Manitowoc MLC300 User manual

Manitowoc Cranes 9660-AM, 2019-03-27
Manitowoc, Wisconsin 54220 U.S.A. 1/65
Liftcrane Luffing Jib Capacities
Luffing Jib No. LJ11:500-501 on
Boom No. B65:505-500
with Mast No. M11:503
135 100 kg VPC (Variable Position Counterweight)
360 Degree Rating
ASME B30.5
MLC300
VPC-MAX
SERIES 1
LIFTING CAPACITIES: Lifting capacities for
various boom lengths, boom angles, luffing jib
lengths, and luffing jib operating radii are for freely
suspended loads
and may be based on percent of static
tipping or strength of structural components.
Capacities must
be reduced by applicable deducts.
Upper luffing jib point capacity for liftcrane service with single
part whip line is 16 600 kg or 33 300 kg with two part whip
line. In all cases, upper luffing jib point capacities cannot
exceed those listed for main luffing jib capacity.
Weight of all load blocks, hooks, weight ball, slings, hoist
lines, etc., beneath boom and luffing jib point sheaves is
considered part of load. Boom and luffing jib are not to be
lowered beyond radii where combined weights are greater
than rated capacity. Where no capacity is shown, operation
is not intended or approved.
LUFFING JIB BACKWARD STABILITY: Capacities
indicated by (b) require 2 270 kg minimum weight suspended
beneath luffing jib point, (c) require 4 540 kg minimum
weight, and (d) require 9 080 kg minimum weight. Caution:
Do not luff into areas indicated by (b), (c), or (d) without
required minimum weight. Luffing jib may not luff down and
luffing hoist wire rope may go slack. Luffing hoist wire rope
may overhaul luffing jib and cause wire rope damage or
failure.
OPERATING CONDITIONS: Machine to operate on a firm,
level, and uniformly supporting surface. Supporting surface
and bearing turntable are to be level within a tolerance of
13 mm in 3 m. During operation, boom must be maintained
at one of the selected angles shown in chart. Refer to Luffing
Jib Rigging No. 84050217, Mast Rigging No. 84045340,
Wire Rope Specifications chart No. 9668-A, Counterweight
Arrangements chart No. 9345-A, Luffing Jib Raising
Procedure chart No. 9665-AM, and Wind Conditions chart
No. 9667-A. Crane operator judgment must be used to allow
for dynamic load effects of swinging, hoisting or lowering,
travel, wind conditions, as well as adverse operating
conditions and physical machine depreciation. Refer to the
Operator Manual for operating guidelines.
MACHINE TRAVEL: Machine to travel on a firm, level, and
uniformly supporting surface. Boom and luffing jib must be
within angle range shown in capacity chart. Refer to
Maximum Allowable Travel Specifications chart No. 9666-A.
OPERATING RADIUS: Operating radius is
horizontal distance from axis of rotation to center of
vertical hoist line or load block.
BOOM ANGLE: Boom angle in degrees (°) is
angle between horizontal and centerline of boom
butt and inserts.
LUFFING JIB ANGLE: Luffing jib angle in
degrees (°) is angle between horizontal and
centerline of luffing jib butt and inserts, and is an
indication of operating radius. In all cases, operating
radius shall govern capacity.
LUFFING JIB POINT ELEVATION: Luffing jib
point elevation is vertical distance from ground level
to centerline of luffing jib point shaft.
MACHINE EQUIPMENT: Machine equipped with VPC-MAX,
9 700 mm crawlers, 1 219 mm or 1 524 mm treads,
9 144 mm live mast, 30,0 m mast, 10 part boom hoist
reeving, boom support straps, 14 part luffing jib hoist reeving,
luffing jib and backstay support straps, and 135 100 kg VPC.
Select counterweight position from Luffing Jib Raising
Procedure chart No. 9665-AM that will allow raising and
lowering of boom and luffing jib length. Counterweight
position selection may be changed with luffing jib on ground
or while luffing jib is within operating range of capacity chart.
REFERENCE ONLY!

9660-AM, 2019-03-27 Manitowoc Cranes
2/65 Manitowoc, Wisconsin 54220 U.S.A.
MLC300
VPC-MAX S-1 ASME B30.5
Explanation of Symbols
LJ11
+
B65
Luffing Jib No. LJ11:500-501
+
Boom No. B65:505-500
VPC (Variable Position Counterweight)
360°
360 Degree Rating
Boom Length
Luffing Jib Length
Boom Angle
(see page 1)
REFERENCE ONLY!

Manitowoc Cranes 9660-AM, 2019-03-27
Manitowoc, Wisconsin 54220 U.S.A. 3/65
MLC300
VPC-MAX S-1 ASME B30.5
Explanation of Symbols
(continued)
Operating Radius
(see page 1)
Luffing Jib Angle
(see page 1)
Luffing Jib Elevation
(see page 1)
Counterweight Position
from Axis of Rotation
Lifting Capacities
(see page 1)
REFERENCE ONLY!

9660-AM, 2019-03-27 Manitowoc Cranes
4/65 Manitowoc, Wisconsin 54220 U.S.A.
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 24,0 m
85° 83° 80°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
15,2 71,7 78,9 147 200d147 200d15,2
16,0 69,8 78,6 141 200d141 200d16,0
18,0 64,5 77,7 123 300b123 300b18,0
20,0 59,0 76,5 107 900b107 900b64,2 77,4 117 300b134 300b20,0
22,0 53,0 75,0 96 400 96 400 58,6 76,2 104 100b117 000b66,4 77,3 100 400c125 500c22,0
24,0 46,6 73,2 87 200 87 200 52,7 74,7 93 300 103 600 60,9 76,3 89 900b112 600b24,0
26,0 39,3 70,9 79 900 79 900 46,2 72,9 84 300 93 300 55,2 74,9 81 300 101 900 26,0
28,0 30,5 67,8 74 400 74 400 38,9 70,5 76 900 85 300 48,9 73,2 74 200 93 200 28,0
30,0 17,7 62,9 68 600 68 600 29,9 67,4 70 600 79 000 42,0 71,1 68 100 85 600 30,0
32,0 16,7 62,2 64 900 74 000 33,8 68,4 62 800 79 000 32,0
34,0 23,1 64,3 58 100 73 300 34,0
36,0 36,0
38,0 38,0
40,0 40,0
42,0 42,0
44,0 44,0
46,0 46,0
48,0 48,0
REFERENCE ONLY!

Manitowoc Cranes 9660-AM, 2019-03-27
Manitowoc, Wisconsin 54220 U.S.A. 5/65
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 24,0 m
75° 70° 65°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
15,2 15,2
16,0 16,0
18,0 18,0
20,0 20,0
22,0 22,0
24,0 24,0
26,0 26,0
28,0 28,0
30,0 57,0 74,3 63 900 81 400 30,0
32,0 51,0 72,7 58 900 75 200 32,0
34,0 44,3 70,8 54 600 69 900 34,0
36,0 36,6 68,2 50 800 65 100 52,6 71,7 47 500 61 800 36,0
38,0 26,9 64,7 47 400 60 900 46,1 69,8 44 400 57 800 38,0
40,0 38,7 67,5 41 600 54 300 40,0
42,0 29,7 64,3 39 000 51 000 47,3 68,3 36 000 48 400 42,0
44,0 16,3 59,1 36 600 48 000 40,1 66,1 33 900 45 600 44,0
46,0 31,5 63,1 31 900 43 100 46,0
48,0 19,5 58,5 30 000 40 800 48,0
REFERENCE ONLY!

9660-AM, 2019-03-27 Manitowoc Cranes
6/65 Manitowoc, Wisconsin 54220 U.S.A.
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 30,0 m
85° 83° 80°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
16,8 72,4 84,7 116 600c116 600c16,8
18,0 69,9 84,3 115 200b115 200b18,0
20,0 65,7 83,4 110 400b110 400b69,7 84,0 114 700b115 500b20,0
22,0 61,4 82,3 97 700 97 700 65,5 83,1 103 600b112 300b22,0
24,0 56,9 81,0 87 800 87 800 61,2 82,0 92 900 105 400 24,0
26,0 52,1 79,5 79 700 79 700 56,6 80,7 84 000 95 700 63,0 82,0 80 800 101 500 26,0
28,0 46,9 77,7 73 400 73 400 51,8 79,2 76 600 86 600 58,5 80,8 73 800 92 700 28,0
30,0 41,3 75,5 68 100 68 100 46,6 77,4 70 300 79 300 53,8 79,4 67 700 85 200 30,0
32,0 34,8 72,8 63 800 63 800 40,9 75,2 64 900 73 200 48,8 77,7 62 400 78 700 32,0
34,0 27,0 69,2 60 500 60 500 34,4 72,4 60 200 68 400 43,3 75,7 57 900 73 100 34,0
36,0 15,7 63,7 54 100 54 100 26,5 68,8 56 000 64 600 37,2 73,2 53 900 68 200 36,0
38,0 14,8 63,0 52 200 56 700 30,0 70,0 50 300 63 800 38,0
40,0 20,4 65,4 47 100 59 600 40,0
42,0 42,0
44,0 44,0
46,0 46,0
48,0 48,0
50,0 50,0
52,0 52,0
54,0 54,0
REFERENCE ONLY!

Manitowoc Cranes 9660-AM, 2019-03-27
Manitowoc, Wisconsin 54220 U.S.A. 7/65
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 30,0 m
75° 70° 65°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
16,8 16,8
18,0 18,0
20,0 20,0
22,0 22,0
24,0 24,0
26,0 26,0
28,0 28,0
30,0 30,0
32,0 59,9 80,2 58 400 74 700 32,0
34,0 55,3 78,8 54 200 69 400 34,0
36,0 50,4 77,2 50 400 64 700 36,0
38,0 45,1 75,3 47 100 60 500 38,0
40,0 39,2 72,9 44 100 56 800 51,7 76,2 41 100 53 800 40,0
42,0 32,4 70,0 41 400 53 500 46,5 74,3 38 600 50 600 42,0
44,0 23,9 66,0 39 000 50 400 40,8 72,1 36 300 47 800 44,0
46,0 34,3 69,3 34 200 45 200 47,5 72,8 31 200 42 600 46,0
48,0 26,3 65,7 32 300 42 800 41,9 70,7 29 400 40 400 48,0
50,0 14,4 59,8 30 500 40 500 35,6 68,0 27 800 38 300 50,0
52,0 28,0 64,6 26 300 36 400 52,0
54,0 17,3 59,4 24 800 34 600 54,0
REFERENCE ONLY!

9660-AM, 2019-03-27 Manitowoc Cranes
8/65 Manitowoc, Wisconsin 54220 U.S.A.
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 36,0 m
85° 83° 80°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
18,3 72,9 90,5 118 100b118 100b18,3
20,0 70,0 89,9 112 000 112 000 20,0
22,0 66,6 89,1 99 400 99 400 69,8 89,7 102 600 114 100 22,0
24,0 63,0 88,1 88 600 88 600 66,4 88,8 91 800 108 100 24,0
26,0 59,3 86,9 80 100 80 100 62,8 87,8 83 000 98 800 67,8 88,7 79 700 100 300 26,0
28,0 55,5 85,6 73 400 73 400 59,1 86,6 75 700 88 700 64,3 87,8 72 600 91 600 28,0
30,0 51,4 84,0 67 700 67 700 55,3 85,3 69 400 80 500 60,6 86,7 66 600 84 100 30,0
32,0 47,2 82,2 62 900 62 900 51,2 83,7 64 000 73 800 56,8 85,4 61 400 77 700 32,0
34,0 42,5 80,1 59 000 59 000 46,9 81,9 59 300 68 400 52,9 83,9 56 900 72 100 34,0
36,0 37,4 77,6 55 700 55 700 42,3 79,7 55 200 63 900 48,7 82,2 52 900 67 200 36,0
38,0 31,6 74,5 52 800 52 900 37,1 77,2 51 500 60 000 44,2 80,2 49 400 62 900 38,0
40,0 24,5 70,5 49 500 50 600 31,2 74,1 48 200 56 900 39,3 77,8 46 300 59 000 40,0
42,0 14,2 64,4 43 200 43 800 24,1 70,1 45 300 53 700 33,8 75,0 43 500 55 500 42,0
44,0 13,4 63,7 42 600 44 800 27,2 71,4 40 900 52 300 44,0
46,0 18,5 66,3 38 500 48 800 46,0
48,0 48,0
50,0 50,0
52,0 52,0
54,0 54,0
56,0 56,0
58,0 58,0
60,0 60,0
REFERENCE ONLY!

Manitowoc Cranes 9660-AM, 2019-03-27
Manitowoc, Wisconsin 54220 U.S.A. 9/65
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 36,0 m
75° 70° 65°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
18,3 18,3
20,0 20,0
22,0 22,0
24,0 24,0
26,0 26,0
28,0 28,0
30,0 30,0
32,0 32,0
34,0 61,8 85,9 52 900 68 100 34,0
36,0 58,1 84,7 49 200 63 500 36,0
38,0 54,2 83,3 45 900 59 400 38,0
40,0 50,0 81,7 43 000 55 700 40,0
42,0 45,7 79,8 40 400 52 400 55,2 82,2 37 100 49 400 42,0
44,0 40,9 77,5 38 000 49 400 51,1 80,6 34 800 46 500 44,0
46,0 35,6 74,9 35 800 46 700 46,8 78,8 32 800 44 000 46,0
48,0 29,4 71,6 33 800 44 300 42,2 76,7 31 000 41 700 51,9 79,1 27 700 39 100 48,0
50,0 21,6 67,1 32 000 42 000 37,0 74,1 29 200 39 500 47,6 77,3 26 100 37 100 50,0
52,0 31,1 71,0 27 600 37 500 43,0 75,2 24 600 35 200 52,0
54,0 23,9 66,9 26 100 35 700 38,0 72,8 23 300 33 500 54,0
56,0 13,0 60,4 24 600 33 900 32,3 69,8 22 000 31 900 56,0
58,0 25,4 65,9 20 800 30 400 58,0
60,0 15,7 60,2 19 600 29 000 60,0
REFERENCE ONLY!

9660-AM, 2019-03-27 Manitowoc Cranes
10/65 Manitowoc, Wisconsin 54220 U.S.A.
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 42,0 m
85° 83° 80°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
19,8 73,3 96,3 101 000 101 000 19,8
20,0 73,0 96,3 100 200 100 200 20,0
22,0 70,1 95,6 92 400 92 400 22,0
24,0 67,1 94,8 85 000 85 000 69,9 95,3 91 200 92 300 24,0
26,0 64,1 93,8 78 300 78 300 67,0 94,5 82 500 85 100 26,0
28,0 61,0 92,7 72 300 72 300 63,9 93,5 75 200 78 500 28,0
30,0 57,8 91,5 66 800 66 800 60,8 92,4 69 000 72 400 65,2 93,5 66 100 81 400 30,0
32,0 54,5 90,1 61 900 61 900 57,6 91,2 63 500 67 000 62,1 92,4 60 900 75 200 32,0
34,0 51,0 88,5 57 500 57 500 54,3 89,8 58 900 62 100 58,9 91,2 56 400 69 600 34,0
36,0 47,3 86,7 53 500 53 500 50,8 88,2 54 800 57 600 55,7 89,9 52 500 64 500 36,0
38,0 43,4 84,6 49 900 49 900 47,1 86,3 51 200 53 600 52,2 88,4 49 000 59 800 38,0
40,0 39,2 82,2 46 600 46 600 43,2 84,3 47 900 50 000 48,6 86,7 45 900 55 600 40,0
42,0 34,5 79,5 43 600 43 600 38,9 81,9 45 000 46 700 44,8 84,7 43 100 51 800 42,0
44,0 29,1 76,1 40 900 40 900 34,2 79,1 42 400 43 700 40,7 82,4 40 600 48 300 44,0
46,0 22,6 71,7 38 400 38 400 28,8 75,6 40 000 41 000 36,2 79,8 38 300 45 200 46,0
48,0 13,1 65,0 34 400 34 400 22,2 71,2 37 800 38 500 31,1 76,7 36 200 42 400 48,0
50,0 12,3 64,3 35 500 35 700 25,1 72,7 34 200 39 800 50,0
52,0 17,1 67,2 32 400 37 400 52,0
54,0 54,0
56,0 56,0
58,0 58,0
60,0 60,0
62,0 62,0
64,0 64,0
66,0 66,0
REFERENCE ONLY!

Manitowoc Cranes 9660-AM, 2019-03-27
Manitowoc, Wisconsin 54220 U.S.A. 11/65
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 42,0 m
75° 70° 65°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
19,8 19,8
20,0 20,0
22,0 22,0
24,0 24,0
26,0 26,0
28,0 28,0
30,0 30,0
32,0 32,0
34,0 34,0
36,0 36,0
38,0 59,9 90,6 45 400 58 800 38,0
40,0 56,7 89,3 42 500 55 200 40,0
42,0 53,3 87,8 39 900 51 900 42,0
44,0 49,8 86,1 37 500 49 000 44,0
46,0 46,0 84,3 35 400 46 300 54,2 86,7 32 000 43 400 46,0
48,0 42,0 82,1 33 400 43 800 50,7 85,1 30 200 41 100 48,0
50,0 37,7 79,6 31 600 41 600 47,0 83,3 28 500 39 000 50,0
52,0 32,8 76,6 30 000 39 500 43,1 81,2 27 000 37 100 51,4 83,6 23 800 34 600 52,0
54,0 27,1 73,0 28 400 37 600 38,8 78,8 25 500 35 300 47,7 81,8 22 500 32 900 54,0
56,0 19,9 68,1 27 000 35 800 34,1 76,0 24 200 33 600 43,8 79,8 21 300 31 400 56,0
58,0 28,7 72,6 22 900 32 000 39,6 77,4 20 100 29 900 58,0
60,0 22,0 68,1 21 700 30 600 35,0 74,7 19 100 28 600 60,0
62,0 12,0 61,0 20 500 29 200 29,7 71,4 18 100 27 300 62,0
64,0 23,4 67,2 17 100 26 100 64,0
66,0 14,4 60,9 16 100 24 900 66,0
REFERENCE ONLY!

9660-AM, 2019-03-27 Manitowoc Cranes
12/65 Manitowoc, Wisconsin 54220 U.S.A.
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 48,0 m
85° 83° 80°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
21,3 73,5 102,2 91 600 91 600 21,3
22,0 72,7 102,0 91 100 91 100 22,0
24,0 70,2 101,2 89 600 89 600 24,0
26,0 67,6 100,4 83 700 83 700 70,0 101,0 81 400 90 000 26,0
28,0 64,9 99,5 75 700 75 700 67,4 100,2 74 100 88 000 28,0
30,0 62,3 98,5 69 100 69 100 64,8 99,2 67 900 84 300 30,0
32,0 59,5 97,3 63 600 63 600 62,1 98,2 62 500 78 500 65,9 99,2 59 700 76 000 32,0
34,0 56,7 96,0 59 100 59 100 59,3 97,0 57 800 71 700 63,2 98,2 55 300 70 500 34,0
36,0 53,7 94,6 55 200 55 200 56,5 95,7 53 700 66 000 60,5 97,1 51 300 65 600 36,0
38,0 50,6 93,0 51 600 51 900 53,5 94,3 50 100 61 300 57,7 95,8 47 800 61 300 38,0
40,0 47,4 91,2 48 300 49 000 50,5 92,6 46 900 57 200 54,8 94,4 44 800 57 500 40,0
42,0 44,0 89,1 45 400 46 400 47,2 90,8 44 000 53 300 51,7 92,9 42 000 54 000 42,0
44,0 40,4 86,9 42 700 44 200 43,8 88,8 41 400 49 500 48,6 91,1 39 500 50 900 44,0
46,0 36,5 84,2 40 200 42 300 40,2 86,5 39 000 46 100 45,3 89,2 37 200 48 100 46,0
48,0 32,1 81,2 38 000 40 400 36,3 83,9 36 900 43 100 41,7 87,0 35 100 45 500 48,0
50,0 27,1 77,5 36 000 37 900 31,9 80,8 34 900 40 300 37,9 84,5 33 200 43 200 50,0
52,0 21,1 72,8 33 900 35 200 26,8 77,1 33 000 37 800 33,7 81,6 31 500 41 000 52,0
54,0 12,2 65,7 28 500 28 500 20,7 72,3 31 300 35 100 29,0 78,2 29 800 38 900 54,0
56,0 11,5 64,9 28 600 29 400 23,4 74,0 28 300 36 500 56,0
58,0 15,9 68,0 26 900 34 000 58,0
60,0 60,0
62,0 62,0
64,0 64,0
66,0 66,0
68,0 68,0
70,0 70,0
REFERENCE ONLY!

Manitowoc Cranes 9660-AM, 2019-03-27
Manitowoc, Wisconsin 54220 U.S.A. 13/65
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 48,0 m
75° 70° 65°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
21,3 21,3
22,0 22,0
24,0 24,0
26,0 26,0
28,0 28,0
30,0 30,0
32,0 32,0
34,0 34,0
36,0 36,0
38,0 38,0
40,0 61,3 96,3 41 100 53 900 40,0
42,0 58,6 95,1 38 500 50 700 42,0
44,0 55,7 93,8 36 200 47 700 44,0
46,0 52,7 92,3 34 000 45 100 46,0
48,0 49,6 90,6 32 100 42 700 56,4 92,7 28 400 39 800 48,0
50,0 46,3 88,8 30 200 40 400 53,5 91,2 26 800 37 700 50,0
52,0 42,9 86,7 28 600 38 400 50,4 89,6 25 200 35 800 52,0
54,0 39,1 84,3 27 000 36 500 47,2 87,8 23 800 34 000 54,0
56,0 35,1 81,5 25 600 34 800 43,8 85,7 22 500 32 400 51,0 88,0 19 500 30 100 56,0
58,0 30,6 78,3 24 200 33 100 40,1 83,4 21 300 30 900 47,8 86,3 18 400 28 600 58,0
60,0 25,3 74,3 22 900 31 600 36,2 80,8 20 100 29 400 44,4 84,3 17 300 27 300 60,0
62,0 18,6 69,1 21 700 30 200 31,8 77,7 19 000 28 100 40,8 82,0 16 400 26 000 62,0
64,0 6,7 59,4 20 500 28 800 26,7 74,0 18 000 26 800 36,9 79,4 15 400 24 900 64,0
66,0 20,5 69,2 17 000 25 700 32,6 76,4 14 600 23 800 66,0
68,0 11,2 61,6 16 000 24 500 27,7 72,9 13 700 22 700 68,0
70,0 21,8 68,3 12 900 21 700 70,0
REFERENCE ONLY!

9660-AM, 2019-03-27 Manitowoc Cranes
14/65 Manitowoc, Wisconsin 54220 U.S.A.
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 54,0 m
85° 83° 80°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
22,9 73,7 108,0 77 300 77 300 22,9
24,0 72,4 107,6 73 700 73 700 24,0
26,0 70,2 106,9 67 700 67 700 26,0
28,0 67,9 106,1 62 200 62 200 70,1 106,6 67 600 67 600 28,0
30,0 65,6 105,2 57 200 57 200 67,8 105,8 62 100 62 100 30,0
32,0 63,2 104,2 52 600 52 600 65,5 104,9 57 100 57 100 68,7 105,7 59 200 64 300 32,0
34,0 60,8 103,1 48 500 48 500 63,1 103,9 52 600 52 600 66,4 104,9 54 700 59 300 34,0
36,0 58,3 101,9 44 700 44 700 60,7 102,8 48 500 48 500 64,1 103,9 50 800 54 600 36,0
38,0 55,7 100,5 41 300 41 300 58,2 101,6 44 700 44 700 61,6 102,8 47 400 50 300 38,0
40,0 53,1 99,1 38 200 38 200 55,6 100,2 41 300 41 300 59,2 101,7 44 300 46 400 40,0
42,0 50,4 97,4 35 400 35 400 53,0 98,8 38 200 38 200 56,7 100,4 41 500 42 900 42,0
44,0 47,5 95,6 32 800 32 800 50,2 97,1 35 400 35 400 54,0 98,9 39 000 39 600 44,0
46,0 44,5 93,6 30 400 30 400 47,4 95,3 32 800 32 800 51,3 97,4 36 700 36 700 46,0
48,0 41,4 91,4 28 200 28 200 44,4 93,3 30 400 30 400 48,5 95,6 34 000 34 000 48,0
50,0 38,0 88,9 26 200 26 200 41,2 91,1 28 200 28 200 45,6 93,7 31 500 31 500 50,0
52,0 34,3 86,1 24 300 24 300 37,8 88,6 26 200 26 200 42,5 91,6 29 200 29 200 52,0
54,0 30,2 82,8 22 600 22 600 34,1 85,7 24 300 24 300 39,2 89,2 27 100 27 100 54,0
56,0 25,5 78,9 21 000 21 000 30,0 82,4 22 600 22 600 35,6 86,5 25 200 25 200 56,0
58,0 19,8 73,9 19 500 19 500 25,2 78,4 21 000 21 000 31,7 83,4 23 400 23 400 58,0
60,0 19,4 73,3 19 500 19 500 27,3 79,7 21 700 21 700 60,0
62,0 10,8 65,4 18 100 18 100 22,0 75,1 20 200 20 200 62,0
64,0 14,9 68,8 18 800 18 800 64,0
66,0 66,0
68,0 68,0
70,0 70,0
72,0 72,0
74,0 74,0
76,0 76,0
REFERENCE ONLY!

Manitowoc Cranes 9660-AM, 2019-03-27
Manitowoc, Wisconsin 54220 U.S.A. 15/65
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 54,0 m
75° 70° 65°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
22,9 22,9
24,0 24,0
26,0 26,0
28,0 28,0
30,0 30,0
32,0 32,0
34,0 34,0
36,0 36,0
38,0 38,0
40,0 40,0
42,0 62,4 102,1 37 800 50 100 42,0
44,0 60,0 101,0 35 400 47 200 44,0
46,0 57,5 99,7 33 300 44 100 46,0
48,0 54,9 98,3 31 300 40 800 48,0
50,0 52,2 96,8 29 500 37 800 50,0
52,0 49,4 95,1 27 900 35 000 55,5 97,2 24 400 35 200 52,0
54,0 46,5 93,2 26 400 32 400 52,9 95,7 23 100 33 500 54,0
56,0 43,5 91,2 24 900 30 100 50,2 94,1 21 800 31 800 56,0
58,0 40,3 88,9 23 600 27 900 47,3 92,3 20 500 30 300 53,4 94,1 17 600 28 000 58,0
60,0 36,8 86,3 22 400 25 900 44,3 90,2 19 400 28 900 50,7 92,5 16 600 26 700 60,0
62,0 33,0 83,3 21 200 24 100 41,1 88,0 18 400 27 600 47,8 90,7 15 600 25 500 62,0
64,0 28,7 79,8 20 100 22 400 37,7 85,5 17 400 26 400 44,9 88,8 14 700 24 300 64,0
66,0 23,8 75,6 19 000 20 800 34,0 82,6 16 400 24 700 41,7 86,6 13 800 23 200 66,0
68,0 17,5 70,0 18 000 19 300 29,9 79,3 15 500 23 000 38,3 84,1 13 000 22 200 68,0
70,0 6,3 59,7 17 000 18 000 25,1 75,3 14 700 21 300 34,7 81,3 12 300 21 300 70,0
72,0 19,3 70,2 13 900 19 900 30,7 78,1 11 600 20 400 72,0
74,0 10,5 62,2 13 000 18 500 26,1 74,2 10 900 19 500 74,0
76,0 20,5 69,4 10 200 18 700 76,0
REFERENCE ONLY!

9660-AM, 2019-03-27 Manitowoc Cranes
16/65 Manitowoc, Wisconsin 54220 U.S.A.
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 60,0 m
85° 83° 80°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
24,4 73,9 113,8 72 100 72 100 24,4
26,0 72,3 113,3 71 300 71 300 26,0
28,0 70,2 112,6 70 300 70 300 28,0
30,0 68,2 111,8 67 800 69 200 70,1 112,3 66 200 70 600 30,0
32,0 66,1 110,9 62 700 65 900 68,1 111,5 60 800 69 800 32,0
34,0 64,0 109,9 58 000 60 700 66,0 110,6 56 200 68 800 34,0
36,0 61,8 108,9 53 800 56 300 63,9 109,7 52 100 66 000 66,8 110,5 49 500 63 800 36,0
38,0 59,6 107,7 50 100 52 500 61,7 108,6 48 500 60 800 64,7 109,6 46 100 59 500 38,0
40,0 57,3 106,5 46 800 49 300 59,5 107,4 45 300 56 000 62,6 108,6 43 000 55 700 40,0
42,0 55,0 105,1 43 900 46 400 57,2 106,2 42 400 51 700 60,4 107,5 40 200 52 300 42,0
44,0 52,6 103,6 41 200 43 900 54,9 104,8 39 800 47 900 58,1 106,2 37 800 49 200 44,0
46,0 50,2 101,9 38 800 41 600 52,5 103,3 37 500 44 600 55,8 104,9 35 500 46 400 46,0
48,0 47,6 100,1 36 600 39 000 50,0 101,6 35 300 41 600 53,5 103,4 33 400 43 900 48,0
50,0 44,9 98,1 34 600 36 500 47,4 99,8 33 400 38 800 51,0 101,8 31 500 41 500 50,0
52,0 42,1 96,0 32 700 34 200 44,8 97,8 31 600 36 400 48,5 100,1 29 700 39 400 52,0
54,0 39,1 93,6 31 000 32 100 41,9 95,6 29 900 34 100 45,9 98,2 28 100 37 300 54,0
56,0 35,9 90,9 29 400 30 200 38,9 93,2 28 400 32 000 43,1 96,1 26 500 35 100 56,0
58,0 32,4 87,9 27 900 28 400 35,7 90,5 26 900 30 100 40,2 93,8 25 100 32 900 58,0
60,0 28,6 84,4 26 600 26 700 32,2 87,5 25 600 28 300 37,1 91,2 23 700 30 900 60,0
62,0 24,2 80,2 25 200 25 200 28,4 83,9 24 300 26 700 33,7 88,3 22 500 29 100 62,0
64,0 18,7 74,9 23 300 23 300 23,9 79,7 23 000 25 100 30,0 85,0 21 300 27 400 64,0
66,0 18,4 74,3 21 800 23 300 25,8 81,1 20 200 25 800 66,0
68,0 10,2 65,9 18 900 19 100 20,8 76,2 19 100 24 300 68,0
70,0 14,1 69,5 18 100 22 600 70,0
72,0 72,0
74,0 74,0
76,0 76,0
78,0 78,0
80,0 80,0
82,0 82,0
REFERENCE ONLY!

Manitowoc Cranes 9660-AM, 2019-03-27
Manitowoc, Wisconsin 54220 U.S.A. 17/65
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 60,0 m
75° 70° 65°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
24,4 24,4
26,0 26,0
28,0 28,0
30,0 30,0
32,0 32,0
34,0 34,0
36,0 36,0
38,0 38,0
40,0 40,0
42,0 42,0
44,0 44,0
46,0 61,1 106,7 31 400 43 200 46,0
48,0 58,9 105,6 29 500 40 800 48,0
50,0 56,6 104,2 27 700 38 600 50,0
52,0 54,2 102,8 26 100 36 600 52,0
54,0 51,8 101,3 24 600 34 700 57,2 103,1 21 100 32 100 54,0
56,0 49,3 99,6 23 200 33 000 54,8 101,7 19 900 30 400 56,0
58,0 46,7 97,7 21 800 31 400 52,4 100,2 18 700 28 900 58,0
60,0 44,0 95,7 20 600 29 900 50,0 98,5 17 600 27 600 60,0
62,0 41,1 93,5 19 500 28 600 47,4 96,7 16 500 26 300 62,0
64,0 38,1 91,0 18 400 27 300 44,7 94,8 15 500 25 000 50,4 97,0 12 800 22 900 64,0
66,0 34,8 88,2 17 400 26 000 41,9 92,6 14 600 23 900 47,9 95,2 11 900 21 800 66,0
68,0 31,2 85,0 16 400 24 900 38,9 90,1 13 800 22 800 45,2 93,3 11 200 20 800 68,0
70,0 27,2 81,3 15 500 23 800 35,7 87,4 12 900 21 800 42,4 91,1 10 400 19 900 70,0
72,0 22,5 76,8 14 600 22 800 32,2 84,4 12 200 20 900 39,4 88,7 9 700 19 000 72,0
74,0 16,5 70,9 13 800 21 800 28,3 80,8 11 400 20 000 36,3 86,1 9 100 18 200 74,0
76,0 6,0 60,0 12 900 20 500 23,8 76,6 10 700 19 100 32,8 83,1 8 400 17 300 76,0
78,0 18,3 71,1 10 000 18 300 29,0 79,7 7 800 16 600 78,0
80,0 24,7 75,6 7 200 15 900 80,0
82,0 19,4 70,4 6 700 15 100 82,0
REFERENCE ONLY!

9660-AM, 2019-03-27 Manitowoc Cranes
18/65 Manitowoc, Wisconsin 54220 U.S.A.
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 66,0 m
85° 83° 80°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
27,4 72,6 119,1 62 200 62 200 27,4
28,0 72,1 118,9 62 200 62 200 28,0
30,0 70,2 118,2 62 100 62 100 30,0
32,0 68,4 117,4 61 500 61 500 70,1 117,9 60 100 61 200 32,0
34,0 66,5 116,6 57 400 60 500 68,3 117,2 55 500 61 200 34,0
36,0 64,6 115,6 53 300 57 700 66,4 116,3 51 500 61 000 36,0
38,0 62,6 114,6 49 500 53 500 64,5 115,3 47 900 59 500 67,2 116,2 45 300 58 600 38,0
40,0 60,6 113,5 46 300 50 000 62,5 114,3 44 700 55 000 65,3 115,3 42 300 55 000 40,0
42,0 58,6 112,3 43 300 47 000 60,5 113,2 41 800 50 900 63,3 114,3 39 500 51 600 42,0
44,0 56,5 111,0 40 600 44 100 58,5 112,0 39 200 47 300 61,3 113,2 37 000 48 500 44,0
46,0 54,4 109,5 38 200 41 100 56,4 110,7 36 900 44 000 59,3 112,0 34 700 45 800 46,0
48,0 52,2 108,0 36 000 38 400 54,3 109,2 34 700 41 100 57,3 110,8 32 600 43 200 48,0
50,0 50,0 106,4 34 000 36 000 52,1 107,7 32 800 38 400 55,2 109,4 30 600 40 900 50,0
52,0 47,6 104,6 32 200 33 700 49,8 106,0 31 000 35 900 53,0 107,9 28 800 38 800 52,0
54,0 45,2 102,6 30 500 31 700 47,5 104,2 29 300 33 600 50,8 106,3 27 200 36 800 54,0
56,0 42,7 100,5 28 900 29 800 45,1 102,3 27 800 31 600 48,5 104,5 25 700 34 600 56,0
58,0 40,0 98,1 27 400 28 000 42,5 100,1 26 300 29 700 46,1 102,6 24 200 32 400 58,0
60,0 37,2 95,6 26 100 26 400 39,8 97,8 24 900 27 900 43,6 100,6 22 900 30 500 60,0
62,0 34,1 92,7 24 800 24 800 37,0 95,2 23 600 26 300 40,9 98,3 21 700 28 700 62,0
64,0 30,8 89,5 23 400 23 400 33,9 92,3 22 300 24 800 38,2 95,8 20 500 27 000 64,0
66,0 27,2 85,7 22 000 22 000 30,6 89,0 21 200 23 400 35,2 93,1 19 400 25 400 66,0
68,0 22,9 81,3 20 600 20 600 26,9 85,3 20 100 22 000 32,0 90,0 18 400 24 000 68,0
70,0 17,8 75,7 18 800 18 800 22,7 80,8 19 000 20 700 28,5 86,4 17 400 22 600 70,0
72,0 17,4 75,1 18 000 18 900 24,5 82,3 16 500 21 300 72,0
74,0 9,5 66,2 15 300 15 300 19,7 77,2 15 600 20 000 74,0
76,0 13,3 70,1 14 700 18 300 76,0
78,0 78,0
80,0 80,0
82,0 82,0
84,0 84,0
86,0 86,0
88,0 88,0
REFERENCE ONLY!

Manitowoc Cranes 9660-AM, 2019-03-27
Manitowoc, Wisconsin 54220 U.S.A. 19/65
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 66,0 m
75° 70° 65°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
27,4 27,4
28,0 28,0
30,0 30,0
32,0 32,0
34,0 34,0
36,0 36,0
38,0 38,0
40,0 40,0
42,0 42,0
44,0 44,0
46,0 46,0
48,0 62,0 112,5 28 500 40 100 48,0
50,0 60,0 111,3 26 700 37 900 50,0
52,0 57,9 110,1 25 100 35 900 52,0
54,0 55,8 108,7 23 600 34 000 54,0
56,0 53,7 107,3 22 200 32 300 56,0
58,0 51,5 105,7 20 900 30 700 56,4 107,6 17 600 28 200 58,0
60,0 49,2 104,0 19 700 29 300 54,2 106,2 16 500 26 800 60,0
62,0 46,8 102,2 18 600 27 900 52,0 104,7 15 500 25 500 62,0
64,0 44,4 100,2 17 500 26 600 49,8 103,0 14 600 24 300 64,0
66,0 41,8 98,0 16 500 25 400 47,4 101,2 13 700 23 200 52,5 103,1 10 900 21 100 66,0
68,0 39,1 95,6 15 600 24 300 45,0 99,2 12 800 22 100 50,2 101,4 10 100 20 100 68,0
70,0 36,2 92,9 14 700 23 200 42,5 97,1 12 000 21 100 47,9 99,7 9 400 19 100 70,0
72,0 33,1 89,9 13 800 22 200 39,8 94,7 11 200 20 200 45,5 97,7 8 700 18 300 72,0
74,0 29,6 86,5 13 000 21 200 36,9 92,1 10 500 19 300 42,9 95,6 8 100 17 400 74,0
76,0 25,8 82,6 12 300 20 300 33,9 89,2 9 800 18 500 40,3 93,3 7 400 16 600 76,0
78,0 21,3 77,8 11 500 19 500 30,6 86,0 9 200 17 700 37,5 90,7 6 900 15 900 78,0
80,0 15,6 71,6 10 800 18 600 26,9 82,2 8 500 16 900 34,5 87,9 6 300 15 200 80,0
82,0 22,6 77,7 7 900 16 200 31,2 84,7 5 800 14 500 82,0
84,0 17,3 71,9 7 300 15 400 27,6 81,1 5 200 13 800 84,0
86,0 23,4 76,7 4 700 13 200 86,0
88,0 18,4 71,3 12 600 88,0
REFERENCE ONLY!

9660-AM, 2019-03-27 Manitowoc Cranes
20/65 Manitowoc, Wisconsin 54220 U.S.A.
LJ11
+
B65
135 100 kg
360°
MLC300 ASME B30.5
VPC-MAX S-1
54,0 m 72,0 m
85° 83° 80°
m°m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg °m
10,6 m
kg
14,6 m
kg m
29,0 72,8 124,9 52 100 52 100 29,0
30,0 72,0 124,6 51 200 51 200 30,0
32,0 70,3 123,9 49 600 49 600 71,9 124,3 51 200 51 200 32,0
34,0 68,6 123,1 48 200 48 200 70,2 123,6 49 700 49 700 34,0
36,0 66,8 122,2 46 800 46 800 68,5 122,8 48 300 48 300 36,0
38,0 65,1 121,3 45 500 45 500 66,7 122,0 46 900 46 900 38,0
40,0 63,3 120,3 44 300 44 300 65,0 121,0 44 500 45 600 67,4 121,9 41 900 47 500 40,0
42,0 61,5 119,2 42 800 43 200 63,2 120,0 41 600 44 500 65,7 121,0 39 100 46 300 42,0
44,0 59,7 118,1 40 400 42 200 61,4 119,0 39 000 43 400 63,9 120,0 36 600 45 100 44,0
46,0 57,8 116,8 38 000 40 800 59,6 117,8 36 700 42 300 62,1 119,0 34 300 44 000 46,0
48,0 55,9 115,5 35 800 38 200 57,7 116,5 34 500 40 700 60,3 117,8 32 200 42 700 48,0
50,0 53,9 114,1 33 800 35 800 55,8 115,2 32 600 38 200 58,4 116,6 30 300 40 700 50,0
52,0 51,9 112,5 32 000 33 600 53,8 113,7 30 800 35 700 56,5 115,3 28 500 38 500 52,0
54,0 49,8 110,8 30 300 31 500 51,8 112,2 29 100 33 500 54,6 113,9 26 900 36 600 54,0
56,0 47,7 109,0 28 700 29 600 49,7 110,5 27 500 31 400 52,6 112,4 25 300 34 400 56,0
58,0 45,5 107,1 27 300 27 900 47,6 108,7 26 000 29 500 50,6 110,8 23 900 32 300 58,0
60,0 43,2 105,0 25 900 26 300 45,3 106,8 24 600 27 800 48,4 109,0 22 600 30 400 60,0
62,0 40,7 102,7 24 600 24 700 43,0 104,7 23 300 26 200 46,3 107,1 21 400 28 600 62,0
64,0 38,2 100,2 23 300 23 300 40,6 102,4 22 100 24 700 44,0 105,1 20 200 26 900 64,0
66,0 35,5 97,5 22 000 22 000 38,1 99,9 20 900 23 300 41,6 102,9 19 100 25 300 66,0
68,0 32,6 94,5 20 800 20 800 35,3 97,1 19 900 22 000 39,1 100,5 18 100 23 900 68,0
70,0 29,5 91,0 19 600 19 600 32,4 94,1 18 800 20 700 36,5 97,8 17 100 22 500 70,0
72,0 26,0 87,1 18 300 18 300 29,3 90,6 17 900 19 600 33,7 94,9 16 200 21 300 72,0
74,0 21,9 82,5 16 900 16 900 25,7 86,7 16 900 18 400 30,6 91,6 15 400 20 100 74,0
76,0 17,0 76,6 15 600 15 600 21,7 82,0 16 100 17 000 27,2 87,9 14 500 18 900 76,0
78,0 16,7 76,0 15 100 15 500 23,4 83,5 13 700 17 800 78,0
80,0 9,1 66,7 12 600 12 600 18,9 78,2 13 000 16 400 80,0
82,0 12,8 70,8 12 200 15 100 82,0
84,0 84,0
86,0 86,0
88,0 88,0
90,0 90,0
92,0 92,0
94,0 94,0
96,0 96,0
REFERENCE ONLY!