Larson Electronics GAU-KFA-PH-600K-TST User manual

GAU-KFA-PH-600K-TST
Larson Electronics, LLC Phone: [phone] Fax: [phone] www.larsonelectronics.com 1of 16
Cart Mounted Forced Air Heater
120V - Kerosene/Diesel - 3000 CFM, 600000 BTUs - 40 Gal Tank - Blue
Instruction Manual
Thank you for your purchase of the Larson Electronics GAU-KFA-PH-600K-TST.
WARNING:
READ CAREFULLY BEFORE INSTALLING FIXTURE. RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE.
CRITICAL SAFETY INSTRUCTIONS:
•INSTALLATION SHOULD ONLY BECONDUCTED BY A QUALIFIED ELECTRICIAN IN ACCORDANCE WITH NEC AND ANY
RELEVANT LOCAL BUILDING CODES.
•RISK OFFIRE OR ELECTRIC SHOCK. FIXTURE INSTALLATION REQUIRES KNOWLEDGE OF FIXTURE'S ELECTRICAL
SYSTEMS. IFNOTQUALIFIED, CONTACT A QUALIFIED ELECTRICIAN.
•BE CERTAIN ELECTRICAL POWER IS OFF BEFORE AND DURING INSTALLATION AND MAINTENANCE.
•MAKE SURE THE SUPPLY VOLTAGE IS THE SAME AS THE FIXTURE'S RATED VOLTAGE.
•TO PREVENT WIRING DAMAGE OR ABRASION, DO NOT EXPOSE WIRING TO EDGES OF SHEET METAL OR SHARP
OBJECTS. SUITABLE FOR DAMP LOCATIONS.
IMPORTANT
READ CAREFULLY BEFORE INSTALLING THIS FIXTURE. SAVE THESE INSTRUCTIONS FOR FUTURE
REFERENCE. THE GAU-KFA-PH-600K-TST MUST BE WIRED IN ACCORDANCE WITH NATIONAL ELECTRICAL
CODE AND ALL APPLICABLE LOCAL CODES. PROPER GROUNDING IS REQUIRED FOR SAFETY.
WE STRONGLY ENCOURAGE ONLY A LICENSED ELECTRICIAN INSTALL, OPERATE AND MAINTAIN THIS
PRODUCT. IF YOU ARE NOT QUALIFIED OR UNFAMILIAR WITH ANY ASPECT OF THIS INSTRUCTION SHEET,
CONSULT AN ELECTRICIAN. THERE ARE NO SERVICEABLE PARTS INSIDE.
WARNING: MAKE SURE POWER IS TURNED OFF BEFORE STARTING THE
INSTALLATION OR PERFORMING ANY MAINTENANCE.
RISK OF FIRE/ELECTRIC SHOCK –DISCONNECT POWER AT BREAKER BEFORE INSTALLING OR SERVICING.
RISK OF PERSONAL INJURY –FIXTURE MAY BECOME UNSTABLE OR DAMAGED IF NOT INSTALLED PROPERLY.
RISK OF BURN –ALLOW FIXTURE TO COOL BEFORE SERVICING.
WARNING:
USER SHOULD BE TRAINED IN THE PROPER USE AND MAINTENANCE OF THIS DEVICE. THIS LINE
CORD IS INTENDED TO ALLOW OPERATORS TO EXTEND POWER TO EQUIPMENT WHEN STATIONARY OUTLETS ARE NOT
READILY AVAILABLE.
IMPROPER USE OF THIS CORD, PLUG, AND RECEPTACLE CAN LEAD TO SERIOUS INJURIES OR DEATH TO
PERSONNEL.
PERIODIC INSPECTION OF THE CORD IS NECESSARY.
THE CORD MUST BE ROUTINELY CHECKED FOR CUTS, BREAKS, OR ANY SEVERE ABRASIONS, AND IF ANY ARE FOUND,
THE CORD MUST BE REPLACED BEFORE RESUMING USE.
 GENERAL HAZARD WARNING:      
        

 
   
            
 
 
   

 

GAU-KFA-PH-600K-TST
Larson Electronics, LLC Phone: [phone] Fax: [phone] www.larsonelectronics.com 2of 16
The Larson Electronics GAU-KFA-PH-600K-TST Cart Mounted Forced Air Heater is a powerful heating solution for indoor facilities. This
kerosene/diesel unit provides 3,000 CFM of air flow and 600,000 BTUs. Equipped with a 40-gallon fuel tank, the portable heater is
mounted on a cart and comes with real-time gauges and a 6" power cord with an extension cord wrap.
WIRING
The GAU-KFA-PH-600K-TST comes with a 6" power cord for completing electrical connections and an extension cord
wrap.
We strongly encourage a licensed electrician install this product,in all locations especially in outdoor areas
where weatherproofing may be required. Universal voltage driver permits operation at 120V AC @ 60Hz.
MOUNTING
The GAU-KFA-PH-600K-TST is mounted on a cart with two wheels and front/rear handles for portability and seamless
transportation around the work site.
Warning: Check product label for correct input voltage!
Attach supply line wires to the appropriate light fixture wires as shown
in thediagram 
Secure each pair of wires according to the diagram. Utilize a junction box or
similar device and take precautionary steps for weatherproofing all
connections if installed in a location where water may come in contact with the
unit. Ensure the unit is properly grounded and that wiring is done according to
all local and national electrical/building codes.
Standard Cord Cap
This unit comes pre-wired from factory with the selected cord cap. Take
precautionary steps for weatherproofing all connections if installed in a
location where water may come in contact with the unit. All outdoor
installations and indoor installations near a wet location require the use of a
GFCI device for safety, according to the National Electrical Code® (NEC).
Ensure the unit is properly grounded.

Table of Contents











   
a    
    
          
      


        
     
        



   
a     
  
 
        
         

 


 
  


 
 



 




Safety Information
 
 

 

�    

 

 






   

 





 











 


I 













 

 




GAU-KFA-PH-600K-TST
Larson Electronics, LLC Phone: [phone] Fax: [phone] www.larsonelectronics.com 3of 16



  





 



 







  


    



Top 
 
Front  

   

 


 
Figure 1.  G 
GAU-KFA-PH-600K-TST
Larson Electronics, LLC Phone: [phone] Fax: [phone] www.larsonelectronics.com 4of 16

Unpacking




NOTE: 
Assembly
 



 
Figure 2.  G 


\

GAU-KFA-PH-600K-TST
Larson Electronics, LLC Phone: [phone] Fax: [phone] www.larsonelectronics.com 5of 16

Assembly
 
 
 
 
  '
 
 
   
 
 ti  
  

   
®®®®  mm
®®®® 
 

  






 

 

  

 

 




 
 Do not operate heater without support
 ame lly assembled.
GAU-KFA-PH-600K-TST
Larson Electronics, LLC Phone: [phone] Fax: [phone] www.larsonelectronics.com 6of 16

Operation










 
 
above.
 




     
 
 








 

 








 

 
   
      




 



 

   


   
I� 
I   1s  
a     


 
    
A
CAUTION    
 

   
A
CAUTION 
 




   
 
 



 
 
   

 
 

 

GAU-KFA-PH-600K-TST
Larson Electronics, LLC Phone: [phone] Fax: [phone] www.larsonelectronics.com 7of 16




 
   


 
 �)
/
   176°F / 80°C
 

 149°F / 65°C

 




 















   





 
A CAUTION 


 


 
GAU-KFA-PH-600K-TST
Larson Electronics, LLC Phone: [phone] Fax: [phone] www.larsonelectronics.com 8of 16

Operation (Continued)
 
 

 

 
 

 

 
 
  
 

.,
Drain Bolt
 
 
GAU-KFA-PH-600K-TST
Larson Electronics, LLC Phone: [phone] Fax: [phone] www.larsonelectronics.com 9of 16

Maintenance
W'
ARN ING 
a  











 



 
 

 
 

 
 
 
 
  

 

 
 
 
 
 
 

 

  

 
  

 
 

Photocell

 
 
 
  
 
 






 
 
 

 
 
 
 
GAU-KFA-PH-600K-TST
Larson Electronics, LLC Phone: [phone] Fax: [phone] www.larsonelectronics.com 10of 16