Master Bilt WCR-23SR User manual

VISION CREATIVE, INC.
중구 남대문로 5가 526
대우재단빌딩 16층
담 당 김세호님 TEL
MODEL
CCR-23SR,49DR,72TR/WCC-23SR/WCR-23SR/CCR-23SF,49DF,72TF/WCR-23SF
BUYER 1차 03.2.7 6차
2차 03.2.13 7차
일정 3차 03.7.22 8차
4차 03.7.25 9차
5차 03.7.28 10차
제판 03.7.28(Han)출력 인인쇄쇄
규격
MEMO
03.12.15-3page-수정 (6)추가
연연락락처처
VVIISSIIOONN담담당당박선민
TEL: [phone] FAX: 774-
1039

Refrigerator
Freezer
Installation and Operation Manual
Please read this manual completely before attempting to install or operate this equipment!
Full Stainless Steel Visible Exterior
Refrigerator
CCR-23SR
CCR-49DR
CCR-72TR
WCC-23SR
WCR-23SR
Freezer
CCR-23SF
WCR-23SF
CCR-49DF
CCR-72TF

1. SPECIFICATION.......................................................................................... 2
2. SERIAL NUMBER........................................................................................ 2
3. INSTALLATION ............................................................................................ 3
4. CLEANING & CAUTION .............................................................................. 4
5. BASIC OPERATION
5-1. REFRIGERATORS ........................................................................... 5~9
5-2. FREEZERS................................................................................... 10~14
6. INSTALLATION METHOD OF REVERSE DOOR................................ 15~16
7. BEFORE REQUESTING SERVICE............................................................17
8. WARRANTY................................................................................................18
9. TERMS OF SALE........................................................................................19
2
CONTENTS
PAGE
The serial number is located on the data label inside.
Please retain the unit’s serial number for service purpose.
SERIAL NUMBER
Refrigerators
SPECIFICATION
MODEL COMP H.P. V/Hz REFRIGERANT AMPS WEIGHT
CCR-23SR 1/4 115V/60Hz R-134a 5.5A 265lbs
CCR-49DR
1/3 115V/60Hz R-134a 9.2A 397lbs
CCR-72TR 2/3 115V/60Hz R-134a 11A 530lbs
WCC-23SR 1/4 115V/60Hz R-404a 9.0A 265lbs
WCR-23SR 1/4 115V/60Hz R-404a 9.0A 265lbs
Freezers
MODEL COMP H.P. V/Hz REFRIGERANT AMPS WEIGHT
CCR-23SF 1/2 115V/60Hz R-404a 8.7A 265lbs
CCR-49DF 3/4 115V/60Hz R-404a 10.5A 397lbs
CCR-72TF
5/4 115V/208~220V/60Hz R-404a 10A 540lbs
WCR-23SF 1/2 115V/60Hz R-404a 8.7A 265lbs

3
1. GOOD AIR CIRCULATION
- Avoid any partitions or objects which may restrict air flow.
- Be sure there is sufficient air space to allow air flow at the rear of the unit.
2. DO NOT PLACE NEAR HEAT
- High ambient temperature will adversly affect cooling efficiency.
3. INDOOR USAGE ONLY
- Be sure to install this unit indoors.
4. STABILIZING
- While in use, make sure the front wheels are locked to keep the unit in place.
5. LEVELING
- Be sure that the unit is level from the front to the back and side to side.
6. UNIT SHOULD BE ON DEDICATED OUTLET.
INSTALLATION

4
1. CLEANING THE INTERIOR AND EXTERIOR
- The interior and exterior of the unit can be cleaned using warm water with soap.
- Do not use an abrasive cleaner because it will scratch the stainless steel surface.
2. CLEANING THE CONDENSER FINS
- To maintain proper refrigeration performance, the Condensing coil must be free of
dust, dirt and grease.
This will require periodic cleaning. Condenser fins should be cleaned at least every
three months (90 days) or as needed.
3. CLEAN THE GASKET
- The door gasket should be cleaned frequently to maintain proper sealing.
4. CHECK AFTER CLEANING
- Check the unit again for safety.
- Check that the unit is operating properly.
1. POWER CORD
- Be sure that the power cord is connected to the proper voltage.
- A protected circuit of the correct voltage and amperage must be run for connection of
the line cord.
-Turn ‘off’ the power switch before disconnecting the power cord, whenever
performing maintenance functions or cleaning the refrigerated
cabinet.
- Dual voltage freezer (CCR-72TF) requires receptacle as the right
sides.
- Compressor warranties are void if compressor burns out due to low
voltage.
2. RE-STARTING
- If disconnected, wait 5 minutes before re-starting.
CAUTION
WH
E
BK RD
CLEANING

5
BASIC OPERATION
WCC-23SR
WCR-23SR
1. The controller(thermostat) is located at the top inside of the unit.
2. The factory setting for the control is ‘Normal’, and maintains about 38˚F (3˚C) inside.
3. Set toward “Cool”for higher temperature and “Cold”for lower temperature.
4. The thermostat controls compressor’s cycling by sensing inside temperature.
5. Interior light is activated by the door switch when door is opened.
6. Cooling fans are activated by the door switch when door is completely closed.
REFRIGERATOR
OFF
COOL
COLD
NORMAL
Temperature Controller
(Thermostat)

6
BASIC OPERATION
CCR-23SR
CCR-49DR
CCR-72TR
1. Plug in and turn on the power switch located on the bottom of the top grille right side.
The Display panel will be lighted and make a beep sound. The compressor will begin
to run.
2. The default temperature setting is No. “5”.
3. The compressor is automatically cycled by the electronic controller (PCB, D-Sensor).
4. The Defrost cycle is automatically controlled by the R-sensor and the PCB.
5. Set level toward “1”for higher temperature and toward “9”for lower temperature.
6. The interior light is activated by the rocker switch at the bottom of the top grille when
the door is opened.
7. Evaporator fan motor(s) will run after all doors are completely closed.
REFRIGERATORS

7
DISPLAY PANEL OF REFRIGERATOR
9
TEMPERATURE Q.C.
8
7654321
FAN DOOR
QUICK COOLING
TEMPERATURE
˚F
TEMP. SETTING
QUICK COOLING
BUTTON
TEMP. CONTROL BUTTON
(SEE TO PAGE 8)
INNER TEMP.
(SEE TO PAGE 9)
(SEE TO PAGE 8)
QUICK COOLING
INDICATOR
FAN RUNNING
INDICATOR
DOOR OPENING
INDICATOR

8
1. If you push the Q.C. (Quick Cooling) button, the compressor will run continuously until
D-Senser detect 14˚F (-10˚C) to bring down the temperature more quickly.
(max.comp.run time = 120 min.)
2. If you push the Q.C. button again during Quick Cooling mode, the compressor will
return to the normal operation.
3. During the Quick Cooling mode, the temperature Up/Down button will not affect the
compressor’s operation.
1. By pushing the up/down button, you can set the inside temperature level from ‘1’to
‘9’.
2. If you want lower temperature, push the Down button to be lighted higher level
numbers.
QUICK COOLING
UP/DOWN BUTTON (Temperature control button)

9
1. It displays inside temperature.
2. Display range is 14˚F to 69˚F (-10˚C ~ +20˚C).
3. When inside temperature is lower than 14˚F, the panel will display ‘’.
and, higher than 69˚F, the panel will display ‘’.
1. If the fan motor is running, fan running indicator will be turned on.
2.
Evaporator fan motor is activated when the door (both doors for CCR-49DR, all three
doors for CCR-72TR) is closed.
1. If any door is opened, door opening indicator will be turned on.
2. In case that any door was opened around 30 seconds, warning beep sound will be
ring three (3) times.
3. In case of passing around 1 minute, warning beep sound will be ring again five (5)
times.
4. In case of passing around 5 minutes, the beep sound will be ring continuously.
5. On all the conditions good, the beep sound will stop immediately if the door closed
properly.
INNER TEMPERATURE DISPLAY
FAN RUNNING INDICATOR
DOOR OPENING INDICATOR