Kenwood TK-8102H User manual

© 2002-2 PRINTED IN JAPAN
B51-8628-00 (N)854
UHF FM TRANSCEIVER
TK-8102H
SERVICE MANUAL
GENERAL .................................................. 2
PARTS LIST ............................................... 4
EXPLODED VIEW.................................... 11
PACKING ................................................. 12
ADJUSTMENT ........................................ 13
PC BOARD VIEWS
DISPLAY UNIT (X54-3340-20) ............ 19
TX-RX UNIT (X57-6390-XX) ............... 21
SCHEMATIC DIAGRAM .......................... 27
BLOCK DIAGRAM ................................... 31
LEVEL DIAGRAM .................................... 33
SPECIFICATIONS .................................... 35
CONTENTS
Panel assy
(A62-0942-03)
Front glass
(B10-2668-03)
Cabinet
(A01-2181-01)
Chassis
(A10-4048-11)
Key top
(K29-9065-01)
Modular jack
(E08-0877-05)
SUPPLEMENT
This TK-8102H service manual contains a number of sections which
differ from the service manual (B51-8611-00) for the TK-8102H.
For items other than those in this TK-8102H service manual please
refer to the service namual (B51-8611-00) for the TK-8102H.

2
TK-8102H GENERAL
INTRODUCTION
SCOPE OF THIS MANUAL
This manual is intended for use by experienced techni-
cians familiar with similar types of commercial grade com-
munications equipment. It contains all required service in-
formation for the equipment and is current as of this publica-
tion date. Changes which may occur after publication are
covered by either Service Bulletins or Manual Revisions,
which are issued as required.
ORDERING REPLACEMENT PARTS
When ordering replacement parts or equipment informa-
tion, the full part identification number should be included.
This applies to all parts : components, kits, and chassis. If
the part number is not known, include the chassis or kit
number of which it is a part and a sufficient description of
the required component for proper identification.
PERSONNEL SAFETY
The following precautions are recommended for person-
nel safety :
• DO NOT transmit if someone is within two feet (0.6
meter) of the antenna.
• DO NOT transmit until all RF connectors are secure and
any open connectors are properly terminated.
• SHUT OFF this equipment when near electrical blasting
caps or while in an explosive atmosphere.
• All equipment should be properly grounded before
power-up for safe operation.
• This equipment should be serviced by only qualified tech-
nicians.
PRE-INSTALLATION CONSIDERNATIONS
1. UNPACKING
Unpack the radio from its shipping container and check
for accessory items. If any item is missing, please contact
KENWOOD immediately.
2. LICENSING REQUIREMENTS
Federal regulations require a station license for each ra-
dio installation (mobile or base) be obtained by the equip-
ment owner. The licensee is responsible for ensuring trans-
mitter power, frequency, and deviation are within the limits
permitted by the station license.
Transmitter adjustments may be performed only by a li-
censed technician holding an FCC first, second or general
class commercial radiotelephone operator’s license. There
is no license required to install or operate the radio.
3. PRE-INSTALLATION CHECKOUT
3-1. Introduction
Each radio is adjusted and tested before shipment. How-
ever, it is recommended that receiver and transmitter opera-
tion be checked for proper operation before installation.
3-2. Testing
The radio should be tested complete with all cabling and
accessories as they will be connected in the final installa-
tion. Transmitter frequency, deviation, and power output
should be checked, as should receiver sensitivity, squelch
operation, and audio output. Signalling equipment operation
should be verified.

3
TK-8102H
5. INSTALLATION PLANNING –CONTROL STATIONS
5-1. Antenna system
Control station. The antenna system selection depends
on many factors and is beyond the scope of this manual.
Your KENWOOD dealer can help you select an antenna sys-
tem that will best serve your particular needs.
5-2. Radio location
Select a convenient location for your control station radio
which is as close as practical to the antenna cable entry
point. Secondly, use your system’s power supply (which
supplies the voltage and current required for your system).
Make sure sufficient air can flow around the radio and power
supply to allow adequate cooling.
SERVICE
This radio is designed for easy servicing. Refer to the
schematic diagrams, printed circuit board views, and align-
ment procedures contained in this manual.
NOTE
If you do not intend to use the 3.5-mm jack for the exter-
nal speaker, fit the supplied speaker-jack cap to stop dust
and sand getting in.
GENERAL
Speaker
jack cap
Power input
connector
Antenna
connector
4. PLANNING THE INSTALLATION
4-1. General
Inspect the vehicle and determine how and where the
radio antenna and accessories will be mounted.
Plan cable runs for protection against pinching or crush-
ing wiring, and radio installation to prevent overheating.
4-2. Antenna
The favored location for an antenna is in the center of a
large, flat conductive area, usually at the roof center. The
trunk lid is preferred, bond the trunk lid and vehicle chassis
using ground straps to ensure the lid is at chassis ground.
4-3. Radio
The universal mount bracket allows the radio to be
mounted in a variety of ways. Be sure the mounting surface
is adequate to support the radio’s weight. Allow sufficient
space around the radio for air cooling. Position the radio
close enough to the vehicle operator to permit easy access
to the controls when driving.
4-4. DC Power and wiring
1. This radio may be installed in negative ground electrical
systems only. Reverse polarity will cause the cable fuse
to blow. Check the vehicle ground polarity before installa-
tion to prevent wasted time and effort.
2. Connect the positive power lead directly to the vehicle
battery positive terminal. Connecting the Positive lead to
any other positive voltage source in the vehicle is not rec-
ommended.
3. Connect the ground lead directly to the battery negative
terminal.
4. The cable provided with the radio is sufficient to handle
the maximum radio current demand. If the cable must be
extended, be sure the additional wire is sufficient for the
current to be carried and length of the added lead.

TK-8102H PARTS LIST
4
✽New Parts. indicates safety critical components.
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert.
L: Scandinavia K: USA P: Canada
Y: PX (Far East, Hawaii) T: England E: Europe
Y: AAFES (Europe) X: Australia M: Other Areas
TK-8102H (Y51-4840-XX)
DISPLAY UNIT (X54-3340-20), TX-RX UNIT (X57-6390-XX)
New Desti-
parts nation
Ref. No. Address Parts No. Description
New Desti-
parts nation
Ref. No.
Address Parts No. Description
1 1B A01-2181-01 CABINET
2 3B A10-4048-11 CHASSIS
3 3A A62-0942-03 PANEL ASSY
5 3A B10-2668-03 FRONT GLASS
6 1D B62-1596-00 INSTRUCTION MANUAL (ENGLISH)
7 1D B62-1597-00 INSTRUCTION MANUAL (SPANISH) K,K2,K3
8 3B B72-2040-04 MODEL NAME PLATE K
8 3B B72-2041-04 MODEL NAME PLATE K2
8 3B B72-2042-04 MODEL NAME PLATE K3
8 3B B72-2043-04 MODEL NAME PLATE M
8 3B B72-2044-04 MODEL NAME PLATE M2
13 3B E04-0167-05 RF COAXIAL PECEPTACLE (M)
14 3C E30-3339-05 DC CORD ACCESSORY
15 2B E30-3448-05 DC CORD (RADIO)
16 2A E37-0961-05 FLAT CABLE
17 3A E37-0962-05 SPEAKER CABLE
20 3B F01-1024-24 HEAT CONDUCTOR CUBE (DRIVE FET)
21 2B F10-2421-01 SHIELDING COVER (UPPER)
22 3C F51-0017-05 FUSE (6✽30) ACCESSORY
- G10-1274-04 FIBROUS SHEET (PANEL ASSY)
26 2B,3B G11-4127-14 RUBBER SHEET
27 3B G13-1468-04 CUSHION (DC CORD)
28 3A G13-1836-04 CUSHION (SPEAKER)
29 3B G53-1525-03 PACKING (PANEL)
30 2B G53-1542-03 PACKING (PHONE JACK)
31 1B G53-1544-01 PACKING
32 2A ✽G53-1548-02 GASKET
34 2C,1D H12-3112-05 PACKING FIXTURE
35 2C ✽H13-1190-02 CARTON BOARD
36 1D H25-2341-04 PROTECTION BAG
37 2D ✽H52-1829-12 ITEM CARTON CASE
39 3C J19-1584-05 HOLDER ACCESSORY K,K2,K3
40 3D J29-0662-03 BRACKET ACCESSORY
42 3A K29-9065-01 KEY TOP
A 2B N67-2608-46 PAN HEAD SEMS SCREW W
B 2B,3B N87-2606-46 BRAZIER HEAD TAPTITE SCREW
C 1B,2B N87-2614-46 BRAZIER HEAD TAPTITE SCREW
44 3C N99-0395-05 SCREW SET ACCESSORY
46 3A ✽T07-0739-05 SPEAKER
47 2C T91-0624-05 MICROPHONE ACCESSORY K,K2,K3
D1-4 B30-2238-05 LED (Y)
D5-10 B30-2239-05 LED (SY)
D11 B30-2237-05 LED (YG)
D12 B30-2240-05 LED (SR)
C4 CK73GB1H103K CHIP C 0.010UF K
C8-17 CK73GB1H103K CHIP C 0.010UF K
C18 CC73GCH1H101J CHIP C 100PF J
C19 CK73GB1H102K CHIP C 1000PF K
CN1 E40-6170-05 FLAT CABLE CONNECTOR
J1 E08-0877-05 MODULAR JACK
CP3,4 RK75GB1J392J CHIP-COM 3.9K J 1/16W
R1-6 RK73GB1J102J CHIP R 1.0K J 1/16W
R7-15 RK73FB2A272J CHIP R 2.7K J 1/10W
Q1-8 KRC102S DIGITAL TRANSISTOR
Q9 KRA225S DIGITAL TRANSISTOR
Q10 KRC102S DIGITAL TRANSISTOR
C12 CK73GB1H102K CHIP C 1000PF K
C14 C92-0560-05 CHIP-TAN 10UF 6.3WV
C22 CK73GB1H102K CHIP C 1000PF K
C24 CK73GB1H103K CHIP C 0.010UF K
C25 CC73GCH1H220J CHIP C 22PF J
C26 CK73GB1C104K CHIP C 0.10UF K
C27 C92-0560-05 CHIP-TAN 10UF 6.3WV
C28 CK73GB1H471K CHIP C 470PF K
C29,30 CK73GB1C104K CHIP C 0.10UF K
C31,32 C92-0507-05 CHIP-TAN 4.7UF 6.3WV
C34 CK73GB1C104K CHIP C 0.10UF K
C35 C92-0560-05 CHIP-TAN 10UF 6.3WV
C36 CK73GB1H103K CHIP C 0.010UF K
C37 CK73GB1C104K CHIP C 0.10UF K
C40 C92-0514-05 CHIP-TAN 2.2UF 10WV
C42 CK73GB1H102K CHIP C 1000PF K
C44 CK73GB1C273K CHIP C 0.027UF K
C45 CK73GB1H102K CHIP C 1000PF K
C48,49 CK73GB1H471K CHIP C 470PF K
C50 CK73GB1C223K CHIP C 0.022UF K
C51 CK73GB1C104K CHIP C 0.10UF K
C52 C92-0507-05 CHIP-TAN 4.7UF 6.3WV
C53 CK73GB1C104K CHIP C 0.10UF K
C54 C92-0560-05 CHIP-TAN 10UF 6.3WV
C55 CK73GB1H471K CHIP C 470PF K
C56 C92-0555-05 CHIP-TAN 0.047UF 35WV
C58 CK73GB1H122K CHIP C 1200PF K
C59 CK73GB1E103K CHIP C 0.010UF K
C60 C92-0543-05 CHIP-TAN 3.3UF 10WV
C61 CK73GB1H821K CHIP C 820PF K
C62 CK73GB1H332K CHIP C 3300PF K
C63 CK73GB1H472K CHIP C 4700PF K
C64 C92-0560-05 CHIP-TAN 10UF 6.3WV
C65 C92-0001-05 CHIP C 0.1UF 35WV
C66 CC73GCH1H151J CHIP C 150PF J
C69 CK73GB1H471K CHIP C 470PF K
C71 CK73GB1C104K CHIP C 0.10UF K
C73 CC73GCH1H040B CHIP C 4.0PF B K2,M2
C73 CC73GCH1H070B CHIP C 7.0PF B K3
C73,74 CC73GCH1H080B CHIP C 8.0PF B K,M
C74 CC73GCH1H050B CHIP C 5.0PF B K2,M2
TK-8102H
DISPLAY UNIT (X54-3340-20)
TX-RX UNIT (X57-6390-XX) -20 : K,M -21 : K2,M2 -22 : K3

TK-8102H
PARTS LIST
5
Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description
New Desti-
parts nation
New Desti-
parts nation
C74 CC73GCH1H080B CHIP C 8.0PF B K3
C75 CC73GCH1H030B CHIP C 3.0PF B K2,M2
C75 CC73GCH1H060B CHIP C 6.0PF B K,M,K3
C77 CC73GCH1H0R5B CHIP C 0.5PF B
C78 CC73GCH1H040B CHIP C 4.0PF B K2,M2
C78 CC73GCH1H050B CHIP C 5.0PF B K3
C78 CC73GCH1H060B CHIP C 6.0PF B K,M
C79 CK73GB1H471K CHIP C 470PF K
C80 CK73GB1H103K CHIP C 0.010UF K
C81 CC73GCH1H271J CHIP C 270PF J
C82 CK73GB1H471K CHIP C 470PF K
C84 CK73GB1C104K CHIP C 0.10UF K
C85 CC73GCH1H010B CHIP C 1.0PF B K,M
C85 CC73GCH1H020B CHIP C 2.0PF B K2,M2
C85,86 CC73GCH1H020B CHIP C 2.0PF B K3
C86 CC73GCH1H1R5B CHIP C 1.5PF B K,M,K2
C86 CC73GCH1H1R5B CHIP C 1.5PF B M2
C87 CC73GCH1H560J CHIP C 56PF J
C88 CK73GB1C104K CHIP C 0.10UF K
C89 CC73GCH1H270J CHIP C 27PF J
C90 CK73GB1H471K CHIP C 470PF K
C94 CC73GCH1H101J CHIP C 100PF J
C95 CC73GCH1H020B CHIP C 2.0PF B K2,K3,M2
C95 CC73GCH1H050B CHIP C 5.0PF B K,M
C97 CC73GCH1H020B CHIP C 2.0PF B K2,K3,M2
C97 CC73GCH1H040B CHIP C 4.0PF B K,M
C99 CC73GCH1H050B CHIP C 5.0PF B K,M
C99,100 CC73GCH1H030B CHIP C 3.0PF B K2,K3,M2
C100 CC73GCH1H040B CHIP C 4.0PF B K,M
C101 CK73GB1H471K CHIP C 470PF K
C102 CK73GB1C104K CHIP C 0.10UF K
C103 C92-0568-05 CHIP-TAN 22UF 10WV
C104,105 CC73GCH1H0R5B CHIP C 0.5PF B
C106 CC73GCH1H180J CHIP C 18PF J
C107 CC73GCH1H060B CHIP C 6.0PF B
C108,109 CK73GB1H471K CHIP C 470PF K
C110 CC73GCH1H060B CHIP C 6.0PF B
C111,112 CC73GCH1H121J CHIP C 120PF J K3
C111,112 CC73GCH1H221J CHIP C 220PF J K,M,K2
C111,112 CC73GCH1H221J CHIP C 220PF J M2
C113 CK73GB1H471K CHIP C 470PF K
C114 CK73GB1C104K CHIP C 0.10UF K
C115 CC73GCH1H060B CHIP C 6.0PF B
C116,117 CK73GB1C104K CHIP C 0.10UF K
C118 CC73GCH1H020B CHIP C 2.0PF B
C119 CK73GB1H103K CHIP C 0.010UF K
C120 CK73GB1H102K CHIP C 1000PF K K3
C120 CK73GB1H472K CHIP C 4700PF K K,M,K2
C120 CK73GB1H472K CHIP C 4700PF K M2
C122 CC73GCH1H040B CHIP C 4.0PF B
C123 C92-0662-05 CHIP-TAN 15UF 6.3WV
C125,126 CK73GB1H471K CHIP C 470PF K
C127 CK73GB1H103K CHIP C 0.010UF K
C128 CK73GB1H102K CHIP C 1000PF K
C129 CK73GB1C104K CHIP C 0.10UF K
C135 CK73GB1H103K CHIP C 0.010UF K
C136 CK73GB1H102K CHIP C 1000PF K
C138 CC73GCH1H330J CHIP C 33PF J
C141 CK73GB1H471K CHIP C 470PF K
C142 CK73GB1E223K CHIP C 0.022UF K
C143 CK73GB1H102K CHIP C 1000PF K
C144 CK73GB1H392K CHIP C 3900PF K
C145 CC73GCH1H060B CHIP C 6.0PF B
C146 CK73GB1H471K CHIP C 470PF K
C147 CK73GB1E223K CHIP C 0.022UF K
C150 CC73GCH1H180J CHIP C 18PF J
C154 CK73GB1H471K CHIP C 470PF K
C155 CK73GB1H103K CHIP C 0.010UF K
C156 CC73GCH1H020B CHIP C 2.0PF B
C157 CK73GB1H471K CHIP C 470PF K
C160 CK73FB1C334K CHIP C 0.33UF K
C162 CC73GCH1H050B CHIP C 5.0PF B
C163 CC73GCH1H120J CHIP C 12PF J
C165 CK73GB1H103K CHIP C 0.010UF K
C166 CC73GCH1H060B CHIP C 6.0PF B K2,M2
C166 CC73GCH1H1R5B CHIP C 1.5PF B K,M
C168 CK73GB1H103K CHIP C 0.010UF K
C169 CK73GB1H471K CHIP C 470PF K
C170 CC73GCH1H050B CHIP C 5.0PF B K,M,K3
C170 CC73GCH1H100C CHIP C 10PF C K2,M2
C171 CC73GCH1H080B CHIP C 8.0PF B
C173 CK73GB1C104K CHIP C 0.10UF K
C174 CC73GCH1H100C CHIP C 10PF C
C176 CK73GB1H471K CHIP C 470PF K
C177 CC73GCH1H070B CHIP C 7.0PF B
C178 CK73GB1C104K CHIP C 0.10UF K
C179 CK73GB1H471K CHIP C 470PF K
C180 CK73GB1H103J CHIP C 0.010UF J
C182 CK73GB1C104K CHIP C 0.10UF K
C184 CK73GB1H471K CHIP C 470PF K
C185 CK73GB1H103J CHIP C 0.010UF J
C186 CC73GCH1H0R5B CHIP C 0.5PF B
C187,188 CK73GB1H471K CHIP C 470PF K
C191 CK73GB1C473K CHIP C 0.047UF K
C192,193 CK73GB1H103J CHIP C 0.010UF J
C194 CK73GB1H471K CHIP C 470PF K
C196 CK73GB1C333K CHIP C 0.033UF K
C197 CK73GB1H471K CHIP C 470PF K
C198 CK73GB1C333K CHIP C 0.033UF K
C199 CC73GCH1H180J CHIP C 18PF J K2,M2
C199 CC73GCH1H330J CHIP C 33PF J K3
C199 CC73GCH1H560J CHIP C 56PF J K,M
C200 CC73GCH1H070B CHIP C 7.0PF B K2,M2
C200 CC73GCH1H080B CHIP C 8.0PF B K3
C200 CC73GCH1H090B CHIP C 9.0PF B K,M
C201 CK73GB1H471K CHIP C 470PF K
C202 CC73GCH1H150J CHIP C 15PF J
C207 CC73GCH1H221J CHIP C 220PF J
C208 CK73GB1H103K CHIP C 0.010UF K
C211 CK73GB1E183K CHIP C 0.018UF K
C212 CK73GB1H822K CHIP C 8200PF K
C213 CK73GB1H471K CHIP C 470PF K
C214 CK73GB1C683K CHIP C 0.068UF K
C217 CK73FB1A105K CHIP C 1.0UF K
C218 CK73GB1C104K CHIP C 0.10UF K
C220 CK73GB1C473K CHIP C 0.047UF K
C221 CK73GB1H471K CHIP C 470PF K
C222 CK73GB1E123K CHIP C 0.012UF K
C223 C92-0507-05 CHIP-TAN 4.7UF 6.3WV
C225 CK73GB1H222K CHIP C 2200PF K
TX-RX UNIT (X57-6390-XX)

TK-8102H PARTS LIST
6
Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description
New Desti-
parts nation
New Desti-
parts nation
C226 CK73GB1C683K CHIP C 0.068UF K
C228 CK73GB1H471K CHIP C 470PF K
C236 CC73GCH1H060B CHIP C 6.0PF B K2,M2
C236 CC73GCH1H070B CHIP C 7.0PF B K,M,K3
C239 CK73GB1H471K CHIP C 470PF K
C247 CC73GCH1H050B CHIP C 5.0PF B K2,M2
C247 CC73GCH1H070B CHIP C 7.0PF B K,M,K3
C251 CK73GB1H471K CHIP C 470PF K
C255 CC73GCH1H0R5B CHIP C 0.5PF B
C262 ✽C92-0795-05 CHIP-TAN 22UF 10WV
C265 ✽C92-0795-05 CHIP-TAN 22UF 10WV
C266 CC73GCH1H030B CHIP C 3.0PF B K2,M2
C266 CC73GCH1H060B CHIP C 6.0PF B K,M,K3
C268 ✽C92-0795-05 CHIP-TAN 22UF 10WV
C271 CK73GB1H103K CHIP C 0.010UF K
C273 CC73GCH1H0R5B CHIP C 0.5PF B
C274 CK73GB1H103K CHIP C 0.010UF K
C275 CK73GB1C104K CHIP C 0.10UF K
C277 CK73FB1A105K CHIP C 1.0UF K
C279 CK73GB1H471K CHIP C 470PF K
C280 ✽C92-0795-05 CHIP-TAN 22UF 10WV
C283 CK73GB1H471K CHIP C 470PF K
C284 CK73FB1C224K CHIP C 0.22UF K
C286 CK73GB1C104K CHIP C 0.10UF K
C288 C92-0721-05 ELECTRO 330UF 25WV
C290 CK73GB1H471K CHIP C 470PF K
C295 CK73GB1H471K CHIP C 470PF K
C298,299 CK73GB1H471K CHIP C 470PF K
C302 C92-0040-05 CHIP-ELE 47UF 16WV
C304 CK73GB1H471K CHIP C 470PF K
C307 CK73GB1H471K CHIP C 470PF K
C308 C92-0560-05 CHIP-TAN 10UF 6.3WV
C310 CK73GB1H103K CHIP C 0.010UF K
C314 CK73GB1C104K CHIP C 0.10UF K
C316 C92-0516-05 CHIP-TAN 4.7UF 16WV
C318 CK73GB1H471K CHIP C 470PF K
C320 C92-0722-05 ELECTRO 470UF 16WV
C326 CK73GB1H471K CHIP C 470PF K
C327 CK73GB1H102K CHIP C 1000PF K
C328 CK73GB1H471K CHIP C 470PF K
C329 CK73GB1H103K CHIP C 0.010UF K
C330-332 CC73GCH1H101J CHIP C 100PF J
C333 CK73GB1H471K CHIP C 470PF K
C334 CC73GCH1H180J CHIP C 18PF J
C335,336 CK73GB1C104K CHIP C 0.10UF K
C337 C92-0507-05 CHIP-TAN 4.7UF 6.3WV
C338 CK73GB1C104K CHIP C 0.10UF K
C340 C92-0560-05 CHIP-TAN 10UF 6.3WV
C341 CK73GB1H471K CHIP C 470PF K
C342 C92-0507-05 CHIP-TAN 4.7UF 6.3WV
C344-350 CK73GB1H471K CHIP C 470PF K
C351 CK73GB1H102K CHIP C 1000PF K
C352,353 CK73GB1H471K CHIP C 470PF K
C355 CK73GB1C104K CHIP C 0.10UF K
C358-360 CK73GB1H471K CHIP C 470PF K
C363 CC73GCH1H050B CHIP C 5.0PF B K2,M2
C363 CC73GCH1H080B CHIP C 8.0PF B K,M,K3
C364,365 CK73GB1H471K CHIP C 470PF K
C366 CC73GCH1H070B CHIP C 7.0PF B
C367 CC73GCH1H470J CHIP C 47PF J K2,M2
C367 CK73GB1H471K CHIP C 470PF K K,M,K3
C369 CK73GB1H471K CHIP C 470PF K
C371,372 CK73GB1H471K CHIP C 470PF K
C374 C92-0507-05 CHIP-TAN 4.7UF 6.3WV
C375 CK73GB1C104K CHIP C 0.10UF K
C376 CK73GB1H471K CHIP C 470PF K
C377 C92-0004-05 CHIP-TAN 1.0UF 16WV
C378 CK73GB1H471K CHIP C 470PF K
C379 CK73GB1C104K CHIP C 0.10UF K
C511 CK73GB1H471K CHIP C 470PF K
C512,513 CC73GCH1H101J CHIP C 100PF J
C515 CK73GB1H471K CHIP C 470PF K
C518 C92-0507-05 CHIP-TAN 4.7UF 6.3WV
C520 CK73GB1H102K CHIP C 1000PF K
C521 CK73GB1H392K CHIP C 3900PF K
C522 CK73FB1A105K CHIP C 1.0UF K
C524 CK73GB1H102K CHIP C 1000PF K
C526 CK73GB1H102K CHIP C 1000PF K
C802 CK73GB1H471K CHIP C 470PF K
C803 CC73FCH1H120J CHIP C 12PF J K,M,K2
C803 CC73FCH1H120J CHIP C 12PF J M2
C803 CC73FCH1H270J CHIP C 27PF J K3
C804,805 CK73GB1H471K CHIP C 470PF K
C806 CC73FCH1H100D CHIP C 10PF D
C807 CK73GB1C104K CHIP C 0.10UF K
C808 C92-0040-05 CHIP-ELE 47UF 16WV
C809 CK73GB1H471K CHIP C 470PF K
C810 CK73GB1H103K CHIP C 0.010UF K
C811 CC73FCH1H471J CHIP C 470PF J
C812 CC73FCH1H120J CHIP C 12PF J
C813 CC73FCH1H150J CHIP C 15PF J K3
C813,814 CC73FCH1H220J CHIP C 22PF J K,M,K2
C813,814 CC73FCH1H220J CHIP C 22PF J M2
C814 CC73FCH1H330J CHIP C 33PF J K3
C815 CK73FB1H471K CHIP C 470PF K
C817 C93-0566-05 CHIP C 33PF J K2,K3,M2
C817 C93-0567-05 CHIP C 39PF J K,M
C818 CK73FB1H471K CHIP C 470PF K
C820 C93-0563-05 CHIP C 18PF J K2,M2
C820 C93-0564-05 CHIP C 22PF J K,M
C820 C93-0565-05 CHIP C 27PF J K3
C821 CK73FB1C474K CHIP C 0.47UF K
C823 C92-0719-05 ELECTRO 47UF 25WV
C825,826 C93-0563-05 CHIP C 18PF 500WV K3
C826 C93-0560-05 CHIP C 10PF 500WV K2,M2
C826 C93-0562-05 CHIP C 15PF 500WV K,M
C827 C93-0599-05 CHIP C 470PF K
C828,829 CM73F2H300J CHIP C 30PF 500WV
C831 CM73F2H200J CHIP C 20PF J K2,M2
C831 CM73F2H270J CHIP C 27PF J K,M
C831 CM73F2H300J CHIP C 30PF J K3
C832 C93-0599-05 CHIP C 470PF K
C833 CK73FB1C474K CHIP C 0.47UF K
C835 C93-0557-05 CHIP C 7.0PF D K2,M2
C835 C93-0558-05 CHIP C 8.0PF D K,M,K3
C836 CK73GB1H471K CHIP C 470PF K
C837 C93-0599-05 CHIP C 470PF K
C838,839 CK73GB1H103K CHIP C 0.010UF K
C841 C93-0560-05 CHIP C 10PF D K3
C841 C93-0561-05 CHIP C 12PF J K,M
TX-RX UNIT (X57-6390-XX)

TK-8102H
PARTS LIST
7
Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description
New Desti-
parts nation
New Desti-
parts nation
C841 C93-0599-05 CHIP C 470PF K K2,M2
C842 C93-0552-05 CHIP C 2.0PF C K2,M2
C842 C93-0556-05 CHIP C 6.0PF D K,M,K3
C843 CC73GCH1H0R5B CHIP C 0.5PF B
C844 CC73GCH1H020B CHIP C 2.0PF B
C846 CK73GB1H471K CHIP C 470PF K
C847 CC73GCH1H0R5B CHIP C 0.5PF B
C848 CC73GCH1H020B CHIP C 2.0PF B
C849 C93-0555-05 CHIP C 5.0PF C K2,M2
C849 C93-0558-05 CHIP C 8.0PF D K,M
C849 C93-0560-05 CHIP C 10PF D K3
C852 CK73GB1H471K CHIP C 470PF K
C853 C93-0553-05 CHIP C 3.0PF C K2,K3,M2
C853 C93-0555-05 CHIP C 5.0PF C K,M
C854 CK73GB1H103K CHIP C 0.010UF K
TC1 C05-0245-05 CERAMIC TRIMMER CAP (10PF) K3
TC1,2 C05-0245-05 CERAMIC TRIMMER CAP (10PF) K,M,K2
TC1,2 C05-0245-05 CERAMIC TRIMMER CAP (10PF) M2
TC2,3 C05-0399-05 CERAMIC TRIMMER CAP (6PF) K3
TC3 C05-0399-05 CERAMIC TRIMMER CAP (6PF) K,M,K2
TC3 C05-0399-05 CERAMIC TRIMMER CAP (6PF) M2
TC5 C05-0399-05 CERAMIC TRIMMER CAP (6PF) K,M,K2
TC5 C05-0399-05 CERAMIC TRIMMER CAP (6PF) M2
TC5 C05-0400-05 CERAMIC TRIMMER CAP (3PF) K3
CN1 E40-5651-05 FLAT CABLE CONNECTOR
CN5 E40-3246-05 PIN ASSY
CN6 E23-0486-05 TERMINAL
J1 E11-0425-05 3.5D PHONE JACK (3P)
101 3B F20-3320-04 INSULATING SHEET (C363/R835) K3
CF1 L72-0993-05 CERAMIC FILTER
CF2 L72-0999-05 CERAMIC FILTER
L1 L92-0140-05 FERRITE CHIP
L2 L41-1005-08 SMALL FIXED INDUCTOR
L3 L92-0138-05 FERRITE CHIP
L4 L92-0140-05 FERRITE CHIP
L5,6 L40-2702-86 SMALL FIXED INDUCTOR (27UH) K,M
L5,6 L40-2785-92 SMALL FIXED INDUCTOR (270NH) K2,K3,M2
L7 L92-0140-05 FERRITE CHIP
L8 L40-2702-86 SMALL FIXED INDUCTOR (27UH) K,M
L8 L40-2785-92 SMALL FIXED INDUCTOR (270NH) K2,K3,M2
L9 L40-3378-67 SMALL FIXED INDUCTOR (33NH) K,M
L9 L40-3978-67 SMALL FIXED INDUCTOR (39NH) K2,M2
L9 L40-5678-67 SMALL FIXED INDUCTOR (56NH) K3
L10 L40-2702-86 SMALL FIXED INDUCTOR (27UH) K,M
L10 L40-2785-92 SMALL FIXED INDUCTOR (270NH) K2,K3,M2
L11 L40-2778-67 SMALL FIXED INDUCTOR (27NH) K,M
L11 L40-3378-67 SMALL FIXED INDUCTOR (33NH) K2,M2
L11 L40-4778-67 SMALL FIXED INDUCTOR (47NH) K3
L12 L40-3381-86 SMALL FIXED INDUCTOR (0.33UH)
L13 L40-1885-92 SMALL FIXED INDUCTOR (180NH) K2,K3,M2
L13 L40-2702-86 SMALL FIXED INDUCTOR (27UH) K,M
L14 L40-3381-86 SMALL FIXED INDUCTOR (0.33UH)
L15 L40-1885-92 SMALL FIXED INDUCTOR (180NH) K2,M2
L15 L40-2702-86 SMALL FIXED INDUCTOR (27UH) K,M
L15 L40-2785-92 SMALL FIXED INDUCTOR (270NH) K3
L16 L92-0140-05 FERRITE CHIP
L17 L41-3385-08 SMALL FIXED INDUCTOR
L18 L92-0140-05 FERRITE CHIP
L19,20 L40-2702-86 SMALL FIXED INDUCTOR (27UH) K,M
L19,20 L40-2785-92 SMALL FIXED INDUCTOR (270NH) K2,K3,M2
L21 L41-2775-06 SMALL FIXED INDUCTOR
L22 L34-4554-05 COIL
L23 L92-0140-05 FERRITE CHIP
L24 L41-2775-06 SMALL FIXED INDUCTOR
L26,27 L40-4785-85 SMALL FIXED INDUCTOR (0.47UH)
L30 L34-4603-05 AIR-CORE COIL K2,M2
L30 L34-4604-05 AIR-CORE COIL K,M
L30 L34-4605-05 AIR-CORE COIL K3
L31 L41-6865-08 SMALL FIXED INDUCTOR
L32 L34-4604-05 AIR-CORE COIL K,M,K2
L32 L34-4604-05 AIR-CORE COIL M2
L32 L34-4605-05 AIR-CORE COIL K3
L36 L34-4603-05 AIR-CORE COIL K2,M2
L36 L34-4604-05 AIR-CORE COIL K,M
L36 L34-4605-05 AIR-CORE COIL K3
L38 L34-4604-05 AIR-CORE COIL K,M,K2
L38 L34-4604-05 AIR-CORE COIL M2
L38 L34-4605-05 AIR-CORE COIL K3
L46 L41-1575-06 SMALL FIXED INDUCTOR
L48,49 L34-4604-05 AIR-CORE COIL
L50 L40-3975-92 SMALL FIXED INDUCTOR (39NH)
L51 L40-1875-92 SMALL FIXED INDUCTOR (18NH) K,M,K2
L51 L40-1875-92 SMALL FIXED INDUCTOR (18NH) M2
L51 L40-2275-92 SMALL FIXED INDUCTOR (22NH) K3
L800 L41-3363-08 SMALL FIXED INDUCTOR
L801 L41-1075-08 SMALL FIXED INDUCTOR
L802 L34-4602-05 AIR-CORE COIL
L803 L34-4607-05 AIR-CORE COIL
L804 L34-4694-05 AIR-CORE COIL
L806 L34-4667-05 AIR-CORE COIL
L807 L34-4669-05 AIR-CORE COIL
L808,809 L34-4694-05 AIR-CORE COIL
L810 L34-4667-05 AIR-CORE COIL
X1 L77-1868-15 TCXO (16.8MHZ)
X2 L77-1867-05 CRYSTAL RESONATOR (7.159MHZ)
X2 L77-1905-05 CRYSTAL RESONATOR (7.159MHZ)
XF1 L71-0591-05 MCF (49.95MHZ/UM-4)
R1 RK73GB1J332J CHIP R 3.3K J 1/16W
R2 RK73GB1J102J CHIP R 1.0K J 1/16W
R3 R92-1252-05 CHIP R 0 OHM J 1/16W
R4,5 RK73GB1J101J CHIP R 100 J 1/16W
R6,7 R92-1252-05 CHIP R 0 OHM J 1/16W
R10,11 RK73GB1J102J CHIP R 1.0K J 1/16W
R12 RK73GB1J152J CHIP R 1.5K J 1/16W
R13 RK73GB1J102J CHIP R 1.0K J 1/16W
R15 RK73GB1J100J CHIP R 10 J 1/16W
R18 RK73GB1J913J CHIP R 91K J 1/16W
R19 RK73GB1J683J CHIP R 68K J 1/16W
R20 RK73GB1J104J CHIP R 100K J 1/16W
R21 RK73GB1J152J CHIP R 1.5K J 1/16W
R22 RK73GB1J122J CHIP R 1.2K J 1/16W
R23 RK73GB1J102J CHIP R 1.0K J 1/16W
R24 RK73GB1J754J CHIP R 750K J 1/16W
R26,27 RK73GH1J153D CHIP R 15K D 1/16W
R28 R92-1252-05 CHIP R 0 OHM J 1/16W
R30 RK73GB1J152J CHIP R 1.5K J 1/16W
R31 RK73GB1J244J CHIP R 240K J 1/16W
R32 R92-1252-05 CHIP R 0 OHM J 1/16W
TX-RX UNIT (X57-6390-XX)

TK-8102H PARTS LIST
8
Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description
New Desti-
parts nation
New Desti-
parts nation
R33 RK73GB1J102J CHIP R 1.0K J 1/16W
R34 RK73GB1J123J CHIP R 12K J 1/16W
R36 RK73GB1J471J CHIP R 470 J 1/16W
R37-39 RK73GB1J103J CHIP R 10K J 1/16W
R40 RK73GB1J224J CHIP R 220K J 1/16W
R41,42 RK73GB1J183J CHIP R 18K J 1/16W
R43 RK73GB1J223J CHIP R 22K J 1/16W
R44 R92-1252-05 CHIP R 0 OHM J 1/16W
R45 RK73GB1J334J CHIP R 330K J 1/16W
R46 RK73GB1J102J CHIP R 1.0K J 1/16W
R47 RK73GB1J473J CHIP R 47K J 1/16W
R48 RK73GB1J683J CHIP R 68K J 1/16W
R49 RK73GB1J823J CHIP R 82K J 1/16W
R50 RK73GB1J153J CHIP R 15K J 1/16W
R51 RK73GB1J102J CHIP R 1.0K J 1/16W
R52 RK73GB1J683J CHIP R 68K J 1/16W
R53 RK73GB1J823J CHIP R 82K J 1/16W
R54 RK73GB1J103J CHIP R 10K J 1/16W
R55 RK73GB1J222J CHIP R 2.2K J 1/16W
R56 RK73GB1J152J CHIP R 1.5K J 1/16W
R57 RK73GB1J683J CHIP R 68K J 1/16W
R58 RK73GB1J473J CHIP R 47K J 1/16W
R59 RK73GB1J223J CHIP R 22K J 1/16W
R60 RK73GB1J103J CHIP R 10K J 1/16W
R61 RK73GB1J473J CHIP R 47K J 1/16W
R62,63 RK73GB1J104J CHIP R 100K J 1/16W
R64 RK73GB1J154J CHIP R 150K J 1/16W
R67 RK73GB1J223J CHIP R 22K J 1/16W
R70 RK73GB1J473J CHIP R 47K J 1/16W
R72 RK73GB1J154J CHIP R 150K J 1/16W
R73,74 RK73GB1J103J CHIP R 10K J 1/16W
R76 RK73GB1J101J CHIP R 100 J 1/16W
R77,78 RK73GB1J103J CHIP R 10K J 1/16W
R80-85 RK73GB1J102J CHIP R 1.0K J 1/16W
R86 RK73GB1J101J CHIP R 100 J 1/16W
R87 RK73GB1J223J CHIP R 22K J 1/16W
R88 RK73GB1J101J CHIP R 100 J 1/16W
R89 RK73GB1J104J CHIP R 100K J 1/16W
R94 RK73GB1J472J CHIP R 4.7K J 1/16W
R95 R92-1252-05 CHIP R 0 OHM J 1/16W
R97 RK73GB1J102J CHIP R 1.0K J 1/16W
R98 RK73GB1J221J CHIP R 220 J 1/16W K,M
R98 RK73GB1J271J CHIP R 270 J 1/16W K2,M2
R98 RK73GB1J331J CHIP R 330 J 1/16W K3
R99 RK73GB1J151J CHIP R 150 J 1/16W K,M
R99 RK73GB1J221J CHIP R 220 J 1/16W K2,M2
R99 RK73GB1J271J CHIP R 270 J 1/16W K3
R100 RK73GB1J102J CHIP R 1.0K J 1/16W
R101 RK73GB1J124J CHIP R 120K J 1/16W
R102 RK73GB1J223J CHIP R 22K J 1/16W
R103 RK73GB1J182J CHIP R 1.8K J 1/16W K,M,K2
R103 RK73GB1J182J CHIP R 1.8K J 1/16W M2
R103 RK73GB1J183J CHIP R 18K J 1/16W K3
R104,105 R92-1252-05 CHIP R 0 OHM J 1/16W
R106 RK73GB1J123J CHIP R 12K J 1/16W K3
R106 RK73GB1J472J CHIP R 4.7K J 1/16W K,M,K2
R106 RK73GB1J472J CHIP R 4.7K J 1/16W M2
R107 RK73GB1J101J CHIP R 100 J 1/16W
R108 RK73GB1J224J CHIP R 220K J 1/16W K3
R108 RK73GB1J274J CHIP R 270K J 1/16W K,M,K2
R108 RK73GB1J274J CHIP R 270K J 1/16W M2
R109 R92-1252-05 CHIP R 0 OHM J 1/16W
R111 RK73GB1J222J CHIP R 2.2K J 1/16W
R113 RK73GB1J183J CHIP R 18K J 1/16W
R114 R92-1252-05 CHIP R 0 OHM J 1/16W
R115 RK73GB1J102J CHIP R 1.0K J 1/16W
R117 RK73GB1J102J CHIP R 1.0K J 1/16W
R118 RK73GB1J473J CHIP R 47K J 1/16W
R119 RK73GB1J102J CHIP R 1.0K J 1/16W
R120 RK73GB1J473J CHIP R 47K J 1/16W
R122,123 RK73GB1J473J CHIP R 47K J 1/16W
R124 RK73GB1J472J CHIP R 4.7K J 1/16W
R127 RK73GB1J104J CHIP R 100K J 1/16W
R128 RK73GB1J105J CHIP R 1.0M J 1/16W
R130 RK73GB1J332J CHIP R 3.3K J 1/16W
R132 RK73GB1J471J CHIP R 470 J 1/16W
R133 RK73GB1J101J CHIP R 100 J 1/16W
R134 R92-1252-05 CHIP R 0 OHM J 1/16W
R135-140 RK73GB1J102J CHIP R 1.0K J 1/16W
R141 RK73GB1J152J CHIP R 1.5K J 1/16W
R142-144 RK73GB1J102J CHIP R 1.0K J 1/16W
R145 R92-1252-05 CHIP R 0 OHM J 1/16W
R146 RK73GB1J334J CHIP R 330K J 1/16W
R147 RK73GB1J124J CHIP R 120K J 1/16W
R149 RK73GB1J104J CHIP R 100K J 1/16W
R150 RK73GB1J102J CHIP R 1.0K J 1/16W
R151 RK73GB1J103J CHIP R 10K J 1/16W
R152 RK73GB1J473J CHIP R 47K J 1/16W
R153 RK73GB1J561J CHIP R 560 J 1/16W
R154 RK73GB1J471J CHIP R 470 J 1/16W
R155 RK73GB1J472J CHIP R 4.7K J 1/16W
R156 RK73GB1J101J CHIP R 100 J 1/16W
R158 RK73GB1J102J CHIP R 1.0K J 1/16W
R159 RK73GB1J101J CHIP R 100 J 1/16W
R160 RK73GB1J102J CHIP R 1.0K J 1/16W
R161 RK73GB1J393J CHIP R 39K J 1/16W
R162 RK73GB1J102J CHIP R 1.0K J 1/16W
R163 RK73GB1J561J CHIP R 560 J 1/16W
R164 RK73GB1J473J CHIP R 47K J 1/16W
R165 R92-1252-05 CHIP R 0 OHM J 1/16W
R166 RK73GB1J102J CHIP R 1.0K J 1/16W
R167 RK73GB1J470J CHIP R 47 J 1/16W
R168 RK73GB1J183J CHIP R 18K J 1/16W
R169 RK73GB1J222J CHIP R 2.2K J 1/16W
R172 RK73GB1J102J CHIP R 1.0K J 1/16W
R173 RK73GB1J104J CHIP R 100K J 1/16W
R174 RK73GB1J220J CHIP R 22 J 1/16W
R175 RK73GB1J470J CHIP R 47 J 1/16W
R176 RK73GB1J823J CHIP R 82K J 1/16W
R177 RK73GB1J102J CHIP R 1.0K J 1/16W
R179 RK73GB1J154J CHIP R 150K J 1/16W
R181 RK73GB1J102J CHIP R 1.0K J 1/16W
R183 RK73GB1J100J CHIP R 10 J 1/16W
R184 R92-1252-05 CHIP R 0 OHM J 1/16W
R185 RK73GB1J471J CHIP R 470 J 1/16W
R186 RK73GB1J100J CHIP R 10 J 1/16W
R188 RK73GB1J104J CHIP R 100K J 1/16W
R189 RK73GH1J124D CHIP R 120K D 1/16W
R190 RK73GB1J123J CHIP R 12K J 1/16W
R191 RK73GH1J913D CHIP R 91K D 1/16W
TX-RX UNIT (X57-6390-XX)

TK-8102H
PARTS LIST
9
Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description
New Desti-
parts nation
New Desti-
parts nation
R192 RK73GB1J562J CHIP R 5.6K J 1/16W
R194 RK73GB1J153J CHIP R 15K J 1/16W
R195 RK73GH1J562D CHIP R 5.6K D 1/16W
R197 RK73GB1J332J CHIP R 3.3K J 1/16W
R198 RK73GB1J100J CHIP R 10 J 1/16W
R202 RK73GB1J332J CHIP R 3.3K J 1/16W
R204 RK73GB1J104J CHIP R 100K J 1/16W
R207 RK73GB1J823J CHIP R 82K J 1/16W
R208 RK73GB1J151J CHIP R 150 J 1/16W
R209 RK73GB1J394J CHIP R 390K J 1/16W
R210 RK73GB1J334J CHIP R 330K J 1/16W
R211 RK73GB1J473J CHIP R 47K J 1/16W
R214 RK73GB1J562J CHIP R 5.6K J 1/16W
R215 RK73GB1J104J CHIP R 100K J 1/16W
R216 RK73GB1J562J CHIP R 5.6K J 1/16W
R217 RK73GB1J474J CHIP R 470K J 1/16W
R218 RK73GB1J394J CHIP R 390K J 1/16W
R219 RK73GB1J105J CHIP R 1.0M J 1/16W
R227 RK73GB1J223J CHIP R 22K J 1/16W
R228 RK73GB1J184J CHIP R 180K J 1/16W
R229 RK73GB1J223J CHIP R 22K J 1/16W
R232 RK73GB1J184J CHIP R 180K J 1/16W
R234 RK73GB1J153J CHIP R 15K J 1/16W
R237 RK73GB1J104J CHIP R 100K J 1/16W
R242 RK73GB1J472J CHIP R 4.7K J 1/16W
R245 RK73GB1J104J CHIP R 100K J 1/16W
R248 RK73GB1J473J CHIP R 47K J 1/16W
R252 RK73GB1J152J CHIP R 1.5K J 1/16W
R255 RK73GB1J473J CHIP R 47K J 1/16W
R256 RK73GB1J104J CHIP R 100K J 1/16W
R258 RK73GB1J104J CHIP R 100K J 1/16W
R260 RK73GB1J473J CHIP R 47K J 1/16W
R261 RK73GB1J123J CHIP R 12K J 1/16W
R262 R92-1215-05 CHIP R 470 J 1/2W
R264 RK73GB1J391J CHIP R 390 J 1/16W
R265 RK73GB1J472J CHIP R 4.7K J 1/16W
R266 RK73GB1J334J CHIP R 330K J 1/16W
R268 R92-0670-05 CHIP R 0 OHM
R271 RK73GB1J472J CHIP R 4.7K J 1/16W
R273 RK73GB1J102J CHIP R 1.0K J 1/16W
R274 RK73GB1J223J CHIP R 22K J 1/16W
R275 RK73GB1J333J CHIP R 33K J 1/16W
R276-278 RK73GB1J102J CHIP R 1.0K J 1/16W
R279 RK73GJ1J393D CHIP R 39K D 1/16W
R280 RK73GH1J274D CHIP R 270K D 1/16W
R281 RK73GB1J102J CHIP R 1.0K J 1/16W
R282 RK73GB1J684J CHIP R 680K J 1/16W
R283 RK73GB1J184J CHIP R 180K J 1/16W
R285 RK73GB1J681J CHIP R 680 J 1/16W
R286 RK73GB1J124J CHIP R 120K J 1/16W
R287 RK73GB1J472J CHIP R 4.7K J 1/16W
R288,289 R92-1252-05 CHIP R 0 OHM J 1/16W
R291 RK73GB1J103J CHIP R 10K J 1/16W
R293 RK73GB1J682J CHIP R 6.8K J 1/16W
R294 RK73FB2A470J CHIP R 47 J 1/10W K,M
R294 RK73FB2A560J CHIP R 56 J 1/10W K2,K3,M2
R295,296 R92-1252-05 CHIP R 0 OHM J 1/16W
R298 RK73GB1J101J CHIP R 100 J 1/16W
R300 R92-1252-05 CHIP R 0 OHM J 1/16W
R301 RK73GB1J104J CHIP R 100K J 1/16W
R302 RK73GB1J683J CHIP R 68K J 1/16W
R303 RK73GB1J334J CHIP R 330K J 1/16W
R304 RK73GB1J224J CHIP R 220K J 1/16W
R305 RK73GB1J913J CHIP R 91K J 1/16W
R306 RK73GB1J334J CHIP R 330K J 1/16W
R307 RK73GB1J333J CHIP R 33K J 1/16W
R308 R92-1252-05 CHIP R 0 OHM J 1/16W
R310 RK73GB1J104J CHIP R 100K J 1/16W
R311 RK73GB1J101J CHIP R 100 J 1/16W
R313 RK73GB1J821J CHIP R 820 J 1/16W
R319,320 RK73GB1J474J CHIP R 470K J 1/16W
R321 R92-1252-05 CHIP R 0 OHM J 1/16W
R322 RK73GB1J683J CHIP R 68K J 1/16W
R323 R92-1252-05 CHIP R 0 OHM J 1/16W
R324,325 RK73GB1J102J CHIP R 1.0K J 1/16W
R326 RK73GB1J333J CHIP R 33K J 1/16W
R327 RK73GB1J102J CHIP R 1.0K J 1/16W
R328 RK73GB1J472J CHIP R 4.7K J 1/16W
R329 RK73GB1J474J CHIP R 470K J 1/16W
R330 RK73GB1J394J CHIP R 390K J 1/16W
R335 RK73GB1J472J CHIP R 4.7K J 1/16W
R800 RK73GB1J153J CHIP R 15K J 1/16W
R801 RK73FB2A220J CHIP R 22 J 1/10W
R802 RK73GB1J333J CHIP R 33K J 1/16W
R803 R92-1217-05 CHIP R 0 OHM
R805 RK73GB1J101J CHIP R 100 J 1/16W
R806 RK73FB2A821J CHIP R 820 J 1/10W K3
R807 R92-1211-05 CHIP R 5.6 J 1/2W K3
R807 R92-1217-05 CHIP R 0 OHM K,M,K2
R807 R92-1217-05 CHIP R 0 OHM M2
R808 RK73GB1J474J CHIP R 470K J 1/16W
R809 RK73FB2A821J CHIP R 820 J 1/10W K3
R810 RK73GB1J471J CHIP R 470 J 1/16W
R811 RK73GB1J473J CHIP R 47K J 1/16W
R812 RK73GB1J471J CHIP R 470 J 1/16W
R813 RK73EB2B100J CHIP R 10 J 1/8W
R814 RK73GB1J683J CHIP R 68K J 1/16W
R815 RK73GB1J821J CHIP R 820 J 1/16W
R818 R92-1252-05 CHIP R 0 OHM J 1/16W
R819 RK73GB1J473J CHIP R 47K J 1/16W
R820 RK73GB1J563J CHIP R 56K J 1/16W
R822 R92-1215-05 CHIP R 470 J 1/2W
R823,824 RK73GB1J473J CHIP R 47K J 1/16W
R825 R92-1252-05 CHIP R 0 OHM J 1/16W
R826 RK73GB1J221J CHIP R 220 J 1/16W
R827 RK73GB1J473J CHIP R 47K J 1/16W
R828 R92-1213-05 CHIP R 100 J 1/2W
R829,830 RK73GB1J223J CHIP R 22K J 1/16W
R831 RK73GB1J472J CHIP R 4.7K J 1/16W
R832 RK73GB1J332J CHIP R 3.3K J 1/16W
R833 RK73GB1J473J CHIP R 47K J 1/16W
R834 RK73GB1J103J CHIP R 10K J 1/16W
R835 RK73GB1J100J CHIP R 10 J 1/16W K3
R888 F53-0108-05 FUSE 1.8A 50V
D1-4 DA221 DIODE
D6 MA2S111 DIODE
D7 HZU5ALL DIODE
D9-12 MA2S304 VARIABLE CAPACITANCE DIODE
D13 DAN222 DIODE
TX-RX UNIT (X57-6390-XX)

TK-8102H PARTS LIST
10
Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description
New Desti-
parts nation
New Desti-
parts nation
D14 MA360 VARIABLE CAPACITANCE DIODE
D15 DAN222 DIODE
D16 MA2S111 DIODE
D18 MA742 DIODE
D19 DAN235E DIODE
D21,22 HVC350B VARIABLE CAPACITANCE DIODE K,M,K3
D21,22 HVC355B VARIABLE CAPACITANCE DIODE K2,M2
D23 DA221 DIODE
D24 MA742 DIODE
D25 HVC355B VARIABLE CAPACITANCE DIODE K3
D25,26 HVC350B VARIABLE CAPACITANCE DIODE K,M
D25,26 HVC355B VARIABLE CAPACITANCE DIODE K2,M2
D26 HVC350B VARIABLE CAPACITANCE DIODE K3
D28 HVC350B VARIABLE CAPACITANCE DIODE K,M,K3
D28 HVC355B VARIABLE CAPACITANCE DIODE K2,M2
D38 ZSH5MA27 SURGE ABSORBER
D39 02DZ18(X,Y) ZENER DIODE
D41 1812L110PR VARISTOR
D43 DAN222 DIODE
D44 1SS372 DIODE
D800 02DZ5.1(Y) ZENER DIODE
D801,802 MA4PH633 DIODE
D803,804 XB15A709 DIODE
D805,806 MA742 DIODE
D807 1SS355 DIODE
IC1 MB15A02 MOS IC
IC3 M62363FP MOS IC
IC4 NJM2902V MOS IC
IC5 TK14489V BI-POLAR IC
IC6 784214AGC141 MPU
IC7 24LC08BT-ISN ROM IC
IC9 LC73872M MOS IC
IC10 NJM2902V MOS IC
IC11 NJM2904V MOS IC
IC14 NJM78L05UA BI-POLAR IC
IC15 PST9140NR MOS IC
IC17 NJM78L05UA BI-POLAR IC
IC18 PST9140NR MOS IC
IC19 TC7W74FU MOS IC
IC20 KIA7808AF ANALOG IC
IC21 NJM2100V MOS IC
IC22 NJM2904V MOS IC
IC101 2B LA4600 BI-POLAR IC
IC800 TA75W01FU MOS IC
Q2 2SJ243 FET
Q3 2SC4649(N,P) TRANSISTOR
Q4 2SA1832(GR) TRANSISTOR
Q5 2SC4738(GR) TRANSISTOR
Q6 2SC4649(N,P) TRANSISTOR
Q7 2SJ243 FET
Q10,11 2SK508NV(K52) FET
Q12 KRX102U TRANSISTOR
Q13 2SK1824 FET
Q14 2SC4617(S) TRANSISTOR
Q15 2SC5108(Y) TRANSISTOR
Q16 KRC414RTK DIGITAL TRANSISTOR
Q18 2SC2412K TRANSISTOR
Q19 2SC4649(N,P) TRANSISTOR
Q20 2SC5108(Y) TRANSISTOR
Q21 3SK255 FET
Q22 2SK1824 FET
Q23 2SC3356(R24) TRANSISTOR
Q24 2SC4617(S) TRANSISTOR
Q26 3SK255 FET
Q29,30 KRC102S DIGITAL TRANSISTOR
Q31 2SA1745(6,7) TRANSISTOR
Q32 DTC363EU DIGITAL TRANSISTOR
Q33 KTA1664(Y) TRANSISTOR
Q34,35 KRC102S DIGITAL TRANSISTOR
Q37 2SK1824 FET
Q38 KRC404RTK DIGITAL TRANSISTOR
Q39 2SC5110(O) TRANSISTOR
Q41 2SC4919 TRANSISTOR
Q42 2SA1641(S,T) TRANSISTOR
Q43 2SK1824 FET
Q101 2B 2SK3478-22 FET
Q800 2SK2596 FET
Q801 2SK3075 FET
TH1 B57331V2104J THERMISTOR
TH3 B57331V2104J THERMISTOR
TH5 B57331V2104J THERMISTOR
TX-RX UNIT (X57-6390-XX)

11
TK-8102H
EXPLODED VIEW
AB
1
2
3
1
31
21
30
26
16
42
46
28
5
3
17
2
20
27
101
32
C
A
A
A
CC
C
CC
Cx2
26
15
B
B
B
B
B
B
Bx2
Bx2
Bx2
Bx2
IC101
Q101
TX-RX UNIT
(X57)
DISPLAY UNIT
(X54)
13
8
29 701
702
A M2.6 x 8 : N67-2608-46
B M2.6 x 6 (Br-Tap) : N87-2606-46
C M2.6 x 14 (Br-Tap) : N87-2614-46
Parts with the exploded numbers larger than 700 are not supplied.

12
TK-8102H PACKING
CD
1
2
3
36 Protection bag
(H25-2341-04)
36 Protection bag
(H25-2341-04)
6 Instruction manual (English)
(B62-1596-00)
7 Instruction manual (Spanish)
(B62-1597-00) : K,K2,K3
34 Packing fixture
(H12-3112-05)
34 Packing fixture
(H12-3112-05)
47 Microphone
(T91-0624-05) : K,K2,K3
37 Item carton case
(H52-1829-12)
40 Bracket
(J29-0662-03)
44 Screw set
(N99-0395-05)
39 MIC holder
(J19-1584-05) : K,K2,K3
35 Carton board
(H13-1190-02)
14 DC cord
(E30-3339-05)
22 Fuse (6*30)
(F51-0017-05) x 2
703
704
Parts with the exploded numbers larger than 700 are not supplied.

13
TK-8102H
Test Equipment Required for Alignment
Test Equipment Major Specifications
1. Standard Signal Generator Frequency Range 400 to 520MHz
(SSG) Modulation Frequency modulation and external modulation
Output –127dBm/0.1µV to greater than –7dBm/100mV
2. Power Meter Input Impedance 50Ω
Operation Frequency 400 to 520MHz or more
Measurement Capability Vicinity of 100W
3. Deviation Meter Frequency Range 400 to 520MHz
4. Digital Volt Meter Measuring Range 1 to 20V DC
(DVM) Accuracy High input impedance for minimum circuit loading
5. Oscilloscope DC through 30MHz
6. High Sensitivity Frequency Range 10Hz to 1000MHz
Frequency Counter Frequency Stability 0.2ppm or less
7. Ammeter 20A
8. AF Volt Meter Frequency Range 50Hz to 10kHz
(AF VTVM) Voltage Range 1mV to 3V
9. Audio Generator (AG) Frequency Range 20Hz to 20kHz or more
Output 0 to 1V
10. Distortion Meter Capability 3% or less at 1kHz
Input Level 50mV to 10Vrms
11. 4ΩDummy Load Approx. 4Ω, 10W or more
12. Regulated Power Supply 13.6V, approx. 20A (adjustable from 9 to 17V)
Useful if ammeter requipped
13. Spectrum Analyzer Center frequency 50KHz to 600MHz
14. Tracking Generator Output Voltage 100mV or more
ADJUSTMENT
Lead wire +
MIC Shield wire –
1
8
Tuning cable (E30-3383-05)
Adapter cable (E30-3383-05) is required for
injecting an audio if PC tuning is used.
See "PC Mode" section for the connection.
MIC connector
(Front view)
Test cable for microphone input (E30-3360-08)
1 : BLC
2 : PSB
3 : E
4 : PTT
5 : ME
6 : MIC
7 : HOOK
8 : CM

14
TK-8102H ADJUSTMENT
Adjustment Location
■Switch
Power
MIC jack 1/2/3/4 keys
Volume
up/down
key
key Speaker
Display
■Adjustment Points
E+B
POWER
RXD
TXD
CV
BPF
AFV
TX-RX UNIT (X57-639)
Component side
RF
ANT
TC5
TC2
TC1
TC3
L22
BPF
+B GND
TX-RX UNIT (X57-639)
Foil side
■Note
•EEPROM
The tuning data (Deviation, Squelch, etc.) for the
EEPROM, is stored in memory. When parts are changed,
readjust the transceiver.
•AF PA IC (IC101)
How to mounting the IC101.
Pin 1 marker
IC101
Part name label face down
TX-RX UNIT (X57-639)
Component side
C828
C829
C826
•SPEAKER CABLE
The speaker cable should be formed before mounting the
shield cover as below.
•FUSE
To mount the Fuse, the cable terminal direction must be
as follows.
Locator
Speaker
cable
This side up This side up
Cable terminal Cable terminal
Fuse

15
TK-8102H
ADJUSTMENT
Replacing a Drive FET (Q801)
1. When replacing the Drive FET, you must also replace its
heat conductor cube, because the heat conductor cube is
removed along with the FET.
2. After removing the FET and its heat conductor cube, sol-
der a new Drive FET to the PCB. Make sure the FET is in
the proper position before soldering.
3. Attach the heat conductor cube to the FET as instructed
below.
■How to Solder the Heat Conductor Cube
1. Place a piece of soldering wire (about 2.5~3.0 mm long x
0.6mm diameter) into the FET hole on the PCB ( q).
2. Place the heat conductor cube on the PCB surface beside
the FET hole. The rounded surface of the heat conductor
cube must face upward (as shown below) ( w).
3. Slide and drop the cube into the FET hole so that the
rounded surface of the cube is now horizontal (as shown
below) ( e).
4. Place a heated soldering iron onto the top of the cube,
using an iron tip 900M-T-3CF. Hold the soldering iron in
position for about 5 seconds (See the figure 2).
PCB
Drive FET
Q801
132
4
PCB
Drive FET
OK NG
Uneven Solder
PCB PCB PCB
Drive FET Drive FET Drive FET
PCB
Drive FET
5
PCB
Drive FET
5. The solder melts and binds the FET and the cube se-
curely. Then, slide the soldering iron along the PCB sur-
face to cool the soldering down ( r). If the heat conduc-
tor cube comes off from the PCB or the soldering can be
seen on the top of the plate, the soldering has not been
successful. The soldering must bind the heat conductor
cube and FET securely (see the figure 3).
■How to Check the Heat Conductor Cube Surface
1. Slide your index finger along the PCB surface (as shown
below) ( t).
The surface should be flat and smooth. If you feel that
the surface is uneven because of solder or flux, grind
them using meshed copper or re-solder the cube in order
to flatten the surface.
6. After soldering the heat conductor cube to the PCB,
check the level of PCB surface. The surface of the heat
conductor cube must be free of flux and solder. It must
be flat and smooth, at the same level as the PCB surface
(as shown below).
Fig. 1
Fig. 2
Fig. 3
Fig. 4
3.0mm
(0.118")
17mm
(0.670")
45°
900M-T-3CF
Fig. 5

16
TK-8102H ADJUSTMENT
PCB Section
1. Setting 1) Power supply voltage
DC Power supply terminal : 13.6V
2. VCO lock 1) CH : TX high Digital voltmeter CV TC2 5.5V ±0.1V
voltage* 2) CH : RX high TC1 5.5V ±0.1V
3) CH : TX low Check 0.8V or more
4) CH : RX low
3. IF coil 1) CH : RX center (Wide) SSG AFV L22 3.2~3.3V (DC)
2) SSG output : –53dBm (501µV) Digital voltmeter
Mod : 1kHz, Dev : 3kHz
4. RF 1) CH : RX center (Wide) Tra generator ANT TC3 Adjust the BPF waveform
bandpass CH : RX low (Wide) Spectrum analyzer BPF TC5 to Fig. 1
filter CH : RX high (Wide)
2) Tra generator output : –30dBm
Connect the spectrum analyzer
to BPF terminal
* Adjustment of TX VCO lock voltage
1. Remove R814, R888 (fuse), R823 and R807 (all on component side).
2. Remove PCB from chassis.
3. Transmit and check voltage at [CV] point.
Warning : Do not transmit if step “1.” is not complete.
4. Adjust of voltage can be done by tuning TC2.
Item Condition Test equipment
Terminal Parts Method
Specifications/
Remarks
Measurement Adjustment
Fig. 1
Test Frequency (MHz)
Channel K,M (F1) K2 (F2) M2 (F2) K3 (F3)
TX RX TX RX TX RX TX RX
1 : Center 470.100 470.050 498.600 498.550 502.600 502.550 415.100 415.050
2 : Low 450.100 450.050 485.100 485.050 485.100 485.050 400.100 400.050
3 : High 489.900 489.950 511.900 511.950 519.900 519.950 429.900 429.950
4 470.000 470.000 498.500 498.500 502.000 502.000 415.000 415.000
5 470.200 470.200 498.700 498.700 502.200 502.200 415.200 415.200
6 470.400 470.400 498.900 498.900 502.400 502.400 415.400 415.400
K,M (F1) K2,M2 (F2) K3 (F3)

17
TK-8102H
Receiver Section
1. Seisitivity 1) CH : RX low (Wide/Narrow) SSG ANT Check SINAD
CH : RX center (Wide/Narrow) Oscilloscope EXT. SP : 12dB or higher
CH : RX high (Wide/Narrow) AF V.M
2) SSG output Distortion meter
: –118dBm (0.28µV) (Wide)
: –116dBm (0.35µV) (Narrow)
Mod : 1kHz
Dev : ±3.0kHz (Wide)
Dev : ±1.5kHz (Narrow)
2. Squelch 9 1) CH : RX low (Wide) PC key Adjust to open the squelch
CH : RX center (Wide/Narrow)
CH : RX high (Wide)
2) SSG output
: –113dBm (0.5µV) (Wide)
: –112dBm (0.56µV) (Narrow)
Mod : 1kHz
Dev : ±3.0kHz (Wide)
Dev : ±1.5kHz (Narrow)
3. Squelch 1 1) CH : RX low (Wide)
CH : RX center (Wide/Narrow)
CH : RX high (Wide)
2) SSG output
: –120dBm (0.22µV) (Wide)
: –119dBm (0.25µV) (Narrow)
Mod : 1kHz
Dev : ±3.0kHz (Wide)
Dev : ±1.5kHz (Narrow)
Item Condition Test equipment
Terminal Parts Method
Specifications/
Remarks
Measurement Adjustment
Transmitter Section
1. Frequency 1) CH : TX center Frequency counter ANT PC key Adjust to center frequency Within ±100Hz
2) Transmit
2. High 1) CH : TX low Power meter 45W ±1.0W
power CH : TX low’
CH : TX center
CH : TX high’
CH : TX high
2) Transmit
3. Low 1) CH : TX low 25W ±1.0W
power CH : TX low’
CH : TX center
CH : TX high’
CH : TX high
2) Transmit
4. DQT 1) CH : TX low (Wide) Modulation analyzer Adjust the waveform as below
balance CH : TC center (Wide/Narrow) or Linear detector
CH : TX high (Wide) (LPF : 3kHz)
2) Transmit Oscilloscope
Item Condition Test equipment
Terminal Parts Method
Specifications/
Remarks
Measurement Adjustment
ADJUSTMENT

18
TK-8102H ADJUSTMENT
Transmitter Section
5. MAX 1) CH : TX low (Wide) Modulation analyzer ANT PC key ±4.0kHz (Wide) ±50Hz
balance CH : TC center (Wide/Narrow) or Linear detector MIC ±2.0kHz (Narrow)
CH : TX high (Wide) (LPF : 15kHz) According to the large +, –
2) AG : 1kHz/50mV Oscilloscope
3) Transmit AG
AF V.M
6. MIC 1) CH : TX center (Wide/Narrow) Check ±3kHz±0.2kHz
sensitivity 2) AG : 1kHz/5mV (Wide)
3) Transmit ±1.5kHz±0.1kHz
(Narrow)
7. DQT 1) CH : TX low (Wide) Modulation analyzer ±0.75kHz (Wide) ±0.05kHz
deviation CH : TX center (Wide/Narrow) or Linear detector ±0.35kHz (Narrow)
CH : TX high (Wide) (LPF : 3kHz)
2) Transmit Oscilloscope
8. QT 1) CH : TX low (Wide) ±0.75kHz (Wide) ±0.05kHz
deviation CH : TX center (Wide/Narrow) ±0.35kHz (Narrow)
CH : TX high (Wide)
2) Transmit
9. DTMF 1) CH : TX center (Wide/Narrow) ±3.0kHz (Wide) ±0.2kHz
deviation 2) Transmit ±1.5kHz (Narrow)
Item Condition Test equipment
Terminal Parts Method
Specifications/
Remarks
Measurement Adjustment
If normal power is not obtained, please follow the
step below
Open the shielding cover (upper), and screw 3 locations
around ANT pin.
1. Switch off the transceiver.
Impedance of Final FET (Q101) and Drive FET (Q801) can
be measured easily using DVM Ωmode.
Normal condition – Gate : 2MΩ~, Drain : 20kΩ~50kΩ
The above impedance values are rough estimations.
2. Switch on the transceiver. Check the voltage at R888
(fuse) output point.
The voltage is around 13.6V in receiving condition. The
voltage will be 12.6V~ in transmitting condition. If found
0V at this point then R888 (fuse) is broken.
3. Remove R807.
4. Connect 50Ωload at the ANT location.
Transmit and check current drain at High power mode.
If the current drain is less than 1A, then Final FET is bro-
ken.
If the current drain is less than 5.0A, short the Drive FET
gate to ground, and check the current drain.
If the current drain is not 0.1A less than the original value,
then the Drive FET is broken.
5. Check input power level at Drive FET gate location.
Connect the wire to [RF] location.
Transmit and check for power to be within the range of
0.7W~1W.
If power found is less than 0.5W, check the circuit before
the Drive FET.

S
RQP
O
NMLK
J
IHGF
E
D
CB
A
1
2
3
4
5
6
7
8
9
10
11
12
13
14
POWER
D4
UP
DOWN
D7
1 2 3 4
D2
D8 D9 D10
D1
PROG
D3
MONI
D5
D6
D12
D11
J1
J72-0790-12
POWER
D4
UP
DOWN
D7
1 2 3 4
D2
D8 D9 D10
D1
PROG
D3
MONI
D5
D6
D12
D11
J1
J72-0790-12
8
8
4
4
1
1
5
5
C17
Q10
Q2 Q6
Q4
Q8
Q1
Q5
R14
C18 C18
C19 C19
R9
R10
C11
C10
R13
R7
R8
C16
R6 R5 R4 R3 R2 R1
C4
CN1
R15
Q9
C13 C12 C9 C8
CP4 CP3
Q3
Q7
R11 R12
C15 C14
1
23
PSB
KMO2
KMO1
KMI4
KMI3
KMI2
KMI1
CM
LEDC4
LEDC3
MICBL
LEDG
LEDR
LEDC2
LEDC1
LEDPF
LEDMON
POWER
MIC
ME
HOOK
PTT
GND
C17
Q10
Q2 Q6
Q4
Q8
Q1
Q5
R14
R9
R10
C11
C10
R13
R7
R8
C16
R6 R5 R4 R3 R2 R1
C4
CN1
R15
Q9
C13 C12 C9 C8
CP4 CP3
Q3 Q7
R11 R12
C15 C14
1
23
GND
PTT
HOOK
ME
MIC
POWER
LEDMON
LEDPF
LEDC1
LEDC2
LEDR
LEDG
MICBL
LEDC3
LEDC4
CM
KMI1
KMI2
KMI3
KMI4
KMO1
KMO2
PSB
PC BOARD VIEWS TK-8102H
DISPLAY UNIT (X54-3340-20) Component side view (J72-0790-12)
DISPLAY UNIT (X54-3340-20) Foil side view (J72-0790-12)
Component side
Foil side
19 20
Ref. No. Address
 Q5 3H
 Q6 4E
 Q7 4H
 Q8 3F
Ref. No. Address
 Q1 3G
 Q2 4D
 Q3 4G
 Q4 3E
Ref. No. Address
 Q9 3A
Q10 4A
 D1 6I
 D2 6E
Ref. No. Address
 D3 3K
 D4 3C
 D5 2I
 D6 3H
Ref. No. Address
 D7 4D
 D8 4F
 D9 4H
 D10 4I
Ref. No. Address
 D11 3F
 D12 2E
KRC404RTK
KRC414RTK
2SA1745
2SA1832
2SC2412K
2SC3356
2SC4617
2SC4738
2SC5108
2SC5110
2SA1641
KTA1664
DTC363EU
KRA225S
KRC102S
2SC4649
2SC4919
TC7W74FU
MA742
2SK508NV
3SK255
2SJ243
2SK1824
M62363FP
KRX102U
PST9140NR
MB15A02
NJM78L05UA
TA75W01FU
LC73872M
NJM2902V
KIA7808AF
TK14489V
2SK3075
2SK3478-22
NJM2100V
NJM2904V
24LC08BT-ISN
784214AGC141
Ref. No. Address
 Q5 11H
 Q6 10E
 Q7 9H
 Q8 11F
Ref. No. Address
 Q1 11G
 Q2 10D
 Q3 9G
 Q4 11E
Ref. No. Address
 Q9 10A
Q10 10A
 D1 8I
 D2 8E
Ref. No. Address
 D3 11K
 D4 11C
 D5 12I
 D6 11H
Ref. No. Address
 D7 10D
 D8 10F
 D9 10H
 D10 10I
Ref. No. Address
 D11 11F
 D12 12E
DA221
2SK2596
LA4600

ABCD E F G H I J K L M N O P Q R S
1
2
3
4
5
6
7
8
9
10
11
12
13
14
J1
R262
C290 C307
R327
Q34
Q42
C823
R888 L803 C817
R822
R820
C804
C810 C809
R823
R808
R818
R826 R824
R825
D800
C815
C283
R811
R807
TH1
L802
B
C
E
Q38
D39
D41
IC101
C350 C295
C299
C328
R154
R265
E
E
SP
+B
CN5
+
C818
C821
C833
C820 Q101
C814
Q801
G
S
S
D
R813
C813
C811 C812
R809
R806
R814 TEMP1
RF
DC
C827
R815
R812 R819
8T
R805 R810
R827
D807
PC
IC800
1
45
8
L804
C831
TEMP2
D
G
SS
SS
C832
C853
C849
C842
C841
D801 D802
C837
TH3
TEMP3
C304
R258
C835
C279
8T
1
10
C262
C280
+
+
+
C308
C310 C298
C329
R255
Q30
D4
R833
R261
R286
R308
R264 C347
C345
C353
C117
C113
C218
C511
C513
Q32
Q35
IC19
1 45
8R5
L1
R114
R137
R136
R139
R143
R134
R335
Q2
D6
R55 C56 R51
R44
R38 R39
R37
R10
R11
R13
C36
C35
C123
C150
C135
D15
Q19
C89
C94
C87
C26
C119
C160
R164
R288
R103
R108
R133
R149
R78 R74 R77
R67
R64
R50
R102
R6
R163 TH5
L14
L17
L12
C27
C55
C25
R127
R140
R144
C524
C520
C173
1
23
R281 R280
R252
C854 C526Q33
IC17
O G
B C
E
I
C341
R834
R279
R4
R3
R2
R285
CN1
GND HOOK MIC LEDMON LEDC1 LEDR MICBL LEDC4 KMI1 KMI3 KMO1 PSB
PTT
ME
POWER
LEDPF
LEDC2
LEDG
LEDC3
CM
KMI2 KMI4
KMO2
D1
D3
D2
C12
R274
R135
R138
R176
R177
C284
C277
C355
C346 C512
C220
R322 R260
R328
R105
C522
R109 R229
IC9
R234
R273
1
7 8
14
C168
R118
R115
R122
POWER
C125
Q16
Q22 Q43
C521
R155
R128
RXD
TXD
DS
GDS
G
D
S
G
C808
+
R184 R271
R28
R20
R15
C338
C29
C37
C34
R23
L3
R60
R34
CV
C65 +
C60
C371
+
+
+
+
+
R56
R46
C332
IC1
C331
C330
C48
D7
Q5
Q4
1
1011
20 L2
X1
R12
R88
R72
C22
C81 C80
Q6
R326 R173
C114
C116 C112
C111
R111 C120
R113 R106
R7
BPF
C14
C342 C32
C40
C374
+
+
+
C156
R278
R277
R276
C351
C28
R22
D43
R313
IC3
1
12
13
24
C145
C88
C102 C335
C138
R287
R153
R132
AFV
R21 +
+
D44
R311
R87
R73
R307 R63
C71
D13
C31 C64
C377
C340
++
+
+
C61
C45 C44
C63
C59
C54
C52
C379
R53
R24 R49 R45
R48 R41
R43R47
R57
R52
R31 C51
C66
C62
R27
+
C518
C24
IC21
1
45
8
IC22
1
45
8
R59 R54
++
R19 R18
C352
C333
C53
R30
IC4
1
78
14
J72-0830-22
Q41
R310
R42
R33
C378
C30
C50
C58
R26
C826C825
C828 C829 (F2)
C829
(F1,F3)
TK-8102H PC BOARD VIEW
21 22
TX-RX UNIT (X57-6390-XX) -20 : K,M -21 : K2,M2 -22 : K3 Component side view (J72-0830-22)
Component side
Foil side
Layer 1
Layer 2
Layer 3
Layer 4
Ref. No. Address
 IC1 12J
 IC3 10N
 IC4 12P
 IC9 9E
 IC17 12B
 IC19 10D
 IC21 10P
 IC22 11P
IC101 10B
IC800 8J
 Q2 11I
 Q4 12H
 Q5 13H
 Q6 13K
 Q16 11F
 Q19 12N
 Q22 11F
 Q30 12C
 Q32 11D
 Q33 13C
 Q34 3D
 Q35 10D
 Q38 4D
 Q41 11O
 Q42 3E
 Q43 12F
 Q101 5K
 Q801 5G
 D1 13F
 D2 12F
 D3 13F
 D4 12D
 D6 12J
 D7 13I
 D13 12O
 D15 12O
 D39 4D
 D41 7C
 D43 11O
 D44 10O
 D800 8J
 D801 6P
 D802 6P
 D807 7K