Mitech Nfcmcu User manual

UsermanualforNFCMCU

ModelnumberNFCMCU.

Contents

1.Introduction

2.SystemOverview

3.Installation

4.Operation

5.ComplianceStatements

6.TechnicalSpecification



1.Introduction

ThisdocumentistheusermanualfortheMitechIntegratedSystemsRFIDmodule–NFCMCU

ThismoduleisusedforMitechIntegratedSystemsproduct,whichisMachineCartUnit(MCU)

ThismodulereadsRFTAGandprovidethisreadingtoMCU





2.SystemOverview

ThismodulereadsdatafromtheuserRFIDcards.AndprovidesitsreadingtoMCU.TheMCUscanbe

installedindifferentcommercialplaces,whenRFIDcardsareused.Basedonthereceiveddatafromthe

NFCMCUmodule,theMCUwillactivateitscorrespondingoutputcontrol,whichisdependinginwhat

environmenttheMCUsareinstalled.

Themoduleisconformalcoated,whichpreventsanycorrosionofitscomponentsinmoisture

environment

ThemoduleisconnectedtotheMCUmainboardviadirectconnection,byusing7pinconnector



3.Installation

TheNFCMCUisinstalledfollowingthesesteps:

‐Obtainthemodulefromtheassembleline

‐Putthemoduleontopsideofthe7pinconnector,whichisalreadysolderedintoMCU

‐Solder7pinconnectorbyusing7solderingpadsofthemodule



AfterinstallingthemodulefollowthetestprocedureoftheMCUdevice



4.Operation

AfterinstallationofthemoduleontheMCUdeviceisfinished,theMCUdeviceisinstalledintoplastic

enclosure.ThensuchMCUstructureisinstalledoncommercialmachines.Itmaybedifferentpayment

systems,commerciallaundrymachinesandetc.TheMCUwillbeequippedwithspecialmounting

hardwaretobemountonspecificcommercialmachine.ThepowersupplysourceforMCUcancome

fromtwosources:individualstepdownseparatedpowersupply,likedesktoppoweradapterorlow

power(12V..24V)canbetakenfromthecommercialmachine,ifthemachinehasprovisionforsuch

connection.AfterinstallingMCUwithitsNFCMCUmodule,powercanbeswitchedONandNFCMCUis

readytoreadRFIDcardsandtransmitdatatoMCU.



5.ComplianceStatement

TheNFCMCUhasbeentestedtoFCC15.225,ICRSS‐210&FCC15B,ICES‐003(ClassB).Alsoitwastested

forClassBAC/DCpowerlineconductedemissionsandforClassBradiatedemission.

ThisdevicecomplieswithPart15oftheFCCrules.Operatingissubjecttothefollowingtwoconditions:

1.Thisdevicemaynotcauseharmfulinterference

2.Thisdevicemustacceptanyinterferencereceived,includinginterferencethatmaycauseundesired

operationofthisdevice.

NOTE:ThisequipmenthasbeentestedandfoundtocomplywiththelimitsforaClassBdigitaldevice,

pursuanttopart15oftheFCCRules.Theselimitsaredesignedtoprovidereasonableprotectionagainst

harmfulinterferenceinaresidentialinstallation.Thisequipmentgenerates,usesandcanradiateradio

frequencyenergyand,ifnotinstalledandusedinaccordancewiththeinstructions,maycauseharmful

interferencetoradiocommunications.However,thereisnoguaranteethatinterferencewillnotoccur

inaparticularinstallation.Ifthisequipmentdoescauseharmfulinterferencetoradioortelevision

reception,whichcanbedeterminedbyturningtheequipmentoffandon,theuserisencouragedtotry

tocorrecttheinterferencebyoneormoreofthefollowingmeasures:

‐Reorientorrelocatethereceivingantenna.

‐Increasetheseparationbetweentheequipmentandreceiver.

‐Connecttheequipmentintoanoutletonacircuitdifferentfromthattowhichthereceiveris

connected.

‐Consultthedealeroranexperiencedradio/TVtechnicianforhelp.

Caution:Changesormodificationsnotexpresslyapprovedbythepartyresponsibleforcompliancecould

voidtheuser'sauthoritytooperatetheequipment.

Thisdevicecontaineda13.56MHzTransmitterandacertified2.4GZigbeeModule(FCCID

2AOE2REX3B,IC:22670‐REX3B).Thisequipmentcomplieswithradiofrequencyexposurelimitssetforth

byFCCforanuncontrolledenvironment.Thisequipmentmustbeinstalledandoperatedwitha

minimumdistanceof20cmbetweenthedeviceandtheuserorbystanders.Thisdevicemustnotbeco‐

locatedoroperatinginconjunctionwithanyotherantennaortransmitter.ThismoduleisFCCPart

15.225/ISEDRSS‐210limitedmodule.Themoduleislimitedtobeusedbythegranteeinitsown

products,notintendedforsaletothirdparties.Thehostdevicewiththisintegratedlimitmodular

approvalshallensuretheradiatedemissionsandspuriousemissioncomplywithFCCpart15.225.The

modulartransmitterisonlyFCCauthorizedforthespecificruleparts(i.e.,FCCtransmitterrules)listed

onthegrant,andthehostproductmanufacturerisresponsibleforcompliancetoanyotherFCCrules

thatapplytothehostnotcoveredbythemodulartransmittergrantofcertification.Whenthehostis

changed,additionaltestandcertificationmayberequired.ThefinalhostproductstillrequiresPart15

SubpartBcompliancetestingwiththemodulartransmitterinstalled.

HostProductLabelling

IftheFCCIDisnotvisiblewhenthemoduleisinstalledinsideanotherdevice,thentheoutsideofthe

deviceintowhichthemoduleisinstalledmustalsodisplayalabelreferringtotheenclosedmodule.

Thisexteriorlabelcanusewordingsuchasthefollowing:

MitechIntegratedSystemsInc.Model:MCU

ContainsFCCID:WSSNFCMCUIC:7992A‐NFCMCU

ContainsFCCID:2AOE2REX3BIC:22670‐REX3B

ThisdevicecomplieswithPart15oftheFCCrules.Operatingissubjecttothefollowingtwoconditions:

(1)Thisdevicemaynotcauseharmfulinterferenceand(2)thisdevicemustacceptanyinterference

received,includinginterferencethatmaycauseundesiredoperation.

