Backup Control ED1C
CI/CO** 28°F / 1°F
Indoor Unit Only, Pressure Defrost
Termination** N/A
**Use a Temperature Pressure Chart to
determine PSIG conversions.
PHYSICALDATA ED1C
Merchandiser Drip Pipe (in.) 1 1/2
Liquid Line (in.) 3/8
Suction Line (in.) 5/8
Estimated Charge (lb)***
12 ft 1.0
***This is an average for all refrigerant
types. Actual refrigerant charge may vary
by approximately half a pound.
Length Added to Lineup by:
Each Plastic End w/ Bumper (in.) 3 1/2
Each End/Partition (in.) 1 1/2
NOTE: The bumper is 4 inches wide. Center of the bumper is
18 1/2(470 mm.) inches from the floor.
Self Service Glass, Serpentine Coil, 1 Display Level
3 of 5
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
P/N 0454041

ED1C-ICE Data Sheet
4 of 5
Impact ED1C-ICE
Delicatessen
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
Electrical Data
Number of Fans 12 ft
Ambient Air Wipe — 15W 6
Amperes Watts
Merchandiser 12 ft 6 ft 12 ft
Fans (Refrigeration) NA NA
Fans (Ambient Air Wipe)
Standard (120V 60Hz) 1.56 60 90
Export (230V 50Hz) NA NA NA
Minimum Circuit Ampacity 1.76
Maximum Over Current Protection 120V 20
Optional Lighting*
Optional Ledge Lighting 0.71 85
*230V lighting values are under review.

5 of 5
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
P/N 0454041
R = Red G = Green BL = Blue LB = Light Blue DB = Dark Blue B = Black W = White
= 120V POWER = 120V NEUTRAL = Field GROUND = Case GROUND
Electric Service Receptacle Receptacles
120V N EUTRAL
MAROON
BAND
120V POWER
W
B
G
N.E.C.
TAGS MAROON
BAND
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
Circled Numbers = Parts List Item Numbers
BROWN BAND
Fans
BROWN BAND
120V POWER
120V NEUTRAL
1
Ambient Fan
Wiring
Glass Air Wipe
Fans
12 ft case has 6 Fans
W
BG
RR
BL
BL
R
BL
BL
GGG
2
33 3
Optional Ledge
Light Circuit Light Circuits