Mangar Camel User manual

Simple solutions for everyday independence
English
User Instrucons
CAMEL

2
Camel
Table of Contents
Warnings .................................................................................................................................. 3
Intended Use ........................................................................................................................... 3
Standard Product Contents .................................................................................................... 4
Connecng the Hand Control and Airo ................................................................................. 4
Switching the Airo 24 ‘On’ & ‘O .......................................................................................... 5
Posioning the paent on the Camel ...................................................................................... 5
Operang ................................................................................................................................. 5
Aer Use .................................................................................................................................. 7
Roune Cleaning ..................................................................................................................... 7
Disinfecng .............................................................................................................................. 7
Maintenance ............................................................................................................................ 7
Transportaon/Storage ..................................................................................................... 8
Disposal/Recycling ......................................................................................................... 8
Troubleshoong ............................................................................................................. 8
Specicaons ................................................................................................................. 9
Warranty ......................................................................................................................... 9
Declaraon of Conformity .............................................................................................. 10

Simple solutions for everyday independence 3
Camel
Intended Use
The Camel by Mangar Health, is an inatable liing device which is designed to sit up and li a fallen person
from the oor. When inated, the Camel lis the paent into a raised seated posion ready to stand with
or without assistance.
This equipment may be used with or without a helper as required.
The Camel is powered by a Mangar Health Airo 24 Compressor and controlled using a 4-Way Hand Control.
Please refer to the separate Airo 24 compressor instrucons before operang.
Patented
WARNINGS
• This equipment MUST only be used by persons familiar in its use.
• The medical state of a person needing to be raised MUST be assessed before commencing a li.
• Ensure that the surface on which the Camel is to be placed is free from sharp objects. NOTE: Place a
blanket, groundsheet, towel or similar under the Camel if using it on a rough surface.
• If a slide sheet has been used to transfer the paent onto the Camel it must be removed from under the
paent before commencing a li.
• Secons 2, 3 and 4 MUST always be fully inated in sequence from the boom up, in order to maintain
stability. NOTE: The backrest may be parally inated before any other secon is raised. Once the
lowest secon is fully inated, the backrest can be raised further as required.
• Do not operate the Airo 24 compressor in the presence of ammable anaesthec mixtures with air,
oxygen or nitrous oxide, as these mixtures can create a combusble environment leading to the potenal
for re or even an explosion in the presence of a spark.
Ensure that you read and understand this instrucon manual before using
this product. Failure to follow the instrucons and safety precauons in
this manual can result in damage and/or serious injury.
Please keep these instrucons in a safe locaon for future reference

4
Camel
A
B
Connecng the Hand Control and Airo 24 -
g. 2
• Remove the Camel from the carrying bag,
unfasten the straps and unroll.
• Connect the four hoses from the hand control
to the corresponding numbered and coloured
connectors on the Camel (A).
• Connect the hose (B) from the hand control to
the Airo 24 compressor.
• Posion the Airo 24 compressor so that it will
not be in the way while posioning the paent.
Ensure that the hoses are not kinked.
A
C
B
Standard Product Contents - g. 1
1 x Camel (A) (including carrying bag).
1 x 4-Way Hand Control (B).
1 x Airo 24 Compressor (C) with user instrucons.
2
1

Simple solutions for everyday independence 5
Camel
Switching the Airo 24 ‘On’ & ‘O’ - g. 3
• To switch on, momentarily press the ‘Power’
buon (A g.3). The boom baery status
indicator light (B) will come on.
• To switch o, momentarily press the ‘Power’
buon. The boom baery status indicator light
will go out.
Posioning the paent on the Camel - g. 4
• Posion the Camel at the side of the paent so
that the paent’s head is level with the Camel
badge (A). NOTE: Place a blanket, groundsheet,
towel or similar under the Camel if using it on a
rough surface.
• Transfer the paent onto the Camel. The head
should lie on the Camel badge (A) and the body
should lie centrally.
Operang
The following instrucons apply equally when
the Camel is being operated by a person raising
themselves without assistance, or by an assistant
raising a paent.
WARNING: If a slide sheet has been used to transfer
the paent onto the Camel it must be removed from
under the paent before commencing a li.
• Switch the Airo 24 to ‘On’. Press the number
1 buon on the hand control to parally inate
the backrest secon unl the paent is in a
comfortable posion - g. 5
• Press the number 2 buon to inate the boom
secon unl it becomes rigid - g. 6
A
A
B
3
4
5
6

6
Camel
• Connue to press buons 3 and 4 in sequence
unl the secons become rigid - g. 7
• Press buon 1 to fully raise the backrest and
arrive at a sing posion - g. 8
• Whether assisted or used alone, the paent
should now be in a posion to stand or transfer
- g. 9
WARNING: In order to maintain stability, secons
must always be fully inated from the boom up,
in sequence.
Note: only the backrest (secon 1) may be parally
inated before the lower secons.
7
8
9

Simple solutions for everyday independence 7
Camel
Aer Use
• To deate, disconnect each of the air hoses
from the Camel. NOTE: The inial ‘rush’ of air as
the hoses are disconnected from the Camel, can
be reduced by rst disconnecng the air hose
from the Airo 24 and then pressing each of the
buons on the hand control.
• Roll up the Camel with the hand control in the
hollow (A) - g. 10 secure the straps and place
in the carrying bag - g. 11
Roune Cleaning
Fully inate all secons of the Camel, sponge clean
with a non abrasive proprietary liquid cleaner or
disinfectant and dry thoroughly. Do not dry using
hot air.
Disinfecng
The Camel should be fully inated and pre-cleaned
by washing with detergent and water, thoroughly
rinsed and then disinfected using a 1:10 soluon of
household liquid bleach and water (1 part bleach
to 10 parts cold water). Leave the soluon on
the Camel for approximately 10 minutes before
thoroughly rinsing o with clean cold water. Allow
to air dry before storage. Do not dry using hot air.
Maintenance
Other than roune cleaning, the Camel is
maintenance free.
We recommend that a thorough examinaon of
the Camel is carried out regularly; the frequency of
examinaon may need to be increased depending
on usage and operang environment.
If required, Mangar Health can provide the above
inspecon within an annual service contract. Please
contact our Customer Service Department for
further details (UK only).
A
10
11

8
Camel
Transportaon / Storage
Disconnect the Airo 24 compressor from the Camel before transporng so as to avoid accidental
inaon of the cushion.
Ensure that the Camel is clean and thoroughly dry before storing. Failure to thoroughly dry the
cushion before storage may result in a build-up of mould on the surface of the product leading to
a weakening of the fabric and consequenal invalidaon of the product warranty. Store in a dry
environment.
To maintain the Airo 24 baery when being stored for long periods, put on charge for 16 hours
every 3 months.
Disposal / Recycling
When the Camel has reached the end of its working life, dispose of it at your local recycling centre
(civic amenity site).
When the Airo 24 has reached the end of its working life, remove the baery for safe disposal in
accordance with your local council guidelines, and dispose of the Airo 24 at your local recycling
centre (civic amenity site).
Troubleshoong
Problem Remedy
Compressor does not run when one or more of
the buons are pressed on the hand control.
Ensure that all the air hoses from the hand
control are connected to the Camel and Airo.
Compressor keeps stopping when trying to
inate the Camel. Check that there are no kinks in the air hoses.
Baery Status Indicator light ashing ‘Red’.
This happens when the compressor’s internal
temperature cut-out has tripped. Leave the
Airo for 60-90 minutes to cool.
Compressor causes electrical interference with
another piece of electrical equipment.
Move either the compressor or other item
further away from each other unl the
interference stops.
For further assistance with resolving a problem please contact our Customer Service
Department by calling [phone] or email [email protected]om

Simple solutions for everyday independence 9
Camel
Specicaons
Maximum user weight: 320kg (50 st)
Seat height (approx): 56cm
Overall length (approx): 112cm
Overall width (approx): 70cm
Deated & rolled (in bag):
Length : 76cm
Diameter: 20cm
Weight (Inc. Hand Control): 6.5kg
Maximum air pressure: 0.35bar (5psi)
Max / Min temperature: +50°C / -15°C
112 cm
56 cm
70 cm
Camel serial number: .............................
Airo 24 serial number: .............................
Date of purchase: .............................
Invoice/Delivery note number: .............................
Mangar Internaonal Ltd, trading as Mangar Health, reserves the right to alter product specicaons and/or any of the informaon
contained within this document without noce.
Warranty
The warranty is given against defects in material and workmanship and comprises piece, parts and labour.
The warranty is not valid in the case of fair wear and tear, wilful damage, common neglect, misuse or
unauthorised alteraon or repair by unqualied persons.
The following statements do not aect the consumer’s statutory rights. This product is sold on the
understanding that in the event of any defect of manufacture or material appearing within the warranty
period, the defect will be reced free of charge providing that:
(a) Reasonable evidence is provided (e.g. purchase invoice, delivery note) that the claim is being made
within the warranty period.
(b) The defect is not aributable to accidental damage (either in transit or otherwise), misuse or
unauthorised repair.

10
Camel
DECLARATION OF CONFORMITY
This is to cerfy that:-
The
Camel - HKA0050
complies with:-
The requirements for Class 1 devices according to Annex VII of the Medical
Devices Direcve 93/42/EEC as amended by 2007/47/EC
Mangar Internaonal Ltd
Presteigne, Powys, Wales,UK. LD8 2UF
tel: [phone]
fax: [phone]
heado[email protected]
www.mangarhealth.com
Signed:
Date: April 2017
C. Butcher (Finance Director)

Simple solutions for everyday independence 11
Camel

Simple solutions for everyday independence
MI0396 issue 1
(03/17)
Mangar Internaonal
Presteigne, Powys, Wales, LD8 2UF
United Kingdom
Tel: [phone]
Fax:[phone]
E-mail: [e-mail]
www.mangarhealth.com