KNEX Education STEM EXPLORATIONS Instruction Manual

1
CAUTION-ELECTRIC TOY:
Not recommended for children under 10 years of age.
As with all electric products, precautions should be
observed during handling and use to prevent electric shock.
• The product should be examined periodically for potential hazards; any potentially
hazardous components should be repaired or replaced.
• The toy must only be used with the recommended transformer.
• The transformer is not a toy.
• The transformer used with the toy is to be regularly examined for damage to the
cord, plug, enclosure and other parts, and in the event of such damage, they must
not be used until the damage has been repaired.
• Disconnect transformer before cleaning any components.
Keep these instructions in a handy location.
They contain important safety information.
Read all warnings and instructions before you
start to build and operate the model.
WARNING: CHOKING HAZARD -
Small parts. Not for children under 3 years.
CAUTION: Keep hair, hands, face, clothing and power cords away from all moving
parts.
Do not put rods smaller than 2 inches in any openings of the motor; they will damage
the motor, and cannot be removed. Use care where you use these models. They could
damage furniture or walls, or injure people or pets.
K’NEX BUILDING BASICS
Start Building
To begin your model, nd the and follow the numbers. Each
piece has its own shape and color. Just look at the pictures, nd
the pieces in your set that match and then connect them together.
Try to face your model in the same direction as the instructions
while you build. The arrows show you where the parts connect,
but not all connections points have arrows. Faded colors show
you this section is already built.
Connectors
There are blue and gray connectors with special long slots.
They slide together as you see in the pictures. Push these parts
together until you hear a “click.”
Spacers
There are places in your model where you need to add blue and
silver spacers. Be sure to use the right color and count them
carefully.
INPUT: 120 Vac60 Hz 0.6 A
OUTPUT: 6 Vdc 2000 mA
2
3
1
1
12
-

22
WARNING: Changes or modifications to this unit not expressly approved by the party
responsible for the compliance could void the users right to operate the equipment.
This device complies with Part 15 of the FCC Rules.
Operation is subject to the following two conditions:
1. This device may not cause harmful interference and
2. This device must accept any interference received, including interference that may cause
undesired operation. This model is tested to comply with FCC standards - FOR HOME OR
OFFICE USE. This equipment has been tested and found to comply with the limits for a Class B
digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide
reasonable protection against harmful interference in a residential installation. This equipment
generates, uses and can radiate radio frequency energy, and, if not installed and used in
accordance with the instructions, may cause harmful interference to radio communications.
However, there is no guarantee that interference will not occur in a particular installation.
If this equipment does cause harmful interference to radio or television reception, which can be
determined by turning the equipment off and on, the user is encouraged to try to correct the inter-
ference by one or more of the following measures: (1) Reorient or relocate the receiving antenna.
(2) Increase the separation between the equipment and receiver. (3) Consult the dealer or an
experienced radio/TV technician. (4) Connect the equipment into an outlet on a circuit
different from that to which the receiver is connected. This Class B digital apparatus complies with
Canadian ICES-003.
FCC Statements:
PARTS LIST

3
K’NEX Car
1
1
x4
x4

44
1 2
-
1 4
-
2
3
4
12
-
1
1
1
1

5
15
-
6
1 6
-
5
14
-
1 5
-

66
1 7
-
1 8
-
7
8
16
-
17
-

7
1 9
-
9
10
1 10
-
18
-
19
-

88
11
12
13
14
110
-
1 14
-

9
Tabletop Car
1
1