IPM IP-05 Series User manual

830802,830803
IP05 SERIES
5:1 RATIO TRANSFER PUMP
OPERATIONS MANUAL
IPM, INC.
Manufactured by International Pump Manufacturing, Inc. ®

2
IP05 series
5:1 RATIO TRANSFER PUMP
OPERATIONS MANUAL and
PARTS IDENTIFICATION DRAWINGS
This manual contains IMPORTANT WARNINGS and INSTRUCTIONS. Read and retain for future reference.
INTERNATIONAL PUMP MANUFACTURING, INC.
3107 142nd Avenue E Suite 106,
Sumner, WA 98390
U.S.A.
TEL: [phone]
FAX: [phone]
Website : www.ipmpumps.com
For Technical Service Call Your Local Distributor
Copyright 2014 by: International Pump Mfg, Inc.
WARNING: The equipment described herein must only be operated
or serviced by properly trained individuals thoroughly familiar with the
operating instructions, mechanics and limitations of the equipment.
Notice: All statements, information and data given herein are believed to be accurate and reliable but are presented without guarantee, warranty or
responsibility of any kind expressed or implied. Statements or suggestions concerning possible use of IPM equipment are made without
representation or warranty that any such use is free of patent infringement, and are not recommendations to infringe any patent. The user should
not assume that all safety measures are indicated or that other measures may not be required.

3
TABLE OF CONTENTS
1.0 SAFETY WARNINGS 4
1.1 Procedure for pressure relief 5
1.2 Pump & component grounding 6
2.0 INSTALLATION 8
2.1 Installation procedures 8
2.2 Additional mounting configurations 9
3.0 OPERATIONS 11
4.0 PARTS IDENTIFICATION 12
4.1 Parts drawing/parts list for 830802 (Air section) 12
4.2 Parts drawing/parts list for 830802 (Fluid section) 13
4.3 Parts drawing/parts list for 830803 (Air section) 14
4.4 Parts drawing/parts list for 830803 (Fluid section) 15
5.0 REPAIR KITS 16
6.0 TROUBLESHOOTING 17
7.0 TECHNICAL SPECIFICATIONS 18
8.0 WARRANTY & DISCLAIMER 21

4
0.1 SGNINRAW YTEFAS
yna gnikam erofeb launam snoitarepo siht ni deniatnoc sgninraw lla evresbo dna daer esaelP
.tnempiuqe eht etarepo ot tpmetta
tnempiuqe fo esusiM
dednetni sti rof ylno tnempiuqe eht esU .yrujni ylidob suoires esuac nac tnempiuqe fo esusiM
nekat eb dluohs eraC .yaw yna ni ti yfidom ot tpmetta ton od dna esoprup revo tneverp ot
MPI ylno esU .ti ot detcennoc seirossecca dna senil esoh ,pmup eht fo noitazirusserp
er rof strap detangised - elbitapmoc htiw ylno pmup eht esU .tnempiuqe siht gniriaper ro gnidliub
ulf ni tluser dluoc tnempiuqe siht fo esu reporpmI .sdiulf eht ni ro niks eht no deyarps gnieb di
.noisolpxe ro erif ,egamad ytreporp ,yrujni ylidob suoires ,resu fo seye
D ro nrow lla dna tnempiuqe dna spmup no edam eb dluohs noitcepsni ecnanetniam ylia
er eb dluohs strap degamad - p esu ton oD .yletaidemmi decalp senil esoh ro stnenopmoc ,spmu
.yrujni dna egamad diova ot tnempiuqe evom ot egarevel sa
esuac ro/dna yltcerrocni noitcnuf ot ti esuac dluoc os gniod sa tnempiuqe siht retla ton oD
dna yna diov osla lliw yaw yna ni tnempiuqe siht gniretlA .yrujni suoires seetnaraug ytnarraw lla
.rerutcafunam eht morf
ytilibitapmoc diulf & lairetaM
fo noitces diulf eht ni desu stnevlos dna sdiulf eht fo ytilibitapmoc lacimehc eht erusne syawlA
atad s’rerutcafunam lacimehc eht kcehC .stnenopmoc rehto sesoh ,spmup eseht dna steehs
htiw ytilibitapmoc erusne ot pmup siht ni stnevlos ro sdiulf gnisu erofeb strahc noitacificeps
.gnirevoc esoh retuo dna gninil esoh renni ,spmup
sesoh dezirusserP
cse diulf eht dluohs regnad a tneserp nac yeht dezirusserp era sesoh eht esuaceB ot eud epa
ssim lareneg ro strap nrow ,egamad - gnisuac ,rotarepo yarps ro hsalps nac diulf gnipacsE .esu
ton od sesoh eht taht erusnE .ytreporp dna tnempiuqe ot egamad ro/dna yrujni ylidob suoires
.egamad ro esusim ,raew ot eud erutpur ro kael
hcae erofeB .deruces era sgulp/snip/spilc lla dna thgit era sgnilpuoc diulf eht taht erusne ,esu
esool ro/dna revoc gniglub ,snoisarba ,stuc ,raew rof esoh fo htgnel eritne eht tcepsnI
gnihsalps ni tluser dna liaf ot esoh eht esuac yam snoitidnoc esehT .snoitcennoc fo gniyarps ro
ytreporp ro/dna yrujni suoires esuac dna rotarepo fo seye eht ni ro niks eht no slacimehc
.egamad
gninraW
eht wollof ,niks eht no ro seye eht ni diulf gnihsalps ro gnikraps citats fo ksir eht ecuder oT
p feiler erusserp erudecor .gnihsulf erofeb
eht daer ,ytefas ruoy roF drazah noisolpxe ro erif eht lla wollof dna gnihsulf erofeb detsil
.snoitadnemmocer

5
noitacificeps erusserP
si ria dna sdiulf rof tnempiuqe siht fo erusserp gnikrow mumixam ehTsrab 521( ISP 0611 ) htiw
p ria gnimocni mumixam a fo ecnarelot erusser )srab 5.21( ISP 081 . dna tnempiuqe lla erusnE
siht fo erusserp gnikrow mumixam eht dnatshtiw ot detar era pmup siht htiw desu seirossecca
rehto yna ro senil esoh ,pmup eht fo erusserp gnikrow mumixam eht deecxe reveN .pmup
stnenopmoc .flesti pmup eht ot dehcatta
r erusserP feile erudecorp
sa hcus yrujni ylidob suoires fo ksir eht diova ot redro nI : niks eht no diulf gnihsalps ,seye eht ni ,
ro yrujni strap gnivom morf- eb dluohs erudecorp sihT .desu eb dluohs erudecorp gniwollof eht
nehw desu ,pmup eht nwod gnittuhs :pmup eht gniriaper ro gnicivres ,metsys eht fo trap yna ro
,stnenopmoc gninaelc ro gnicalper nehw ro/dna diulfgnipmup desaec .
.1 ot evlav ria eht esolC .pmup eht
.2 ni erusserp ria eht eveiler ot )snoitcurtsni noitallatsni ees( evlav nwod deelb ria eht esU
.metsys eht
.3 ap latem eht htiw tcatnoc ni liap latem dednuorg a gnidloh yb erusserp diulf eht eveileR tr
av gnisnepsid diulf eht fonepo ylwols dna evl .evlav eht
.4 diulf eht hctac ot ydaer reniatnoc a htiW, noitallatsni ees( evlav niard eht nepo
.)snoitcurtsni
.5 .niaga diulf esnepsid ot emit si ti litnu nepo evlav niard eht evael ot ecitcarp doog a si tI
eht taht erusnu era uoy fI ro tnenopmoc a ni egakcolb a ot eud( deveiler neeb sah erusserp diulf
eht wolla ot gnilpuoc dne esoh eht gninesool ylwols yb erusserp eht eveiler ot luferac eb )esoh a
b nac gnittif eht ,deveiler neeb sah erusserp eht retfA .ylwols epacse ot erusserp diulf devomer e
.devomer segakcolb yna dna yletelpmoc
noitarepo gnitaitini erofeb pmup eht hsulF
.1 fI .strap pmup eht tcetorp ot ni tfel si hcihw ,lio POD thgiewthgil htiw detset si pmup ehT
lio hsulf ,lio yb detanimatnoc emoceb yam gnipmup era uoy diulf eht a htiw pmup morf
.woleb noitcurtsni gnihsulf eht wolloF .esu erofeb tnevlos elbitapmoc
.2 elbitapmoc a htiw metsys eht hsulf ,yfidilos ro pu tes taht sdiulf gnipmup nehW
dliub evomer ot yrassecen sa netfo sa tnevlos- i slacimehc deifidilos fo pu ro pmup eht n
.sesoh
.3 etalucric ot tnevlos eht wolla ,metsys gnitalucric a ylppus ot desu gnieb si pmup eht fI
fi netfo erom ro sruoh 84 yreve setunim 03 tsael ta rof metsys eritne eht hguorht
noitacifidilos dna gnilttes tneverp ot yrassecen .slacimehc fo
.4 tew eht llif syawlA - eht peek ot tnevlos elbitapmoc ro )LST( diuqil laes taorht fo lluf 2/1 puc
.gnikcap taorht pmup gnigamad dna dor tnemecalpsid eht no gniyrd morf diulf
.5 non a gnipmup era uoy nehw ,yltneuqerf gnikcap taorht eht etacirbuL - ro diulf gnitacirbul
.yad eno naht erom rof nwod gnittuhs era

6
.6 dliub eht tneverp ot si hcihw fo esoprup eht ,ebut tew a setaroprocni spmup refsnart MPI -
tfahs eht sa gnikcap eht egamad dluow hcihw tfahs pmup eht no trid dna lacimehc fo pu
.meht hguorht setacorpicer ton sah taht pmup a nehw lluf eb tsum ebut tew sihT neeb
delaes a fo tnemnorivne detcetorp eht edistuo derots si denaelc dna dehsulf ylhguoroht
dellif yllaitrap a ni dellatsni eb pmup a dluohS .esu ni si pmup eht nehw sa llew sa murd
sum ebut eht ,ebut tew eht fo pot eht woleb si level diuqil eht erehw murd yllaunam eb t
.murd eht otni gnitresni ot roirp lacimehc reporp eht htiw dellif
.7 O ot dettimmoc si pmup a ecn hcihw yfitnedi ot ecitcarp doog si ti ,lacimehc ralucitrap a
etanimile ot rof detangised si pmup ralucitrap a lacimehc pu xim fo ytilibissop eht dna
noitanimatnoc .
noitacirbuL
.rotaluger ria eht morf erutsiom niarD .yliad detacirbul eb dluohs pmup refsnarT yllaunam oT
,rotom eht etacirbul ni lio fo 01 yletamixorppa ecalp dna rotom eht ta senil ria eht tcennocsid
eht telni ria ia eht tcennoceR . peek oslA .rotom eht otni lio wolb ot ria eht no nrut dna enil r
tew eht - ecuder lliw sihT .tnevlos elbitapmoc ro )LST( diuqiL laeS taorhT htiw dellif puc
thgit tsuj si ti os ylkeew tun gnikcap eht tsujdA .efil gnikcap eht gnolorp dna ecnanetniam
t hguone revo ton od tub egakael tneverp o - .noitarepo pmup tcirtser lliw siht sa nethgit
pmup fo erac & nwod tuhS
eht wollof ,nwod tuhs thginrevo roF p feiler erusserp erudecor .)5 egap( pmup eht pots syawlA
morf diulf eht tneverp ot ekorts eht fo mottob ta dna dor tnemecalpsid desopxe eht no gniyrd
gnikcap taorht eht gnigamad .
noisolpxE ro eriF morf sdrazaH
rehto ro slacimehc elbitsubmoc morf semuf ro sropav etingi nac skraps erehw tsixe sdrazaH
.cte ,tsud evisolpxe sa hcus tsixe snoitidnoc suodrazah morf detaerc eb nac skraps esehT
eht yb detareneg yticirtcele citats eht morf ro droc ylppus lacirtcele na gniggulpnu ro ni gniggulp
.esoh dna pmup eht hguorht diulf fo wolf
icirtcele citats tneverp ot dednuorg ylreporp eb tsum tnempiuqe eht fo trap yrevE morf yt
nac skraps esehT .suodrazah emoceb ot metsys ro pmup eht gnisuac dna kraps a gnitareneg
taht erusnE .yrujni ylidob suoires dna egamad tnempiuqe dna ytreporp ,noisolpxe ,erif a esuac
dednuorg ylreporp era seirossecca dna stnenopmoc lla dna pmup eht ylppus lacirtcele taht dna
.tsixe sdrazah eseht nehw deggulpnu ro ni deggulp ton era sdroc
noitarepo pmup eunitnocsid ,tsixe yticirtcele citats ro skraps fo ecnedive yna dluohS
eht tcerroc dna yticirtcele citats eht fo ecruos eht etagitsevnI .yletaidemmi .melborp gnidnuorg
.deriaper si melborp gnidnuorg eht litnu metsys eht esu ton oD
1.1 serudecorp gnidnuorg tnenopmoc dna pmuP
wolla ot wercs kcol eht nesooL .pmup eht gnidnuorg rof serudecorp gniwollof eht esu syawlA
.gul gnidnuorg eht fo eloh erob eht otni eriw eguag 21 dezis muminim a fo dne eno fo noitresni

7
ne rehto eht eruceS .yleruces wercs kcol eht nethgit dna eriw tresnI eurt a ot dnuorg eht fo d
eht eziminim ot yrassecen si stnenopmoc lla dna pmup eht fo gnidnuorG .dnuorg htrae
lacol htiw ecnailpmoc ni eb tsum gnidnuorG .yticirtcele citats ot eud skraps fo ytilibissop
of seitirohtua lacol eht htiw kcehC .sedoc lacirtcele epyt eht htiw dna aera ruoy ni stnemeriuqer r
.desu gnieb tnempiuqe fo
eht eziminim ot yrassecen si tnempiuqe gnisnepsid rehto lla dna pmup eht fo gnidnuorG
ilpmoc ni eb tsum gnidnuorG .yticirtcele citats ot eud skraps fo ytilibissop lacol htiw ecna
htiw kcehC .sedoc lacirtcele fo epyt eht htiw dna aera ruoy ni stnemeriuqer rof seitirohtua lacol
:dednuorg si tnempiuqe gniwollof eht lla taht erusnE .desu gnieb tnempiuqe
.1 :rosserpmoC riA dednemmocer sa serudecorp gnidnuorg eht wolloF
.rerutcafunam eht yb
.2 :sesoH riA .sesoh ria dednuorg esU
.3 ot desu reniatnoC diulF
:metsys eht ylppus .sedoc lacol ot gnidrocca enod eb tsum gnidnuorG
.4 :pmuP .1 erugiF ot gnirrefer dedulcni serudecorp eht wolloF
.5 :sesoH diulF esU .sesoh diulf dednuorg
.6 :evlaV gnisnepsiD ot esoh diulf eht hguorht tcudnoc ot latem eb tsum evlav ehT
tsum hcihw pmup eht osla .dednuorg ylreporp eb
.7 :tnioP gnisnepsiD .sedoc lacol ot gnidrocca enod eb tsum gnidnuorG
.8 :sreniatnoC tnevloS occa enod eb tsum gnidnuorG esU .sedoc lacol ot gnidr
evitcudnoc latem .dednuorg ylreporp era taht sliap
.9 gninaelc ,gnisnepsiD yb ytivitcudnoc niatniaM fo trap latem gnidloh ylmrif
saeler erusserp ro :e id gnisneps .reniatnoc dednuorg fo edis eht ot evlav
gnidnuorG esoH
eht taht tnatropmi yrev si tI dna ria htob rof desu sesoh eb diulfeht taht dna epyt gnidnuorg a fo
esoh eht fo skcehc ralugeR .deniatniam si ytiunitnoc dnuorgs’ ecnatsiser dnuorg a htiw
natsiser m eht ot nosirapmoc a dna egnar elbatius a gnisu retem ec rutcafuna s s’re noitacificep
erusne lliw eb dluohs ti stimil deificeps nihtiw ton si ti fI .snoitacificeps nihtiw si dnuorg eht
.yletaidemmi decalper
ninaelC tnevloS g
hWne tcatnoc ni evlav gnisnepsid eht fo trap latem eht dloh ,tnevlos htiw metsys eht gninaelc
seye eht ni ro niks eht no diulf gnihsalps fo ytilibissop eht eziminim ot liap latem dednuorg a htiw
s lanoitidda rof erusserp diulf wol esU .skraps citats ro .ytefa

8
straP gnivoM morF sdrazaH
eht esU erudecorP feileR erusserP 5 egap yllanoitnetninu gnitrats morf pmup eht tneverp ot
rehto ro sregnif ot drazah gnihcnip a tneserp strap gnivom taht erac ekaT .derised ton nehw
gnivom eseht fo raelc yatS .strap ydob reveN .pmup eht gnitarepo ro gnitrats nehw strap
.devomer setalp rotom ria eht htiw pmup eht etarepo
sdradnatS ytefaS
eht rednu tnemnrevoG setatS detinU eht yb dehsilbatse neeb evah sdradnats ytefaS
eht ot ylppa yeht sa detlusnoc eb dluohs sdradnats esehT .tcA htlaeH dna ytefaS lanoitapuccO
.desu gnieb tnempiuqe fo sepyt gnireffid dna sdrazah suoirav
0.2 NOITALLATSNI
1.2 lacipyT tnuom llawnoitarugifnoc pmup
2 erugiF stciped sni tnuom llaw lacipyt a dna snoitpo suoirav htiw noitallat ytefas dedda rof seirossecca ,
ycneiciffe snrecnoc ecnanetniam dna nu tnuom llaw dna noisrev murD . era sti ni elbaliava htob PI eht 50
.spmup seires

9
snoitarugifnoc gnitnuom lanoitiddA 2.2

10

11
0.3 NOITAREPO S
pmuP eht fo tnemtsujdA dna pu tratS
.1 2 erugif gnisU )9 egap( dna evlav ria retsam ,ylppus ria niam ffo tuhs ,ecnerefer a sa diulf
evlav niard . tey pit yarps eht llatsni ton oD .
.2 ebut noitcus tresnI murd ylppus diulf eht otni tes tnuom llaw rof - rof flesti pmup eht ro pu
tinu htgnel murd .
.3 nug yarps eht dloH .nepo reggirt eht dloh dna murd ylppus eht fo edis eht ot ylmrif
.4 o ylluferaC s’pmup eht nep deelb - evlav ria retsam epyt .
.5 lS ylppus ria niam eht nepo ylwo strats pmup eht litnu gnilcyc , ta eb lliw hcihwuoba 04 t
.2( ISP .)rab 8
.6 pmup eht elcyC dna pmup eht erusne ot degrup si ria eht lla litnu ylwols ylluf era sesoh
demirp .
.7 eht kcol dna reggirt nug yarps eht esaeleR llats yletelpmoc dluohs pmup ehT .ytefas
rednu .desaeler si reggirt eht nehw erusserp
.8 irp senil dna pmup eht htiWdem dna a etauqedadeilppus emulov dna erusserp ri eht
.desolc dna denepo si nug yarps eht sa pots dna trats lliw pmup
.9 wollof ,erusserp eht eveiler oT eht p feiler erusserp erudecor 5 egap( ) , th pit eht llatsni ne
dna draug .nug eht ni pit yarps
.01 u ,ycneiciffe mumitpo roF da na es ria dezis yletauqe rotaluger eeps pmup eht lortnoc ot d
dna .stluser derised teg ot yrassecen erusserp ria tsewol eht desu syawlA .erusserp diulf
diulf etsaw serusserp rehgiH snrettap yarps citarre etaerc , w erutamerp esuac dna fo rae
dna sgnikcap pmup eht elzzon s.
.11 org a otnI ,reniatnoc latem dednu ylwols nepo evlav gnisnepsid ehtlatem erusnE . - ot -
.evlav eht dna reniatnoc eht neewteb tcatnoc latem
:etoN dluohs pmup ehT reven eb dewolla fo yrd nur ot diulf . ytpme snur murd nehW eht
pmup yllacitamard esaercni lliw deeps dna tnempiuqe gamad e rucco lliw ,noitarepo gniruD .
dnuof eb pmup eht dluohs gninnur tsaf oot .ylppus diulf eht kcehc dna yletaidemmi ti pots ria fI
og sah nett ,metsys eht otni erudecorp gnimirp a enod eb dluohs neeb sah ria lla taht erusnE .
dellepxe l eht morf snoitarepo lamron gnimuser erofeb seni dellif ti evael ro pmup eht hsulF .
a htiwelbatius .esu ni ton nehw tnevlos eht wollof syawlA p feiler erusserp erudecor )5 egap(
eht fo dne eht ta ffo tuhs metsys gnirud ro emit fo doirep yna rof yawa tup eb pmup eht dluohs
.yad

12

31
2.4 Pnoitces diulf rof gniward stra
38 # pmuP 2080

14

51
4.4 aP tr s noitces diulf rof gniward
38 # pmuP 3080

16

71
0.6 GNITOOHSELBUORT
melborP
sesuaC
dednemmoceR
snoituloS
.etarepo ton seod pmuP
si erusserp ro ylppus riA
senil riA .etauqedani
.detcirtser
.erusserp ria esaercnI
ni snoitcirtser yna rof kcehC
.enil ria
ton si evlav gnisnepsiD
.deggolc ro nepo
nepO toof raelc ro/dna
.evlav
,sevlav ,senil diulf deggolC
ria degamad ro sesoh
feiler erusserp wolloF
raelc ot erudecorp
.noitcurtsbo
.rotom
ecalpeR .rotom ria ecivreS
.yrassecen sa strap
diulf detsuahxe ro detelpeD
.ylppus
emirP .diulf llifeR ro metsys
.ti hsulf
rotom ria degamad ro nroW
cte ,laes ,gnikcap ,teksag
ecalpeR .rotom ria ecivreS
.yrassecen sa strap
noN - .tsuahxe ria pots
gnikcap ro evlav ekatnI
.ffo nrow
strap nrow ecalpeR
.noitarepo pmup citarrE
ton si evlav ekatnI
.desolc yletelpmoc
dna noitcurtsbo raelC
ecalpeR .pmup ecivres
.yrassecen sa strap
ekatni nrow ro nepo dleH
.evlav
dna noitcurtsbo raelC
.pmup ecivres
.ekortspu no tuptuo woL
.yrassecen sa strap ecalpeR
notsip nrow ro nepo dleH
.evlav
raelC dna noitcurtsbo
.pmup ecivres
.ekorts nwod no tuptuo woL
.yrassecen sa strap ecalpeR
ria ro senil ria ni noitcirtseR
.wol erusserp
ro erusserp ria esaercnI
.ylppus
.sekorts htob no tuptuo woL
.sevlav deggolc ro desolC
.evlav raelc ro evlav nepO
tneiciffusni si ylppus diulF
.detsuahxe ro
ro metsys emirP .diulf llifeR
.ti hsulf
,senil diulf ni snoitcurtsbO
.cte ,sevlav ,sesoh
feiler erusserp wolloF
raelc neht ,erudecorp
.noitcurtsbo

81
0.7 LACINHCET NOITACIFICEPSS
c noitacilppa dednemmoceR trah pmup seires 50PI rof
yrtsudnI
noitacilppA
ytisocsiV
)SPC(egnaR

lohoclA
0- 001
eyD
0- 0001
edirolhC lyhteM
0- 002
stnevloS
0- 005

)xetaL(tniaP
001 - 0001
)esab liO(tniaP
001 - 008
)dooW(relaeS
001 - 008
)esab liO(niatS
001 - 0001

itnA - ezeerF
03 - 001
tnacirbuL eiD
03 - 05
liO raeG
002 - 0001
tnacirbuL
001 - 0051
tnegA esaeleR dloM
03 - 001
liO
001 - 005
pmup seires 50PI rof snoitacificeps lanoitarepO
yrogetaC
ataD
wolf diulf mumixaM
)nim/sretiL 4.11( MPG 3
diulf mumixaM erusserp gnikrow
)rab521( isp 0081
egnar erusserp tupni riA
4 0 – 2( isp 081 – )raB 5.21
ezis telni riA
8/3 F( TPN ” )
ezis telni diulF
F( TPN ”4/3 )
ezis teltuo diulF
F( TPN ”4/3 )
dednemmoceR deeps elcyc
51 - nim/selcyc 52
thgieW - PI 50 htgnel murD / thgieW - htgnel ybbutS 50PI
)gK 41( sbl 13 22 ( sbl )gK 01
gnikcaP slaes/s
WMHU ,nolfeT EP
rednilyc dna doR
403 leets sselniats
81
0.7 LACINHCET NOITACIFICEPSS
c noitacilppa dednemmoceR trah pmup seires 50PI rof
yrtsudnI
noitacilppA
ytisocsiV
)SPC(egnaR

lohoclA
0- 001
eyD
0- 0001
edirolhC lyhteM
0- 002
stnevloS
0- 005

)xetaL(tniaP
001 - 0001
)esab liO(tniaP
001 - 008
)dooW(relaeS
001 - 008
)esab liO(niatS
001 - 0001

itnA - ezeerF
03 - 001
tnacirbuL eiD
03 - 05
liO raeG
002 - 0001
tnacirbuL
001 - 0051
tnegA esaeleR dloM
03 - 001
liO
001 - 005
pmup seires 50PI rof snoitacificeps lanoitarepO
yrogetaC
ataD
wolf diulf mumixaM
)nim/sretiL 4.11( MPG 3
diulf mumixaM erusserp gnikrow
)rab521( isp 0081
egnar erusserp tupni riA
4 0 – 2( isp 081 – )raB 5.21
ezis telni riA
8/3 F( TPN ” )
ezis telni diulF
F( TPN ”4/3 )
ezis teltuo diulF
F( TPN ”4/3 )
dednemmoceR deeps elcyc
51 - nim/selcyc 52
thgieW - PI 50 htgnel murD / thgieW - htgnel ybbutS 50PI
)gK 41( sbl 13 22 ( sbl )gK 01
gnikcaP slaes/s
WMHU ,nolfeT EP
rednilyc dna doR
403 leets sselniats
81
0.7 LACINHCET NOITACIFICEPSS
c noitacilppa dednemmoceR trah pmup seires 50PI rof
yrtsudnI
noitacilppA
ytisocsiV
)SPC(egnaR

lohoclA
0- 001
eyD
0- 0001
edirolhC lyhteM
0- 002
stnevloS
0- 005

)xetaL(tniaP
001 - 0001
)esab liO(tniaP
001 - 008
)dooW(relaeS
001 - 008
)esab liO(niatS
001 - 0001

itnA - ezeerF
03 - 001
tnacirbuL eiD
03 - 05
liO raeG
002 - 0001
tnacirbuL
001 - 0051
tnegA esaeleR dloM
03 - 001
liO
001 - 005
pmup seires 50PI rof snoitacificeps lanoitarepO
yrogetaC
ataD
wolf diulf mumixaM
)nim/sretiL 4.11( MPG 3
diulf mumixaM erusserp gnikrow
)rab521( isp 0081
egnar erusserp tupni riA
4 0 – 2( isp 081 – )raB 5.21
ezis telni riA
8/3 F( TPN ” )
ezis telni diulF
F( TPN ”4/3 )
ezis teltuo diulF
F( TPN ”4/3 )
dednemmoceR deeps elcyc
51 - nim/selcyc 52
thgieW - PI 50 htgnel murD / thgieW - htgnel ybbutS 50PI
)gK 41( sbl 13 22 ( sbl )gK 01
gnikcaP slaes/s
WMHU ,nolfeT EP
rednilyc dna doR
403 leets sselniats

91
pmup seires 50PI rof shparg ecnamrofreP
ledoM
A
B
murD 50PI
"57.45
"526.24
ybbutS 50PI
"12.52
"57.31
p daer ot woH ecnamrofre shparg
wolF/erusserP c riAnoitpmusno
.trahc fo egde mottob gnola wolf diulf etacoL .1 .trahc fo egde mottob gnola wolf deriuqer etacoL .1
erusserp ria tupni rof enil dlob ot yllacitrev wolloF .2 .erusserp ria tupni rof enil dlob ot yllacitrev wolloF .2 .
rahc fo egde thgir ot yllatnoziroh wolloF .3 daer ot trahc fo egde tfel ot yllatnoziroh wolloF .3 daer ot t
.erusserp diulf elbaliava mumixam .noitpmusnoc ria
etuniM reP selcyC
081
)90.5(
051
)742.4(
021
)893.3(
09
)845.2(
06
)996.1(
03
)948.0(
31.1
)82.4(
62.2
)55.8(
93.3
)38.21(
25.4
)11.71(
isp 081
isp 001
isp 04
isp 081
isp 001
isp 04
0081
)421(
0051
)4.301(
0021
)8.28(
009
)1.26(
006
)4.14(
003
)7.02(
52
001
MMCS( MFCS noitpmusnoc riA )
ISP erusserP diulF )raB(
MP/sretiL( MPG wolF diulF )
05
57
91
pmup seires 50PI rof shparg ecnamrofreP
ledoM
A
B
murD 50PI
"57.45
"526.24
ybbutS 50PI
"12.52
"57.31
p daer ot woH ecnamrofre shparg
wolF/erusserP c riAnoitpmusno
.trahc fo egde mottob gnola wolf diulf etacoL .1 .trahc fo egde mottob gnola wolf deriuqer etacoL .1
erusserp ria tupni rof enil dlob ot yllacitrev wolloF .2 .erusserp ria tupni rof enil dlob ot yllacitrev wolloF .2 .
rahc fo egde thgir ot yllatnoziroh wolloF .3 daer ot trahc fo egde tfel ot yllatnoziroh wolloF .3 daer ot t
.erusserp diulf elbaliava mumixam .noitpmusnoc ria
etuniM reP selcyC
081
)90.5(
051
)742.4(
021
)893.3(
09
)845.2(
06
)996.1(
03
)948.0(
31.1
)82.4(
62.2
)55.8(
93.3
)38.21(
25.4
)11.71(
isp 081
isp 001
isp 04
isp 081
isp 001
isp 04
0081
)421(
0051
)4.301(
0021
)8.28(
009
)1.26(
006
)4.14(
003
)7.02(
52
001
MMCS( MFCS noitpmusnoc riA )
ISP erusserP diulF )raB(
MP/sretiL( MPG wolF diulF )
05
57
91
pmup seires 50PI rof shparg ecnamrofreP
ledoM
A
B
murD 50PI
"57.45
"526.24
ybbutS 50PI
"12.52
"57.31
p daer ot woH ecnamrofre shparg
wolF/erusserP c riAnoitpmusno
.trahc fo egde mottob gnola wolf diulf etacoL .1 .trahc fo egde mottob gnola wolf deriuqer etacoL .1
erusserp ria tupni rof enil dlob ot yllacitrev wolloF .2 .erusserp ria tupni rof enil dlob ot yllacitrev wolloF .2 .
rahc fo egde thgir ot yllatnoziroh wolloF .3 daer ot trahc fo egde tfel ot yllatnoziroh wolloF .3 daer ot t
.erusserp diulf elbaliava mumixam .noitpmusnoc ria
etuniM reP selcyC
081
)90.5(
051
)742.4(
021
)893.3(
09
)845.2(
06
)996.1(
03
)948.0(
31.1
)82.4(
62.2
)55.8(
93.3
)38.21(
25.4
)11.71(
isp 081
isp 001
isp 04
isp 081
isp 001
isp 04
0081
)421(
0051
)4.301(
0021
)8.28(
009
)1.26(
006
)4.14(
003
)7.02(
52
001
MMCS( MFCS noitpmusnoc riA )
ISP erusserP diulF )raB(
MP/sretiL( MPG wolF diulF )
05
57

20
Pump viscosity guide
All calculations in Centipoise (cps)
Air pressure requirements: For optimum pump performance, 40 – 100 PSI
should be supplied to the IP05 series transfer pumps.
IP01 series pumps: 1 – 2,000 cps
IP02 series pumps: 1 – 4,000 cps
OP series pumps: 1 – 4,000 cps
IP05 series pumps: 1 – 10,000 cps
IP10 series pumps: 1 – 20,000 cps
IP15 series pumps: 1 – 20,000 cps
IP30 series pumps: 1 – 20,000 cps
Calculations are based on the following general guidelines
zInbound air pressure: 100 psi
zPressure at dispense point: 0 psi
zHose/pipe length w/smooth inner surface = L: 25 feetxHose size = D: ¾”
zFlow rate = Q: 2 gpm
zViscosity = V:
zPressure loss in hose/pipe (psi), P: P = 0.0273QVL/D4
The above viscosity values are only general guidelines. Other factors should always be taken into consideration
such as; dispensing valves, fittings, hose unions, elevation, outside ambient temperature, etc.