Hussmann IMPACT Elite E1S Instruction Manual

B
(Optional
Lights)
A
E
D
C
T'Stat Bulb
Location
P/N 0453531_B
Note: Changed items have been underlined.
E1S
Technical Data Sheet
P/N 0453531_B
NSF®Certified
July 2007
Item Part # Description Wiring Item #
FAN ASSEMBLIES AND THERMOSTATS
A. 4W Standard Fan Assembly (1)
0392457 Fan Motor, Evaporator
(MO.4410101)
0409513 Fan Blade, (FB.0409513)
embossing toward motor
4W Energy Efficient Fan Assembly (1)
0439051 Fan Motor, Evaporator
(MO.4410109)
0409513 Fan Blade, (FB.0409513)
embossing toward motor
B. 0411744 Standard Non-adjustable (2)
Defrost Thermostat (CT.0411744)
C. 0137880 Optional Adjustable (3)
Refrigeration Thermostat
(CT.4481084)
Item Part # Description Wiring Item #
HEATERS
D. 0496496 Heater, Anti-Sweat (4)
(HE.4850738)
LAMPS AND BALLASTS
E. 0355716 Ballast, Electronic
2 lamps (BA.0355716) (5)
0355398 Ballast, Electronic
3 lamps (BA.4480118)
Fluorescent Lamp (6)
Replace with like fixtures
We reserve the right to change or revise specifications
and product design in connection with any feature of
our products. Such changes do not entitle the buyer to
corresponding changes, improvements, additions or
replacements for equipment previously sold or shipped.
©2007 HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
U.S. & CANADA 1-800-922-1919 • MEXICO 1-800-522-1900 • WWW.HUSSMANN.COM

2 of 6 E1S Technical Data Sheet
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
Engineering
Plan Views Dimensions shown as inches and (mm).
10-2005
27 1/8
(689)
A
D
C
46 1/8
(1172)
30 1/4
(768)
51/4 (133)
E
34 1/8
(867)
Legs
Water Seal
C
L
Front
Refrigeration
Outlet
Electrical
B
Waste Outlet
E1S
Delicatessen
Precut & Packaged
Produce
4 ft 6 ft 8 ft 12 ft
General
(A) Case Length (without ends or partitions) 48 1/4(1226) 72 3/8(1838) 96 3/8 (2448) 144 1/2(3670)
Maximum O/S dimension back to front (with bumper) 46 1/8(1172) 46 1/8(1172) 46 1/8(1172) 46 1/8(1172)
Back of case to front of front panel 34 1/8 (867) 34 1/8 (867) 34 1/8 (867) 34 1/8 (867)
RH end of case to outside edge of external support 1 3/8(35) 1 3/8(35) 1 3/8(35) 1 3/8(35)
Distance between edges of
external support and center support NA 28 1/2(724) 40 1/2 (1029) 40 1/2 (1029)
Distance between edges of center supports NA NA NA 43 7/8 (1114)
Distance between edges of external supports 37 (940) NA NA NA
Electrical Service (Electrical Field Wiring connection point)
(C) Length of electrical raceway 34 1/2 (876) 26 (660) 38 (965) 38 (965)
RH End of case to center of farthest knockout 12 1/4 (311) 12 1/4 (311) 12 1/4 (311) 12 1/4 (311)
Back of case to center of end knockout 5 1/4 (133) 5 1/4 (133) 5 1/4 (133) 5 1/4 (133)
(B) RH End of case to RH end of raceway 6 7/8 (175) 6 7/8 (175) 6 7/8 (175) 6 7/8 (175)
Waste Outlet
(D) RH End of case to the center of waste outlet 24 1/8 (613) 24 1/8 (613) 24 1/8 (613) 72 1/4 (1835)
LH End of case to the center of waste outlet 24 1/8 (613) 48 1/4 (1226) 72 1/4 (1835) 72 1/4 (1835)
Back O/S of case to center of waste outlet 27 1/8 (689) 27 1/8 (689) 27 1/8 (689) 27 1/8 (689)
Water Seal
Edge of water seal to center of waste outlet 4 (102) 4 (102) 4 (102) 4 (102)
Outside diameter of the drip pipe 1 1/2 (38) 1 1/2 (38) 1 1/2 (38) 1 1/2 (38)
(Field installed water seal outlets, tees, and connectors
are shipped with the merchandiser.)
Refrigeration Outlet
Back of case to center of refrigeration outlet 30 1/4 (768) 30 1/4 (768) 30 1/4 (768) 30 1/4 (768)
(E) RH end of case to center of refrigeration outlet 8 3/8 (213) 8 3/8 (213) 8 3/8 (213) 8 3/8 (213)

REFRIGERATION DATA
Note: This data is based on store temperature
and humidity that does not exceed 75 (°F)
and 55% R.H.
E1S
Discharge Air (°F) 27
Evaporator (°F) 20
Unit Sizing (°F) 18
Btu/hr/ft E1S
Parallel 490
Conventional 525
DEFROST DATA
E1S
Frequency (hr) 12
Defrost Water 0.8 lb/ft/day
(± 15% based on case configuration and
product loading).
OFFTIME E1S
Temp Term (°F) 43
Failsafe (minutes) 90
ELECTRIC OR GAS Not Recommended
Standard Defrost Thermostat
Close on rise: close 48°F – open 33°F
CONVENTIONAL CONTROLS
Low Pressure Backup Control
CI/CO*E1S
Temp (°F) 13 / 3
Indoor Unit Only, Pressure Defrost
Termination Not Recommended
PHYSICAL DATA
Drip Pipe (in.) 1 1/2
Liquid Line (in.) 3/8
Suction Line (in.) 5/8
Estimated Charge (lb)** E1S
4 ft 0.8
6 ft 1.2
8 ft 1.5
12 ft 2.0
**This is an average for all refrigerant
types actual refrigerant charge may vary
by approximately half a pound.
Length (in.) Added to Lineup by Each
End or Insulated Partition 1
3 of 6
P/N 0453531_B HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. • WWW.HUSSMANN.COM
Impact Elite E1S
Delicatessen
Precut & Packaged Produce
Elite specialty self-serve merchandiser, straight front glass, 1 display level
NSF Certification
These merchandisers are manufactured to meet ANSI /National
Sanitation Foundation (NSF®) Standard #7 requirements.
E1S
22
(559)
33 1/8
(841)
7
(178)
FAN COIL
32
(813)
Refrigeration
Outlet
34 1/8
(867)
46 1/8
(1172)
4 3/4
(121)
12
(305)
27 1/8
(689)
30 1/4
(768)
37 3/8
(949)
8 7/8
(225)
Dimensions shown as in. & (mm).

4 of 6 E1S Technical Data Sheet
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.
Impact Elite E1S
Delicatessen
Precut & Packaged Produce
Electrical Data
4 ft 6 ft 8 ft 12 ft
Number of Fans — 4W 1223
Number of Fans — 4W (Export) 1223
(Export: 230V 50 hz shown)
Amperes Watts
Merchandiser 4 ft 6 ft 8 ft 12 ft 4 ft 6 ft 8 ft 12 ft
Fans
120V 60Hz Standard 0.31 0.62 0.62 0.93 24 48 48 72
120V 60Hz Energy Efficient 0.14 0.28 0.28 0.42 10 20 20 30
230V 50Hz Export 0.18 0.36 0.36 0.54 27 54 54 81
Constant On Anti-sweat Heaters 0.13 0.26 0.26 0.39 16 32 32 48
Minimum Circuit Ampacity
120V 60Hz Standard Fans 0.64 1.08 1.08 1.52
120V 60Hz Energy Efficient Fans 0.47 0.74 0.74 1.01
230V 50Hz Export Fans 0.51 0.82 0.82 1.13
Maximum Over Current Protection 20 20 20 20
230V 50Hz Export 15 15 15 15
Standard Lighting
None
Optional Lighting
1 Row of Rail Lights 0.49 0.49 0.49 0.71 59 59 59 86
1 Row of Ledge Lights 0.49 0.49 0.49 0.71 59 59 59 86
1 Row of Shelves
2 Rows of Shelves
3 Rows of Shelves

R = Red G = Green BL = Blue LB = Light Blue DB = Dark Blue B = Black W = White
= 120V POWER = 120V NEUTRAL = Field GROUND = Case GROUND
Fan Wiring
Offtime Defrost
Fans
Electric Service Receptacle Receptacles
120V N EUTRAL
MAROON
BAND
120V P OWER
W
B
G
N.E.C.
TAGS
MAROON
BAND
Defrost
Termination
Thermostat
Refrigeration
Thermostat
To
Condensing Unit
}
(Field Installed)
23
BROWN BAND
Fans
BROWN BAND
120V POWER
120V NEUTRAL
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
Circled Numbers = Parts List Item Numbers
Grayed components in 12 foot models only.
1
4 ft case has 1 Fan
6 ft case has 2 Fans
8 ft case has 2 Fans
12 ft case has 3 Fans
DB
DB
LB
LB
Anti-sweat Heaters 4
5 of 6
P/N 0453531_B HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A. • WWW.HUSSMANN.COM

Optional Lighting: 1 Row Ledge or 1 Row Rail
Light Circuits
WARNING
All components must have mechanical ground, and the merchandiser must be grounded.
= 120V POWER = 120V NEUTRAL
Grayed components in 12 foot models only.
R = Red Y = Yellow G = Green BL = Blue B = Black W = White
CIRCLED NUMBERS = PARTS LIST ITEM NUMBERS
120V NEUTRAL
ORANGE OR TAN BAND
W
Light
Switch
120V POWER
ORANGE OR TAN
BAND
B
BL
R
R
BL
BL
5
66
R
6
6 of 6 E1S Technical Data Sheet
HUSSMANN CORPORATION, Bridgeton, MO 63044-2483 U.S.A.