Lumineux Carsington Plus Sports User manual

READ THESE INSTRUCTIONS
THOROUGHLY BEFORE
INSTALLATION KEEP THESE
INSTRUCTIONS FOR
FUTURE REFERENCE.
IMPORTANT:
This product must be installed
by a qualifi ed electrician or
competent person, and in
accordance with current building
and IET wiring regulations.
• Light Fitting
• Instruction Manual
• Driver (Purchased separately)
Carsington Plus
Sports
Floodlight
600W, 960W and 1650W
Manby Business Park, Manby, Lincolnshire, LN11 8UT
Lumineux is a B&T Associates Ltd company.
Technical Helpline: [phone]
www.lumineux.co.uk
Carsington Plus
Sports Floodlight
TOOLS REQUIRED
BOX CONTENTS
• Screwdriver
• 36mm Spanner
This lighting  xture has been properly
packed to avoid damage during
transit. Before commencing with the
installation carefully inspect the
luminaire to con rm there is no
damage. DO NOT INSTALL if any
damage has occurred to the  xture
or any of its components:
• Turn off the mains power before performing inspections, installation
or removal
• Verify that the supply voltage is correct by comparing it with the luminaire
label information
• It is the installers responsibility to ensure installation is suitable for the total
load of the luminaire(s). The supply cable, fuses/circuit brakers must be
correctly rated for the electrical load and considering for any transient
inrush currents that may occur
• Do not perform insulation strength or resistance tests on installed
luminarie(s) connected
PLEASE READ THESE INSTRUCTIONS
BEFORE INSTALLATION.
WARNING: Risk of electric shock! Isolate the
mains power before proceeding.
INSTALLATION INSTRUCTIONS
IP66
Warranty
5 YR
Hours
60,000
IK09
Lm/W
135
M2
M1
M3
M1
M2
M1
M1
M1 M2
Da Da
0-10V Dimming Connection
DALI Dimming Connection
AC Mains Connection
0-10V Dimming Connection
DALI Dimming Connection
AC Mains Connection
Da Da
M1
+
-
M1
9.5
5
+
-
M1
A E N
+
-
1 2
+
-
1 2
M1
M2
M1
+
-
1 2
+
-
3 4
+
-
1 2
+
-
3 4
M1 M2 M3
+
-
5 6
A N
A N
A N
A E N
+
-
1 2 3 4
+
-
+
-
1 2
+
-
3 4
+
-
5 6
M1 M2 M3
149.00
148. 00
31 7. 00
22.00
90.00
29.00
Ø9 .0 0
Ø15.00
22.00
90.00
29.00
Ø9 .0 0
Ø15.00
317.00
197.50
148.00
Recommend 5 core cable
Cable size Cable size
1.5mm² 45m Max
2.5mm² 90m Max
Recommend 7 core cable
Cable size Cable size
1.5mm² 45m Max
2.5mm² 90m Max
25 degrees Hois ng
Angle of elevaon 25 degree
Ver cal Hois ng
Horizontal installaon
Installation must be conducted by a qualifi ed electrician.
The Carsington has a variety of installation methods. See below:
Quick connectors for portable Control Gear
M2
M1
M3
M1
M2
M1
M1
M1 M2
Da Da
0-10V Dimming Connection
DALI Dimming Connection
AC Mains Connection
0-10V Dimming Connection
DALI Dimming Connection
AC Mains Connection
Da Da
M1
+
-
M1
9.5
5
+
-
M1
A E N
+
-
1 2
+
-
1 2
M1
M2
M1
+
-
1 2
+
-
3 4
+
-
1 2
+
-
3 4
M1 M2 M3
+
-
5 6
A N
A N
A N
A E N
+
-
1 2 3 4
+
-
+
-
1 2
+
-
3 4
+
-
5 6
M1 M2 M3
149.00
148. 00
31 7. 00
22.00
90.00
29.00
Ø9 .0 0
Ø15.00
22.00
90.00
29.00
Ø9 .0 0
Ø15.00
317.00
197.50
148.00
Recommend 5 core cable
Cable size Cable size
1.5mm² 45m Max
2.5mm² 90m Max
Recommend 7 core cable
Cable size Cable size
1.5mm² 45m Max
2.5mm² 90m Max
25 degrees Hois ng
Angle of elevaon 25 degree
Ver cal Hois ng
Horizontal installaon
M1, M2 & M3
• Hex key
6mm & 8mm
Carsington Plus Control Gear
960W
Part No: 430512
100V - 277V
1650W
Part No: 430514
100V - 277V
960W
Part No: 430526
390V - 415V
1650W
Part No: 430527
390V - 415V
1. For wiring the driver to the light, an additional H07RN-F will be required. (not supplied)
2. Remote installation of control gear: Extend M1, M2 and M3 depending on wattage
3. Use IP68 connectors supplied with control gear

Carsington Plus Sports Floodlight
The light source of this unit is not
replaceable; when the light source
reaches its end of life the whole
luminaire shall be replaced.
Disposal of Electronic Equipment
WEEE Directive 2002/96/EC This
product falls within the scope of
the Waste Electrical & Electronic
Equipment Directive (WEEE), which
means the product should not be
disposed of as normal household
waste. Please recycle where
facilities exist or check with your
Local Authority.
RoHS – All components and
materials used in this product are
RoHS 2002/95/EC compliant.
Specications may change from
time to time. The information
contained in this leaet is for
guidance only and should not be
considered as always accurate
and should be treated as
not representative.
Standard -20º to +45ºC
Technical Helpline: [phone]
DISPOSAL
WARRANTY
OPERATING TEMPERATURE
Part No. Description Watts L(mm) W(mm) H(mm)
430510-25 Carsington Plus 600W 728 538 114
430510-40 Carsington Plus 600W 728 538 114
430510-60 Carsington Plus 600W 728 538 114
430511-25 Carsington Plus 960W 580 656 138
430513-25 Carsington Plus 1650W 791 673 138
Part No. Description Watts L(mm) W(mm) H(mm)
430512 Carsington Plus Control Gear - 100V - 277V 960W 613 185 74
430526 Carsington Plus Control Gear - 390V - 415V 960W 613 185 74
430514 Carsington Plus Control Gear - 100V - 277V 1650W 628 185 119
430527 Carsington Plus Control Gear - 390V - 415V 1650W 628 185 119
CARSINGTON PLUS SPORTS FLOODLIGHT DIMENSIONS
CARSINGTON PLUS CONTROL GEAR DIMENSIONS
Revision 2
L (mm)
H (mm)W (mm)
This luminaire is warranted for a
period of 5 years from the date of
purchase. The backup battery
pack in the emergency version is
warranted for a period of 12 or 24
months*. The warranty could be
invalidated should the light tting
not be installed according to these
instructions, outside the scope of
the specication or the product
has been altered or tampered with
in any way. Please see website for
terms and conditions.
* Please see our website for more detailed information.
CARSINGTON PLUS BACK SPILL PLATE INSTALLATION
M5 screws*4pcs
Unscrew the screws
M5 inner hexagon
M5*22mm stainless steel
inner hexagon screw*4pcs
M5 stainless steel washer*4pcs
Light barrier*1pc
M5 inner hexagon
Fix light barrier,tighten M5*22mm screws and washer
Complete installation of light barrier
Light Barrier -Installation Instructions
W (mm)
L (mm) H (mm)
4mm Hex Key
4mm Hex Key
M5 22mm stainless steel
inner hexagon screw - 4pcs
M5 stainless steel
washers - 4pcs
Light barrier - 1pc