Life Fitness SBWBE User manual

Back Extension
Owner’s Manual

2
Tools Required:
O7mm Allen Wrench
O17mm Wrench
ORatchet
O3” Ratchet Extension
O17mm Socket
O7mm Hex Bit
Back Extension
1. Assembly Instructions
Qty
1
1
2
10
2
1
10
2
1
2
2
2
2
1
Description
Front Foot
Center Frame
M10 x 135mm Bolt
Flat Washer
Nylock Nut
Waist Frame
M10 x 25mm Bolt
Spacer
Hole Plug
Roller Pad
Plate
Bearing Cap
Angle Pad
Gas Spring
Part Number
78770XX
78761XX
3256221
3102514
3242002
78768XX
3256202
7385203
3237403
7424701
7322301
7308701
7877101
3235702
Item
1
2
3
4
5
6
7
8
9
10
11
12
13
14

1. Attach the FRONT FOOT (1) to the CENTER FRAME (2) using two M10 x
135mm BOLTS (3), FLAT WASHERS (4), and NYLOCK NUTS (5). Tighten
the BOLTS and NUTS securely.
2. With the WAIST FRAME (6) positioned as shown, carefully slide the
WAIST FRAME into the CENTER FRAME (2). Pull the POSITIONING PIN
(A) upward to allow the WAIST FRAME to slide past. Release the POSI-
TIONING PIN and allow the pin to engage the WAIST FRAME.
Slide the GLIDE CAP (B) downward and into the top of the CENTER
FRAME (2). Secure the GLIDE CAP using two M10 x 25mm BOLTS (7) and
SPACERS (8). Tighten the BOLTS securely.
Insert the SMALL HOLE PLUG (9) into the access hole located opposite
the POSITIONING PIN (A)
3

4
3. Attach one ROLLER PAD (10) to a CENTER FRAME SHAFT (C) using ONE
PLATE (11), M10 x 25mm BOLTS (7) and BEARING CAP (12). Tighten the
BOLTS securely.
Repeat for the remaining ROLLER PAD (10).
4. Attach the ANGLE PADS (13) to the WAIST FRAME (6) as shown using six
M10 x 25mm BOLTS (7) and FLAT WASHERS (4). Tighten the BOLTS
securely.
5. Snap the GAS SPRING (14) to the CENTER FRAME (2) and WAIST FRAME
(6) as shown.
Be sure the GAS SPRING snaps securely to the mounting posts.
Back Extension
1. Assembly Instructions

It is the sole responsibility of the purchaser of Life Fitness products to instruct all individuals, whether they are the end user or supervising personnel on
proper usage of the equipment.
It is recommended that all users of Life Fitness exercise equipment be informed of the following information prior to its use.
PROPER USAGE
1. Do not use any equipment in any way other than designed or intended by the manufacturer. It is imperative that all Life Fitness equipment is used
properly to avoid injury.
2. Keep hands and feet clear at all times from moving parts to avoid injury.
3. It is the purchaser's sole responsibility to properly instruct end users and supervising personnel as to the proper operating procedures of all Life
Fitness equipment.
CHECK FOR DAMAGED PARTS
1. DO NOT use any equipment that is damaged and or has worn or broken parts. Use only replacement parts supplied by Life Fitness.
2. MAINTAIN LABELS AND NAMEPLATES. Do not remove labels for any reason. They contain important information. If unreadable or missing, con-
tact LIFE FITNESS for a replacement.
3. SECURE EQUIPMENT. All equipment MUST be secured to the floor to stabilize and eliminate rocking or tipping over. This must be performed by a
licensed contractor.
4. Ensure that any person(s) making adjustments or performing maintenance or repair of any kind is qualified to do so. Life Fitness will provide serv-
ice and maintenance training at our corporate facility upon request or in the field if appropriate arrangements are made.
SPECIFIC OPERATING WARNINGS
1. Do not allow users to wear loose fitting clothing while using equipment. It is also recommended to have users secure long hair back and up to
avoid contact with moving parts.
2. It is the purchaser's sole responsibility to properly instruct end users and supervising personnel as to the proper operating procedures of all Life
Fitness equipment.
3. Keep children away from strength equipment. Parent or others supervising children must provide close supervision of children if the equipment is
used in the presence of children.
4. UNDERSTANDING EACH AND EVERY WARNING TO THE FULLEST EXTENT IS IMPORTANT. IF ANY OF THESE WARNINGS ARE UNCLEAR, ASK
FOR CLARIFICATION FROM LIFE FITNESS PERSONNEL.
5. It is recommended that all individuals consult a physician prior to commencing an exercise program. If at any time during exercise a exerciser
feels faint, dizzy or experience pain, he/she should stop and consult a physician.
5
Back Extension
2. Safety & Warranty

6
WARRANTY
WHAT IS COVERED
This Life Fitness commercial exercise equipment (Back Extension) is warranted to be free of all defects in material and workmanship.
WHO IS COVERED
The manufacturer’s warranty covers the original purchaser or any person receiving the Product as a gift from the original purchaser.
WHO PAYS TRANSPORTATION & INSURANCE FOR SERVICE
If the Product or any covered part must be returned to a service facility for repairs, Life Fitness, will pay all transportation and insurance charges for the
first year. The purchaser is responsible for transportation and insurance charges during the second and third years (if applicable).
WHAT WE WILL DO TO CORRECT COVERED DEFECTS
Life Fitness will ship any new or rebuilt replacement parts or components, or, at the option of Life Fitness, replace the Product. Such replacement parts are
warranted for the remaining portion of the original warranty period.
WHAT IS NOT COVERED
Any failures or damage caused by unauthorized service, misuse, accident, negligence, improper assembly or installation, debris resulting from any con-
struction activities in the Product's environment, rust or corrosion as a result of the Product's location, alterations or modifications without our written
authorization or by failure on the purchaser’s part to use, operate and maintain the Product as set out in your Owner’s Manual (.Manual.). All terms of this
warranty are void if this Product is moved beyond the continental borders of the United States of America (excluding Alaska, Hawaii and Canada) and are
then subject to the terms provided by that country's local authorized Life Fitness representative.
OWNER’S MANUAL
It is VERY IMPORTANT THAT YOU READ THIS MANUAL before operating the Product. Remember to perform the periodic maintenance specified in the
Manual to assure proper operation and continued satisfaction with the Product.
Back Extension
2. Safety & Warranty

HOW TO GET PARTS & SERVICE
Call Customer Support Services at [phone] or [phone], Monday through Friday from 8:00 a.m. to 6:00 p.m. Central Standard Time. Have the
following information available when calling; name, address and serial number of the Product. Life Fitness will provide information on how to obtain a
replacement part, advice on how and where to ship the Product for service or, if necessary, arrange for on-site service.
Before shipping the Product:
1. Obtain a Return Authorization Number (RA#) from Customer Support Services
2. Securely pack your Product (use the original shipping carton, if possible)
3. Write the RA# on the outside of the carton
4. Insure the Product, and
5. Include a letter explaining the defect or problem and a copy of the proof of purchase if you believe the service is covered by warranty.
EXCLUSIVE WARRANTY
THIS LIMITED WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES OF ANY KIND EITHER EXPRESSED OR IMPLIED, INCLUDING BUT NOT LIMITED TO
THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, AND ALL OTHER OBLIGATIONS OR LIABILITIES ON
THE PART OF LIFE FITNESS. Life Fitness neither assumes nor authorizes any person to assure for Life Fitness any other obligation or liability concerning
the sale of this Product. Under no circumstances shall Life Fitness be liable under this warranty, or otherwise, of any damage to any person or property,
including any lost profits or lost savings, for any special, indirect, secondary, incidental or consequential damages of any nature arising out of the use of or
inability to use this Product. Some states do not allow the exclusion or limitation of implied warranties or of liability for incidental or consequential dam-
ages, so the above limitations or exclusions may not apply in those instances.
CHANGES IN WARRANTY NOT AUTHORIZED
No one is authorized to change, modify or extend the terms of this limited warranty.
EFFECT OF STATE LAWS
This warranty gives you specific legal rights and you may have other rights, which vary, from state to state.
THE LIFE FITNESS PLEDGE TO YOU
Life Fitness Products are designed and manufactured to the highest standards.
Life Fitness wants its customers to be completely satisfied with the its Product and will do everything possible under the terms of this warranty to keep its
customers secure in knowing they have bought the best!
7

General Specifications
1. Frame Construction
Frame is constructed of mechanical quality steel purchased in mill run quantities.
Frame is primarily 2 ½" x 4 ½" oval-shaped tubing with 11 gauge wall thickness.
2. Frame Finish
Prior to applying finish, each part is chemically washed to prepare surface for maximum adhesion.
3. Upholstery
Contoured pads.
All edges are stitched to eliminate any folds in the material that would limit durability.
4. Foam
Three and four pound EVA foam (deformation resistant) or equivalent is used on all machines. The foam is injection molded directly to the multi-
ply wood support board with integral 10mm T-nuts.
5. Hand Grips
Hand grips are an extruded 60-durometer-thermorubber compound that is non-absorbing, wear and tear resistant, and exhibits good dry and wet
frictional characteristics.
The grips are retained with aluminum collars, which eliminate the tendency of the grips to slide off the handle.
6. Foot Platforms
Foot platforms are molded rubber with a slip resistant texture.
7. Equipment Anchoring
All machines have holes in the feet, which allow for easy anchoring to the floor. Life Fitness recommends that all machines be anchored to the
floor to minimize the possibility of tipping.
8. Warranty
10-year minimum warranty on frames, 5 years on integral bearings, 1 year on grips, and 90 days on upholstery and any items not specified.
9. Liability Insurance
Certificate of insurance available upon request.
Back Extension
3. Specifications
8

Product Specifications
Body Weight Back Extension Product # - SBWBE
Machine Weight: 140 lbs. 63,5 kg.
Size: in = 54 L x 37 W x 37 H cm = 137 L x 94 W x 94 H
• Adjustable pad support to accommodate users of all sizes.
• V-shaped pad design provides greater comfort throughout range of motion.
• Lower roller pads positioned to increase stabilization and comfort throughout the exercise.
• Handles positioned for easy entry and exit without interfering with the exercise.
• Wheels for easy transportation.
9

10
ONCE A DAY
OWipe down upholstery with a mild soap and water or comparable all purpose cleaner.
ONCE A WEEK
OVisually inspect all hardware for loosening, tampering or wear.
OCheck condition of hand grips.
ONCE A MONTH
OInspect hardware and tighten any bolts or nuts that may have loosened during use.
ACTION DAILY MONTHLY BI-ANNUALLY AS NEEDED
CLEAN
Upholstery X
Hand Grips X
INSPECT
Hardware X
Frame X
Hand Grips X
CLEAN
OUpholstery with a mild soap and water.
OHand grips with mild soap and water.
INSPECT
OHardware should be checked for looseness. Tighten as required using metric tools.
OFrames should be inspected for wear or damage.
OHand grips should be checked for wear or damage.
NOTE: Use polishing compound (such as car wax) to clean and remove shoe scuffs from frame surfaces as necessary.
Back Extension
4. Maintenance

11

© 2005 Life Fitness, a division of Brunswick Corporation. All rights reserved.
Life Fitness is a registered trademark of Brunswick Corporation.
8006201 REV. A 10-28-05