IEI Technology KINO-PV-D5252 User manual

KINO-PV-D5252/D4252 Mini ITX SBC
Page i
User Manual
KINO-PV-D5252/D4252
Mini ITX SBC with Intel® Atom™ Processor D425/D525, DDR3
VGA, Dual LVDS, Dual GbE LAN, USB 2.0, SATA 3Gb/s, RoHS
MODEL:
Rev. 1.11 – November 6, 2015

KINO-PV-D5252/D4252 Mini ITX SBC
Page ii
Revision
Date Version Changes
November 6, 2015 1.11 Changed J2 to JP4
May 29, 2015 1.10 Updated for R11 version
January 17, 2012 1.02 Minor update to Figure 1.4 Data flow Block Diagram
Minor update to Figure 3-1: Connector and Jumper
Locations
Updated Table D-1 Digital I/O Connector Pinouts
June 17, 2011 1.01 Added KEY1 connector. Minor update to J_VLVDS1 and
J_VLVDS2 jumper settings.
March 24, 2011 1.00 Initial release

KINO-PV-D5252/D4252 Mini ITX SBC
Page iii
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

KINO-PV-D5252/D4252 Mini ITX SBC
Page iv
Manual Conventions
WARNING
Warnings appear where overlooked details may cause damage to the
equipment or result in personal injury. Warnings should be taken
seriously.
CAUTION
Cautionary messages should be heeded to help reduce the chance of
losing data or damaging the product.
NOTE
These messages inform the reader of essential but non-critical
information. These messages should be read carefully as any directions
or instructions contained therein can help avoid making mistakes.
HOT SURFACE
This symbol indicates a hot surface that should not be touched without
taking care.

KINO-PV-D5252/D4252 Mini ITX SBC
Page v
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 INTRODUCTION........................................................................................................... 2
1.2 CONNECTORS ............................................................................................................. 3
1.3 DIMENSIONS............................................................................................................... 4
1.4 DATA FLOW................................................................................................................ 5
1.5 TECHNICAL SPECIFICATIONS ...................................................................................... 6
2 UNPACKING................................................................................................................. 8
2.1ANTI-STATIC PRECAUTIONS........................................................................................ 9
2.2 UNPACKING PRECAUTIONS......................................................................................... 9
2.3 PACKING LIST........................................................................................................... 10
2.3.1 Optional Items...................................................................................................11
3 CONNECTORS ........................................................................................................... 12
3.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 13
3.1.1 KINO-PV-D5252/D4252 Layout...................................................................... 13
3.1.2 Peripheral Interface Connectors ..................................................................... 14
3.1.3 External Interface Panel Connectors............................................................... 15
3.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 15
3.2.1 12V Power Connector...................................................................................... 15
3.2.2 Battery Connector............................................................................................ 16
3.2.3 CompactFlash® Slot........................................................................................ 17
3.2.4 Digital I/O Connector...................................................................................... 19
3.2.5 Fan Connector (CPU)...................................................................................... 20
3.2.6 Fan Connector................................................................................................. 21
3.2.7 Flash SPI ROM................................................................................................ 22
3.2.8 Front Panel Connector .................................................................................... 23
3.2.9 Keyboard/Mouse Connector............................................................................ 24
3.2.10 Keypad Connector ......................................................................................... 24
3.2.11 LVDS1 Connector (For Intel® Atom™ processor D525 dual LVDS only) ... 25

KINO-PV-D5252/D4252 Mini ITX SBC
Page vi
3.2.12 LVDS1 Backlight Inverter Connector............................................................ 27
3.2.13 LVDS2 Connector.......................................................................................... 28
3.2.14 LVDS2 Backlight Inverter Connector............................................................ 29
3.2.15 Parallel Port Connector ................................................................................ 29
3.2.16 PCIe Mini Card Slot ...................................................................................... 31
3.2.17 SATA Drive Connectors ................................................................................. 32
3.2.18 SATA Power Connectors................................................................................ 33
3.2.19 Serial Port Connectors (RS-232)................................................................... 35
3.2.20 Serial Port Connector (RS-232)..................................................................... 36
3.2.21 SMBus Connector .......................................................................................... 37
3.2.22 USB Connectors............................................................................................. 38
3.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 39
3.3.1 Audio Connector .............................................................................................. 40
3.3.2 Ethernet and USB Connector........................................................................... 40
3.3.3 Power Connector............................................................................................. 42
3.3.4 Serial Port Connector...................................................................................... 42
3.3.5 VGA Port Connector........................................................................................ 43
4 INSTALLATION ......................................................................................................... 45
4.1ANTI-STATIC PRECAUTIONS...................................................................................... 46
4.2 INSTALLATION CONSIDERATIONS.............................................................................. 47
4.2.1 Installation Notices.......................................................................................... 47
4.3 UNPACKING.............................................................................................................. 48
4.4 SO-DIMM INSTALLATION ....................................................................................... 48
4.4.1 SO-DIMM Installation..................................................................................... 49
4.5 COMPACTFLASH®INSTALLATION ............................................................................ 50
4.6 JUMPER SETTINGS .................................................................................................... 51
4.6.1 AT/ATX Power Select Jumper Settings ............................................................ 52
4.6.2 Clear CMOS Jumper........................................................................................ 53
4.6.3 CompactFlash® Card Setup Jumper............................................................... 54
4.6.4 LVDS1 Panel Resolution Type Select Jumper (For Intel® Atom™ processor
D525 dual LVDS only).............................................................................................. 55
4.6.5 LVDS2 Panel Resolution Select Jumper.......................................................... 56
4.6.6 LVDS1 Voltage Select setting........................................................................... 57
4.6.7 LVDS2 Voltage Select setting........................................................................... 58

KINO-PV-D5252/D4252 Mini ITX SBC
Page vii
4.6.8 Serial Port Setting Jumper............................................................................... 59
4.7 CHASSIS INSTALLATION............................................................................................ 60
4.7.1 Airflow.............................................................................................................. 60
4.7.2 Motherboard Installation................................................................................. 60
4.8 INTERNAL PERIPHERAL DEVICE CONNECTIONS........................................................ 61
4.8.1 AT/ATX Power Connection.............................................................................. 61
4.8.2 Single RS-232 Cable with Slot Bracket............................................................ 62
4.9 SOFTWARE INSTALLATION ........................................................................................ 63
5 BIOS SCREENS........................................................................................................... 65
5.1 INTRODUCTION......................................................................................................... 66
5.1.1 Starting Setup................................................................................................... 66
5.1.2 Using Setup...................................................................................................... 66
5.1.3 Getting Help..................................................................................................... 67
5.1.4 Unable to Reboot After Configuration Changes.............................................. 67
5.1.5 BIOS Menu Bar................................................................................................ 67
5.2 MAIN........................................................................................................................ 68
5.3ADVANCED............................................................................................................... 69
5.3.1 ACPI Settings................................................................................................... 70
5.3.2 Trusted Computing........................................................................................... 71
5.3.3 CPU Configuration.......................................................................................... 72
5.3.4 IDE Configuration........................................................................................... 73
5.3.5 USB Configuration........................................................................................... 74
5.3.6 Super IO Configuration ................................................................................... 75
5.3.6.1 Serial Port 0 Configuration....................................................................... 76
5.3.6.2 Parallel Port Configuration....................................................................... 79
5.3.7 H/W Monitor.................................................................................................... 81
5.3.8 Secondary Super IO Configuration ................................................................. 83
5.3.8.1 Serial Port 5 Configuration....................................................................... 83
5.3.8.2 Serial Port 6 Configuration....................................................................... 84
5.3.9 Serial Port Console Redirection ...................................................................... 85
5.4 CHIPSET ................................................................................................................... 86
5.4.1 Host Bridge Configuration .............................................................................. 87
5.4.1.1 Memory Frequency and Timing................................................................ 88
5.4.1.2 OnChip VGA Configuration..................................................................... 89

KINO-PV-D5252/D4252 Mini ITX SBC
Page viii
5.4.2 South Bridge Configuration............................................................................. 90
5.4.3 Intel IGD SWSCI OpRegion............................................................................. 91
5.5 BOOT........................................................................................................................ 94
5.6 SECURITY................................................................................................................. 95
5.7 EXIT......................................................................................................................... 96
A REGULATORY COMPLIANCE.............................................................................. 98
B BIOS OPTIONS ........................................................................................................ 100
C TERMINOLOGY ..................................................................................................... 103
D DIGITAL I/O INTERFACE..................................................................................... 107
D.1 INTRODUCTION...................................................................................................... 108
D.2ASSEMBLY LANGUAGE SAMPLE 1.......................................................................... 109
D.3ASSEMBLY LANGUAGE SAMPLE 2.......................................................................... 109
E WATCHDOG TIMER................................................................................................110
F HAZARDOUS MATERIALS DISCLOSURE.........................................................113
F.1 HAZARDOUS MATERIALS DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS
ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY ......................................114

KINO-PV-D5252/D4252 Mini ITX SBC
Page ix
List of Figures
Figure 1-1: KINO-PV-D5252/D4252................................................................................................2
Figure 1-2: Connectors ..................................................................................................................3
Figure 1-3: KINO-PV-D5252/D4252 Dimensions (mm) ................................................................4
Figure 1-4: Data Flow Block Diagram...........................................................................................5
Figure 3-1: Connector and Jumper Locations...........................................................................13
Figure 3-2: 12 V Power Connector Location..............................................................................16
Figure 3-3: Battery Connector Location.....................................................................................17
Figure 3-4: CompactFlash® Slot Location.................................................................................18
Figure 3-5: Digital I/O Connector Locations ..............................................................................19
Figure 3-6: CPU Fan Connector Location..................................................................................20
Figure 3-7: Fan Connector Location...........................................................................................21
Figure 3-8: Flash SPI ROM Connector Location .......................................................................22
Figure 3-9: Front Panel Connector Location .............................................................................23
Figure 3-10: Keyboard/Mouse Connector Location..................................................................24
Figure 3-11: Keypad Connector Location..................................................................................25
Figure 3-12: LVDS1 Connector Location ...................................................................................26
Figure 3-13: LVDS1 Backlight Inverter Connector Location....................................................27
Figure 3-14: LVDS2 Connector Location ...................................................................................28
Figure 3-15: LVDS2 Backlight Inverter Connector Location....................................................29
Figure 3-16: Parallel Port Connector Location..........................................................................30
Figure 3-17: PCIe Mini Card Slot Location.................................................................................31
Figure 3-18: SATA Drive Connector Locations .........................................................................33
Figure 3-19: SATA Power Connector Locations .......................................................................34
Figure 3-20: SATA Power Connector Locations .......................................................................35
Figure 3-21: Serial Port (COM5 and COM6) Connector Pinout Locations..............................36
Figure 3-22: Serial Port (COM2) Connector Location...............................................................37
Figure 3-23: SMBus Connector Locations.................................................................................38
Figure 3-24: USB Connector Pinout Locations.........................................................................39
Figure 3-25: KINO-PV-D5252/D4252 External Peripheral Interface Connector ......................40
Figure 3-26: Audio Connector.....................................................................................................40

KINO-PV-D5252/D4252 Mini ITX SBC
Page x
Figure 3-27: RJ-45 Ethernet Connector......................................................................................41
Figure 3-28: VGA Connector .......................................................................................................43
Figure 4-1: SO-DIMM Installation................................................................................................49
Figure4-2: SO-DIMM Connector Location..................................................................................49
Figure 4-3: CompactFlash® Card Installation ...........................................................................51
Figure 4-4: AT/ATX Power Select Jumper Location..................................................................53
Figure 4-5: Clear CMOS Jumper .................................................................................................54
Figure 4-6: CompactFlash® Setup Jumper Location ...............................................................55
Figure 4-7: LVDS1 Panel Resolution Jumper Location............................................................56
Figure 4-8: LVDS2 Panel Resolution Jumper Location............................................................57
Figure 4-9: LVDS1 Voltage Select Jumper Location.................................................................58
Figure 4-10: LVDS2 Voltage Select Jumper Location...............................................................59
Figure 4-11: Serial Port Jumper Locations................................................................................60
Figure 4-12: Power Cable to Motherboard Connection............................................................61
Figure 4-13: Connect Power Cable to Power Supply................................................................62
Figure 4-14: Single RS-232 Cable Installation ...........................................................................63
Figure 4-15: Introduction Screen................................................................................................64
Figure 4-16: Available Drivers.....................................................................................................64

KINO-PV-D5252/D4252 Mini ITX SBC
Page xi
List of Tables
Table 1-1: Technical Specifications..............................................................................................7
Table 3-1: Peripheral Interface Connectors...............................................................................14
Table 3-2: Rear Panel Connectors..............................................................................................15
Table 3-3: 12 V Power Connector Pinouts .................................................................................16
Table 3-4: Battery Connector Pinouts........................................................................................17
Table 3-5: CompactFlash® Slot Pinouts....................................................................................19
Table 3-6: Digital I/O Connector Pinouts....................................................................................20
Table 3-7: CPU Fan Connector Pinouts......................................................................................21
Table 3-8: Fan Connector Pinouts..............................................................................................22
Table 3-9: SPI Flash Connector Pinouts ....................................................................................22
Table 3-10: Front Panel Connector Pinouts...............................................................................23
Table 3-11: Keyboard/Mouse Connector Pinouts .....................................................................24
Table 3-12: Keypad Connector Pinouts......................................................................................25
Table 3-13: LVDS1 Connector Pinouts.......................................................................................27
Table 3-14: LVDS1 Backlight Inverter Connector Pinouts .......................................................27
Table 3-15: LVDS2 Connector Pinouts.......................................................................................28
Table 3-16: LVDS2 Backlight Inverter Connector Pinouts .......................................................29
Table 3-17: Parallel Port Connector Pinouts .............................................................................30
Table 3-18: PCIe Mini Card Slot Pinouts ....................................................................................32
Table 3-19: SATA Drive Connector Pinouts...............................................................................33
Table 3-20: SATA Power Connector Pinouts.............................................................................34
Table 3-21: SATA Power Connector Pinouts.............................................................................35
Table 3-22: Serial Port Connector Pinouts ................................................................................36
Table 3-23: Serial Port (COM2) Connector Pinouts...................................................................37
Table 3-24: SMBus Connector Pinouts ......................................................................................38
Table 3-25: USB Port Connector Pinouts...................................................................................39
Table 3-26: LAN Pinouts ..............................................................................................................41
Table 3-27: RJ-45 Ethernet Connector LEDs.............................................................................41
Table 3-28: USB Pinouts..............................................................................................................42
Table 3-29: Power Connector Pinouts........................................................................................42

KINO-PV-D5252/D4252 Mini ITX SBC
Page xii
Table 3-30: Serial Port Pinouts....................................................................................................43
Table 3-31: VGA Connector Pinouts...........................................................................................44
Table 4-1: Jumpers.......................................................................................................................52
Table 4-2: AT/ATX Power Select Jumper Settings....................................................................52
Table 4-3: Clear CMOS Jumper Settings....................................................................................54
Table 4-4: CompactFlash® Setup Jumper Settings..................................................................54
Table 4-5: LVDS1 Panel Resolution Jumper Settings...............................................................56
Table 4-6: LVDS2 Panel Resolution Jumper Settings...............................................................57
Table 4-7: LVDS1 Voltage Select Jumper Settings...................................................................58
Table 4-8: LVDS2 Voltage Select Jumper Settings...................................................................58
Table 4-9: Serial Port Jumper Settings.......................................................................................59
Table 5-1: BIOS Navigation Keys................................................................................................67

KINO-PV-D5252/D4252 Mini ITX SBC
Page xiii
BIOS Menus
BIOS Menu 1: Main.......................................................................................................................68
BIOS Menu 2: Advanced..............................................................................................................69
BIOS Menu 3: ACPI Settings .......................................................................................................70
BIOS Menu 4: TPM Configuration...............................................................................................71
BIOS Menu 5: CPU Configuration...............................................................................................72
BIOS Menu 6: IDE Configuration.................................................................................................73
BIOS Menu 7: USB Configuration...............................................................................................74
BIOS Menu 8: Super IO Configuration........................................................................................75
BIOS Menu 9: Serial Port 0 Configuration Menu.......................................................................76
BIOS Menu 10: Parallel Port Configuration Menu.....................................................................79
BIOS Menu 11: Hardware Health Configuration........................................................................81
BIOS Menu 12: Secondary Super IO Configuration..................................................................83
BIOS Menu 13: Serial Port Console Redirection.......................................................................85
BIOS Menu 14: Chipset................................................................................................................86
BIOS Menu 15: Host Bridge Chipset Configuration..................................................................87
BIOS Menu 16: Memory Frequency and Timing Configuration...............................................88
BIOS Menu 17: OnChip VGA Configuration...............................................................................89
BIOS Menu 18: South Bridge Chipset Configuration................................................................90
BIOS Menu 19: Intel IGD SWSCI OpRegion ...............................................................................92
BIOS Menu 20: Boot.....................................................................................................................94
BIOS Menu 21: Security...............................................................................................................95
BIOS Menu 22: Exit.......................................................................................................................96

KINO-PV-D5252/D4252 Mini ITX SBC
Page 1
Chapter
1
1 Introduction

KINO-PV-D5252/D4252 Mini ITX SBC
Page 2
1.1 Introduction
Figure 1-1: KINO-PV-D5252/D4252
The KINO-PV-D5252/D4252 Mini ITX motherboard is an Intel® Atom™ processor D525 or
D425 platform. Up to two 4.0 GB 800 MHz DDR3 SDRAM SO-DIMMs are supported by
the KINO-PV-D5252/D4252.
The integrated Intel® ICH8M Chipset supports two GbE LAN ports through two Realtek
RTL8111E Ethernet controllers (with ASF 2.0 support on LAN1). The
KINO-PV-D5252/D4252 also supports two SATA 3Gb/s drives and provides 5 V SATA
power.
The KINO-PV-D5252/D4252 supports an integrated GMA 3150 graphics card with a
graphic core speed of 400MHz. Eight USB 2.0 channels, one PCI slot, one PCIe Mini
socket, one CompactFlash® connector and one PCIe x1 slot provide flexible expansion
options. High Definition Audio (HDA) support ensures HDA devices can be easily
implemented on the KINO-PV-D5252/D4252. Serial device connectivity is provided by
three external RS-232 ports, two internal RS-232 ports and one internal RS-232/422/485
connector.

KINO-PV-D5252/D4252 Mini ITX SBC
Page 3
1.2 Connectors
The connectors on the KINO-PV-D5252/D4252 are shown in the figure below.
Figure 1-2: Connectors

KINO-PV-D5252/D4252 Mini ITX SBC
Page 4
1.3 Dimensions
The dimensions of the board are listed below:
Figure 1-3: KINO-PV-D5252/D4252 Dimensions (mm)

KINO-PV-D5252/D4252 Mini ITX SBC
Page 5
1.4 Data Flow
5Figure 1-4 shows the data flow between the two on-board chipsets and other components
installed on the motherboard and described in the following sections of this chapter.
Figure 1-4: Data Flow Block Diagram

KINO-PV-D5252/D4252 Mini ITX SBC
Page 6
1.5 Technical Specifications
KINO-PV-D5252/D4252 technical specifications are listed in table below.
Specification KINO-PV-D5252/D4252
Form Factor Mini ITX
CPU Options Intel® Atom™ processor D525, 1.8 GHz/1MB L2 cache
Intel® Atom™ processor D425, 1.8 GHz/512KB L2 cache
Express Chipset Intel® ICH8M
Graphics Engine GMA 3150
Memory Two 204-pin SO-DIMM sockets support 800 MHz 4.0 GB (max.)
DDR3 SDRAM SO-DIMM
Audio Realtek ALC662-GR HD audio codec
LAN Two Realtek RTL8111E PCIe GbE controllers with ASF 2.0 support
on LAN1
Super I/O Fintek F81865
Digital I/O 8-bit digital I/O
BIOS UEFI BIOS label
SMBus One 4-pin wafer connector
Watchdog Timer Software programmable supports 1~255 sec. system reset
Expansion
PCIe One PCIe Mini slot (PCIe + USB + SATA signal)
One PCIe x1 slot
PCI One PCI slot
I/O Interface Connectors
Display Ports Analog CRT, resolution support up to 2048x1536
CRT hot plug supported
18-bit single-channel LVDS, resolution support up to WXGA
1366x768 or XGA1024x768
24-bit dual-channel LVDS by Novatek NT68660BUFG, resolution
support up to 1920x1080

KINO-PV-D5252/D4252 Mini ITX SBC
Page 7
Specification KINO-PV-D5252/D4252
Ethernet Two RJ-45 GbE ports by Realtek RTL8111E with ASF 2.0 support
on LAN1
Serial Ports Three RS-232 via Rear I/O
Two RS-232 via four 10-pin headers
One RS-232/422/485 via 14–pin header
USB 2.0/1.1 Ports Four external USB ports
Four internal USB ports via 8-pin headers
Parallel Ports One LPT connector via 26-pin header
TPM INFINEON SLB9635TT1.2 (Optional)
Storage
Serial ATA Two SATA 3.0 Gb/s connectors
One 5 V SATA power connector
One 5 V/12 V SATA power connector
Environmental and Power Specifications
Power Supply 12 V only
ATX and AT power supported
Power Connector One external DIN 4-pin DC jack
One internal 4-pin power connector
Power Consumption 12 V @ 1.95A (Intel® Atom™ D525 1.8GHz with DDR3 1GB*2)
Operating Temperature -20°C ~ 60°C with free air, -20°C ~ 70°C with force air for D525
processor
-20°C ~ 65°C with free air, -20°C ~ 70°C with force air for D425
processor
Humidity 5% ~ 95% (non-condensing)
Physical Specifications
Dimensions 170 mm x 170 mm
Weight GW/NW 800 g / 340 g
Table 1-1: Technical Specifications