Icom DS-100 User manual

CLASS D/DSC TERMINAL
DS-100
SERVICE
MANUAL
DS-100_TOPCOVER.qxd 00.7.27 11:30 AM Page 1

INTRODUCTION
This service manual describes the latest service information
for the DS-100 CLASS D/DSC TERMINAL at the time of
publication
DANGER
NEVER connect the terminal unit to an AC outlet or to a DC
power supply that uses more than 16 V. This will ruin the
terminal unit.
DO NOT expose the terminal unit to rain, snow or any liquids.
DO NOT reverse the polarities of the power supply when
conecting the terminal unit.
DO NOT apply an RF signal of more than 20 dBm (100 mW)
to the antenna connector. This could damage the terminal
unit’s front end.
ORDERING PARTS
Be sure to include the following four points when ordering
replacement parts:
1. 10-digit order numbers
2. Component part number and name
3. Equipment model name and unit name
4. Quantity required
<SAMPLE ORDER>
1110003200 S.IC TA31136FN DS-100 MAIN UNIT 5 pieces
8810006050 Screw Icom screw E7 DS-100 Rear panel 10 pieces
Addresses are provided on the inside back cover for your
convenience.
REPAIR NOTES
1. Make sure a problem is internal before disassembling the
terminal unit.
2. DO NOT open the terminal unit until the terminal unit is
disconnected from its power source.
3. DO NOT force any of the variable components. Turn
them slowly and smoothly.
4. DO NOT short any circuits or electronic parts. An insu-
lated tuning tool MUST be used for all adjustments.
5. DO NOT keep power ON for a long time when the termi-
nal unit is defective.
6. READ the instructions of test equipment thoroughly
before connecting equipment to the terminal unit.
To upgrade quality, any electrical or mechanical parts and
internal circuits are subject to change without notice or
obligation.

TABLE OF CONTENTS
SECTION 1 SPECIFICATIONS
SECTION 2 INSIDE VIEWS
SECTION 3 CIRCUIT DESCRIPTION
3 - 1 RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 1
3 - 2 PLL CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 2
3 - 3 DSC CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 2
3 - 4 NMEAAND DATA INTERFACE CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 2
3 - 5 POWER SUPLLY CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 2
3 - 6 LOGIC CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 2
3 - 7 PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 2
SECTION 4 ADJUSTMENT PROCEDURES
4 - 1 PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 1
4 - 2 REFERENCE AND RECEIVER ADJUSTMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 2
SECTION 5 PARTS LIST
SECTION 6 MECHANICAL PARTS
SECTION 7 SEMI-CONDUCTOR INFORMATION
SECTION 8 BOARD LAYOUTS
8 - 1 LOGIC UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 - 1
8 - 2 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 - 3
SECTION 9 BLOCK DIAGRAM
SECTION 10 VOLTAGE DIAGRAM
10 - 1 LOGIC UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 - 1
10 - 2 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 - 2

1 - 1
SECTION 1 SPECIFICATIONS
‘‘GENERAL
• Frequency coverage : 156.525 MHz (Ch 70) Rx only
• Mode : 16K0G2B
• Power supply requirement : 13.8 V DC (negative ground)
• Usable temperature range : –20˚C to +60˚C
• Current drain (at 13.8 V DC) : 1.0 A (approx.)
• Antenna impedance : 50 Ω(nominal)
• Output impedance (for testing) : 100 kΩ(nominal)
• Dimensions (projections not included) : 165(W)×110(H)×78(D) mm
•Weight : 1 kg (approx.)
‘‘RECEIVER
•Receive system : Double conversion superheterodyne system
•Intermediate frequencies : 1st 21.7 MHz
2nd 450 kHz
•Sensitivity : -10 dBµ typical at 12 dB SINAD
•Adjacent channel selectivity : 70 dB
•Spurious response : 70 dB
•Intermodulation rejection ratio : 68 dB
•Hum and noise : –40 dB
Specifications are measured in accordance with EN301-025.
All stated specifications are subject to change without notice or obligation.

SECTION 2 INSIDE VIEWS
2 - 1
• MAIN UNIT
Speaker
(SP1: PS1740P02)
1st mixer
(Q2: 3SK166)
Crystal filter
(FI1, FI2: FL-310)
VCO circuit
PLL IC
(IC2: µPD3140GS)
2nd IF filter
(FI3: ALFY450E)
FM IF IC
(IC1: TA31136FN)
DSC decoder
(IC4: NJM2211M)
Reference Oscillator
(X2: CR-659 21.25 MHz)
• LOGIC UNIT
LCD driver
IC6, IC7: HD61202UFS
IC8: HD61203UFS
System clock
(X1: CR–610 7.9872 MHz)
Reset IC
(IC4: S-80928ANMP)
Inverter IC
(IC5: NJM2360M)
CPU
(IC1: MB90F583BPFV-G)

SECTION 3 CIRCUIT DESCRIPTION
3 - 1
3-1 RECEIVER CIRCUITS
3-1-1 RF AMPLIFER CIRCUIT (MAIN UNIT)
The RF circuit amplifies signals within the range of frequen-
cy coverage and filters out-of-band signals.
The signals from the antenna connector are amplified at the
RF amplifier (Q1) via the bandpass filter (L1, C3). The ampli-
fied signals are applied to the 1st mixer circuit (Q2) after out-
of-band signals are suppressed at the 3-stage of bandpass
filters (L2, L3, L4, C11, C14, C17).
3-1-2 1ST MIXER AND 1ST IF CIRCUITS
(MAIN UNIT)
The 1st mixer circuit converts the received signal into a fixed
frequency of the 1st IF signal with a PLL output frequency.
By changing the PLL frequency, only the desired frequency
will pass through a crystal filter at the next stage of the 1st
mixer.
The signals from the RF circuit are mixed at the 1st mixer
(Q2) with a 1st LO signal coming from the PLL circuit to pro-
duce a 21.7 MHz 1st IF signal.
The 1st IF signal is applied to the crystal filters (FI1, FI2) to
suppress out-of-band signals. The filtered 1st IF signal is
amplified at the 1st IF amplifier (Q3), then applied to the 2nd
mixer circuit (IC1, pin 16).
3-1-3 2ND IF AND DEMODULATOR CIRCUITS
(MAIN UNIT)
The 2nd mixer circuit converts the 1st IF signal into a 2nd IF
signal. A double conversion superheterodyne system (which
converts receive signals twice) improves the image rejection
ratio and obtains stable receiver gain.
The 1st IF signal from the IF amplifier is applied to the 2nd
mixer section of the FM IF IC (IC1, pin 16), and is mixed with
the 2nd LO signal to be converted into a 450 kHz 2nd IF sig-
nal.
The FM IF IC contains the 2nd mixer, limiter amplifier, quad-
rature detector and active filter circuits. A 2nd LO signal
(21.25 MHz) is produced at the PLL circuit using reference
frequency.
The 2nd IF signal from the 2nd mixer (IC1, pin 3) passes
through ceramic filter (FI3) to remove unwanted hetero-
dyned frequencies. It is then amplified at the limiter amplifi-
er (IC1, pin 5), and is applied to the quadrature detector
(IC1, pins 10, 11) to demodulate the 2nd IF signal into AF
signals.
3-1-4 SQUELCH CIRCUIT (MAIN UNIT)
A portion of the AF signals from the FM IF IC (IC1, pin 9) is
applied to the active filter section (IC1, pin 8) where noise
components are amplified and detected with an internal
noise detector. The squelch level adjustment pot (R29) is
connected to the active filter input (pin 8) to control the input
noise level.
The active filter section amplifies noise components. The fil-
tered signals are rectified at the noise detector section and
converted into “SQL”signal (DC voltage) at the noise com-
parator section. The “SQL”signal is output from pin 13.
This squelch circuit is only used for the BUSY detection of
Ch70, and is not related the DSC decoder sensitivity and
etc.
•2nd IF and demodulator circuits
Mixer
16
Limiter
amp.
2nd IF filter
450 kHz
PLL IC
IC2
X2
21.25 MHz
X1
(21.25 MHz)
RSSI
IC1 TA31136FN
13 1st IF (21.7 MHz)
from Q3
"SQL" signal to the CPU
(LOGIC unit; IC1) pin 38
11109
87 5 3
AF signal "DEMOD"
R8V
Squelch level
adjustment pot 2
17 16
Active
filter
FI3
Noise
detector
FM
detector

3 - 2
3-2 PLL CIRCUIT
3-2-1 PLL CIRCUIT (MAIN UNIT)
A PLL circuit provides stable oscillation of the receiver 1st
LO frequency. The PLL output compares the phase of the
divided VCO frequency to the reference frequency. The PLL
output frequency is controlled by the divided ratio (N-data) of
a programmable divider.
The PLL IC (IC2) contains a prescaler, programmable
counter, programmable divider phase detector, charge
pomp and etc. The entered signal is divided at the prescaler
and programmable counter section by the N-data ratio from
the CPU. The divided signal is detected on phase at the
phase detector using the reference frequency (21.25 MHz).
If the oscillated signal drifts, its phase changes from that of
the reference frequency, causing a lock voltage change to
compensate for the drift in the oscillated frequency.
3-3 DSC CIRCUITS
3-3-1 DSC DECODE CIRCUIT (MAIN UNIT)
The AF signals from FM IF IC (IC1, pin 9) are filtered at the
bandpass filter (IC3) with +18 dB/octave characteristics to
remove except 1300 Hz and 2100 Hz signals. The filtered
signals are converted analog signals into digital signals at
IC4, and are then applied to the CPU after shaping wave-
form at IC6.
3-3-2 DSC ENCODE CIRCUT (MAIN UNIT)
The DSC signals from the D/A outputs of CPU are amplified
at the buffer amplifier (Q17) and converted into 600 Ω
impedance at T1. The signals are output to the connected
transceiver as floating system output.
3-4 NMEA AND DATA INTERFACE
CIRCUITS
3-4-1 NMEA CIRCUIT (MAIN UNIT)
The NMEA signals (GGA) from OPC-945 are applied to IC5
and are shaped waveform at IC6, and are then applied to
the CPU.
3-4-2 DATA INTERFACE CIRCUIT (MAIN UNIT)
The control signals from the connected transceiver with
OPC-951 are applied to IC8 and are shaped wave form at
IC6, and are then applied to the CPU.
3-5 POWER SUPPLY CIRCUITS
3-5-1 VOLTAGE LINE (MAIN UNIT)
•PLL circuit
Shift register
Prescaler
Phase
detector
Loop
filter
Programmable
counter
Programmable
divider
X2
21.25 MHz
21.25 MHz signal
to the FM IF IC
VCO
Buffer
Buffer
Buffer Q8
Q7
Q6
3
4
5
PSTB
IC2 (PLL IC)
PCK
PDATA
to 1st mixer circuit
17
16
82
Q5, D4, D5
LINE
13.8 V
8 V
5 V
R8V
DESCRIPTION
The voltage from the connected transceiver.
Common 8 V converted from the 13.8 V line and
regulated by the 8 V regulator circuit (IC9).
Common 5 V converted from the 8 V line and
regulated by the 5 V regulator circuit (IC10).
8 V for receiver circuits regulated by the R8V
regulator circuit (Q15, Q16).

3 - 3
3-6 LOGIC CIRCUITS (LOGIC UNIT)
•CPU
IC1 is 16 bit single chip microcomputer and contains serial
I/O, timer, A/D converter, D/A converter, programmable I/O,
ROM and RAM.
•SYSTEM CLOCK CIRCUIT
X1 is a high-stability crystal oscillator and oscillated a
7.9872 MHz system clock for the CPU (IC1).
•RESET CIRCUIT
IC4 is a reset IC. When turn power ON, IC4 outputs a reset
signal (“LOW”pulse) to CPU (IC1, pin 75).
•LCD DRIVER
IC6–IC8 are LCD driver for a dot matrix LCD.
•INVERTER CIRCUIT
IC4 is a –8V DC-DC converter IC and converts –8 V from the
HV line. The converted voltage (–8V) is used for driving the
LCD.
•CLOCK CIRCUIT
IC3 is a clock IC and also used for backup the position/time
information for DSC.
•DIMMER CIRCUIT
Q2, Q3, Q6 are dimmer circuit and control the LCD backlight
(LED).
3-7 PORT ALLOCATIONS
3-7-1 CPU (LOGIC UNIT)
Outputs control signal for the LCD
contrast.
Input port for serial signal from the
NMEA connector (MAIN unit; J1) via
the photo coupler (MAIN unit; IC5)
and buffer amplifer (MAIN unit; IC6).
Outputs serial signal to the NMEA
connector (MAIN unit; J1) via the
buffer amplifier (Q13, Q14, D11).
Input port for noise level signal (DC
voltage) for squelch operation.
Output LCD backlight control signals
for the dimmer circuit (Q2, Q3, Q6).
Input port for the DSC decode signal.
Low : DSC signal is decoded.
Input port for the PLL unlock signal.
Low : While PLL is locked.
Outputs chip select signal for the LCD
drivers (IC6–IC8).
Output control signals for the LCD dri-
ver (IC6–IC8).
Input port for the control signal from
IC-M501EURO via the photo coupler
(MAIN unit; IC8) and buffer amplifier
(MAIN unit; IC6).
Outputs the control signal to IC-
M501EURO via the Buffer amplifier
(MAIN unit; Q11, Q12, D10).
Outputs busy LED (MAIN unit; DS1)
control signal.
Input port for the [ENT] key.
Input port for the [CLR] key.
Input port for the [CALL] key.
Input port for the [DISTRESS] key.
Outputs beep audio signal.
Outputs chip select signal for the clock
IC (IC3).
Outputs strobe signals for the PLL cir-
cuit.
Output data signals for the LCD driver
(IC6–IC8).
Outputs clock signal to the clock IC
(IC3).
Outputs serial signal for the clock IC
(IC3).
Input port for serial signal from the
clock IC (IC3).
Input port for the [1], [2] keys.
CADJ
NMEAI
NMEAO
SQL
DIM0–
DIM3
DDEC
UNLK
CS1,
CS2
RW,
DI, E
DATAS
DATAM
BUSY
KEY-ENT
KEY-CLR
KEY-CAL
KEY-DTR
BEEP
CCS
PSTB
DB0–
DB7
SCK
SO
SI
KEY-1,
KEY-2
31
36
37
38
41–44
45
46
52, 53
54,
55, 56
57
58
60
65
66
67
68
69
73
74
83–90
96
97
98
99, 100
1–7
8
10
11
12
13
14
15
19
20
23
24
26
30
KEY-3–
KEY-9
KEY-0
KEY-L
KEY-U
KEY-D
KEY-R
KEY-A
KEY-BS
CLRX
CLTX
ECK
EDA
RCEV
DSMOD
Input port for the [3]–[9] keys.
Input port for the [0] key.
Input port for the [LEFT] key.
Input port for the [UP] key.
Input port for the [DOWN] key.
Input port for the [RIGHT] key.
Input port for the [A/a] key.
Input port for the [BS] key.
Input port for the cloning data from the
buffer (MAIN unit; D8).
Output port for the cloning data to the
buffer (MAIN unit; Q9).
Outputs clock signal for EEPROM
(IC2).
Outputs serial data signal for EEP-
ROM (IC2).
Outputs the R8V regulator circuit
(MAIN unit; Q15, Q16) control signal.
High : While receiving
D/A output port for the DSC encode
signal to the buffer amplifier (MAIN
unit; Q17).
Pin Port Description
number name
Pin Port Description
number name

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE
4-1 PREPARATION
■REQUIRED TEST EQUIPMENT
4 - 1
SECTION 4 ADJUSTMENT PROCEDURES
DC power supply
Frequency counter
Standard signal
generator (SSG)
Distortion meter
Output voltage : 13.8 V DC
Current capacity : 2 A or more
Frequency range : 0.1–300 MHz
Frequency accuracy: ±1 ppm or better
Sensitivity : 100 mV or better
Frequency range : 0.1–300 MHz
Output level : 0.1 µV–32 mV
(–127 to –17 dBm)
Frequency range : 1 kHz ±10 %
Measuring range : 1–100 %
Digital multimeter
DC voltmeter
AC millivoltmeter
Oscilloscope
External speaker
Terminator
Measuring range : 10 mV–10 V
Input impedance : 50 kΩ/V DC or bet-
ter
Measuring range : 10 mV–10 V
Frequency range : DC–20 MHz
Measuring range : 0.01–20 V
Input impedance : 4 Ω
Capacity : 5 W or more
Impedance : 100 kΩ
‘‘CONNECTIONS
to the antenna connector Standard signal
generator
–17 to –125 dBm
(32 mV to 0.13 µV)
to DC cable
DC power supply
13.8 V /15 A
–+
Black Red
iM501EURODS-100

4-2 REFERENCE AND RECEIVER ADJUSTMENTS
4 - 2
LOCK
VOLTAGE
REFERENCE
FREQUENCY
SENSITIVITY
SQUELCH
ADJUSTMENT
ADJUSTMENT ADJUSTMENT CONDITION MEASUREMENT VALUE POINT
UNIT LOCATION UNIT ADJUST
1
1
1
1
•Receiving
•Receiving
•Connect an distortion meter with
an 100 kΩdummy load to the
extenal speaker jack J4 on MAIN
unit.
•Connect an SSG to the antenna
connector and set as:
Frequency : 156.525 MHz
Level : 10 µV*
(–97 dBm)
Modulation : 1 kHz
Deviation : ±3.0 kHz
•Receiving
•Turn R29 counter clockwise on
the MAIN unit to 9 o’clock posi-
tion.
•Connect an SSG to the antenna
connector and set as:
Frequency : 156.525 MHz
Level : 0.25 µV*
(–119 dBm)
Modulation : 1 kHz
Deviation : ±3.0 kHz
•Receiving
MAIN
MAIN
MAIN
MAIN
Connect a digital
multi-meter or oscil-
loscope to check
point CP3.
Connect a frequen-
cy counter to check
point CP4.
Connect a digital
multi-meter or oscil-
loscope to check
point CP1.
DS1
2.1 V
134.825000 MHz
Maximum voltage
At the point where the
check point DS1 just
turns OFF.
MAIN
MAIN
MAIN
MAIN
L9
C57
L1, L2,
L3, L4
Turn R29
to clock-
wise.
*This output level of a standard signal generator (SSG) is indicated as SSG’s open circuit.

4 - 3
Lock voltage
adjustment
L9
Squelch
adjustment
R29
L4
L1
L2
L3
Reference frequency
check point
Sensitivity
adjustment
CP4
Reference frequency
adjustment
C57
Lock voltage
check point
CP3
Sensitivity
check point
CP1
Squelch
check point
DS1
External SP
connector
J4
•MAIN unit

S.=Surface mount
IC1 1140008940 S.IC MB90F583BPFV-G
IC2 1130009680 S.IC HN58X2432TI
IC3 1130007450 S.IC RTC-4553A
IC4 1110004710 S.IC S-80928ANMP-DDR-T2
IC5 1110004200 S.IC NJM2360M-TE3
IC6 1130008850 S.IC HD61202UFS
IC7 1130008850 S.IC HD61202UFS
IC8 1130008860 S.IC HD61203UFS
IC9 1110003870 S.IC NJM2058M-T1
IC10 1110003870 S.IC NJM2058M-T1
Q2 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
Q3 1520000460 S.TRANSISTOR 2SB1132 T100 R
Q4 1510000580 S.TRANSISTOR 2SA1362-GR (TE85R)
Q5 1590000420 S.TRANSISTOR RN1404 (TE85R)
Q6 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
D1 1720000360 S.DIODE HSU88TRF
D2 1750000020 S.DIODE 1SS184 (TE85R)
D3 1790001470 S.DIODE SB10-05PCP-TD
D4 1790001010 S.ZENER MA8043-L (TX)
X1 6050010290 S.XTAL CR-610 (7.9872 MHz)
X2 6050011030 S.XTAL DMX-26S 32.768KHZ
L1 6200009370 S.COIL SLF7032T-221MR29-2
L2 6200008880 S.COIL SLF7032T-681MR16-2
R1 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R2 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R3 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R4 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R5 7410000990 S.ARRAY EXB-V8V 470JV
R9 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R10 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R11 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R12 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R13 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R14 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R15 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R16 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R17 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R18 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R19 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R20 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R21 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R22 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R23 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R24 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R25 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R26 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R27 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R28 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R29 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R30 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R31 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R32 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)
R33 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)
R34 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R35 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)
R36 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)
R37 7030006600 S.RESISTOR RR0816P-822-D (8.2 kΩ)
R38 7030006460 S.RESISTOR RR0816P-152-D (1.5 kΩ)
R39 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R40 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R41 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R42 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R43 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R44 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R45 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R46 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R47 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R48 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R49 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R50 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R51 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R52 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R53 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R54 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R55 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R56 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ)
R57 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R60 7030003220 S.RESISTOR ERJ3GEYJ 150 V (15 Ω)
R61 7030003220 S.RESISTOR ERJ3GEYJ 150 V (15 Ω)
R62 7030003220 S.RESISTOR ERJ3GEYJ 150 V (15 Ω)
R63 7030003220 S.RESISTOR ERJ3GEYJ 150 V (15 Ω)
R64 7030003220 S.RESISTOR ERJ3GEYJ 150 V (15 Ω)
R65 7030003220 S.RESISTOR ERJ3GEYJ 150 V (15 Ω)
R66 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)
R67 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)
R68 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)
R69 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
R70 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)
R71 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)
R72 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R73 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R74 7510000900 S.THERMISTOR NTCCF2012 3SH 223KC-T
R75 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)
R76 7030003790 S.RESISTOR ERJ3GEYJ 824 V (820 kΩ)
R77 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R78 7030003840 S.RESISTOR ERJ3GEYJ 225 V (2.2 MΩ)
R79 7030003810 S.RESISTOR ERJ3GEYJ 125 V (1.2 MΩ)
R80 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)
R81 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ)
R82 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R83 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R84 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R87 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R88 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
R89 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R90 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
R91 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
R92 7030003750 S.RESISTOR ERJ3GEYJ 394 V (390 kΩ)
R93 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
R94 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R95 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R96 7030004120 S.RESISTOR ERJ3GEYJ 203 V (20 kΩ)
R97 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ)
R98 7030004120 S.RESISTOR ERJ3GEYJ 203 V (20 kΩ)
R99 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R100 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R101 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R102 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R103 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R104 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)
R105 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R106 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R107 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)
C1 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C2 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C3 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C4 4030008890 S.CERAMIC C1608 JB 1C 273K-T-A
C6 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C7 4510006670 S.ELECTROLYTIC ECEV1CA471P
C8 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C9 4510005370 S.ELECTROLYTIC ECEV1AA221P
C10 4030011280 S.CERAMIC C1608 CH 1H 271J-T-A
C11 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C12 4510007120 S.ELECTROLYTIC ECEV1AA101SP
C13 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C14 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C15 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C16 4030009650 S.CERAMIC C1608 CH 1H 240J-T-A
C17 4030009650 S.CERAMIC C1608 CH 1H 240J-T-A
C18 4030007070 S.CERAMIC C1608 CH 1H 330J-T-A
5 - 1
SECTION 5 PARTS LIST
REF ORDER DESCRIPTION
NO. NO.
[LOGIC UNIT] REF ORDER DESCRIPTION
NO. NO.
[LOGIC UNIT]

[MAIN UNIT][LOGIC UNIT]
S.=Surface mount
C19 4030007010 S.CERAMIC C1608 CH 1H 100D-T-A
C20 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C21 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C22 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C23 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C24 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C25 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C26 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C27 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C28 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C29 4030009990 S.CERAMIC C1608 CH 1H 200J-T-A
C30 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C31 4550006660 S.TANTALUM ECST1CC226R
C32 4510005370 S.ELECTROLYTIC ECEV1AA221P
C33 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C34 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
J1 6510019500 S.CONNECTOR 52559-2290
J2 6510021300 S.CONNECTOR 52365-1091
J3 6510021860 CONNECTOR BH-800.8
DS1 5030001850 LCD TSD0402-UFFDCW
DS2 5040002310 S.LED SML-311YTT86
DS3 5040002310 S.LED SML-311YTT86
DS4 5040002310 S.LED SML-311YTT86
DS5 5040002310 S.LED SML-311YTT86
DS6 5040002310 S.LED SML-311YTT86
DS7 5040002310 S.LED SML-311YTT86
DS8 5040002310 S.LED SML-311YTT86
DS9 5040002310 S.LED SML-311YTT86
DS10 5040002310 S.LED SML-311YTT86
DS11 5040002310 S.LED SML-311YTT86
DS12 5040002310 S.LED SML-311YTT86
DS13 5040002310 S.LED SML-311YTT86
DS14 5040002310 S.LED SML-311YTT86
DS15 5040002310 S.LED SML-311YTT86
DS16 5040002310 S.LED SML-311YTT86
DS17 5040002310 S.LED SML-311YTT86
DS18 5040002310 S.LED SML-311YTT86
DS19 5040002310 S.LED SML-311YTT86
DS20 5040002310 S.LED SML-311YTT86
DS21 5040002310 S.LED SML-311YTT86
DS22 5040002310 S.LED SML-311YTT86
DS24 5040002310 S.LED SML-311YTT86
DS25 5040002310 S.LED SML-311YTT86
DS26 5040002310 S.LED SML-311YTT86
DS27 5040002310 S.LED SML-311YTT86
DS28 5040002310 S.LED SML-311YTT86
DS29 5040002310 S.LED SML-311YTT86
DS30 5040002310 S.LED SML-311YTT86
DS31 5040002310 S.LED SML-311YTT86
DS32 5040002310 S.LED SML-311YTT86
DS33 5040002310 S.LED SML-311YTT86
DS34 5040002310 S.LED SML-311YTT86
DS35 5040002310 S.LED SML-311YTT86
DS36 5040002310 S.LED SML-311YTT86
DS37 5040002310 S.LED SML-311YTT86
DS38 5040002310 S.LED SML-311YTT86
DS39 5040002310 S.LED SML-311YTT86
DS40 5040002310 S.LED SML-311YTT86
DS41 5040002310 S.LED SML-311YTT86
DS42 5040002310 S.LED SML-311YTT86
BT1 3020000020 LITHIUM CR2032
W1 8900006530 CABLE OPC-618
EP1 0910052953 PCB B 5475C
EP2 8930052541 LCD CONTACT SRCN-2349-SP-N-W-1
IC1 1110003200 S.IC TA31136FN (EL)
IC2 1130007610 S.IC µPD3140GS-E1 (DS8)
IC3 1110003750 S.IC M5218AFP 600C
IC4 1110003650 S.IC NJM2211M-TE1
IC5 1170000280 S.IC TLP121 (GB-TPL)
IC6 1130007420 S.IC TC7W14FU (TE12L)
IC8 1170000280 S.IC TLP121 (GB-TPL)
IC9 1110002030 IC TA7808S
IC10 1180001070 S.IC TA7805F (TE16L)
Q1 1580000700 S.FET 3SK292 (TE85R)
Q2 1580000490 S.FET 3SK166A-2-T7
Q3 1530002360 S.TRANSISTOR 2SC2714-Y (TE85R)
Q4 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
Q5 1560000330 S.FET 2SK210-GR (TE85R)
Q6 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)
Q7 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)
Q8 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)
Q9 1590000660 S.TRANSISTOR DTC144TU T107
Q11 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
Q12 1590000660 S.TRANSISTOR DTC144TU T107
Q13 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
Q14 1590000660 S.TRANSISTOR DTC144TU T107
Q15 1520000460 S.TRANSISTOR 2SB1132 T100 R
Q16 1590000660 S.TRANSISTOR DTC144TU T107
Q17 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
Q18 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
Q19 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
Q20 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
Q21 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
Q22 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
D2 1790001330 S.ZENER MA8036-L (TX)
D4 1790000640 S.VARICAP MA363B (TX)
D5 1790000640 S.VARICAP MA363B (TX)
D6 1750000550 S.DIODE 1SS355 TE-17
D8 1750000130 S.DIODE DA204U T107
D9 1750000550 S.DIODE 1SS355 TE-17
D10 1750000130 S.DIODE DA204U T107
D11 1750000130 S.DIODE DA204U T107
D12 1790000950 S.ZENER MA8056-M (TX)
D13 1790000950 S.ZENER MA8056-M (TX)
D14 1790000950 S.ZENER MA8056-M (TX)
FI1 2010002420 MONOLITH FL-310 (21R15AB)
FI2 2010002420 MONOLITH FL-310 (21R15AB)
FI3 2020001680 CERAMIC ALFY450E
X1 6070000210 S.DISCRIMINATOR CDBCA450CX24
X2 6050010800 S.XTAL CR-659 (21.25 MHz)
L1 6150003820 COIL LS-440
L2 6150003820 COIL LS-440
L3 6150003820 COIL LS-440
L4 6150003820 COIL LS-440
L5 6200003050 S.COIL NL 322522T-R82J-3
L6 6200004600 S.COIL MLF1608D R15K-T
L7 6200002410 S.COIL NL 252018T-056J
L8 6200003100 S.COIL NL 322522T-3R9J-3
L9 6130002360 S.COIL LB-257
L10 6200003090 S.COIL NL 322522T-2R7J-3
L11 6200004700 S.COIL MLR1608M R10K-T
L12 6200004700 S.COIL MLR1608M R10K-T
L13 6200004700 S.COIL MLR1608M R10K-T
L14 6200004920 S.COIL MLF1608A 2R2K-T
L15 6200002420 S.COIL NL 252018T-068J
R1 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ)
R3 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)
R4 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)
R5 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R6 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R7 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R8 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R9 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R12 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
5 - 2
REF ORDER DESCRIPTION
NO. NO. REF ORDER DESCRIPTION
NO. NO.

[MAIN UNIT][MAIN UNIT]
S.=Surface mount
R14 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
R15 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R16 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)
R17 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
R18 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R20 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R21 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R22 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R23 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)
R24 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
R25 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω)
R26 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)
R27 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
R28 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R29 7310002740 S.TRIMMER RV-150 (RH03A3A14X0FC) 103
R30 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)
R31 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R32 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)
R33 7410000950 S.ARRAY EXB-V8V 102JV
R34 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)
R36 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)
R37 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R38 7030003300 S.RESISTOR ERJ3GEYJ 680 V (68 Ω)
R39 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R40 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R41 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R42 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R43 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω)
R44 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)
R45 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω)
R46 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ)
R47 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R48 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ)
R49 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R50 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R51 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω)
R52 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)
R53 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
R54 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)
R55 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)
R56 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R57 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R58 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R59 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R60 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ)
R61 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R62 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)
R63 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R64 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)
R65 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)
R66 7310002720 S.TRIMMER RV-148
(RH03A3AS3X0DA) 472
R67 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)
R68 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R69 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R70 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R72 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ)
R73 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R74 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R75 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ)
R76 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R77 7030003210 S.RESISTOR ERJ3GEYJ 120 V (12 Ω)
R78 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R79 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)
R80 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R81 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ)
R82 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R83 7030003210 S.RESISTOR ERJ3GEYJ 120 V (12 Ω)
R84 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R85 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R86 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R87 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R88 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
R89 7410000990 S.ARRAY EXB-V8V 470JV
R90 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)
R91 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R94 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)
R95 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R96 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R97 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)
R98 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)
R99 7030003770 S.RESISTOR ERJ3GEYJ 564 V (560 kΩ)
R100 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ)
R101 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ)
R102 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)
R103 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)
R104 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)
R105 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R106 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R107 7030003290 S.RESISTOR ERJ3GEYJ 560 V (56 Ω)
R108 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R109 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R111 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R112 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R113 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R114 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R115 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ)
R116 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)
R117 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R118 7030003330 S.RESISTOR ERJ3GEYJ 121 V (120 Ω)
R119 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R120 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R121 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
R123 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ)
C1 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A
C2 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A
C3 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A
C4 4030009510 S.CERAMIC C1608 CH 1H 010B-T-A
C5 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C6 4030007170 S.CERAMIC C1608 CH 1H 221J-T-A
C7 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C8 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C9 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C10 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C11 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A
C12 4030006970 S.CERAMIC C1608 CH 1H 060D-T-A
C13 4030006970 S.CERAMIC C1608 CH 1H 060D-T-A
C14 4030006980 S.CERAMIC C1608 CH 1H 070D-T-A
C15 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-A
C16 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T-A
C17 4030006990 S.CERAMIC C1608 CH 1H 080D-T-A
C18 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C19 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C20 4030009920 S.CERAMIC C1608 CH 1H 050B-T-A
C21 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C22 4030007110 S.CERAMIC C1608 CH 1H 680J-T-A
C23 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C25 4030011770 S.CERAMIC C1608 CH 1H 060B-T-A
C27 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C28 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C29 4030008880 S.CERAMIC C1608 JB 1C 223K-T-A
C30 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C31 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C32 4030008880 S.CERAMIC C1608 JB 1C 223K-T-A
C33 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C34 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C36 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C37 4030007080 S.CERAMIC C1608 CH 1H 390J-T-A
C38 4030007080 S.CERAMIC C1608 CH 1H 390J-T-A
C39 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C40 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C41 4030007130 S.CERAMIC C1608 CH 1H 101J-T-A
C42 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C43 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C44 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C45 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C46 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C47 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C48 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C49 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C50 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C51 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C52 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C53 4030012600 S.CERAMIC C2012 JB 1A 105M-T-A
C54 4030007160 S.CERAMIC C1608 CH 1H 181J-T-A
C55 4030007160 S.CERAMIC C1608 CH 1H 181J-T-A
C56 4030007040 S.CERAMIC C1608 CH 1H 180J-T-A
C57 4610002150 S.TRIMMER CTZ3S-10A-W1-AF
C58 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A
C59 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C60 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C61 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C62 4030008880 S.CERAMIC C1608 JB 1C 223K-T-A
5 - 3
REF ORDER DESCRIPTION
NO. NO. REF ORDER DESCRIPTION
NO. NO.

[MAIN UNIT][MAIN UNIT]
S.=Surface mount
C63 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C64 4550006170 S.TANTALUM ECST1AY225R
C66 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C67 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C68 4030012600 S.CERAMIC C2012 JB 1A 105M-T-A
C69 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C70 4550000530 S.TANTALUM TESVA 1V 104M1-8L
C72 4030009520 S.CERAMIC C1608 CH 1H 020B-T-A
C73 4030009520 S.CERAMIC C1608 CH 1H 020B-T-A
C74 4030009910 S.CERAMIC C1608 CH 1H 040B-T-A
C75 4030009560 S.CERAMIC C1608 CH 1H R75B-T-A
C76 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C77 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C78 4030009990 S.CERAMIC C1608 CH 1H 200J-T-A
C79 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C80 4030009920 S.CERAMIC C1608 CH 1H 050B-T-A
C81 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A
C82 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C83 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A
C84 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C85 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C86 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C87 4030008850 S.CERAMIC C1608 JB 1C 123K-T-A
C88 4030008900 S.CERAMIC C1608 JB 1C 333K-T-A
C89 4030008900 S.CERAMIC C1608 JB 1C 333K-T-A
C90 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C91 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
C92 4030011810 S.CERAMIC C1608 JB 1A 224K-T-N
C93 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C94 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C95 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C96 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C97 4340000020 S.MYLAR ECWU 1C 333JB5
C98 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C99 4030006870 S.CERAMIC C1608 JB 1H 222K-T-A
C100 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C101 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
C102 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C103 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C104 4030006850 S.CERAMIC C1608 JB 1H 471K-T-A
C106 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
C107 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C108 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C109 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C110 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C111 4510004590 ELECTROLYTIC 16 MV 470 HC
C112 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C113 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C114 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C115 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C116 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C117 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C118 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C119 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C120 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C121 4030007090 S.CERAMIC C1608 CH 1H 470J-T-A
C123 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C124 4550006150 S.TANTALUM ECST1CY105R
C126 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C127 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C130 4030012600 S.CERAMIC C2012 JB 1A 105M-T-A
C131 4550006130 S.TANTALUM ECST1VY224R
C132 4030008890 S.CERAMIC C1608 JB 1C 273K-T-A
C133 4030008890 S.CERAMIC C1608 JB 1C 273K-T-A
C134 4030006870 S.CERAMIC C1608 JB 1H 222K-T-A
C135 4030009490 S.CERAMIC C1608 JB 1H 821K-T-A
C136 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C137 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C138 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C139 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C140 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C141 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C142 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C143 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C144 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C145 4030007030 S.CERAMIC C1608 CH 1H 150J-T-A
C146 4030007030 S.CERAMIC C1608 CH 1H 150J-T-A
C147 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C148 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C149 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C150 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C151 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
C152 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C153 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C154 4550006830 S.TANTALUM ECST1DY475R
C155 4030009490 S.CERAMIC C1608 JB 1H 821K-T-A
C156 4030006870 S.CERAMIC C1608 JB 1H 222K-T-A
C157 4510004630 S.ELECTROLYTIC ECEV1CA100SR
J1 6510022310 S.CONNECTOR B5B-PH-SM3-TB
J2 6510022030 S.CONNECTOR B10B-ZR-SM3-TF
J3 6510019500 S.CONNECTOR 52559-2290
J4 6510003380 S.CONNECTOR B02B-EH-S
DS1 5040002310 S.LED SML-311YTT86
T1 5920000570 TRANSFORMER 12T01
SP1 2520000110 PIEZO BUZZER PS1740P02
EP1 0910052942 PCB B 5473B
5 - 4
REF ORDER DESCRIPTION
NO. NO. REF ORDER DESCRIPTION
NO. NO.

J1 6510004880 Connector MR-DS-E 01 1
W1 8900009740 Cable OPC-945 1
W2 8900009690 Cable OPC-951 1
EP1 6910011940 Bead ZCAT2436-1330A-M 1
MP3 8410002340 2349 heatsink 1
MP4 8210017200 2349 front panel assembly 1
MP5 8210017150 2345 rear panel assembly 1
MP6 8930052060 2345 F-packing 1
MP7 8930052050 2345 R-packing 1
MP16 8930052430 2345 A-IC crip 1
MP18 8810008660 Screw PH BT M3 ×8 NI-ZU 5
MP19 8810008660 Screw PH BT M3 ×8 NI-ZU 7
MP20 8810004540 Screw M3 ×8 SUS 6
MP21 8810006050 Icom screw E7 6
MP22 8930052290 O ring (AD) 6
MP23 8850000690 Flat washer M3 (3×7×0.5) SUS 6
MP25 8810004540 Screw M3 ×8 SUS 2
MP26 8930034300 1542 ANT seal 1
MP27 8930049320 2288 VENT. sheet 1
REF. NO.
SECTION 6 MECHANICAL PARTS
[CHASSIS PARTS]
ORDER NO. DESCRIPTION QTY.
MP1 8610010560 2040 knob bolt (black) 2
MP2 8010018151 2345 mobile bracket-1 1
MP3 8850000500 Spring washer M5 SUS 2
MP4 8810001490 Screw PH A M5 ×20 SUS 2
MP5 8850000180 Flat washer M5 SUS 2
[UNPACKING]
REF. NO. ORDER NO. DESCRIPTION QTY.
6 - 1
REF. NO.
SP1 2520000110 Piezo buzzer PS1740P02 1
MP1 8510012590 2289 VCO case 1
[MAIN UNIT]
ORDER NO. DESCRIPTION QTY.
J3 6510021860 Connector BH-800.8 1
BT1 3020000110 Lithium CR2032 1
DS1 5030001850 LCD TSD0402-UFFDCW 1
EP2 8930052541 LCD contact SRCN-2349-SP-N-W-1 2
MP1 8210016790 2349 reflector 1
MP2 8930051950 2349 LCD holder 1
MP3 8930052530 2349 LCD filter 1
[LOGIC UNIT]
REF. NO. ORDER NO. DESCRIPTION QTY.
Screw abbreviations PH: Pan head BT: Self-Tapping
SUS: Stainless NI-ZU: Nickel-zinc

6 - 2
MAIN UNIT
LOGIC UNIT
MP7 (CH)
MP21 (CH)
MP23 (CH)
MP22 (CH)
MP20 (CH)
MP19 (CH)
MP4 (CH)
MP6 (CH)
MP2 (L)
DS1 (L)
EP2 (L)
MP18 (CH)
MP16 (CH)
MP1 (M)
J3 (L)
+BT1 (L)
MP3 (L)
MP1 (L)
MP5 (CH)
W2 (CH)
EP1 (CH)
W2 (CH)
SP1 (M)
MP25 (CH)
MP3 (CH)
J1 (CH)
W1 (CH)
MP26 (CH)
Unit abbreviations (CH): CHASSIS PARTS
(M): MAIN UNIT
(L): LOGIC UNIT

7 - 1
SECTION 7 SEMI-CONDUCTOR INFORMATION
• TRANSISTORS AND FET’S
2SA1362 GR 2SB1132T100 R 2SC2714Y 2SC4116 BL 2SC4215 O
2SK210 GR 3SK166A-2-T7 3SK292 DTC144TUT107 RN1404
(Symbol: AEG) (Symbol: BAR) (Symbol: QY) (Symbol: LL) (Symbol: QO)
(Symbol:YG) (Symbol: K) (Symbol: UK) (Symbol: 06) (Symbol: XD)
B
EC
B
C
E
B
EC
B
EC
B
EC
D
GS
D
S
G2
G1
D
S
G2
G1
B
E
C
B
E
C
•DIODES
1SS184 1SS355 DA204 U T107 HSU88TRF MA363 B
MA8036 L MA8043 L MA8056 M SB10 05PCPTD
(Symbol: B3) (Symbol: A) (Symbol: K) (Symbol: 9) (Symbol: 6D)
(Symbol: 3_6) (Symbol: 4_3) (Symbol: 5-6) (Symbol: SA)
C
A1
A2
ACAC

8 - 1
8-1 LOGIC UNIT
SECTION 8 BOARD LAYOUTS
• TOP VIEW

8 - 2
• BOTTOM VIEW
1
7
14
8
1
25
26
14
85
50
14
58
51
75
76
100
80 51
30
30 1
51 80 81
100
50
31
1
100
81
31
50
30 1
51 80 81
100
50
31
1
7
14
8
1
7
14
8
BEEP
8V
GND
5V
DATAM
NMEAI
DSMOD
SQL
CLRX UNLK
PCK
Vcc
BUSY
GND
DATAS
NMEAO
GND
DDEC
RCEV
CLTX
PDATA
PSTB
1
2
21
22 to MAIN unit J3
J1