Kenwood TK-8180 Operating manual

© 2004-10 PRINTED IN JAPAN
B51-8702-00 (N)907
UHF FM TRANSCEIVER
TK-8180
SERVICE MANUAL
Panel assy
(A62-1094-23)
Key top
(K29-9312-31)
Metallic cabinet
(A01-2194-11)
Microphone
(T91-0639-05)
GENERAL .......................................................... 2
PARTS LIST ....................................................... 4
EXPLODED VIEW............................................ 14
PACKING ......................................................... 15
ADJUSTMENT ................................................ 16
PC BOARD
DISPLAY UNIT (X54-3480-10) .................... 28
TX-RX UNIT (X57-6990-XX) (A/3, C/3)...... 30
CONTENTS
SUPPLEMENT
TX-RX UNIT (X57-6990-XX) (B/3) .............. 32
SCHEMATIC DIAGRAM
DISPLAY UNIT (X54-3480-10) .................... 36
TX-RX UNIT (X57-6990-XX) ....................... 38
INTERCONNECTION DIAGRAM .................... 47
BLOCK DIAGRAM ........................................... 48
LEVEL DIAGRAM ............................................ 50
SPECIFICATIONS ......................... BACK COVER
This TK-8180 service manual contains a number of
sections which differ from the service manual (B51-
8692-00) for the TK-8180.
For items other than those in this TK-8180 service
manual please refer to the service manual (B51-8692-
00) for the TK-8180.
Service Manual List
Title Part number Remarks Destination
TK-8180 B51-8692-00 K
TK-8180 B51-8702-00 (This service manual) SUPPLEMENT K2

TK-8180
2
INTRODUCTION
SCOPE OF THIS MANUAL
This manual is intended for use by experienced techni-
cians familiar with similar types of commercial grade commu-
nications equipment. It contains all required service informa-
tion for the equipment and is current as of this publication
date. Changes which may occur after publication are covered
by either Service Bulletins or Manual Revisions, which are
issued as required.
ORDERING REPLACEMENT PARTS
When ordering replacement parts or equipment informa-
tion, the full part identification number should be included.
This applies to all parts : components, kits, and chassis. If the
part number is not known, include the chassis or kit number
of which it is a part and a sufficient description of the required
component for proper identification.
PERSONAL SAFETY
The following precautions are recommended for personal
safety :
•DONOT transmit if someone is within two feet (0.6
meter) of the antenna.
•DONOT transmit until all RF connectors are secure and
any open connectors are properly terminated.
•SHUT OFF this equipment when near electrical blasting
caps or while in an explosive atmosphere.
•All equipment should be properly grounded before power-
up for safe operation.
•This equipment should be serviced by only qualified tech-
nicians.
PRE-INSTALLATION CONSIDERATIONS
1. UNPACKING
Unpack the radio from its shipping container and check for
accessory items. If any item is missing, please contact
KENWOOD immediately.
2. LICENSING REQUIREMENTS
Federal regulations require a station license for each radio
installation (mobile or base) be obtained by the equipment
owner. The licensee is responsible for ensuring transmitter
power, frequency, and deviation are within the limits permit-
ted by the station license.
Transmitter adjustments may be performed only by a li-
censed technician holding an FCC first, second or general
class commercial radiotelephone operator’s license. There is
no license required to install or operate the radio.
3. PRE-INSTALLATION CHECKOUT
3-1. Introduction
Each radio is adjusted and tested before shipment. How-
ever, it is recommended that receiver and transmitter opera-
tion be checked for proper operation before installation.
3-2. Testing
The radio should be tested complete with all cabling and
accessories as they will be connected in the final installation.
Transmitter frequency, deviation, and power output should
be checked, as should receiver sensitivity, squelch operation,
and audio output. Signalling equipment operation should be
verified.
4. PLANNING THE INSTALLATION
4-1. General
Inspect the vehicle and determine how and where the ra-
dio antenna and accessories will be mounted.
Plan cable runs for protection against pinching or crushing
wiring, and radio installation to prevent overheating.
4-2. Antenna
The favored location for an antenna is in the center of a
large, flat conductive area, usually at the roof center. The
trunk lid is preferred, bond the trunk lid and vehicle chassis
using ground straps to ensure the lid is at chassis ground.
4-3. Radio
The universal mount bracket allows the radio to be
mounted in a variety of ways. Be sure the mounting surface
is adequate to support the radio’s weight. Allow sufficient
space around the radio for air cooling. Position the radio close
enough to the vehicle operator to permit easy access to the
controls when driving.
4-4. DC Power and wiring
1. This radio may be installed in negative ground electrical
systems only. Reverse polarity will cause the cable fuse to
blow. Check the vehicle ground polarity before installation
to prevent wasted time and effort.
2. Connect the positive power lead directly to the vehicle
battery positive terminal. Connecting the Positive lead to
any other positive voltage source in the vehicle is not rec-
ommended.
3. Connect the ground lead directly to the battery negative
terminal.
4. The cable provided with the radio is sufficient to handle
the maximum radio current demand. If the cable must be
extended, be sure the additional wire is sufficient for the
current to be carried and length of the added lead.
GENERAL

TK-8180
3
GENERAL
Speaker
jack cap
D-sub
cap
Power input
connector
Ignition
sense cable
Antenna
connector
5. INSTALLATION PLANNING –CONTROL STATIONS
5-1. Antenna system
Control station. The antenna system selection depends on
many factors and is beyond the scope of this manual. Your
KENWOOD dealer can help you select an antenna system
that will best serve your particular needs.
5-2. Radio location
Select a convenient location for your control station radio
which is as close as practical to the antenna cable entry point.
Secondly, use your system’s power supply (which supplies
the voltage and current required for your system). Make sure
sufficient air can flow around the radio and power supply to
allow adequate cooling.
SERVICE
This radio is designed for easy servicing. Refer to the
schematic diagrams, printed circuit board views, and align-
ment procedures contained in this manual.
NOTE
•If you do not intend to use the speaker 3.5-mm jack and
the D-sub 25-pin connector, fit the supplied speaker-jack
cap and D-sub cap to stop dust and sand from getting in.
•If the transceiver is turned ON or OFF when the power-on/
off status message is enabled, the transceiver sends the
status.

TK-8180
4
PARTS LIST
✽New Parts. indicates safety critical components.
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert.
L: Scandinavia K:USA P:Canada
Y: PX (Far East, Hawaii) T:England E:Europe
Y:AAFES (Europe) X:Australia M:Other Areas
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
11BA01-2194-11 METALLIC CABINET
23AA62-1094-23 PANEL ASSY
42AB09-0681-03 CAP (KAP-2)
51DB62-1766-10 INSTRUCTION MANUAL
72BE04-0167-05 RF COAXIAL PECEPTACLE (M)
82BE30-7520-05 DC CORD (PIG TAIL)
92CE30-7523-05 DC CORD ASSY (WATER-PROOF)
10 2A E37-1110-05 FLAT CABLE (30P/D-SUB)
11 1A E37-1118-05
LEAD WIRE WITH CONNECTOR (SHORT CABLE)
12 2A E37-1120-05 FLAT CABLE (30P/TX-RX)
13 3B E37-1124-05
LEAD WIRE WITH CONNECTOR (2P/SP)
15 2B F10-2488-02 SHIELDING PLATE (CHASSIS)
16 1A F10-2489-03 SHIELDING CASE (FINAL)
17 1A F10-2490-03 SHIELDING CASE (VCO)
18 1C F52-0024-05 FUSE (BLADE TYPE) 15A/32V
20 3B G10-1342-04 FIBROUS SHEET (BIRITSUKI)
21 2A G11-4290-04 RUBBER SHEET (CHASSIS)
22 1B G11-4343-04 SHEET
23 1A G13-2018-04 CUSHION
24 2B G13-2047-04 CUSHION (DC SCREW)
25 1B G53-1613-01 PACKING (SHIELD PLATE)
26 3A G53-1614-23 PACKING (CHASSIS)
27 1A G53-1616-03 PACKING (PHONE JACK)
28 2B G53-1626-03 PACKING (D-SUB OUTER)
29 3B G53-1643-04 PACKING (DC CORD)
30 3B G53-1645-03 PACKING (D-SUB INNER)
31 2A G53-1662-04 PACKING (O RING)
32 2C H02-0624-03 INNER CARTON CASE
33 2D H12-3170-01 PACKING FIXTURE (LOWER)
34 1D H12-3171-03 PACKING FIXTURE (UPPER)
36 2D H25-2352-04 PROTECTION BAG (250/350/0.07)
37 3D H52-2069-02 ITEM CARTON CASE
39 1C J19-1584-05 HOLDER (ACCESSORY)
40 3B J19-5464-13 HOLDER (SP)
41 3B J19-5468-02 HOLDER (PANEL)
42 2B J21-8479-02 MOUNTING HARDWARE (D-SUB)
43 3B J21-8481-03 MOUNTING HARDWARE (SP)
44 2C J29-0662-03 BRACKET (ACCESSORY)
45 3B J30-1289-04 SPACER (SP)
47 3A ✽K29-9312-31 KEY TOP
A2BN09-2409-05 HEXAGON HEAD SCREW (D-SUB)
B1A,2A N67-3008-48 PAN HEAD SEMS SCREW (FINAL IC)
C
1A,2A,2B N87-2606-48 BRAZIER HEAD TAPTITE SCREW (ANT, PCB)
D1AN87-2608-46 BRAZIER HEAD TAPTITE SCREW (AUDIO IC)
49 2C N99-2039-05 SCREW SET (ACCESSORY)
51 3B T07-0757-05 SPEAKER
52 1C T91-0639-05 MICROPHONE (ACCESSORY)
54 2A W09-0971-05 LITHIUM CELL
101 3B B11-1825-04 FILTER (LCD)
102 3B B38-0888-05 LCD
D907 B30-2151-05 LED (R/G)
D909-920 B30-2281-05 LED (Y)
D921-930 B30-2282-05 LED (Y)
C904 CC73GCH1H101J CHIP C 100PF J
C906 CK73GB1H103K CHIP C 0.010UF K
C907,908 CK73HB1H102K CHIP C 1000PF K
C909-911 CC73GCH1H101J CHIP C 100PF J
C912,913 CK73GB1H102K CHIP C 1000PF K
C914 CC73GCH1H101J CHIP C 100PF J
C915 CK73GB1H102K CHIP C 1000PF K
C916,917 CK73GB1C104K CHIP C 0.10UF K
C918 C92-0628-05 CHIP-TAN 10UF 10WV
C920 CC73GCH1H101J CHIP C 100PF J
C921 CK73GB1H102K CHIP C 1000PF K
C922 CK73GB1H103K CHIP C 0.010UF K
C924,925 CC73GCH1H100D CHIP C 10PF D
C926-928 CK73GB1H102K CHIP C 1000PF K
C930 CK73GB1H103K CHIP C 0.010UF K
C931 C92-0784-05 CHIP-TAN 4.7UF 10WV
C932-934 CK73GB1H103K CHIP C 0.010UF K
C935 CK73GB1H471K CHIP C 470PF K
C936 CK73GB1C104K CHIP C 0.10UF K
C937 CK73GB1H103K CHIP C 0.010UF K
C938 CK73GB1H102K CHIP C 1000PF K
103 3B E29-1202-04 INTER CONNECTOR (LCD)
CN901 E40-5704-05 PIN ASSY
CN902 E40-6372-05 FLAT CABLE CONNECTOR
J901 3B E08-0877-05 MODULAR JACK
104 3B G11-4342-04 SHEET
105 3B J19-5467-03 HOLDER (LCD)
106 3B J21-8470-03 MOUNTING HARDWARE (LCD)
-J31-0551-05 COLLAR
L901,902 L40-1095-85 SMALL FIXED INDUCTOR (1.0UH)
L903-907 L92-0140-05 CHIP FERRITE
L908,909 L92-0163-05 BEADS CORE
X901 L77-1956-05 CRYSTAL RESONATOR (14.7456MHZ)
CP901-911 RK75HA1J101J CHIP-COM 100 J 1/16W
R901 RK73GB1J102J CHIP R 1.0K J 1/16W
R903 RK73GB1J471J CHIP R 470 J 1/16W
R904 RK73GB1J102J CHIP R 1.0K J 1/16W
R905 RK73GB1J472J CHIP R 4.7K J 1/16W
R907 RK73GB1J333J CHIP R 33K J 1/16W
R909-911 RK73GB1J473J CHIP R 47K J 1/16W
R913-916 RK73HB1J474J CHIP R 470K J 1/16W
R917 RK73FB2A471J CHIP R 470 J 1/10W
R918 RK73FB2A271J CHIP R 270 J 1/10W
R919 RK73HB1J102J CHIP R 1.0K J 1/16W
R920 R92-1368-05 CHIP R 0 OHM
R925 RK73HB1J471J CHIP R 470 J 1/16W
R926 RK73HB1J473J CHIP R 47K J 1/16W
TK-8180 DISPLAY UNIT (X54-3480-10)
TK-8180 (Y51-5030-XX)
DISPLAY UNIT (X54-3480-10)

TK-8180
5
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
R927-935 RK73HB1J102J CHIP R 1.0K J 1/16W
R936 RK73HB1J103J CHIP R 10K J 1/16W
R939 RK73GB1J472J CHIP R 4.7K J 1/16W
R940 RK73HB1J101J CHIP R 100 J 1/16W
R941 RK73HB1J102J CHIP R 1.0K J 1/16W
R942 RK73EB2B470J CHIP R 47 J 1/8W
R943 RK73EB2B101J CHIP R 100 J 1/8W
R944 R92-1368-05 CHIP R 0 OHM
R945 RK73GB1J103J CHIP R 10K J 1/16W
R947-950 RK73FB2A101J CHIP R 100 J 1/10W
R951,952 RK73FB2A391J CHIP R 390 J 1/10W
R953,954 RK73FB2A821J CHIP R 820 J 1/10W
R955-958 RK73HB1J472J CHIP R 4.7K J 1/16W
R959 RK73HB1J103J CHIP R 10K J 1/16W
R962,963 RK73GB1J103J CHIP R 10K J 1/16W
R967 RK73HB1J271J CHIP R 270 J 1/16W
R969 R92-1368-05 CHIP R 0 OHM
R970 RK73GB1J103J CHIP R 10K J 1/16W
R971 RK73HB1J102J CHIP R 1.0K J 1/16W
D901,902 02DZ18(X,Y) ZENER DIODE
D903 MINISMDC020 VARISTOR
D904-906 DA204U DIODE
IC901 TA78L05F MOS-IC
IC902 30302M8-8Z7GP MICROCONTROLLER IC
IC903 LC75810T-8726 MOS-IC
Q901,902 DTC144EE DIGITAL TRANSISTOR
Q904-906 DTC114EE DIGITAL TRANSISTOR
Q907 2SC2873(Y) TRANSISTOR
Q909,910 12A02CH TRANSISTOR
Q911 DTC114EE DIGITAL TRANSISTOR
Q913 DTC114EE DIGITAL TRANSISTOR
TH901 S1R103J440H THERMISTOR
C1 CK73GB1H102K CHIP C 1000PF K
C2-5 CC73GCH1H101J CHIP C 100PF J
C6 C92-0585-05 CHIP-TAN 4.7UF 16WV
C7,8 CC73GCH1H101J CHIP C 100PF J
C9 CC73GCH1H060D CHIP C 6.0PF D
C10 CC73GCH1H101J CHIP C 100PF J
C13-15 CC73GCH1H101J CHIP C 100PF J
C16 CC73GCH1H060D CHIP C 6.0PF D K
C16 CC73GCH1H080D CHIP C 8.0PF D K2
C17 CC73GCH1H220J CHIP C 22PF J
C18 CK73GB1H471K CHIP C 470PF K
C19 CC73GCH1H470J CHIP C 47PF J
C20 CC73GCH1H101J CHIP C 100PF J
C21 CK73FB1H471K CHIP C 470PF K
C22 CK73GB1H471K CHIP C 470PF K
C24 C92-0606-05 CHIP-TAN 4.7UF 10WV
C25 C93-0550-05 CHIP C 1.0PF C K
C25 C93-0552-05 CHIP C 2.0PF C K2
C26 CC73GCH1H220J CHIP C 22PF J
C27 CC73GCH1H470J CHIP C 47PF J
C28 CC73GCH1H101J CHIP C 100PF J
C29-31 CK73GB1H471K CHIP C 470PF K
C32 C92-0834-05 ELECTRO 47UF 25WV
C33-35 CC73GCH1H101J CHIP C 100PF J
C38-40 CC73GCH1H220J CHIP C 22PF J
C42 C93-0555-05 CHIP C 5.0PF C
C43 CC73FCH1H030C CHIP C 3.0PF C K
C43 CC73FCH1H050C CHIP C 5.0PF C K2
C44 C93-0573-05 CHIP C 120PF J
C45 C93-0552-05 CHIP C 2.0PF C K2
C45 C93-0553-05 CHIP C 3.0PF C K
C47 CC73GCH1H0R5B CHIP C 0.5PF B
C48 CC73GCH1H020B CHIP C 2.0PF B K2
C48 CC73GCH1H030B CHIP C 3.0PF B K
C49 CC73GCH1H101J CHIP C 100PF J
C50 C93-0557-05 CHIP C 7.0PF D K2
C50 C93-0558-05 CHIP C 8.0PF D K
C51 CC73GCH1H101J CHIP C 100PF J
C52 CC73GCH1H0R5B CHIP C 0.5PF B
C53 C93-0559-05 CHIP C 9.0PF D K2
C53 C93-0560-05 CHIP C 10PF D K
C54 C93-0554-05 CHIP C 4.0PF C K2
C55 CC73GCH1H020B CHIP C 2.0PF B
C56 CC73GCH1H101J CHIP C 100PF J
C57 CC73GCH1H0R5B CHIP C 0.5PF B
C58 CC73GCH1H020B CHIP C 2.0PF B
C59 CC73GCH1H101J CHIP C 100PF J
C60 C93-0556-05 CHIP C 6.0PF D K
C60 C93-0558-05 CHIP C 8.0PF D K2
C61,62 CC73GCH1H101J CHIP C 100PF J
C63 CC73GCH1H050C CHIP C 5.0PF C K2
C64 CC73GCH1H080D CHIP C 8.0PF D K2
C65 CC73GCH1H060D CHIP C 6.0PF D K2
C74 CC73GCH1H101J CHIP C 100PF J
C76,77 CK73GB1H471K CHIP C 470PF K
C79,80 CK73GB1H471K CHIP C 470PF K
C83 C93-0554-05 CHIP C 4.0PF C K2
C119 CC73GCH1H050B CHIP C 5.0PF B K
C119 CC73GCH1H100D CHIP C 10PF D K2
C121 CK73GB1H471K CHIP C 470PF K
C124 CC73GCH1H060B CHIP C 6.0PF B K2
C124 CC73GCH1H100D CHIP C 10PF D K
C125 CK73GB1H471K CHIP C 470PF K
C127 CC73GCH1H220J CHIP C 22PF J K
C127 CC73GCH1H270J CHIP C 27PF J K2
C128 CC73GCH1H070B CHIP C 7.0PF B K2
C128 CC73GCH1H090B CHIP C 9.0PF B K
C129 CK73GB1H471K CHIP C 470PF K
C130 CC73GCH1H050B CHIP C 5.0PF B
C131 CK73GB1H471K CHIP C 470PF K
C132 CC73GCH1H220J CHIP C 22PF J K
C132 CC73GCH1H270J CHIP C 27PF J K2
C133 CC73GCH1H060B CHIP C 6.0PF B K
C133 CC73GCH1H070B CHIP C 7.0PF B K2
C134 CC73GCH1H030B CHIP C 3.0PF B
C135 CC73GCH1H220J CHIP C 22PF J K
C135 CC73GCH1H270J CHIP C 27PF J K2
C136 CC73GCH1H040B CHIP C 4.0PF B K
C136 CC73GCH1H060B CHIP C 6.0PF B K2
C137 CK73GB1H471K CHIP C 470PF K
C138 CC73GCH1H050B CHIP C 5.0PF B
C139 CK73GB1H471K CHIP C 470PF K
C140 CC73GCH1H220J CHIP C 22PF J K
C140 CC73GCH1H270J CHIP C 27PF J K2
C141 CC73GCH1H090B CHIP C 9.0PF B K
TX-RX UNIT (X57-6990-XX) -10 : K -11 : K2
DISPLAY UNIT (X54-3480-10)
TX-RX UNIT (X57-6990-XX)

TK-8180
6
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
C141 CC73GCH1H100D CHIP C 10PF D K2
C142 CK73GB1H471K CHIP C 470PF K
C143 CK73GB1H103K CHIP C 0.010UF K
C144 CC73GCH1H070B CHIP C 7.0PF B K
C144 CC73GCH1H080B CHIP C 8.0PF B K2
C145 CC73GCH1H020B CHIP C 2.0PF B K2
C145 CC73GCH1H1R5B CHIP C 1.5PF B K
C146 CK73GB1H471K CHIP C 470PF K
C147 CC73GCH1H050B CHIP C 5.0PF B K
C147 CC73GCH1H080B CHIP C 8.0PF B K2
C148 CC73GCH1H010B CHIP C 1.0PF B
C149 CK73GB1H471K CHIP C 470PF K
C150 CC73GCH1H050B CHIP C 5.0PF B K
C150 CC73GCH1H080B CHIP C 8.0PF B K2
C151 CC73GCH1H010B CHIP C 1.0PF B
C152 CK73GB1H471K CHIP C 470PF K
C153 CC73GCH1H050B CHIP C 5.0PF B K
C153 CC73GCH1H080B CHIP C 8.0PF B K2
C154 CC73GCH1H020B CHIP C 2.0PF B K2
C154 CC73GCH1H1R5B CHIP C 1.5PF B K
C155,156 CK73GB1H471K CHIP C 470PF K
C171 CC73GCH1H060B CHIP C 6.0PF B K
C171 CC73GCH1H100D CHIP C 10PF D K2
C173 CC73GCH1H120J CHIP C 12PF J K
C173 CC73GCH1H180J CHIP C 18PF J K2
C175 CC73GCH1H060B CHIP C 6.0PF B K
C175 CC73GCH1H100D CHIP C 10PF D K2
C176-178 CK73GB1H471K CHIP C 470PF K
C181 CK73GB1H471K CHIP C 470PF K
C182,183 CK73GB1H103K CHIP C 0.010UF K
C184 CK73GB1H471K CHIP C 470PF K
C185 CK73GB1H103K CHIP C 0.010UF K
C186 CC73GCH1H330J CHIP C 33PF J
C187 CC73GCH1H390J CHIP C 39PF J
C188,189 CC73GCH1H040B CHIP C 4.0PF B
C190 CC73GCH1H390J CHIP C 39PF J
C192-194 CK73GB1H103K CHIP C 0.010UF K
C195 CK73GB1H471K CHIP C 470PF K
C196,197 CK73GB1H103K CHIP C 0.010UF K
C198 CC73GCH1H680J CHIP C 68PF J
C199 CC73GCH1H390J CHIP C 39PF J
C200,201 CC73GCH1H040B CHIP C 4.0PF B
C202 CC73GCH1H390J CHIP C 39PF J
C204-206 CK73GB1H103K CHIP C 0.010UF K
C207 CK73GB1H471K CHIP C 470PF K
C208,209 CK73GB1H103K CHIP C 0.010UF K
C210 CC73GCH1H680J CHIP C 68PF J
C211 CC73GCH1H100D CHIP C 10PF D
C212 CK73GB1H471K CHIP C 470PF K
C213 CK73GB1H103K CHIP C 0.010UF K
C214 CK73GB1C104K CHIP C 0.10UF K
C215 CC73GCH1H180J CHIP C 18PF J
C216 CC73GCH1H150J CHIP C 15PF J
C217 CK73GB1H102K CHIP C 1000PF K
C218 CK73GB1H103K CHIP C 0.010UF K
C219 CK73FB1C105K CHIP C 1.0UF K
C220,221 CK73GB1C104K CHIP C 0.10UF K
C222 CK73GB1H102K CHIP C 1000PF K
C223 CK73GB1C104K CHIP C 0.10UF K
C224,225 CC73GCH1H271J CHIP C 270PF J
C226,227 CK73GB1H102K CHIP C 1000PF K
C228 CK73GB1C104K CHIP C 0.10UF K
C229 CK73GB1C333K CHIP C 0.033UF K
C230 CK73GB1H103K CHIP C 0.010UF K
C231 CC73GCH1H820J CHIP C 82PF J
C232,233 CK73GB1H102K CHIP C 1000PF K
C234 CK73FB1C224K CHIP C 0.22UF K
C235 CK73GB1C104K CHIP C 0.10UF K
C236 CK73GB1H103K CHIP C 0.010UF K
C237 C92-0712-05 CHIP-TAN 22UF 6.3WV
C238 CK73GB1H103K CHIP C 0.010UF K
C239,240 CK73GB1C104K CHIP C 0.10UF K
C241 CK73GB1H102K CHIP C 1000PF K
C251,252 CK73GB1H471K CHIP C 470PF K
C253 CK73GB1H103K CHIP C 0.010UF K
C255 C92-0694-05 CHIP-TAN 10UF 16WV
C256 CK73GB1H103K CHIP C 0.010UF K
C257 C92-0519-05 CHIP-TAN 1.0UF 25WV
C258 C92-0516-05 CHIP-TAN 4.7UF 16WV
C259 C92-0628-05 CHIP-TAN 10UF 10WV
C260-262 CC73GCH1H101J CHIP C 100PF J
C299 CC73GCH1H0R5B CHIP C 0.5PF B
C302 CC73GCH1H0R5B CHIP C 0.5PF B K
C302 CC73GCH1H1R5B CHIP C 1.5PF B K2
C306 CC73GCH1H100D CHIP C 10PF D
C307 CK73GB1H471K CHIP C 470PF K
C308 CC73GCH1H100D CHIP C 10PF D K
C308,309 CC73GCH1H101J CHIP C 100PF J K2
C309 CC73GCH1H101J CHIP C 100PF J K
C311 CC73GCH1H101J CHIP C 100PF J K2
C311 CC73GCH1H390J CHIP C 39PF J K
C312 C92-0555-05 CHIP-TAN 0.047UF 35WV
C314 CK73FB1E104K CHIP C 0.10UF K
C316 CC73GCH1H080D CHIP C 8.0PF D K
C316,317 CC73GCH1H101J CHIP C 100PF J K2
C317 CC73GCH1H101J CHIP C 100PF J K
C318 C92-0657-05 CHIP-TAN 2.2UF 20WV
C320 C92-0657-05 CHIP-TAN 2.2UF 20WV
C322 CK73GB1E473J CHIP C 0.047UF J K
C322,323 CK73GB1H471K CHIP C 470PF K K2
C323 CK73GB1H471K CHIP C 470PF K K
C324 CK73GB1C104K CHIP C 0.10UF K
C325 CK73GB1H102K CHIP C 1000PF K
C327 CK73FB1E224K CHIP C 0.22UF K
C331 CK73GB1H103K CHIP C 0.010UF K
C333 CC73GCH1H040B CHIP C 4.0PF B K2
C333 CC73GCH1H050B CHIP C 5.0PF B K
C334 CK73GB1H102K CHIP C 1000PF K
C335 CK73GB1C223K CHIP C 0.022UF K
C338 C92-0502-05 CHIP-TAN 0.33UF 35WV
C339 CK73GB1H471K CHIP C 470PF K
C342 CK73GB1H102K CHIP C 1000PF K
C343 C92-0628-05 CHIP-TAN 10UF 10WV
C346,347 CC73GCH1H220G CHIP C 22PF G K
C346,347 CC73GCH1H390J CHIP C 39PF J K2
C350 CC73GCH1H080D CHIP C 8.0PF D K
C350 CC73GCH1H110J CHIP C 11PF J K2
C351 CC73GCH1H0R5B CHIP C 0.5PF B K
C351 CC73GCH1H1R5B CHIP C 1.5PF B K2
C352 CC73GCH1H120J CHIP C 12PF J
TX-RX UNIT (X57-6990-XX)

TK-8180
7
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
C353 CC73GCH1H471J CHIP C 470PF J
C354 CC73GCH1H040B CHIP C 4.0PF B K
C354,355 CC73GCH1H050B CHIP C 5.0PF B K2
C355 CC73GCH1H050B CHIP C 5.0PF B K
C356 CC73GCH1H0R5B CHIP C 0.5PF B
C357 CC73GCH1H060B CHIP C 6.0PF B K
C357,358 CC73GCH1H060B CHIP C 6.0PF B K2
C358 CC73GCH1H050B CHIP C 5.0PF B K
C359,360 CC73GCH1H070B CHIP C 7.0PF B
C361-363 CC73GCH1H471J CHIP C 470PF J
C364 CC73GCH1H0R5B CHIP C 0.5PF B K
C364,365 CC73GCH1H0R5B CHIP C 0.5PF B K2
C365 CC73GCH1H0R3B CHIP C 0.3PF B K
C367 CK73GB1H102K CHIP C 1000PF K
C368 CC73GCH1H471J CHIP C 470PF J
C369,370 CK73GB1H471K CHIP C 470PF K
C371 C92-0560-05 CHIP-TAN 10UF 6.3WV
C372 CC73GCH1H180J CHIP C 18PF J K2
C372 CC73GCH1H220J CHIP C 22PF J K
C373 CC73GCH1H471J CHIP C 470PF J
C374 CK73GB1H102K CHIP C 1000PF K
C375 CC73GCH1H120J CHIP C 12PF J K2
C375 CC73GCH1H270J CHIP C 27PF J K
C376-378 CK73GB1H471K CHIP C 470PF K
C379 CC73GCH1H050C CHIP C 5.0PF C K2
C379 CC73GCH1H060D CHIP C 6.0PF D K
C380,381 CK73GB1H471K CHIP C 470PF K
C382 CK73GB1H103K CHIP C 0.010UF K
C383 CK73GB1H102K CHIP C 1000PF K
C384 CK73GB1H103K CHIP C 0.010UF K
C385 CK73GB1H471K CHIP C 470PF K
C386 C92-0713-05 CHIP-TAN 10UF 6.3WV
C387,388 CC73GCH1H050C CHIP C 5.0PF C K
C387,388 CC73GCH1H080D CHIP C 8.0PF D K2
C389 CC73GCH1H020B CHIP C 2.0PF B K2
C389 CC73GCH1H060B CHIP C 6.0PF B K
C390 CC73GCH1H080B CHIP C 8.0PF B K2
C390 CC73GCH1H120J CHIP C 12PF J K
C391 CC73GCH1H020B CHIP C 2.0PF B K
C391 CC73GCH1H1R5B CHIP C 1.5PF B K2
C392 CC73GCH1H120J CHIP C 12PF J K
C392 CC73GCH1H220J CHIP C 22PF J K2
C393 CC73GCH1H050B CHIP C 5.0PF B K2
C393 CC73GCH1H060B CHIP C 6.0PF B K
C394 CC73GCH1H020B CHIP C 2.0PF B K2
C394 CC73GCH1H040B CHIP C 4.0PF B K
C395 CC73GCH1H020B CHIP C 2.0PF B K
C395 CC73GCH1H2R5B CHIP C 2.5PF B K2
C396 CK73GB1H103K CHIP C 0.010UF K
C397 CC73GCH1H120J CHIP C 12PF J
C398 CC73GCH1H010B CHIP C 1.0PF B K
C398 CC73GCH1H070B CHIP C 7.0PF B K2
C400 CK73FB1A105K CHIP C 1.0UF K
C403 CK73HB1A104K CHIP C 0.10UF K
C404 CC73HCH1H050C CHIP C 5.0PF C
C406 CC73GCH1H0R3B CHIP C 0.3PF B
C407 CK73GB1H103K CHIP C 0.010UF K
C408,409 CC73HCH1H150G CHIP C 15PF G
C410-412 CK73GB1C104K CHIP C 0.10UF K
C420,421 CC73GCH1H101J CHIP C 100PF J
C422 CK73GB1H102K CHIP C 1000PF K
C423 CK73FF1C105Z CHIP C 1.0UF Z
C424 CK73GB1H102K CHIP C 1000PF K
C425-428 CC73GCH1H101J CHIP C 100PF J
C429 CK73GB1A105K CHIP C 1.0UF K
C430,431 CC73GCH1H101J CHIP C 100PF J
C432 CK73GB1H102K CHIP C 1000PF K
C433 CK73GB1C104K CHIP C 0.10UF K
C434 CK73GB1H561K CHIP C 560PF K
C435 CK73GB1H102K CHIP C 1000PF K
C436,437 CC73GCH1H101J CHIP C 100PF J
C438 CK73GB1E103K CHIP C 0.010UF K
C439 CK73GB1H102K CHIP C 1000PF K
C440 CK73GB1C104K CHIP C 0.10UF K
C441 CK73FB0J106K CHIP C 10UF K
C442 CK73GB1C104K CHIP C 0.10UF K
C443 CK73GB1H103K CHIP C 0.010UF K
C444 CC73GCH1H390J CHIP C 39PF J
C445 CC73GCH1H150J CHIP C 15PF J
C446 CK73GB1H103K CHIP C 0.010UF K
C447 CK73HB1A333K CHIP C 0.033UF K
C448 CC73GCH1H101J CHIP C 100PF J
C450 CK73FB0J106K CHIP C 10UF K
C451 CK73GB1H103K CHIP C 0.010UF K
C452 CC73GCH1H101J CHIP C 100PF J
C453 CK73GB1C104K CHIP C 0.10UF K
C454 CK73GB1H103K CHIP C 0.010UF K
C455 C92-0589-05 CHIP-TAN 47UF 6.3WV
C457 CK73GB1H471K CHIP C 470PF K
C459 C92-0628-05 CHIP-TAN 10UF 10WV
C460-463 CK73GB1H103K CHIP C 0.010UF K
C464 CK73HB1A333K CHIP C 0.033UF K
C465 CC73GCH1H220J CHIP C 22PF J
C467,468 CK73GB1H103K CHIP C 0.010UF K
C469 CK73GB1C104K CHIP C 0.10UF K
C470 CK73GB1H103K CHIP C 0.010UF K
C472 CK73GB1C104K CHIP C 0.10UF K
C475 CC73GCH1H101J CHIP C 100PF J
C476 CK73GB1C104K CHIP C 0.10UF K
C477 CK73GB1H102K CHIP C 1000PF K
C478 CC73HCH1H101J CHIP C 100PF J
C479,480 CK73GB1H102K CHIP C 1000PF K
C481 CK73HB1H102K CHIP C 1000PF K
C482 CK73FB1A475K CHIP C 4.7UF K
C483 CK73GB1H103K CHIP C 0.010UF K
C484 CK73FB1A475K CHIP C 4.7UF K
C485 CK73FB1A105K CHIP C 1.0UF K
C487 CK73HB1H102K CHIP C 1000PF K
C488 CC73GCH1H120J CHIP C 12PF J
C489 CK73GB1C104K CHIP C 0.10UF K
C490 CK73HB1H102K CHIP C 1000PF K
C491,492 CK73GB1C104K CHIP C 0.10UF K
C493 CK73FB1A475K CHIP C 4.7UF K
C495 CC73GCH1H181J CHIP C 180PF J
C496 CK73GB1C104K CHIP C 0.10UF K
C497 CK73GB1H102K CHIP C 1000PF K
C498 CC73HCH1H101J CHIP C 100PF J
C499 CK73GB1H821K CHIP C 820PF K
C500 CC73HCH1H101J CHIP C 100PF J
C501 CC73GCH1H220J CHIP C 22PF J
TX-RX UNIT (X57-6990-XX)

TK-8180
8
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
C502 CK73HB1H102K CHIP C 1000PF K
C503 CC73GCH1H680J CHIP C 68PF J
C504 CK73HB1H102K CHIP C 1000PF K
C505,506 CK73GB1A105K CHIP C 1.0UF K
C507 CK73GB1C104K CHIP C 0.10UF K
C511 CK73GB1C104K CHIP C 0.10UF K
C512,513 CK73GB1H102K CHIP C 1000PF K
C514 CC73GCH1H820J CHIP C 82PF J
C515,516 CK73HB1H102K CHIP C 1000PF K
C517 CK73GB1H103K CHIP C 0.010UF K
C518 CK73GB1C104K CHIP C 0.10UF K
C519,520 CK73GB1H102K CHIP C 1000PF K
C524 CK73GB1H102K CHIP C 1000PF K
C525,526 CK73GB1C104K CHIP C 0.10UF K
C528 CK73GB1H222K CHIP C 2200PF K
C529 CC73GCH1H470J CHIP C 47PF J
C530 CK73FB0J106K CHIP C 10UF K
C531 CK73GB1H102K CHIP C 1000PF K
C532 CK73GB1E123K CHIP C 0.012UF K
C533 CK73GB1E153K CHIP C 0.015UF K
C534 CK73GB1H102K CHIP C 1000PF K
C535 CK73GB1C683K CHIP C 0.068UF K
C536,537 CK73GB1C104K CHIP C 0.10UF K
C538 CK73GB1H102K CHIP C 1000PF K
C539,540 C92-0628-05 CHIP-TAN 10UF 10WV
C541 CK73GB1C104K CHIP C 0.10UF K
C542 CK73GB1H102K CHIP C 1000PF K
C543,544 C92-0628-05 CHIP-TAN 10UF 10WV
C545 CK73HB1H102K CHIP C 1000PF K
C546 CK73GB1H103K CHIP C 0.010UF K
C547-549 CK73HB1H102K CHIP C 1000PF K
C550 CC73HCH1H101J CHIP C 100PF J
C551-553 CK73HB1H102K CHIP C 1000PF K
C554 CC73HCH1H101J CHIP C 100PF J
C555-557 CK73HB1H102K CHIP C 1000PF K
C558 CC73HCH1H101J CHIP C 100PF J
C559 CK73HB1H102K CHIP C 1000PF K
C560,561 CK73GB1C104K CHIP C 0.10UF K
C562-565 C92-0519-05 CHIP-TAN 1.0UF 25WV
C566 CK73FB1C105K CHIP C 1.0UF K
C567 CC73HCH1H101J CHIP C 100PF J
C568 CK73HB1H102K CHIP C 1000PF K
C570 CK73FB1C105K CHIP C 1.0UF K
C572,573 CK73GB1H102K CHIP C 1000PF K
C574 C92-0672-05 ELECTRO 22UF 16WV
C575 C92-0834-05 ELECTRO 47UF 25WV
C576 C92-0836-05 ELECTRO 330UF 16WV
C577 CK73GB1C104K CHIP C 0.10UF K
C578 C92-0834-05 ELECTRO 47UF 25WV
C579 CK73GB1H102K CHIP C 1000PF K
C580 C92-0834-05 ELECTRO 47UF 25WV
C581,582 CK73GB1H102K CHIP C 1000PF K
C583 CK73GB1H471K CHIP C 470PF K
C584 CC73GCH1H220J CHIP C 22PF J
C585-587 CC73GCH1H101J CHIP C 100PF J
C588 CK73GB1H102K CHIP C 1000PF K
C591 CK73GB1C104K CHIP C 0.10UF K
C592,593 CC73GCH1H070D CHIP C 7.0PF D
C594 CK73GB1H471K CHIP C 470PF K
C595 CC73GCH1H101J CHIP C 100PF J
C701 CK73GB1H102K CHIP C 1000PF K
C702-704 CC73GCH1H101J CHIP C 100PF J
C705-711 CK73GB1H102K CHIP C 1000PF K
C712 CC73GCH1H101J CHIP C 100PF J
C713 CK73GB1H102K CHIP C 1000PF K
C714,715 CC73GCH1H101J CHIP C 100PF J
C716,717 CK73GB1H102K CHIP C 1000PF K
C718-720 CC73GCH1H101J CHIP C 100PF J
C721 CK73GB1H102K CHIP C 1000PF K
C722,723 CC73GCH1H101J CHIP C 100PF J
C801 C92-0777-05 ELECTRO 1000UF 25WV
C802 CK73GB1H102K CHIP C 1000PF K
C803 CK73GB1E473J CHIP C 0.047UF J
C804 CC73GCH1H471J CHIP C 470PF J
C805 CK73GB1H102K CHIP C 1000PF K
C806 CC73GCH1H101J CHIP C 100PF J
C807 CK73GB1E473J CHIP C 0.047UF J
C808 CK73GB1C104K CHIP C 0.10UF K
C809 CC73GCH1H471J CHIP C 470PF J
C810 CK73GB1E473J CHIP C 0.047UF J
C811,812 CK73GB1C104K CHIP C 0.10UF K
C813,814 CC73GCH1H471J CHIP C 470PF J
C815 C92-0585-05 CHIP-TAN 4.7UF 16WV
C816 C92-0628-05 CHIP-TAN 10UF 10WV
C817 CC73GCH1H471J CHIP C 470PF J
C818 CK73GB1H472K CHIP C 4700PF K
C819,820 CK73GB1C104K CHIP C 0.10UF K
C821 C92-0585-05 CHIP-TAN 4.7UF 16WV
C822 CC73GCH1H471J CHIP C 470PF J
C823 CK73GB1H102K CHIP C 1000PF K
C824 CK73GB1H103K CHIP C 0.010UF K
C825 CK73HB1H102K CHIP C 1000PF K
C826 CK73GB1H471K CHIP C 470PF K
C831,832 C92-0585-05 CHIP-TAN 4.7UF 16WV
TC301,302 C05-0396-05 CERAMIC TRIMMER CAPACITOR (8PF)
CN1-3 E23-1081-05 TERMINAL
CN13 E23-1081-05 TERMINAL
CN100-102 E23-1081-05 TERMINAL
CN202,203 E23-1081-05 TERMINAL
CN301,302 E40-6404-05 PIN ASSY
CN322,323 E23-1081-05 TERMINAL
CN326 E23-1081-05 TERMINAL
CN329 E23-1081-05 TERMINAL
CN403 E40-6361-05 PIN ASSY
CN427 E40-6371-05 FLAT CABLE CONNECTOR
CN428 E40-6373-05 PIN ASSY
CN429 E40-6412-05 FLAT CABLE CONNECTOR
CN701 E40-6371-05 FLAT CABLE CONNECTOR
CN802,803 E23-1260-04 TERMINAL
CN804 E40-3246-05 PIN ASSY
CN815 E23-1081-05 TERMINAL
J401 E11-0425-05 3.5D PHONE JACK (3P)
J701 E58-0494-05 SUB SOCKET (D)
F401 F53-0352-05 FUSE (2A)
F801 F53-0278-05 FUSE (5A)
CN401 J19-5386-05 HOLDER
CD171 L79-1701-05 TUNING COIL
CF171 L72-0376-05 CERAMIC FILTER
TX-RX UNIT (X57-6990-XX)

TK-8180
9
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
CF172 L72-0998-05 CERAMIC FILTER
L1 L40-1875-92 SMALL FIXED INDUCTOR (18NH)
L2 L92-0140-05 CHIP FERRITE
L3 L40-2275-92 SMALL FIXED INDUCTOR (22NH)
L4 L92-0140-05 CHIP FERRITE
L5,6 L92-0179-05 CHIP FERRITE
L7 L34-4638-05 AIR-CORE COIL
L8 L34-4758-05 AIR-CORE COIL
L9,10 L34-4743-05 AIR-CORE COIL
L12 L34-4743-05 AIR-CORE COIL
L13 L34-4482-05 AIR-CORE COIL
L14 L40-4763-92 SMALL FIXED INDUCTOR (4.7NH) K2
L101 L41-1078-14 SMALL FIXED INDUCTOR K2
L101 L41-8268-14 SMALL FIXED INDUCTOR K
L108 L92-0140-05 CHIP FERRITE
L109 L41-1278-14 SMALL FIXED INDUCTOR K2
L109 L41-1878-14 SMALL FIXED INDUCTOR K
L110-113 L34-4565-05 AIR-CORE COIL K
L110-113 L34-4566-05 AIR-CORE COIL K2
L114-117 L41-1078-14 SMALL FIXED INDUCTOR K2
L114-117 L41-8268-14 SMALL FIXED INDUCTOR K
L119 L41-2263-14 SMALL FIXED INDUCTOR K2
L119 L41-3378-14 SMALL FIXED INDUCTOR K
L171,172 L41-1578-14 SMALL FIXED INDUCTOR K
L171,172 L41-1878-14 SMALL FIXED INDUCTOR K2
L173,174 L39-1421-05 TOROIDAL COIL
L175 L92-0140-05 CHIP FERRITE
L176 L39-1421-05 TOROIDAL COIL
L177 L41-2785-14 SMALL FIXED INDUCTOR
L178,179 L41-3988-14 SMALL FIXED INDUCTOR
L180 L40-6875-92 SMALL FIXED INDUCTOR (68NH)
L181 L40-1001-86 SMALL FIXED INDUCTOR (10UH)
L182 L40-1085-92 SMALL FIXED INDUCTOR (100NH)
L183,184 L41-3988-14 SMALL FIXED INDUCTOR
L185 L40-6875-92 SMALL FIXED INDUCTOR (68NH)
L186 L40-1001-86 SMALL FIXED INDUCTOR (10UH)
L187 L40-1085-92 SMALL FIXED INDUCTOR (100NH)
L188 L40-8281-86 SMALL FIXED INDUCTOR (0.82UH)
L189 L40-1091-86 SMALL FIXED INDUCTOR (1.0UH)
L251 L33-1468-05 SMALL FIXED INDUCTOR
L301 L40-2295-85 SMALL FIXED INDUCTOR (2.2UH)
L302 L92-0140-05 CHIP FERRITE
L304-306 L92-0140-05 CHIP FERRITE
L309,310 L40-1095-85 SMALL FIXED INDUCTOR (1.0UH)
L311,312 L41-1098-08 SMALL FIXED INDUCTOR
L314 L34-4607-05 AIR-CORE COIL K
L314 L34-4608-05 AIR-CORE COIL K2
L315-317 L41-1098-08 SMALL FIXED INDUCTOR
L318 L40-2775-92 SMALL FIXED INDUCTOR (27NH) K2
L318,319 L40-2275-92 SMALL FIXED INDUCTOR (22NH) K
L319 L40-3375-92 SMALL FIXED INDUCTOR (33NH) K2
L320 L40-1075-92 SMALL FIXED INDUCTOR (10NH) K
L320,321 L40-1575-92 SMALL FIXED INDUCTOR (15NH) K2
L321 L40-8265-92 SMALL FIXED INDUCTOR (8.2NH) K
L322 L41-5668-14 SMALL FIXED INDUCTOR K
L322,323 L41-5668-14 SMALL FIXED INDUCTOR K2
L323 L41-4763-14 SMALL FIXED INDUCTOR K
L324 L41-2263-14 SMALL FIXED INDUCTOR K
L324 L41-3363-14 SMALL FIXED INDUCTOR K2
L325 L34-4605-05 AIR-CORE COIL K
L325 L34-4645-05 AIR-CORE COIL K2
L326 L41-1098-08 SMALL FIXED INDUCTOR K
L326 L41-4785-08 SMALL FIXED INDUCTOR K2
L327 L40-3375-92 SMALL FIXED INDUCTOR (33NH) K
L327,328 L40-1875-92 SMALL FIXED INDUCTOR (18NH) K2
L328 L40-2275-92 SMALL FIXED INDUCTOR (22NH) K
L401,402 L92-0138-05 CHIP FERRITE
L403-407 L92-0140-05 CHIP FERRITE
L408 L92-0138-05 CHIP FERRITE
L409 L92-0140-05 CHIP FERRITE
L410,411 L92-0179-05 CHIP FERRITE
L701,702 L92-0140-05 CHIP FERRITE
X171 L77-1762-05 CRYSTAL RESONATOR (44.395MHZ)
X301 L77-1952-05 TCXO (16.8MHZ)
X401 L77-1802-05 CRYSTAL RESONATOR (32768HZ)
X403 L77-1965-05 CRYSTAL RESONATOR (3.6864MHZ)
X404 L77-1950-05 CRYSTAL RESONATOR (11.0592MHZ)
XF171 L71-0618-05 MCF (44.85M)
CP401 R90-0740-05 MULTIPLE RESISTOR
CP402-417 RK75HA1J102J CHIP-COM 1.0K J 1/16W
R1 RK73GB1J821J CHIP R 820 J 1/16W
R2 RK73GB1J5R6J CHIP R 5.6 J 1/16W
R3 RK73GB1J821J CHIP R 820 J 1/16W
R4 RK73GB1J333J CHIP R 33K J 1/16W
R5 RK73GB1J682J CHIP R 6.8K J 1/16W
R6 RK73GB1J221J CHIP R 220 J 1/16W
R7 RK73GB1J100J CHIP R 10 J 1/16W
R8 RK73GB1J471J CHIP R 470 J 1/16W
R9 RK73GB1J220J CHIP R 22 J 1/16W
R10 RK73GB1J561J CHIP R 560 J 1/16W
R11 RK73GB1J272J CHIP R 2.7K J 1/16W
R12 RK73GB1J100J CHIP R 10 J 1/16W
R13 RK73GB1J331J CHIP R 330 J 1/16W
R14 R92-1252-05 CHIP R 0 OHM J 1/16W
R15 RK73FB2A221J CHIP R 220 J 1/10W
R16,17 RK73FB2A470J CHIP R 47 J 1/10W
R18 RK73FB2A221J CHIP R 220 J 1/10W
R19 RK73GB1J151J CHIP R 150 J 1/16W
R21 RK73GB1J331J CHIP R 330 J 1/16W K
R21 RK73GB1J471J CHIP R 470 J 1/16W K2
R22 RK73GB1J102J CHIP R 1.0K J 1/16W
R23 RK73GB1J682J CHIP R 6.8K J 1/16W
R24 RK73GB1J104J CHIP R 100K J 1/16W
R25 R92-1261-05 CHIP R 150 J 1/2W
R26 RK73GB1J103J CHIP R 10K J 1/16W K
R26 RK73GB1J822J CHIP R 8.2K J 1/16W K2
R27 RK73GB1J104J CHIP R 100K J 1/16W
R28 R92-1252-05 CHIP R 0 OHM J 1/16W K
R29 RK73GB1J104J CHIP R 100K J 1/16W K2
R29 RK73GB1J823J CHIP R 82K J 1/16W K
R30 R92-1061-05
JUMPER REST 0 OHM
R31 RK73GB1J332J CHIP R 3.3K J 1/16W
R33 R92-1252-05 CHIP R 0 OHM J 1/16W
R38 R92-1252-05 CHIP R 0 OHM J 1/16W
R71 RK73GB1J563J CHIP R 56K J 1/16W
R72 RK73GB1J333J CHIP R 33K J 1/16W
R75 RK73GB1J473J CHIP R 47K J 1/16W
R76-78 RK73GB1J104J CHIP R 100K J 1/16W
R79 RK73GB1J124J CHIP R 120K J 1/16W K2
TX-RX UNIT (X57-6990-XX)

TK-8180
10
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
R79 RK73GB1J224J CHIP R 220K J 1/16W K
R81,82 RK73GB1J104J CHIP R 100K J 1/16W
R84 RK73GB1J124J CHIP R 120K J 1/16W K
R84 RK73GB1J823J CHIP R 82K J 1/16W K2
R85 RK73GB1J104J CHIP R 100K J 1/16W
R86 RK73GB1J824J CHIP R 820K J 1/16W
R87 RK73GB1J823J CHIP R 82K J 1/16W
R88,89 RK73GB1J104J CHIP R 100K J 1/16W
R90 RK73GB1J334J CHIP R 330K J 1/16W
R108 R92-1252-05 CHIP R 0 OHM J 1/16W
R109 RK73GB1J102J CHIP R 1.0K J 1/16W
R115,116 RK73GB1J183J CHIP R 18K J 1/16W
R119 R92-1252-05 CHIP R 0 OHM J 1/16W
R120 RK73GB1J221J CHIP R 220 J 1/16W
R121-124 RK73GB1J104J CHIP R 100K J 1/16W
R126 R92-1252-05 CHIP R 0 OHM J 1/16W
R129-133 RK73GB1J104J CHIP R 100K J 1/16W
R134 R92-1252-05 CHIP R 0 OHM J 1/16W
R171 RK73GB1J271J CHIP R 270 J 1/16W
R172 RK73GB1J180J CHIP R 18 J 1/16W
R173 RK73GB1J271J CHIP R 270 J 1/16W
R174 RK73GB1J680J CHIP R 68 J 1/16W
R175 RK73GB1J222J CHIP R 2.2K J 1/16W
R176 RK73GB1J470J CHIP R 47 J 1/16W
R177 RK73GB1J102J CHIP R 1.0K J 1/16W
R178 R92-1252-05 CHIP R 0 OHM J 1/16W
R179 RK73GB1J102J CHIP R 1.0K J 1/16W
R180 RK73GB1J821J CHIP R 820 J 1/16W
R181 RK73GB1J331J CHIP R 330 J 1/16W
R182 RK73GB1J332J CHIP R 3.3K J 1/16W
R183 RK73GB1J680J CHIP R 68 J 1/16W
R184 RK73GB1J100J CHIP R 10 J 1/16W
R185 RK73GB1J821J CHIP R 820 J 1/16W
R186 RK73GB1J331J CHIP R 330 J 1/16W
R187 RK73GB1J332J CHIP R 3.3K J 1/16W
R188 RK73GB1J680J CHIP R 68 J 1/16W
R189 RK73GB1J100J CHIP R 10 J 1/16W
R190 RK73GB1J153J CHIP R 15K J 1/16W
R191,192 RK73GB1J223J CHIP R 22K J 1/16W
R193 RK73GB1J473J CHIP R 47K J 1/16W
R194,195 RK73GB1J223J CHIP R 22K J 1/16W
R196 RK73GB1J153J CHIP R 15K J 1/16W
R197,198 RK73GB1J334J CHIP R 330K J 1/16W
R199 RK73GB1J560J CHIP R 56 J 1/16W
R200 RK73GB1J332J CHIP R 3.3K J 1/16W
R202 RK73GB1J472J CHIP R 4.7K J 1/16W
R203 RK73GB1J332J CHIP R 3.3K J 1/16W
R204 RK73GB1J222J CHIP R 2.2K J 1/16W
R205 RK73GB1J332J CHIP R 3.3K J 1/16W
R206 RK73GB1J102J CHIP R 1.0K J 1/16W
R207 RK73GB1J473J CHIP R 47K J 1/16W
R208 RK73GB1J392J CHIP R 3.9K J 1/16W
R209 RK73GB1J100J CHIP R 10 J 1/16W
R210 RK73GB1J272J CHIP R 2.7K J 1/16W
R212 RK73GB1J104J CHIP R 100K J 1/16W
R217 R92-1252-05 CHIP R 0 OHM J 1/16W
R221 RK73GB1J473J CHIP R 47K J 1/16W
R251 RK73GB1J102J CHIP R 1.0K J 1/16W
R252 RK73GB1J472J CHIP R 4.7K J 1/16W
R253 RK73GB1J103J CHIP R 10K J 1/16W
R254,255 R92-1252-05 CHIP R 0 OHM J 1/16W
R256 RK73GB1J124J CHIP R 120K J 1/16W
R257 RK73GB1J153J CHIP R 15K J 1/16W
R258 RK73GB1J220J CHIP R 22 J 1/16W
R295 R92-1252-05 CHIP R 0 OHM J 1/16W
R298 R92-1368-05 CHIP R 0 OHM
R301 R92-1252-05 CHIP R 0 OHM J 1/16W
R302 RK73GB1J100J CHIP R 10 J 1/16W
R303 RK73GB1J561J CHIP R 560 J 1/16W
R305 RK73GB1J560J CHIP R 56 J 1/16W
R306 RK73GB1J183J CHIP R 18K J 1/16W
R307 R92-1252-05 CHIP R 0 OHM J 1/16W
R308 RK73GB1J392J CHIP R 3.9K J 1/16W
R309,310 RK73GB1J101J CHIP R 100 J 1/16W
R311 RK73GB1J182J CHIP R 1.8K J 1/16W K
R311,312 RK73GB1J102J CHIP R 1.0K J 1/16W K2
R312 RK73GB1J102J CHIP R 1.0K J 1/16W K
R315 RK73GB1J102J CHIP R 1.0K J 1/16W
R316 RK73GB1J104J CHIP R 100K J 1/16W K
R316 RK73GB1J823J CHIP R 82K J 1/16W K2
R317 R92-1252-05 CHIP R 0 OHM J 1/16W
R318 R92-1301-05 CHIP R 4.7K J 1/4W K2
R318 R92-2577-05 METAL-R 1.8K J 1/4W K
R319 RK73GB1J100J CHIP R 10 J 1/16W
R320 RK73GB1J180J CHIP R 18 J 1/16W
R321 RK73GB1J103J CHIP R 10K J 1/16W
R322 R92-1252-05 CHIP R 0 OHM J 1/16W
R323 RK73GB1J102J CHIP R 1.0K J 1/16W
R325 RK73GB1J154J CHIP R 150K J 1/16W
R326 RK73GB1J271J CHIP R 270 J 1/16W K
R326 RK73GB1J331J CHIP R 330 J 1/16W K2
R327 RK73GB1J100J CHIP R 10 J 1/16W
R330 RK73GB1J100J CHIP R 10 J 1/16W
R332 RK73GB1J100J CHIP R 10 J 1/16W
R333-335 R92-1252-05 CHIP R 0 OHM J 1/16W
R336 RK73GB1J102J CHIP R 1.0K J 1/16W
R337 RK73GB1J103J CHIP R 10K J 1/16W
R339 RK73GB1J104J CHIP R 100K J 1/16W
R340 RK73GB1J101J CHIP R 100 J 1/16W
R341,342 RK73GB1J181J CHIP R 180 J 1/16W
R343 RK73GB1J472J CHIP R 4.7K J 1/16W
R344 RK73GB1J180J CHIP R 18 J 1/16W K2
R344 RK73GB1J470J CHIP R 47 J 1/16W K
R345 RK73GB1J221J CHIP R 220 J 1/16W K2
R345 R92-1252-05 CHIP R 0 OHM J 1/16W K
R347 RK73GB1J472J CHIP R 4.7K J 1/16W
R348 RK73GB1J103J CHIP R 10K J 1/16W
R349 RK73GB1J183J CHIP R 18K J 1/16W K2
R349,350 RK73GB1J333J CHIP R 33K J 1/16W K
R350 RK73GB1J393J CHIP R 39K J 1/16W K2
R351 RK73GB1J472J CHIP R 4.7K J 1/16W
R352 RK73GB1J100J CHIP R 10 J 1/16W K
R352 RK73GB1J101J CHIP R 100 J 1/16W K2
R353 RK73GB1J472J CHIP R 4.7K J 1/16W
R354 RK73GB1J121J CHIP R 120 J 1/16W K2
R355 RK73GB1J101J CHIP R 100 J 1/16W K2
R355 RK73GB1J560J CHIP R 56 J 1/16W K
R356 RK73GB1J103J CHIP R 10K J 1/16W K2
R356,357 RK73GB1J103J CHIP R 10K J 1/16W K
R357,358 RK73GB1J223J CHIP R 22K J 1/16W K2
TX-RX UNIT (X57-6990-XX)

TK-8180
11
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
R358 RK73GB1J822J CHIP R 8.2K J 1/16W K
R359 RK73GB1J101J CHIP R 100 J 1/16W K
R359,360 RK73GB1J101J CHIP R 100 J 1/16W K2
R360 RK73GB1J121J CHIP R 120 J 1/16W K
R361 RK73GB1J221J CHIP R 220 J 1/16W
R362 R92-1252-05 CHIP R 0 OHM J 1/16W
R365,366 RK73GB1J222J CHIP R 2.2K J 1/16W
R367 RK73GB1J332J CHIP R 3.3K J 1/16W
R369 R92-1252-05 CHIP R 0 OHM J 1/16W
R370 RK73GB1J103J CHIP R 10K J 1/16W K
R370 RK73GB1J183J CHIP R 18K J 1/16W K2
R371 R92-1252-05 CHIP R 0 OHM J 1/16W
R373 RK73GB1J100J CHIP R 10 J 1/16W K
R373 R92-1252-05 CHIP R 0 OHM J 1/16W K2
R375 RK73GB1J331J CHIP R 330 J 1/16W K
R375 RK73GB1J821J CHIP R 820 J 1/16W K2
R376,377 R92-1252-05 CHIP R 0 OHM J 1/16W
R378 RK73GB1J103J CHIP R 10K J 1/16W
R400 RK73HH1J105D CHIP R 1.0M D 1/16W
R401 RK73HH1J362D CHIP R 3.6K D 1/16W
R402 RK73HH1J512D CHIP R 5.1K D 1/16W
R403 RK73HH1J105D CHIP R 1.0M D 1/16W
R405,406 RK73HB1J474J CHIP R 470K J 1/16W
R407 RK73HB1J103J CHIP R 10K J 1/16W
R410 RK73HB1J103J CHIP R 10K J 1/16W
R411,412 RK73HB1J474J CHIP R 470K J 1/16W
R414 RK73HB1J103J CHIP R 10K J 1/16W
R415 RK73HB1J474J CHIP R 470K J 1/16W
R416 R92-1368-05 CHIP R 0 OHM
R418,419 RK73HB1J473J CHIP R 47K J 1/16W
R420 RK73HB1J334J CHIP R 330K J 1/16W
R421,422 RK73HB1J473J CHIP R 47K J 1/16W
R423 R92-1368-05 CHIP R 0 OHM
R424-427 RK73HB1J102J CHIP R 1.0K J 1/16W
R428 R92-1368-05 CHIP R 0 OHM
R429,430 RK73HB1J471J CHIP R 470 J 1/16W
R431 R92-1368-05 CHIP R 0 OHM
R432 RK73HB1J102J CHIP R 1.0K J 1/16W
R434 RK73HB1J473J CHIP R 47K J 1/16W
R435 RK73HB1J102J CHIP R 1.0K J 1/16W
R437 R92-1368-05 CHIP R 0 OHM
R439 R92-1368-05 CHIP R 0 OHM
R440-444 RK73HB1J102J CHIP R 1.0K J 1/16W
R445,446 RK73GB1J103J CHIP R 10K J 1/16W
R447 RK73HB1J474J CHIP R 470K J 1/16W
R448 RK73HB1J102J CHIP R 1.0K J 1/16W
R449 RK73HB1J474J CHIP R 470K J 1/16W
R450 RK73HB1J102J CHIP R 1.0K J 1/16W
R451 RK73HB1J474J CHIP R 470K J 1/16W
R452 RK73HB1J102J CHIP R 1.0K J 1/16W
R453 RK73HB1J474J CHIP R 470K J 1/16W
R454 RK73HB1J102J CHIP R 1.0K J 1/16W
R455,456 RK73HB1J471J CHIP R 470 J 1/16W
R457 RK73HB1J473J CHIP R 47K J 1/16W
R458,459 RK73HB1J474J CHIP R 470K J 1/16W
R461 RK73HB1J474J CHIP R 470K J 1/16W
R465 RK73GB1J473J CHIP R 47K J 1/16W
R466 RK73HB1J473J CHIP R 47K J 1/16W
R467 R92-1368-05 CHIP R 0 OHM
R468 RK73HB1J473J CHIP R 47K J 1/16W
R469 RK73HB1J102J CHIP R 1.0K J 1/16W
R470 RK73GB1J102J CHIP R 1.0K J 1/16W
R471,472 RK73HB1J102J CHIP R 1.0K J 1/16W
R473,474 R92-1252-05 CHIP R 0 OHM J 1/16W
R475 RK73GB1J101J CHIP R 100 J 1/16W
R476 RK73HB1J473J CHIP R 47K J 1/16W
R477,478 RK73HB1J474J CHIP R 470K J 1/16W
R481 RK73HB1J474J CHIP R 470K J 1/16W
R482 RK73HB1J473J CHIP R 47K J 1/16W
R483-486 R92-1252-05 CHIP R 0 OHM J 1/16W
R487 RK73GB1J185J CHIP R 1.8M J 1/16W
R488,489 R92-1252-05 CHIP R 0 OHM J 1/16W
R490 RK73GB1J184J CHIP R 180K J 1/16W
R491 R92-1252-05 CHIP R 0 OHM J 1/16W
R492 RK73GB1J684J CHIP R 680K J 1/16W
R493 RK73GB1J105J CHIP R 1.0M J 1/16W
R494,495 RK73GB1J472J CHIP R 4.7K J 1/16W
R496 RK73GB1J104J CHIP R 100K J 1/16W
R497 RK73GB1J332J CHIP R 3.3K J 1/16W
R498 RK73GB1J274J CHIP R 270K J 1/16W
R499 RK73GB1J104J CHIP R 100K J 1/16W
R500 R92-1252-05 CHIP R 0 OHM J 1/16W
R501 RK73GB1J472J CHIP R 4.7K J 1/16W
R502 RK73GB1J103J CHIP R 10K J 1/16W
R503 RK73GB1J104J CHIP R 100K J 1/16W
R504 RK73GB1J103J CHIP R 10K J 1/16W
R505 RK73GB1J683J CHIP R 68K J 1/16W
R506,507 RK73GB1J224J CHIP R 220K J 1/16W
R508 RK73GB1J102J CHIP R 1.0K J 1/16W
R509 RK73GB1J333J CHIP R 33K J 1/16W
R511 RK73HB1J152J CHIP R 1.5K J 1/16W
R512 RK73GB1J153J CHIP R 15K J 1/16W
R513 RK73GB1J564J CHIP R 560K J 1/16W
R514 RK73GB1J183J CHIP R 18K J 1/16W
R515 RK73GB1J104J CHIP R 100K J 1/16W
R517 RK73GB1J223J CHIP R 22K J 1/16W
R519 RK73GB1J104J CHIP R 100K J 1/16W
R520 R92-1252-05 CHIP R 0 OHM J 1/16W
R521 RK73GB1J473J CHIP R 47K J 1/16W
R522 RK73GB1J104J CHIP R 100K J 1/16W
R523 RK73GB1J564J CHIP R 560K J 1/16W
R524 RK73GB1J103J CHIP R 10K J 1/16W
R525 RK73HB1J152J CHIP R 1.5K J 1/16W
R526 RK73GB1J274J CHIP R 270K J 1/16W
R527 RK73GB1J392J CHIP R 3.9K J 1/16W
R528 RK73GB1J473J CHIP R 47K J 1/16W
R529 RK73GB1J684J CHIP R 680K J 1/16W
R530 RK73GB1J334J CHIP R 330K J 1/16W
R531 RK73GB1J103J CHIP R 10K J 1/16W
R532 RK73GB1J102J CHIP R 1.0K J 1/16W
R533 RK73GB1J104J CHIP R 100K J 1/16W
R534 RK73GB1J273J CHIP R 27K J 1/16W
R535 RK73GB1J394J CHIP R 390K J 1/16W
R536 RK73GB1J153J CHIP R 15K J 1/16W
R539 RK73GB1J393J CHIP R 39K J 1/16W
R540 RK73GB1J473J CHIP R 47K J 1/16W
R541,542 R92-1252-05 CHIP R 0 OHM J 1/16W
R545 RK73GB1J103J CHIP R 10K J 1/16W
R546 R92-1252-05 CHIP R 0 OHM J 1/16W
R548 RK73GB1J823J CHIP R 82K J 1/16W
TX-RX UNIT (X57-6990-XX)

TK-8180
12
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
R549 RK73GB1J473J CHIP R 47K J 1/16W
R550 RK73GB1J472J CHIP R 4.7K J 1/16W
R552 RK73GB1J103J CHIP R 10K J 1/16W
R553 RK73GB1J472J CHIP R 4.7K J 1/16W
R554 RK73GB1J563J CHIP R 56K J 1/16W
R555 RK73GB1J123J CHIP R 12K J 1/16W
R556 RK73GB1J563J CHIP R 56K J 1/16W
R557 RK73GB1J472J CHIP R 4.7K J 1/16W
R558 RK73GB1J394J CHIP R 390K J 1/16W
R559 RK73GB1J124J CHIP R 120K J 1/16W
R560 RK73GB1J394J CHIP R 390K J 1/16W
R563 RK73GB1J394J CHIP R 390K J 1/16W
R565 R92-1252-05 CHIP R 0 OHM J 1/16W
R566 RK73GB1J105J CHIP R 1.0M J 1/16W
R567 RK73GB1J394J CHIP R 390K J 1/16W
R568 RK73GB1J124J CHIP R 120K J 1/16W
R569 RK73GB1J104J CHIP R 100K J 1/16W
R570 RK73GB1J154J CHIP R 150K J 1/16W
R571 RK73GB1J124J CHIP R 120K J 1/16W
R572 R92-1368-05 CHIP R 0 OHM
R573 RK73GB1J682J CHIP R 6.8K J 1/16W
R574,575 R92-1368-05 CHIP R 0 OHM
R576 RK73GB1J224J CHIP R 220K J 1/16W
R578 R92-1368-05 CHIP R 0 OHM
R579 RK73GB1J223J CHIP R 22K J 1/16W
R580,581 RK73GB1J151J CHIP R 150 J 1/16W
R582 RK73GB1J105J CHIP R 1.0M J 1/16W
R583,584 R92-1252-05 CHIP R 0 OHM J 1/16W
R585 RK73GB1J184J CHIP R 180K J 1/16W
R586 RK73GB1J102J CHIP R 1.0K J 1/16W
R587 RK73GB1J154J CHIP R 150K J 1/16W
R588 RK73GB1J472J CHIP R 4.7K J 1/16W
R589,590 R92-1252-05 CHIP R 0 OHM J 1/16W
R591 R92-1368-05 CHIP R 0 OHM
R592 R92-1252-05 CHIP R 0 OHM J 1/16W
R594 RK73GB1J681J CHIP R 680 J 1/16W
R595 RK73GB1J274J CHIP R 270K J 1/16W
R596 R92-1252-05 CHIP R 0 OHM J 1/16W
R597 RK73GB1J105J CHIP R 1.0M J 1/16W
R598 RK73GB1J472J CHIP R 4.7K J 1/16W
R599 RK73GB1J184J CHIP R 180K J 1/16W
R600 RK73GB1J472J CHIP R 4.7K J 1/16W
R601 RK73GB1J474J CHIP R 470K J 1/16W
R602 RK73GB1J105J CHIP R 1.0M J 1/16W
R603,604 R92-1252-05 CHIP R 0 OHM J 1/16W
R606 R92-1252-05 CHIP R 0 OHM J 1/16W
R607 RK73GB1J274J CHIP R 270K J 1/16W
R608 RK73GB1J184J CHIP R 180K J 1/16W
R609 RK73GB1J223J CHIP R 22K J 1/16W
R610 RK73GB1J154J CHIP R 150K J 1/16W
R611 RK73GB1J103J CHIP R 10K J 1/16W
R612,613 RK73GB1J104J CHIP R 100K J 1/16W
R614 R92-1368-05 CHIP R 0 OHM
R615,616 RK73GB1J472J CHIP R 4.7K J 1/16W
R617 RK73GB1J104J CHIP R 100K J 1/16W
R618 RK73GB1J224J CHIP R 220K J 1/16W
R619 RK73GB1J104J CHIP R 100K J 1/16W
R620 RK73GB1J224J CHIP R 220K J 1/16W
R621,622 R92-0670-05 CHIP R 0 OHM
R623,624 RK73GB1J473J CHIP R 47K J 1/16W
R625 RK73GB1J472J CHIP R 4.7K J 1/16W
R629,630 R92-0670-05 CHIP R 0 OHM
R632 RK73GB1J473J CHIP R 47K J 1/16W
R633 R92-0670-05 CHIP R 0 OHM
R636 R92-0670-05 CHIP R 0 OHM
R641,642 RK73GB1J472J CHIP R 4.7K J 1/16W
R643 RK73GB1J471J CHIP R 470 J 1/16W
R644 RK73GB1J102J CHIP R 1.0K J 1/16W
R645 RK73GB1J562J CHIP R 5.6K J 1/16W
R646 RK73GB1J472J CHIP R 4.7K J 1/16W
R647 RK73GB1J104J CHIP R 100K J 1/16W
R648 RK73GB1J222J CHIP R 2.2K J 1/16W
R651 R92-1252-05 CHIP R 0 OHM J 1/16W
R652 RK73GB1J561J CHIP R 560 J 1/16W
R653 RK73GB1J2R2J CHIP R 2.2 J 1/16W
R654 R92-0670-05 CHIP R 0 OHM
R655 R92-1252-05 CHIP R 0 OHM J 1/16W
R657 RK73HB1J472J CHIP R 4.7K J 1/16W
R658 R92-1368-05 CHIP R 0 OHM
R659 RK73GB1J333J CHIP R 33K J 1/16W
R661 RK73GB1J472J CHIP R 4.7K J 1/16W
R663,664 RK73GB1J472J CHIP R 4.7K J 1/16W
R701-705 RK73GB1J473J CHIP R 47K J 1/16W
R706-710 RK73GB1J471J CHIP R 470 J 1/16W
R711-713 RK73GB1J473J CHIP R 47K J 1/16W
R714-720 RK73GB1J471J CHIP R 470 J 1/16W
R800 RK73HH1J105D CHIP R 1.0M D 1/16W
R801 RK73GB1J224J CHIP R 220K J 1/16W
R802 RK73GB1J334J CHIP R 330K J 1/16W
R803 RK73GB1J103J CHIP R 10K J 1/16W
R804 RK73HH1J104D CHIP R 100K D 1/16W
R805 RK73GB1J471J CHIP R 470 J 1/16W
R806,807 RK73GB1J103J CHIP R 10K J 1/16W
R808,809 RK73GB1J473J CHIP R 47K J 1/16W
R811,812 RK73GB1J103J CHIP R 10K J 1/16W
R813 RK73GB1J472J CHIP R 4.7K J 1/16W
R814 RK73GB1J473J CHIP R 47K J 1/16W
R815 RK73GB1J683J CHIP R 68K J 1/16W
R818 RK73GB1J473J CHIP R 47K J 1/16W
R900-903 R92-1368-05 CHIP R 0 OHM
D1 02DZ5.6(X,Y) ZENER DIODE
D2 XB15A709 DIODE
D3 XB15A407A2GB DIODE K
D3,4 XB15A407A2GB DIODE K2
D6-8 HSM88AS DIODE
D103-106 1SV286 VARIABLE CAPACITANCE DIODE
D107-110 1SV291 VARIABLE CAPACITANCE DIODE
D111 HVC131 DIODE
D171,172 DAN235E DIODE
D173 RB706F-40 DIODE
D174 MA2S111 DIODE
D251 1SS388 DIODE
D308,309 BB664 VARIABLE CAPACITANCE DIODE
D311 BB664 VARIABLE CAPACITANCE DIODE
D313 BB664 VARIABLE CAPACITANCE DIODE
D314 1SV278 VARIABLE CAPACITANCE DIODE
D315,316 HVC131 DIODE
D402-404 1SS388 DIODE
D405 EMZ6.8N ZENER DIODE
D406 02DZ5.1(Y) ZENER DIODE
TX-RX UNIT (X57-6990-XX)

TK-8180
13
PARTS LIST
Ref. No. Address Parts No. Description Desti-
nation
New
parts
Ref. No. Address Parts No. Description Desti-
nation
New
parts
TX-RX UNIT (X57-6990-XX)
D407 RB706F-40 DIODE
D408,409 MA742 DIODE
D412-414 DA204U DIODE
D416 DAN202U DIODE
D417,418 1SS388 DIODE
D421-423 1SS388 DIODE
D600,601 1SS388 DIODE
D701 02DZ18(X,Y) ZENER DIODE
D702,703 1SS355 DIODE
D704-708 DA204U DIODE
D709,710 02DZ18(X,Y) ZENER DIODE
D711-713 DA204U DIODE
D714 02DZ18(X,Y) ZENER DIODE
D801 22ZR-10D SURGE ABSORBER
D802 DSA3A1 DIODE
D804 02DZ18(X,Y) ZENER DIODE
D805 02CZ9.1(X,Y) ZENER DIODE
IC1 2A ✽RA30H4047M-23 MOS-IC K2
IC1 2A RA30H4452M-23 MOS-IC K
IC71,72 TA75W01FU MOS-IC
IC171 SPM5001 MOS-IC
IC172 TA31136FN MOS-IC
IC251 MAX5026EUT+T MOS-IC
IC301 ADF4111BCP7 MOS-IC
IC302 TC7S66FU MOS-IC
IC401 AT24256N10SI27 ROM IC
IC402 RV5C386A MOS-IC
IC403 BU4094BCFV MOS-IC
IC404 30625MGP-169GP MICROPROCESSOR IC
IC405 AT29C040A-90TI ROM IC
IC406-409 TC75W51FU MOS-IC
IC410 M62364FP MOS-IC
IC411 LMC7101BIM5 MOS-IC
IC412 TC75W51FU MOS-IC
IC413 TC7MZ4053FK MOS-IC
IC414 TC75W51FU MOS-IC
IC415 AQUA-L MOS-IC
IC416 ADM202EARN MOS-IC
IC417 2A TA7252AP ANALOGUE IC
IC801 S-80942CNNBG9C MOS-IC
IC802 XC61CN5002NR MOS-IC
IC803 TA7808F ANALOGUE IC
IC804 TA7805F MOS-IC
IC805 NJM78L05UA BI-POLAR IC
IC807 XC6201P502PR MOS-IC
Q1 2SC5108(Y) TRANSISTOR
Q2 2SC5192 TRANSISTOR
Q3 DTC114EE DIGITAL TRANSISTOR
Q70 DTC114EE DIGITAL TRANSISTOR
Q72 2SK1824 FET
Q103 2SC3357 TRANSISTOR
Q171,172 2SC5108(Y) TRANSISTOR
Q173 DTA114EE DIGITAL TRANSISTOR
Q174 DTC144EE DIGITAL TRANSISTOR
Q175 2SC4617(Q) TRANSISTOR
Q176 2SK1824 FET
Q177 DTC144EE DIGITAL TRANSISTOR
Q178 DTA144EE DIGITAL TRANSISTOR
Q179 DTC144EE DIGITAL TRANSISTOR
Q251 2SC4617(S) TRANSISTOR
Q301 2SC5108(Y) TRANSISTOR
Q302,303 2SC4116(BL) TRANSISTOR
Q306,307 2SK508NV(K52) FET
Q308,309 2SC4116(GR) TRANSISTOR
Q310 DTC114EE DIGITAL TRANSISTOR
Q311 2SC5108(Y) TRANSISTOR
Q312 2SC4617(S) TRANSISTOR
Q313 2SC5108(Y) TRANSISTOR
Q402 DTC114YE DIGITAL TRANSISTOR
Q405 DTA114EE DIGITAL TRANSISTOR
Q406 HN1J02FU FET
Q409 DTC363EU DIGITAL TRANSISTOR
Q410 2SC4116(Y) TRANSISTOR
Q411 2SA1586(Y,GR) TRANSISTOR
Q412 2SK1824 FET
Q413,414 2SJ243 FET
Q415 HN1L02FU FET
Q416,417 2SJ243 FET
Q418 DTC114EE DIGITAL TRANSISTOR
Q419 DTC363EU DIGITAL TRANSISTOR
Q600 DTA144EE DIGITAL TRANSISTOR
Q701,702 2SD2114K(W) TRANSISTOR
Q801 2SC2873(Y) TRANSISTOR
Q802 DTC114EE DIGITAL TRANSISTOR
Q803-805 12A02CH TRANSISTOR
Q806-809 DTC114EE DIGITAL TRANSISTOR
Q810 2SJ645 FET
Q811 DTC114TE DIGITAL TRANSISTOR
Q812 DTC114EE DIGITAL TRANSISTOR
TH1 S1R104J475H THERMISTOR
TH171 S1R473J475H THERMISTOR

TK-8180
14
EXPLODED VIEW
3
2
1
BA
Right Side
Front
Rear
1
16
23
25
22
15
24
17
27
11
12
54
10
29
8
30
42
28
431
7
21
26
41
20
20
20
20
105
101
103
102
106
47
2
40
51
45
43
13
IC1
Cx2
Cx2
Cx2
Cx2 Cx3
Cx3
C
C
C
C
C
C
C
C
C
C
B
B
Bx2
D
TX-RX unit
(B/3) TX-RX unit
(C/3) Cx2
A
A
Display unit
701
702
703
704
705
706
103
104 x2
IC417
J901
TX-RX
unit (A/3)
A:N09-2409-05
B M3 x 8 : N67-3008-48
C M2.6 x 6 (Br-Tap) : N87-2606-48
D M2.6 x 8 (Br-Tap) : N87-2608-46
Parts with the exploded numbers larger than 700 are not supplied.

TK-8180
15
PACKING
Parts with the exploded numbers larger than 700 are not supplied.
3
2
1
DC
5 Instruction manual
(B62-1766-10)
9 DC cord assy
(Water-proof)
(E30-7523-05)
18 Fuse (Blade)
15A/32V
(F52-0024-05) x 2
32 Inner carton case
(H02-0624-03)
33 Packing fixture (Lower)
(H12-3170-01)
34 Packing fixture (Upper)
(H12-3171-03)
36 Protection bag
(H25-2352-04)
37 Item carton case
(H52-2069-02)
39 Holder
(J19-1584-05)
44 Bracket
(J29-0662-03)
49 Screw set
(N99-2039-05)
52 Microphone
(T91-0639-05)
707 Pamphlet x 2

TK-8180
16
Controls
Panel Test Mode
■Test mode operation features
This transceiver has a test mode. To enter test mode,
press [A] key and turn power on. Hold [A] key until fre-
quency version appears on LCD. Test mode can be inhib-
ited by programming. To exit test mode, switch the power
on again. The following functions are available in test mode.
■Key operation
Key
“FNC”not appears
Function Display
[S] Shifts to Panel tuning mode -
[A] Function on “FNC” appears
[B] MSK 1200bps and 2400bps 2400bps : icon appears
[C] Test signaling CH up Signaling No.
[]/[ ] Test frequency CH up/down Channel No.
[]/[ ]Volume up/down -
[ ] Squelch on/off
[■]Narrow/Wide 4k/Wide 5k Narrow : “n”,
Wide 4k : “s”,
Wide 5k : “w”
Microphone key
[PTT] Transmit -
[0] to [9] Use as the DTMF keypad. -
and [A], If a key is pressed during
[B], [C], transmission, the DTMF
[D], [#], corresponding to the key
[✳]that was presses is sent.
Key
“FNC”appears
Function Display
[S] High power / Low power Low : icon appears
[A] Function off -
[B] Compander on/off On : icon appears
[C] Beat shift on/off On : icon appears
[]/[ ]Function off -
[]/[ ]Function off -
[ ] Squelch level 0 On : icon appears
[■]LCD all lights LCD all point appears
Microphone key
[PTT] Transmit -
[0] to [9] Function off -
and [A],
[B], [C],
[D], [#],
[✳]
Notes :
•If a [S], [A], [B], [C] key is pressed during transmission, the
DTMF corresponding to the key that was pressed is sent.
•The “Wide 4k” can not use, please skip it.
•LED indicator
Red LED Lights during transmission.
Green LED Lights when there is carrier.
•Sub LCD indicator
“FNC” Appears at function on.
•LCD display in panel test mode
Power
switch
Modular
MIC jack
Programmable
function keys
Volume
Up/Down key
Channel
Up/Down key
LCD
n1 1
–
Channel No.
n : Narrow
s : Wide 4k
w : Wide 5k
Signaling No.
ADJUSTMENT

TK-8180
17
■Frequency and Signaling
The set has been adjusted for the frequencies shown in
the following table. When required, readjust them following
the adjustment procedure to obtain the frequencies you want
in actual operation.
•Test frequency
CH
KK2
RX (MHz) TX (MHz) RX (MHz) TX (MHz)
1 485.05000 485.10000 435.05000 435.10000
2 450.05000 450.10000 400.05000 400.10000
3 519.95000 519.90000 469.95000 469.90000
4 485.00000 485.00000 435.00000 435.00000
5 485.20000 485.20000 435.20000 435.20000
6 485.40000 485.40000 435.40000 435.40000
7~16 - - - -
•Test signaling
No. RX TX
1None None
2None 100Hz Square Wave
3LTR Data : LTR Data :
AREA=0, GOTO=12 AREA=0, GOTO=12
HOME=12 HOME=12
ID=47, FREE=25 ID=47, FREE=25
4QT : 67.0Hz QT : 67.0Hz
5QT : 151.4Hz QT : 151.4Hz
6QT : 210.7Hz QT : 210.7Hz
7QT : 254.1Hz QT : 254.1Hz
8DQT : D023N DQT : D023N
9DQT : D754I DQT : D754I
10 DTMF : 159D DTMF : 159D
11 None DTMF Code 9
12 2-tone : 2-tone :
A : 304.7Hz A : 304.7Hz
B : 3106.0Hz B : 3106.0Hz
No. RX TX
13 Single Tone : 979.9Hz Single Tone : 979.9Hz
14 None Single Tone : 1000Hz
15 5-tone (CCIR 12345) 5-tone (CCIR 12345)
16 None MSK
17 MSK : MSK :
Preamble : 0xAAAA Preamble : 0xAAAA
Sync : 0x23EB Sync : 0x23EB
Data : 0x230960C6AAAA Data : 0x230960C6AAAA
CRC : 0xC4D7 CRC : 0xC4D7
Note : The “5-tone signaling” can not use, please skip it.
Panel Tuning Mode
■Preparations for tuning the transceiver
Before attempting to tune the transceiver, connect the
unit to a suitable power supply.
Whenever the transmitter is turned, the unit must be con-
nected to a suitable dummy load (i.e. power meter).
The speaker output connector must be terminated with a
4Ωdummy load and connected to an AC voltmeter and an
audio distortion meter or a SINAD measurement meter at all
times during tuning.
■Transceiver tuning
(To place transceiver in tuning mode)
Press [S] key, now in tuning mode. Use [B] key to write
tuning data through tuning modes, and [ ]/[ ] to adjust tun-
ing requirements (1 to 256 appeares on LCD).
Use [C] key to select the adjustment item through tuning
modes. Use [A] key to adjust 3 or 5 reference level adjust-
ments, and use [■] key to switch between Wide 5k/Wide 4k/
Narrow.
Channel appears on LCD. Set channel according to tuning
requirements.
•LCD display in panel tuning mode
nBAL 256
Adjustment item
n : Narrow
s : Wide 4k
w : Wide 5k
Adjustment value (1~256)
ADJUSTMENT

TK-8180
18
■Key operation
Key
Function
Push Hold (1 second)
[S] End of panel tuning mode -
[A] To enter 3 or 5 reference -
level adjustments
[B] Writes the adjustment value -
[C] Go to next adjustment item Back to last adjustment item
[]/[ ] Adjustment value up/down Continuation up/down
[]/[ ]Volume level up/down Continuation up/down
[ ] Squelch on/off -
[■]Selects Narrow, -
Wide 4k, Wide 5k
■3 or 5 reference level adjustments frequency
Tuning K K2
point RX (MHz) TX (MHz) RX (MHz) TX (MHz)
Low 450.05000 450.10000 400.05000 400.10000
Low’ 467.55000 467.60000 417.55000 417.60000
Center 485.05000 485.10000 435.05000 435.10000
High’ 502.55000 502.60000 452.55000 452.60000
High 519.95000 519.90000 469.95000 469.90000
■Adjustment item and Display (✳✳✳ : 1~256)
Order Adjustment item Display
1Frequency FREQ ✳✳✳
2Shift 1 SHFT1 ✳✳✳
3Shift 2 SHFT2 ✳✳✳
4Max high power MHPWR ✳✳✳
5Max low power M LPWR ✳✳✳
6High power HPWR ✳✳✳
7Low power LPWR ✳✳✳
8Balance B A L ✳✳✳
9Max deviation DEV ✳✳✳
10 QT Q T ✳✳✳
11 DQT DQT ✳✳✳
12 LTR L T R ✳✳✳
13 DTMF DTMF ✳✳✳
14 MSK MS K ✳✳✳
15 Tone TONE ✳✳✳
16 Sensitivity 1 SENS1 ✳✳✳
17 Squelch S Q L ✳✳✳
18 Low RSSI LRSSI ✳✳✳
19 Squelch tight SQLT ✳✳✳
20 High RSSI HRSSI ✳✳✳
ADJUSTMENT

TK-8180
19
■Flow chart
Note : The “Wide 4k” can not use, please skip it.
Frequency
[C]
Shift 1
[C]
Shift 2
[C]
High power
[C]
Low power
[C]
Balance Narrow
[C] [C]
[C] [C]
[C][A]
Balance Wide 4k Balance Wide 5k
Max deviation Narrow
[C] [A]
Max deviation Wide 4k Max deviation Wide 5k
QT Narrow
[C] [C]
[C] [C]
[C][A]
QT Wide 4k QT Wide 5k
DTMF Narrow
[C] [C] [C]
DTMF Wide 4k DTMF Wide 5k
MSK Narrow
[C] [C] [C]
MSK Wide 4k MSK Wide 5k
Tone Narrow
[C] [C] [C]
Tone Wide 4k Tone Wide 5k
LTRNarrow
[C] [C][A]
LTRWide 5k
DQT Narrow
Low RSSI Narrow
[C] [C] [C][A]
Low RSSI Wide 4k
[C] [A] [A]
[A] [A]
[A] [A]
[A] [A]
Squelch Wide 4k
Low RSSI Wide 5k
Squelch tight Narrow
[C] [C] [C][A]
Squelch tight Wide 4k Squelch tight Wide 5k
High RSSI Narrow
[C] [C] [C][A]
High RSSI Wide 4k High RSSI Wide 5k
Squelch Narrow
[C] [C][A]
Squelch Wide 5k
[C] [A]
DQT Wide 4k DQT Wide 5k
[A]
[A]
Sensitivity 1
[C]
[A]
[A]
[A]
3 reference level
adjustments
3 reference level
adjustments
5 reference level
adjustments
5 reference level
adjustments
[C]
Max high power
[C]
Max low power
[A]
[A]
5 reference level
adjustments
5 reference level
adjustments
3 reference level
adjustments
3 reference level
adjustments
3 reference level
adjustments
3 reference level
adjustments
3 reference level
adjustments
5 reference level
adjustments
3 reference level
adjustments
3 reference level
adjustments
3 reference level
adjustments
3 reference level
adjustments
[ ] [ ] [ ]
[ ] [ ] [ ]
[ ] [ ] [ ]
[ ] [ ] [ ]
[ ] [ ]
[ ] [ ] [ ]
[ ] [ ] [ ]
[ ] [ ] [ ]
[ ] [ ] [ ]
[ ] [ ] [ ]
[ ] [ ] [ ]
[ ] [ ] [ ]
3 reference level
adjustments
3 reference level
adjustments exit
[C]
Low
[C]
Center
[C]
High
[A]
[A]
[A]
5 reference level
adjustments
5 reference level
adjustments exit
[C]
Low
[C]
Low’
[C]
Center
[C]
High’
[C]
High
[A]
[A]
[A]
[A]
[A]
ADJUSTMENT

TK-8180
20
Test Equipment Required for Alignment
Test Equipment Major Specifications
1. Standard Signal Generator Frequency Range 400 to 520MHz
(SSG) Modulation Frequency modulation and external modulation
Output 0.1µV to greater than 1mV
2. Power Meter Input Impedance 50Ω
Operation Frequency 400 to 520MHz or more
Measurement Capability Vicinity of 50W
3. Deviation Meter Frequency Range 400 to 520MHz
4. Digital Volt Meter Measuring Range 1 to 20V DC
(DVM) Accuracy High input impedance for minimum circuit loading
5. Oscilloscope DC through 30MHz
6. High Sensitivity Frequency Range 10Hz to 600MHz
Frequency Counter Frequency Stability 0.2ppm or less
7. Ammeter 13A or more
8. AF Volt Meter Frequency Range 50Hz to 10kHz
(AF VTVM) Voltage Range 3mV to 3V
9. Audio Generator (AG) Frequency Range 50Hz to 5kHz
Output 0 to 1V
10. Distortion Meter Capability 3% or less at 1kHz
Input Level 50mV to 10Vrms
11. Voltmeter Measuring Range 10 to 1.5V DC or less
Input Impedance 50kΩ/V or greater
12. 4ΩDummy Load Approx. 4Ω, 20W
13. Regulated Power Supply 13.6V, approx. 20A (adjustable from 9 to 20V)
Useful if ammeter requipped
1
8
1 : BLC
2 : +B
3 : GND
4 : PTT/TXD
(PC serial data
from radio)
MIC connector (Front panel view)
5 : MICE
6 : MIC
7 : HOOK/RXD
(PC serial data
to radio)
8 : DM
Test cable for microphone input (E30-3360-08)
3
2
4
5
6
7
8
3
1
2
4
5
6
7
8
1GREEN
RED
BLACK
BLUE
SHIELD
WHITE
GRAY
YELLOW
PTT
E
MIC-E
MIC
HK
Tuning cable (E30-3383-05)
Adapter cable (E30-3383-05) is
required for injecting an audio if
PC tuning is used.
See “PC Mode” section fot the
connection.
Lead wire +
MIC
Shield wire –
ADJUSTMENT
to transceiver
to VGS-1
Check Jig for the VGS-1
KENWOOD part : W05-1127-00