IEI Technology KINO-DH610 User manual

KINO-DH610
Page I
IEI Technology Corp.
User Manual
KINO-DH610
MODEL:
Mini-ITX SBC Supports LGA1155 for Intel® Core™ i3
/
Pentium
®
/
Celeron® CPU, DDR3, VGA/DVI-D/HDMI, Dual PCIe GbE, Ten USB 2.0,
Four SATA 3Gb/s, HD Audio and RoHS
Rev. 1.00 - 30 December, 2011
KINO-DH610 CPU Card

KINO-DH610
Page II
Revision
Date Version Changes
30 December, 2011 1.00 Initial release

KINO-DH610
Page III
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

KINO-DH610
Page IV
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 INTRODUCTION........................................................................................................... 2
1.2 CONNECTORS ............................................................................................................. 2
1.3 DIMENSIONS............................................................................................................... 4
1.4 DATA FLOW................................................................................................................ 5
1.5 TECHNICAL SPECIFICATIONS ...................................................................................... 6
2 UNPACKING................................................................................................................. 9
2.1ANTI-STATIC PRECAUTIONS...................................................................................... 10
2.2 UNPACKING PRECAUTIONS....................................................................................... 10
2.3 PACKING LIST............................................................................................................11
2.4 OPTIONAL ITEMS...................................................................................................... 12
3 CONNECTORS ........................................................................................................... 14
3.1 PERIPHERAL INTERFACE CONNECTORS..................................................................... 15
3.1.1 KINO-DH610 Layout....................................................................................... 15
3.1.2 Peripheral Interface Connectors ..................................................................... 16
3.1.3 External Interface Panel Connectors............................................................... 17
3.2 INTERNAL PERIPHERAL CONNECTORS...................................................................... 17
3.2.1 Battery Connector............................................................................................ 17
3.2.2 BIOS Update Connector.................................................................................. 18
3.2.3 DDR3 SO-DIMM Slots .................................................................................... 19
3.2.4 Debug Port Connector..................................................................................... 20
3.2.5 Digital I/O Connector...................................................................................... 21
3.2.6 EC Update Connector...................................................................................... 22
3.2.7 Fan Connector (CPU)...................................................................................... 23
3.2.8 Fan Connector (PCH)...................................................................................... 24
3.2.9 Front Panel Connector .................................................................................... 24
3.2.10 Keyboard/Mouse Connector .......................................................................... 25
3.2.11 PCI Slot.......................................................................................................... 26
3.2.12 PCIe x1 Slot ................................................................................................... 27

KINO-DH610
Page V
3.2.13 Power Connector........................................................................................... 28
3.2.14 SATA Drive Connectors ................................................................................. 28
3.2.15 SATA Power Connectors................................................................................ 29
3.2.16 Serial Port Connector (RS-232/422/485) ...................................................... 30
3.2.17 TPM Connector.............................................................................................. 31
3.2.18 USB Connectors............................................................................................. 32
3.3 EXTERNAL PERIPHERAL INTERFACE CONNECTOR PANEL ......................................... 33
3.3.1 Audio Connector .............................................................................................. 34
3.3.2 Ethernet and USB Connector........................................................................... 34
3.3.3 HDMI Connector............................................................................................. 35
3.3.4 Power Connector............................................................................................. 36
3.3.5 RS-232 Serial Port........................................................................................... 37
3.3.6 VGA and DVI Connector ................................................................................. 38
4 INSTALLATION ......................................................................................................... 39
4.1ANTI-STATIC PRECAUTIONS...................................................................................... 40
4.2 INSTALLATION CONSIDERATIONS.............................................................................. 41
4.3 BASIC INSTALLATION ............................................................................................... 42
4.3.1 Socket LGA1155 CPU Installation .................................................................. 42
4.3.2 Cooling Kit Installation ................................................................................... 45
4.3.3 DIMM Installation........................................................................................... 47
4.4 JUMPER SETTINGS .................................................................................................... 48
4.4.1 AT/ATX Mode Select Jumper ........................................................................... 48
4.4.2 Clear CMOS Jumper........................................................................................ 49
4.5 INTERNAL PERIPHERAL DEVICE CONNECTIONS........................................................ 50
4.5.1 SATA Drive Connection ................................................................................... 51
4.6 EXTERNAL PERIPHERAL INTERFACE CONNECTION ................................................... 52
4.6.1 Audio Connection............................................................................................. 53
4.6.2 DVI Display Device Connection...................................................................... 53
4.6.3 HDMI Display Device Connection.................................................................. 54
4.6.4 LAN Connection............................................................................................... 55
4.6.5 Serial Device Connection ................................................................................ 56
4.6.6 USB Connection............................................................................................... 57
4.6.7 VGA Monitor Connection ................................................................................ 58
5 BIOS SCREENS........................................................................................................... 60

KINO-DH610
Page VI
5.1 INTRODUCTION......................................................................................................... 61
5.1.1 Starting Setup................................................................................................... 61
5.1.2 Using Setup...................................................................................................... 61
5.1.3 Getting Help..................................................................................................... 62
5.1.4 Unable to Reboot after Configuration Changes.............................................. 62
5.1.5 BIOS Menu Bar................................................................................................ 62
5.2 MAIN........................................................................................................................ 63
5.3ADVANCED............................................................................................................... 64
5.3.1 ACPI Configuration......................................................................................... 65
5.3.2 Trusted Computing........................................................................................... 66
5.3.3 CPU Configuration.......................................................................................... 67
5.3.3.1 CPU Information....................................................................................... 68
5.3.4 SATA Configuration ......................................................................................... 69
5.3.5 USB Configuration........................................................................................... 71
5.3.6 Super IO Configuration ................................................................................... 72
5.3.6.1 Serial Port n Configuration....................................................................... 73
5.3.7 H/W Monitor.................................................................................................... 76
5.3.7.1 CPU Fan Configuration ............................................................................ 77
5.3.7.2 SYS Fan 1 Configuration.......................................................................... 78
5.3.8 Serial Port Console Redirection ...................................................................... 80
5.3.9 IEI Feature....................................................................................................... 81
5.4 CHIPSET ................................................................................................................... 82
5.4.1 Northbridge Configuration.............................................................................. 83
5.4.2 Southbridge Configuration .............................................................................. 85
5.4.3 Integrated Graphics......................................................................................... 87
5.4.4 ME Subsystem.................................................................................................. 88
5.5 BOOT........................................................................................................................ 89
5.6 SECURITY................................................................................................................. 91
5.7 SAVE &EXIT............................................................................................................ 92
6 SOFTWARE DRIVERS.............................................................................................. 94
6.1AVAILABLE SOFTWARE DRIVERS .............................................................................. 95
6.2 SOFTWARE INSTALLATION ........................................................................................ 95
6.3 CHIPSET DRIVER INSTALLATION............................................................................... 97
6.4 GRAPHICS DRIVER INSTALLATION.......................................................................... 100

KINO-DH610
Page VII
6.5 LAN DRIVER INSTALLATION.................................................................................. 103
6.6AUDIO DRIVER INSTALLATION ............................................................................... 105
A BIOS MENU OPTIONS........................................................................................... 108
B ONE KEY RECOVERY............................................................................................111
B.1 ONE KEY RECOVERY INTRODUCTION .....................................................................112
B.1.1 System Requirement........................................................................................113
B.1.2 Supported Operating System..........................................................................114
B.2 SETUP PROCEDURE FOR WINDOWS.........................................................................115
B.2.1 Hardware and BIOS Setup .............................................................................115
B.2.2 Create Partitions ............................................................................................116
B.2.3 Install Operating System, Drivers and Applications..................................... 120
B.2.4 Build-up Recovery Partition.......................................................................... 120
B.2.5 Create Factory Default Image....................................................................... 123
B.3 SETUP PROCEDURE FOR LINUX.............................................................................. 128
B.4 RECOVERY TOOL FUNCTIONS ................................................................................ 131
B.4.1 Factory Restore ............................................................................................. 133
B.4.2 Backup System............................................................................................... 134
B.4.3 Restore Your Last Backup.............................................................................. 135
B.4.4 Manual........................................................................................................... 136
B.5 OTHER INFORMATION ............................................................................................ 136
B.5.1 Using AHCI Mode or ALi M5283 / VIA VT6421A Controller....................... 136
B.5.2 System Memory Requirement ........................................................................ 138
C TERMINOLOGY ..................................................................................................... 139
D WATCHDOG TIMER .............................................................................................. 144
E HAZARDOUS MATERIALS DISCLOSURE ....................................................... 147
E.1 HAZARDOUS MATERIAL DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS
ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY ..................................... 148

KINO-DH610
Page VIII
List of Figures
Figure 1-1: KINO-DH610.................................................................................................................2
Figure 1-2: Connectors ..................................................................................................................3
Figure 1-3: KINO-DH610 Dimensions (mm) .................................................................................4
Figure 1-4: Data Flow Diagram......................................................................................................5
Figure 3-1: Connector and Jumper Locations...........................................................................15
Figure 3-2: Battery Connector Location.....................................................................................18
Figure 3-3: BIOS Update Connector Location...........................................................................19
Figure 3-4: DDR3 SO-DIMM Slot Locations ...............................................................................20
Figure 3-5: Debug Port Connector Location..............................................................................20
Figure 3-6: Digital I/O Connector Location ................................................................................21
Figure 3-7: EC Update Connector Location...............................................................................22
Figure 3-8: CPU Fan Connector Locations................................................................................23
Figure 3-9: PCH Fan Connector Location..................................................................................24
Figure 3-10: Front Panel Connector Location ...........................................................................25
Figure 3-11: Keyboard/Mouse Connector Location..................................................................26
Figure 3-12: PCI Slot Location ....................................................................................................27
Figure 3-13: PCIe x1 Slot Location .............................................................................................27
Figure 3-14: Power Connector Location ....................................................................................28
Figure 3-15: SATA Drive Connector Locations .........................................................................29
Figure 3-16: SATA Power Connector Locations .......................................................................29
Figure 3-17: RS-232/422/485 Serial Port Connector Location（RS-232+RS422/485）..........30
Figure 3-18: TPM Connector Location........................................................................................31
Figure 3-19: USB Connector Locations......................................................................................32
Figure 3-20: KINO-DH610 External Peripheral Interface Connector........................................33
Figure 3-21: Audio Connector.....................................................................................................34
Figure 3-22: LAN Connector........................................................................................................35
Figure 3-23: Power Connector ....................................................................................................36
Figure 3-24: RS-232 Serial Port Connector................................................................................37
Figure 3-25: VGA Connector .......................................................................................................38
Figure 4-1: Disengage the CPU Socket Load Lever..................................................................43
Figure 4-2: Remove Protective Cover.........................................................................................43

KINO-DH610
Page IX
Figure 4-3: Insert the Socket LGA1155 CPU..............................................................................44
Figure 4-4: Close the Socket LGA1155 ......................................................................................45
Figure 4-5: Cooling Kits (CF-1156A-RS, CF-1156B-RS, CF-1156C-RS, CF-1156D-RS)..........45
Figure 4-6: Cooling Kit Support Bracket....................................................................................46
Figure 4-7: DIMM Installation.......................................................................................................47
Figure 4-8: Jumper Locations.....................................................................................................48
Figure 4-9: AT/ATX Mode Select Jumper Location...................................................................49
Figure 4-10: Clear CMOS Jumper Location ...............................................................................50
Figure 4-11: SATA Drive Cable Connection...............................................................................51
Figure 4-12: SATA Power Drive Connection..............................................................................52
Figure 4-13: Audio Connector.....................................................................................................53
Figure 4-14: DVI Connector .........................................................................................................54
Figure 4-15: LAN Connection......................................................................................................56
Figure 4-16: Serial Device Connector.........................................................................................57
Figure 4-17: USB Connector........................................................................................................58
Figure 4-18: VGA Connector .......................................................................................................59
Figure 6-1: Introduction Screen..................................................................................................96
Figure 6-2: Available Drivers.......................................................................................................96
Figure 6-3: Chipset Driver Screen...............................................................................................97
Figure 6-4: Chipset Driver Welcome Screen..............................................................................98
Figure 6-5: Chipset Driver License Agreement.........................................................................98
Figure 6-6: Chipset Driver Read Me File ....................................................................................99
Figure 6-7: Chipset Driver Setup Operations ............................................................................99
Figure 6-8: Chipset Driver Installation Finish Screen............................................................ 100
Figure 6-9: Graphics Driver Welcome Screen........................................................................ 101
Figure 6-10: Graphics Driver License Agreement.................................................................. 101
Figure 6-11: Graphics Driver Setup Operations..................................................................... 102
Figure 6-12: Graphics Driver Installation Finish Screen ....................................................... 102
Figure 6-13: LAN Driver Welcome Screen .............................................................................. 103
Figure 6-14: LAN Driver Ready to Install Screen.................................................................... 104
Figure 6-15: LAN Driver Setup Status Screen ........................................................................ 104
Figure 6-16: LAN Driver Installation Complete....................................................................... 105
Figure 6-17: Audio Driver – Extracting Files........................................................................... 106
Figure 6-18: Audio Driver Welcome Screen............................................................................ 106
Figure 6-19: Audio Driver Installation...................................................................................... 106

KINO-DH610
Page X
Figure 6-20: Audio Driver Installation Complete.................................................................... 107
Figure B-1: IEI One Key Recovery Tool Menu ........................................................................ 112
Figure B-2: Launching the Recovery Tool.............................................................................. 117
Figure B-3: Recovery Tool Setup Menu .................................................................................. 117
Figure B-4: Command Mode..................................................................................................... 117
Figure B-5: Partition Creation Commands.............................................................................. 119
Figure B-6: Launching the Recovery Tool.............................................................................. 121
Figure B-7: System Configuration for Windows .................................................................... 121
Figure B-8: Build-up Recovery Partition................................................................................. 122
Figure B-9: Press any key to continue.................................................................................... 122
Figure B-10: Press F3 to Boot into Recovery Mode............................................................... 123
Figure B-11: Recovery Tool Menu ........................................................................................... 123
Figure B-12: About Symantec Ghost Window........................................................................ 124
Figure B-13: Symantec Ghost Path ......................................................................................... 124
Figure B-14: Select a Local Source Drive ............................................................................... 125
Figure B-15: Select a Source Partition from Basic Drive ...................................................... 125
Figure B-16: File Name to Copy Image to ............................................................................... 126
Figure B-17: Compress Image.................................................................................................. 126
Figure B-18: Image Creation Confirmation............................................................................. 127
Figure B-19: Image Creation Complete................................................................................... 127
Figure B-20: Image Creation Complete................................................................................... 127
Figure B-21: Press Any Key to Continue ................................................................................ 128
Figure B-22: Partitions for Linux.............................................................................................. 129
Figure B-23: System Configuration for Linux......................................................................... 130
Figure B-24: Access menu.lst in Linux (Text Mode).............................................................. 130
Figure B-25: Recovery Tool Menu ........................................................................................... 131
Figure B-26: Recovery Tool Main Menu.................................................................................. 132
Figure B-27: Restore Factory Default...................................................................................... 133
Figure B-28: Recovery Complete Window.............................................................................. 133
Figure B-29: Backup System.................................................................................................... 134
Figure B-30: System Backup Complete Window ................................................................... 134
Figure B-31: Restore Backup ................................................................................................... 135
Figure B-32: Restore System Backup Complete Window..................................................... 135
Figure B-33: Symantec Ghost Window ................................................................................... 136

KINO-DH610
Page XI
List of Tables
Table 1-1: Technical Specifications..............................................................................................8
Table 3-1: Peripheral Interface Connectors...............................................................................16
Table 3-2: Rear Panel Connectors..............................................................................................17
Table 3-3: Battery Connector Pinouts........................................................................................18
Table 3-4: BIOS Update Connector Pinouts ..............................................................................19
Table 3-5: Debug Port Connector Pinouts.................................................................................21
Table 3-6: Digital I/O Connector Pinouts....................................................................................22
Table 3-7: EC Update Connector Pinouts ..................................................................................23
Table 3-8: CPU Fan Connector Pinouts......................................................................................23
Table 3-9: PCH Fan Connector Pinouts......................................................................................24
Table 3-10: Front Panel Connector Pinouts...............................................................................25
Table 3-11: Keyboard/Mouse Connector Pinouts .....................................................................26
Table 3-12: Power Connector Pinouts........................................................................................28
Table 3-13: SATA Power Connector Pinouts.............................................................................30
Table 3-14: RS-232/422/485 Serial Port Connector Pinouts（RS-232+RS422/485）.............31
Table 3-15: TPM Connector Pinouts...........................................................................................32
Table 3-16: USB Connector Pinouts...........................................................................................33
Table 3-17: LAN and USB Connector Pinouts...........................................................................35
Table 3-18: HDMI Connector Pinouts .........................................................................................36
Table 3-19: Power Connector Pinouts........................................................................................37
Table 3-20: RS-232 Serial Port Connector Pinouts...................................................................37
Table 3-21: DVI and VGA Connector Pinouts ............................................................................38
Table 4-1: Jumpers.......................................................................................................................48
Table 4-2: AT/ATX Mode Select Jumper Settings .....................................................................49
Table 4-3: Clear CMOS Jumper Settings....................................................................................50
Table 5-1: BIOS Navigation Keys................................................................................................62

KINO-DH610
Page XII
List of BIOS Menus
BIOS Menu 1: Main.......................................................................................................................63
BIOS Menu 2: Advanced..............................................................................................................65
BIOS Menu 3: ACPI Configuration..............................................................................................65
BIOS Menu 4: TPM Configuration...............................................................................................66
BIOS Menu 5: CPU Configuration...............................................................................................67
BIOS Menu 6: CPU Configuration...............................................................................................68
BIOS Menu 7: IDE Configuration.................................................................................................69
BIOS Menu 9: USB Configuration...............................................................................................71
BIOS Menu 10: Super IO Configuration......................................................................................72
BIOS Menu 11: Serial Port n Configuration Menu.....................................................................73
BIOS Menu 12: Hardware Health Configuration........................................................................76
BIOS Menu 13: CPU Fan Configuration......................................................................................77
BIOS Menu 14: SYS Fan 1 Configuration...................................................................................79
BIOS Menu 15: Serial Port Console Redirection Menu.............................................................80
BIOS Menu 16: IEI Feature...........................................................................................................81
BIOS Menu 17: Chipset................................................................................................................82
BIOS Menu 18: Northbridge Chipset Configuration..................................................................83
BIOS Menu 19: Southbridge Chipset Configuration.................................................................86
BIOS Menu 20: Integrated Graphics...........................................................................................87
BIOS Menu 21: ME Subsystem....................................................................................................88
BIOS Menu 22: Boot.....................................................................................................................89
BIOS Menu 23: Security...............................................................................................................91
BIOS Menu 24:Exit........................................................................................................................92

KINO-DH610
Page 1
1 Introduction
Chapter
1

KINO-DH610
Page 2
1.1 Introduction
Figure 1-1: KINO-DH610
The KINO-DH610 is a Mini-ITX motherboard. It accepts a LGA1155 Intel® Core™ i3/
Pentium®/Celeron® processor and supports two 204-pin 1333/1066 MHz dual-channel
DDR3 SO-DIMM modules up to 16 GB.
The integrated Intel® H61 System Chipset supports two GbE LAN ports through dual
Realtek RTL8111E PCIe GbE controllers (with ASF 2.0 support). The KINO-DH610 also
supports four SATA 3Gb/s drives and provides 5 V SATA power.
The KINO-DH610 includes a VGA, DVI-D and HDMI port. Expansion and I/O include one
PCI slot, one PCIe x1 slot, four USB 2.0 ports on the rear panel and six USB 2.0 ports by
pin header. Serial device connectivity is provided by one external RS-232 and one internal
RS-232/422/485 connectors.
1.2 Connectors
The connectors on the KINO-DH610 are shown in the figure below.

KINO-DH610
Page 3
Figure 1-2: Connectors

KINO-DH610
Page 4
1.3 Dimensions
The dimensions of the board are listed below:
Length: 170 mm
Width: 170 mm
Figure 1-3: KINO-DH610 Dimensions (mm)

KINO-DH610
Page 5
1.4 Data Flow
Figure 1-4 shows the data flow between the system chipset, the CPU and other
components installed on the motherboard.
Figure 1-4: Data Flow Diagram

KINO-DH610
Page 6
1.5 Technical Specifications
KINO-DH610 technical specifications are listed in table below.
Specification KINO-DH610
Form Factor Mini-ITX
Socket LGA1155
CPU Supported Socket 1155 Intel® Core™ i3/ Pentium®/ Celeron® dual core
processor
System Chipset Intel® H61
Memory Two 204-pin 1066/1333 MHz dual-channel DDR3 SO-DIMM
supported (system max. 16 GB)
Graphics Engine Support for DX10.1 and OpenGL3.0, full MPEG2. VC1.AVC
decode
Audio Realtek ALC662 HD Audio codec
LAN Two Realtek RTL8111E PCIe GbE controllers withASF 2.0
support
Embedded Controller iWDD
Super I/O Fintek F81866
Digital I/O 8-bit digital I/O, 4-bit input/4-bit output
BIOS UEFI BIOS
Watchdog Timer Software programmable supports 1~255 sec. system reset
Expansions
PCIe One PCIe x1 slot
PCI One PCI slot
I/O Interface Connectors
Audio Connector Two external audio jacks (Line-out, Mic)

KINO-DH610
Page 7
Specification KINO-DH610
Display Ports One VGA integrated in Intel® H61
One DVI-D integrated in Intel® H61
One HDMI integrated in Intel® H61
Ethernet Two RJ-45 GbE ports
Keyboard/Mouse One internal keyboard and mouse connector via 6-pin wafer
TPM One 20-pin header
Fan One 4-pin CPU fan connector
One 3-pin system fan connector
Serial Ports One external RS-232 serial port via DB-9 male connector
One RS-232 and one RS-422/485 via internal 14-pin header
USB Ports Four external USB 2.0 ports by rear IO
Six internal USB 2.0 ports via three 8-pin headers
Storage
Serial ATA Four SATA 3Gb/s connectors
Environmental and Power Specifications
Power Supply Maximum input voltage range: 9 V ~ 28 V
Recommended operating input voltage range: 12 V ~ 24 V
Power Connector One external DC jack (4-pin DIN)
One internal 4-pin power connector
Power Consumption [email protected] (2.2 GHz Intel® G620T with two 1066 MHz 2 GB
DDR3 running 3DMark06 burn in)
[email protected] (2.8 GHz Intel® Core™ i7-2600S with two 1066
MHz 2 GB DDR3 running 3DMark06 burn in)
Operating Temperature -10ºC ~ 60ºC
Humidity 5% ~ 95% (non-condensing)
Physical Specifications
Dimensions 170 mm x 170 mm

KINO-DH610
Page 8
Specification KINO-DH610
Weight GW/NW 1100 g / 700 g
Table 1-1: Technical Specifications