MIRACO BIGSpring 6200 User manual

READ CAREFULLY
A DIVISION OF
AHRENS AGRICULTURAL INDUSTRIES Co.
BOX 686
GRINNELL, IOWA 50112
PHONE [phone]
TOLL FREE1 800 541 7866
FAX [phone]
BIGSpring
MODEL 6200, 6300, 6400
Heater Options
Part 162 - USA Heater Kit, 110 Volt - 500 Watt
Part 163 - EURO Heater Kit, 220 Volt - 500 Watt
INSTALLATIONS AND SPECIFICATIONS

Part I General
A. Description #6200
1. 7'Plong livestock waterer with automatic rHILOl and optional heat or constant fORw features.
Part I General
A. Description #6300
1. 12' Plong livestock waterer with automatic refLOl and optional heat or constant IORw features.
Part I General
A. Description #6400
1. 10'P long livestock waterer with automatic refLOO and optional heat or constant fORw features.
B. Material necessary for installation
1. concrete for the base
2. tefORn tape thread sealer
3. 3/8"FP concrete hammer drill
4. #158 Miraco hose w/shutoff hookup kit (provided)
Part II Materials, Products
A. Materials
1. High impact rockite, Polyethylene
2. Polyurethane insulation 2" to 5"FP[FP
B. Valve
1. Miraco Valve (standard)
C. Hookup assembly
1. 3/4" x 24"FP[FP 200 psiEDU rubber hose
2. 3/4"FP plastic ball shutoff valve
3. Stainless Steel arm and thumb screw w/polyethylene 5" x 5"FP[FP ball
D. Heat
1. Optional 500 watt submersible heater
E. Anchor bolts
1. (6) 3/8" x 4"FP[FP stainless steel concrete anchors
(provided in parts bag)
Model Capacity Gallons / L Description Dimensions Wt.
6200
150 hd beef
75 hd dairy
60Gal
227.12L
Constant Flow or
Optional Heater
84" x 22" x 22"
(213.36cm x 55.88cm x 55.88cm)
170lbs
77.11Kg
Model Capacity Gallons / L Description Dimensions Wt.
6300
250-300 hd beef
125 dairy
110Gal
416.40L
Constant Flow or
Optional Heater
500W
142" X 22" X 22"
(360.68cm x 55.88cm x 55.88cm)
275lb
124.74kg
Model Capacity Gallons / L Description Dimensions Wt.
6400
200 hd beef
75 hd dairy
80Gal
302.83L
Constant Flow or
Optional Heater
120" x 22" x 22"
(304.80cm x 55.88cm x 55.88cm)
212lb
96.16kg

Step 4
Mark and drill (6) 3/8"FP holes in concrete pad. Holes
can be drilled directly thru the tank holes at an angle
and then anchors can be driven into place also.
Step 1
Attach the 200 psiEDU hose with shutoff valve to
the PVC elbow, use tefORn tape on all threaded ILtWLQJV.
Step 2
Set the entire assembly into the valve cradle.
Step 3
Place the stainless steel bracket over the PVCILWWLQJV
and attach with 1/4"FP stainless steel screws
Step 5
After inserting 3/8" x 4"FP[FPDQFKRUEROWV
(provided), set tank over the bolts and install nuts and
tighten.
Step 6
Attach fORat assembly and adjust water level to
desired height.
provided.

Access doors on each end for access to constant flow fitting on
the bottom side of the tank. Constant flow drain pipes can be
plumbed to drain on the ends or in the center.
Center access door should be used for access to an approved
electrical outlet for optional heaters.
Miraco Livestock waterers Express warranty and
Waiver of implied warranties and consequential damages
Express Warranty
Ahrens Agricultural Industries Co. , dba Miraco, expressly warrants that the Miraco
waterers (excluding valve and valve parts) will be free of defects in materials and
workmanship for a period of five (5) years from delivery. The Miraco valve and valve
parts are warranted to be free of defects in materials and workmanship for a period of one
(1) year from delivery. Such warranty does not apply to any Miraco unit that has been
subjected to misuse, or material failure to install, operate or maintain in accordance with
Miraco’s written instructions, or other events acts or omission, including but not limited
to acts of nature, which affect the Miraco unit materially and adversely and are not
attributable to Miraco.
This warranty is limited to the repair or replacement of the defective part, at the option of
Miraco. Such repair or replacement part is warranted only for the unexpired portion of
the original warranty period. Buyers with warranty claims should contact their local
dealer immediately.
Heaters in all electrically heated units are warranted for a period of one (1) year.
Waiver of implied warranties and
Consequential damages
Except for the above express warranty, this product is sold as is. Implied warranties of
merchantability and fitness for a particular purpose, as well as special, indirect or
consequential damages, are all waived by the buyer.