Kettler KALOS Ibiza User manual

Ibiza Free Standing Heater
KLEH162-0600
Assembly Instructions
Nov 2020
ASSEMBLY
TIME
PERSONS
REQUIRED
IMPORTANT
PLEASE KEEP THIS BOOKLET FOR FUTURE REFERENCE.
THIS IS IMPORTANT INFORMATION REGARDING THE USE AND
CARE OF YOUR HALOGEN HEATER.

Important Information
Important advice before you begin:
This appliance is not intended for use by persons (including children) with reduced physical,
sensory or mental capabilities or lack of experience and knowledge if they have been given
supervision or instruction concerning use of the appliance in a safe way and understand the
hazards involved.
Children should not play with the appliance.
Cleaning and user maintenance should not be made by children without supervision.
Do not use any other tools other than those recommended to build this product.
Please do not use substitute parts. Use only additional or replacement parts supplied by Kettler.
In the unlikely event that this product has missing or damaged parts, please visit our
website www.kettler.co.uk/shop.
Unpack the halogen heater making sure that all the items are present and that
there are no components left in the box and that the heater head is free from any
packing material.
Using the detailed drawing follow the steps to assemble your halogen heater.
DO NOT connect the halogen heater to the electrical supply until all the
assembly is complete.
DO NOT connect the halogen heater to the electrical supply if any of the
components or the power cord is damaged in any way.
If in doubt contact your supplier.

For Your Safety
Warning
• This heater is not equipped with a device
to control the room temperature. DO
NOT use this heater in small rooms when
they are occupied by persons not capable
of leaving the room on their own, unless
constant supervision is provided.
• Children of less than 3 years
should be kept away unless continuously
supervised.
• Children aged from 3 years and less
than 8 years shall not plug in, regulate
and clean the appliance or perform user
maintenance.
Caution
• Some parts of this product can become
very hot and cause burns. Particular
attention has to be given where children
and vulnerable people are present.
• If the supply cord is damaged, it must be
replaced by the manufacturer, its service
agent or similarly qualified person in
order to avoid a hazard.
• The heater must not be located
immediately below an electrical
socket-outlet.
• Don’t use this heater in the
immediate surroundings of a bath,
a shower or a swimming pool.
• In order to avoid a hazard due
to inadvertent resetting of the thermal
cut-out, this appliance must not be
supplied through an external switching
device, such as a timer or connected to a
circuit that is regularly switched on and
off by utility.
• Only use the halogen heater on a firm
solid horizontal area where all the feet
on the base are in contact with the floor.
(Should the heater be tilted or fall over
the auto cut off switch will activate)

For Your Safety
1. Site the heater outside or in a large
open area and well away from any
obstructions such as branches or where
the heater is near any objects that can
be effected by heat, such as furniture,
curtains or other inflammable objects
(minimum distance 1 meter).
2. DO NOT push any items through,
obstruct or cover the grill of the heater.
3. Suggest follow the standard statement:
The heater must not be located
immediately below a socket outlet.
4. DO NOT move when connected to an
electrical supply and always wait for the
patio heater to cool down before storing
away.
5. DO NOT touch the heater when in use.
6. The indication of the different positions
of switches shall be visible from a
distance of 1m.
7. The unit must be placed with the
clearance of 100cm to the wall.
8. DON’T place the unit closed to curtain
and/or other flammable objects.
Otherwise there will be a danger of
catching fire.
9. DON’T wrap the power supply cord on
the unit.
10. The unit must be handled with care, and
avoid vibration or hitting.
12. If the unit gets damaged, it must be
repaired by professional electricians.
13. The unit is for household use only. It
is not safe to use on a building site,
greenhouse, barn or stable where there’s
flammable dust.
14. The head of the unit is at high
temperature during operation. Unplug
the unit and wait untill it cools before
cleaning.
15. DON’T use this unit in a place where
causticity or volatile air exists, i.e. dust,
steam, gas, etc.
16. DON’T use this unit as a cloth drier or
towel drier.
17. DON’T use this unit in place of animal
propagating and raising.
18. DON’T immerse this unit into water for
cleaning.
19. The unit should be plugged into a socket,
which is easily visible and reachable.
20. One dark point may exist on the surface
of the heating elements during the
first few minutes after it is turned on.
This is normal, and will not affect the
performance of the unit.
21. DO NOT use this heater with a
programmer, timer, separate remote-
control system or any other device that
switches the heater on automatically,
since a fire risk exists if the heater is
covered or positioned incorrectly.
22. This appliance is not intended for use
by a person (including children) with
reduced physical, sensory or mental
capabilities, or lack of experience and
knowledge, unless they have been given
supervision or instruction concerning
use of the appliance by a person
responsible for their safety.

For Your Safety
23. Children should be supervised to ensure
that they do not play with the appliance.
24. If the supply cord is damaged, it must be
replaced by the manufacturer, its service
agent or similarly qualified persons in
order to avoid a hazard.
Warning
• These appliances must be earthed.
• Before installing or replacing the bulb, the appliance must be always being disconnected
from the 220-240V supply.
Ibiza Freestanding Heater is built with the best quality components in accordance to the
prevailing legal regulations and certified for safety in use. For best results from the appliance
please ensure that the installation is done by a qualified electrician in accordance with the
following instructions and taking full account of current regulations. When using the heater,
please carefully follow the instructions and recommendations below.
Connection to 220-240 Volts Power Supply
It is important to ensure that the electricity supply is of adequate capacity for the electrical load
required by the appliance being installed.
• Installation.
Minimum required distances:
• 500mm from the side wall
• 500 mm from the ceiling
• Generally heaters must be placed at a safe distance (clear space) of at least 2.0m from
combustible materials and glass walls. If installed in workshops or garages where inflammable or
combustible paints are used, the heaters must be installed at a distance of at least 4.0m from the
source of danger.
• If the heaters are placed in areas where spray painting of any description is taking place, they
should not be used during the painting operations.
• Never use the heater in particularly dusty and explosive areas.

Assembly
1. Fix the bottom
tube onto
the base by
screwing.
2. Connect the
middle tube with
bottom tube by
screwing them
together.

Assembly
3. Connect the top tube
with middle tube by
screwing them together
(as same as Step2).
4. Place the power
cord plug through
the base , bottom
tube, middle
tube and top
tube. Connect the
power cord plug
to the socket in
the heater head.

Assembly
5. Insert the Heater Head
onto the top tube and
fix in position using the
4*8mm screws.
6. Fix the Power
Cord on the Base
by using the
4*M4 screws.

Assembly
7. Fix the heater to the
ground by screwing via
the fixing plates.
8. Loosen the two M6*10 screws by the L hexagonal wrench to change the best angle of the
heating head, then retighten them.

Operation
Remote Control Operation
• Touch the for the low setting (800W)
• Touch the for the medium setting (1600W)
• Touch the for the high setting (2500W)
• Press again to turn off.
Connect the power cable to a 220-240V 13amp supply that is located in a safe, dry area.
• Press “ ” to turn the heater on
• Press on the panel for low setting (800W)
• Press on the panel for the medium setting (1600W)
• Press on the panel for the high setting (2500W)
• Press again to switch off the heater.

Operation
Care and Maintenance
• When disconnected from the electrical
supply, clean the outside of the patio heater
with a damp cloth. Never use corrosive or
solvent cleaners or immerse in water.
• Any maintenance or repairs including
replacing the halogen tube should only be
carried out by a qualified electrician or by a
recommended service center.
Storage
If the heater will not be used for a long
period of time, store, it in a cool, dry location,
to prevent dust and dirt build-up, use the
original packaging to repack the heater.
Technical Specification
• Ratings: 220-240V 50Hz
• Wattage max: 2500W
• Insulation: class 1
This product contains recyclable materials.
Do not dispose this product as unsorted
municipal waste. Please contact your local
municipality for the nearest collection point.
WEEE

Notes

Notes

Maintenance and Care Instructions
• When disconnected from the electrical supply, clean the outside of the patio heater with a
damp cloth. Never use corrosive or solvent cleaners or immerse in water.
• Any maintenance or repairs including replacing the halogen tube should only be carried out by
a qualified electrician or by a recommended service center.
• Check all components regularly for correct function, damage and loose connections especially
at the start of the season and at 1-2 month intervals dependent on use.
• Damaged components may endanger your safety or shorten the life of the product. Replace all
damaged parts immediately. Use only spare parts manufactured by Kettler. Should you wish to
purchase spare parts, they can be ordered directly from: www.kettler.co.uk/shop
• Kettler will not be responsible for damaged caused by improper use.
Storage
• If the heater will not be used for a long period of time, store it in a cool, dry location when not
in use. To prevent dust and dirt build-up, use the original packaging to repack the unit.
www.kettler.co.uk
Warranty For Home Use
This product is covered by a 12 month
warranty against manufacturing faults.
This warranty applies to domestic use
only. It does not cover commercial use,
mis-use or accidental damage.
To validate your warranty, register
at www.kettler.co.uk and quote
the product code from the front of
this booklet.
12Mth
Warranty