Kalee Big Toys 40027-12V Guide

Adult Assembly Required
Please read this manual carefully before assembly and use.
Battery Operated Ride-On Vehicle
Assembly Manual ＆ User ’ s Guide
BATTERY OPERATED FIRE ENGINE
Model NO . 40027-12V
CHILDREN’S PRODUCTS

Vehicle/Battery
Specifications
Age:3-7 Years
Vehicle weight limit: 45kg / 100 Lbs
Speed:Max speed 3.0-4.8 KM/H; 2-3 MPH
Battery Type:Sealed lead-acid rechargeable,12 volt 7Ah
Charging time:Always charge the battery for 8-10 hours before first use
and when charging is needed.Never charge over 20 hours.
Battery Life:Recharging about 300 times.
Power input for Charger:A/C 120 volts 60Hz
Power output to battery:DC 14 volts,1000 mA
Manufactured By:
Kalee Children’s Products Co.,Ltd.
1

Parts List:
Light Bar
4 pcs M8 Nut
Meter Panel
4 pcs Washers
Steering Wheel
Gear Box
2 pcs Front Wheel 2 pcs Rear Wheel
2 pcs Front Wheel Cover 2 pcs Rear Wheel Cover
Before assembly you should check to see that the following parts are included:
Wrench
2

Gear Box
Rear Wheel
Rear Wheel Cover
Washer
Nut
Wrench
Right
Left
3
How to assemble the vehicle
1. Connect the plug on the light bar to the plug
on the body;
2. Position light bar on top of the vehicle.
Secure with the 2 screws provided;
3. Position the Meter Panel and snap
into place;
4. Connect the plug on the steering wheel
to the plug from the meter panel;
5. Place the steering wheel onto the
steering column and secure with
screw.
6. Position the gear box onto the right side,
rear axle, put the rear wheels, rear wheel
covers and washers onto each side of the
rear axle, secure the nuts with the wrenches.
Place the front wheels, front wheel covers
and washers onto each side of the front axle,
secure the nuts with the wrenches.

CHARGING THE BATTERY
1)The vehicle is shipped with the battery unpluged. The vehicle must be charged up
before the first use.
2) Locate one red plug and one white plug on the underside of the vehicle.The white
plug goes to the battery and the the red plug goes to the foot pedal. Connect the
white battery plug to the red plug on the battery charger. Then plug charger into
a houshold wall outlet. When charging is complete, reconnect the battery plug to
the vehicle plug.
3) Make sure that the local voltage is the same as the charger before charging the
battery
Battery/charger Safety and Warnings
◆The charger is not a toy.The battery should be charged by adults only.
Do not allow children to play with charger or to recharge the battery.
◆Before the first use,you should charge the battery for 8-10 hours.Do
not charge the battery for more than 20 hours to avoid overheating
the charger.
◆It is normal for the adapter to feel warm during charging,but if the
charger feels very hot,stop charging,unplug charger and check the
battery and adapter.
◆When the vehicle begins to run slowly,recharge the battery.
◆To lengthen the life of the battery,always charge the battery before
storing and at least every three months thereafter.
◆Use only batteries of the same or equlvalent type as recommended by
the manufacturer.
◆Do not connect the battery terminals directly together or the battery
will short circult.
◆Charger should be examined regularly for damage to the cord,plug and
other parts.If any damage is found the charger should be repaired or
replaced immediately.Do not use damaged charger.
Battery plug
Charger plug
4
! WARNING- Only use the charger specified by the manufacturer.

Vehicle Safety Warnings:
! WARNING:
To reduce the risk of injury,adult supervision
is required.
Never use in roadways,near motor vehicles.
On or near steep inclines or steps,swimming
Pools or other bodies of water,always wear
shoes,and never allow more than 1 rider.
●Use the toy only on flat surface,such as inside your house,garden,or
playground.Do not ride the vehicle in dangerous places such as busy
streets,roads,or highways.
●Never use near swimming pools or other bodies of water.
●Never ride the toy in the mud or sandy areas.Never ride in hilly areas
or on steep slopes.This vehicie was made to operate on dry level ground.
●Never ride in the dark or in dimly lit areas.
●Clean the vehicle only with a damp cloth and never submerge vehicle in water
or spray vehicle with water from a hose.
●Only one person should ride this vehicle at a time.
●Do not exceed recommended weight limit.
●Please keep these instructions for reference about usage,storage and
safety guidelines.
●If vehicle is equipped with forward/reverse switch,never press this
switch while vehicle is in motion.Always stop the vehicle before
switching directions.
! WARNING
Contains small parts.Sharp points and sharp
edges.Adult assembly required.
! WARNING
Choking Hazard - Small parts
Not for children under 3 years old
Looking for dependable ride-ons and scooters? Rely on Big Toys for quality and long-lasting products.