Montigo H34VO Instruction Manual

WARNING
FOR OUTDOOR USE ONLY.
WARNING
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide which has
no odor. Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space such as a
camper, tent, car or home.
®
C
US
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could result in serious injury,
death, or property damage.
—Donotstoreorusegasolineorotherammablevaporsand
liquidsinthevicinityofthisoranyotherappliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any
phoneinyourbuilding.
• Leavethebuildingimmediately.
• Immediatelycallyourgassupplierfromaneighbour's
phone. Follow the gas supplier’s instructions.
• Ifyoucannotreachyourgassupplier,callthere
department.
—Installationandservicemustbeperformedbyaqualied
installer,serviceagencyorthegastter.
DivineOutdoor
OUTDOOR RESIDENTIAL GAS FIREPLACE
H34VO*,H34VO*E
Natural Gas or Propane Gas
H38VO*,H38VO*E
Natural Gas or Propane Gas
Installation and service must be performed by a qualied installer,
service agency or the gas tter. Check local codes and read all
instructions prior to installation.
Installer: Leave this manual with the appliance. Please refer to the
Montigo website for the most current version of the replaces manual
Consumer: Retain this manual for future reference. Please refer to the
Montigo website for the most current version of the replaces manual
NOTICE
Some materials used in the manufacturing process of this product can
expose you to Benzene which is known in the State of California to
cause cancer and birth defects or other reproductive harm. For more
information go to www.P65warnings.ca.gov
WARNING
HL38VO*,HL38VO*E
Natural Gas or Propane Gas
H42VO*,H42VO*E
Natural Gas or Propane Gas
XG0150
Installation & Maintenance Manual

Page 2
You must read and understand this manual prior to installation, operation or
troubleshooting this appliance. Please retain this owner’s manual for future reference
and maintenance.
NOTICE
XG0150 - 140707.2
Table of Contents
Divine Outdoor Gas Fireplace
Introduction .................................................................................3
Models .................................................................................3
Installation
Before you Start .................................................................................4
Installation Checklist ...............................................................................4
Section 1: Installation Overview and Product Dimensions.....................5
Section 2: Framing the Fireplace ...........................................................6
Clearances ............................................................................6 - 7
Finishing around the Fireplace ...........................................................7
Section 3: Venting ............................................................................. N/A
Section 4: Wiring .................................................................................8
    ▪Honeywellgascontrolandpilot..............................................8
Section 5: Installing the Gas Line...........................................................9
Section 5-1: Fuel Conversion..................................................................9
Section 5-2: Gas Pressure......................................................................9
Section 5-3: Gas Connection ..................................................................9
Section 6: .............................................................................N/A
Section 7: Installing and Removing the Door .......................................10
Section 8: Installing the Accessories .............................................11 - 14
   ▪InstallingtheH34VONLogSet.................................................. 11
   ▪InstallingtheH38VONLogSet..................................................12
   ▪InstallingtheH42VONLogSet..................................................13
   ▪InstallingtheHL38VOLFirestones ............................................14
Section 9: Operation ........................................................15 - 16
   ▪Start-upSequencewithContinuousPilot ..................................15
   ▪Start-upSequencewithHoneywellElectronicIgnition .............16
Maintenance .......................................................................17 - 18
   ▪General  ...............................................................................17
   ▪Cleaning ...............................................................................17
   ▪Hi-LoBurnerAdjustment............................................................17
   ▪PilotBurnerAdjustment .............................................................17
   ▪ReplacementParts ....................................................................18
Appendix
A. Termination Locations ..............................................................19
B. Warranty ...............................................................................20
C. State of Massachusetts. ..........................................................21
Installer: Leave this manual with the appliance. Do not remove.
Consumer: Retain this manual for maintenance and future reference. Do not Discard.
NOTICE

Page 3
XG0150 - 140707.2
Indicates a hazardous situation which, if not
avoided, WILL result in death or serious
injury or property damage.
Indicates a hazardous situation which, if not
avoided, COULD result in death or serious
injury or property damage.
Indicates a hazardous situation which, if not
avoided, WILL result in minor or moderate
injury.
Address practices that are important, but
not related to personal injury
DANGER WARNING
CAUTION NOTICE
Divine Outdoor Gas Fireplace
Safety Alert Key
Introduction
WARNING
Hot glass will cause
burns. Do not touch
glass until unit is cooled.
Never allow children to
touch glass.
Irritant
Cutting
Watch your step
Slippery floor
High temperatures
Glass hazard
Danger of suffocation
High voltage
Toxic
Flammable materials
Corrosive
Fork lift trucks
Danger overhead crane
Explosion risk
Oxidising
Danger of death
Biohazard
Laser Radiation
Danger of entrapment
Hot surface
General Warning
Blank
Gas bottles
Watch for
falling objects
Electricity
Danger for cutter
Entrapment hazard
Battery hazard
Rotating parts
Low temperature
Strong magnetic field
Optical radiation
Non ionizing
radiation
Radiation
Hazardous to the
Environment
Danger of harming
your hands
Congratulations on your purchase of a Montigo Fireplace.
With over 30 years of experience, Montigo is committed to providing you
withagasreplacethatisnotonlyabeautifuladditiontoyourspace,but
thatisalsodesignedandmanufacturedtothehighestsafety,reliability
and engineering standards.
We strongly encourage you to read and carefully follow the instructions
laidout in this Installation,Operationand Maintenance Manual andretain
itfor your futurereference. Pay special attention toall cautions, warnings,
and notices throughout this manual intended to ensure your safety.
This manual covers installation, operation and maintenance. Lighting,
operationand care ofthis replace canbe easily performedby the
homeowner.Allinstallationandserviceworkshouldbeperformedby
aqualiedorlicensedinstaller,plumberorgastterascertiedbythe
state,province,regionorgoverningbodywherethereplaceisbeing
installed.
Thisinstallation,operationandmaintenancemanualisapplicabletothe
modelsdescribedbelow.Refertoyourratingplatetoverifyincluded
options.
How to use this manual:
This manual covers installation, operation and maintenance. Lighting,
operationand care ofthis replace canbe easily performedby the
homeowner. However, all installation and service work should be
performedbyaqualiedorlicensedinstaller,plumber,orgastterwho
isqualiedorlicensedbythestate,province,region,orgoverningbody
inwhichtheapplianceisbeinginstalled.
Warranty and Installation Information: (See Appendix B)
TheMontigowarrantywill bevoidedby,andMontigo disclaimsany
responsibilityfor,thefollowingactions:
 ► Modication of the replace and/or components including
Direct-Ventassemblyorglassdoors.
 ► Useofanycomponentpartnotmanufacturedorapprovedby
MontigoincombinationwiththisMontigoreplacesystem.
 ► Installationotherthanasinstructedinthismanual.
ConsultyourlocalGasInspectionBranchoninstallationrequirements
forfactory-builtgasreplaces.Installation&repairsshouldbedoneby
aqualiedcontractor.
MODEL Natural Gas Liquid Propane Gas Rating (BTU hr) Traditional Burner Linear Burner Standing Pilot Ignition Honeywell Hot Surface Ignition
H34VON X 26,000 X X
H34VOL X 26,000 X X
H38VON X 34,000 X X
H38VOL X 34,000 X X
HL38VON X 34,000 X X
HL38VOL X 34,000 X X
H42VON X 40,000 X X
H42VOL X 40,000 X X
H34VONE X 26,000 X X
H34VOLE X 26,000 X X
H38VONE X 34,000 X X
H38VOLE X 34,000 X X
HL38VONE X 34,000 X X
HL38VOLE X 34,000 X X
H42VONE X 40,000 X X
H42VOLE X 40,000 X X

Divine Outdoor Gas Fireplace
Page 4 XG0150 - 140707.2
Installation
Installation and repairs should be done by an authorized gas fireplace service technician.
The appliance should be inspected before use and at least annually by a professional. More
frequent cleaning may be required due to excessive lint from carpeting, bedding material,
etc. It is imperative that control compartments, burners and circulating air passageways of
the fireplace are kept clean.
NOTICE
Due to high operating temperatures, this appliance should be located out of traffic &
away from furniture and draperies.
Children and adults should be alerted to the hazards of the high surface temperature,
which could cause burns or clothing ignition.
Young children should be carefully supervised when they are in the same room as the
appliance.
Clothing or other flammable materials should not be placed on or near the appliance.
CAUTION
When this appliance is installed directly on any combustible material other than wood
flooring, it must be installed on a metal or wood panel extending the full width and
depth of the appliance or a fire will occur causing serious injury, property damage or
even death.
DANGER
Installation Checklist
Determinethedesiredinstalllocationofyourreplace.
See Section 1, Dimensions on Page 5, and refer to the Framing
Section 2 for details.
LayoutElectricalRequirementsRefertoSection 4: Wiring, for
Details.
Refer to Section 5: Installing the Gas Line, for details on the
gas connection and access.
Refertolocalcodesandguidelinesforinstallationrequirements.
Installation and repairs should be done by a qualied
contractor and must conform to:
• Installations in Canada must conform to the current CAN/CGA
B-149.1 and .2 Gas Installation Code and local regulations.
• Installations in Canada must conform to the local codes or in the
absenceoflocalcodestothecurrentversionofNaturalGasand
PropaneInstallationCode,CSAB149.ElectricalInstallationsmust
conformtothelocalcodesor,intheabsenceoflocalcodes,tothe
currentversionofCanadianElectricalCode,CSAC22.1.1
• Installations in the USA must conform to the local codes or in the
absenceoflocalcodestothecurrentversionofNationalFuelGas
Code,ANSIZ223.1/NFPA54.ElectricalInstallationsmustconform
tothelocalcodesor,intheabsenceoflocalcodes,tothecurrent
versionoftheNationalElectricalCode,ANSI/NFPA70.SeeAp-
pendix C for installation within the State of Massachusetts.
IMPORTANT MESSAGE: SAVE THESE INSTRUCTIONS
TheDivineOutdoorVentlessreplacemustbeinstalledinaccordance
with these Instructions. Carefully read all the Instructions in this manual
rst.ConsulttheLocalGasBranchtodeterminetheneedforapermit
priortostartingtheinstallation.Itistheresponsibilityoftheinstallerto
ensurethisreplaceisinstalledincompliancewiththemanufacturers
instructionsandallapplicablecodes.
BEFORE YOU START:
Young children should be carefully supervised when they are
in the same room as the applicance. Toddlers, young children
and others may be susceptible to accidental contact burns. A
physical barrier is recommended if there are at risk individuals
in the house. To restrict access to a fireplace or stove, install
an adjustable safety gate to keep toddlers, young children and
other at risk individuals out of the room and away from hot
surfaces.
CAUTION

Divine Outdoor Gas Fireplace
Page 5
XG0150 - 140707.2
Installation
Section 1: Installation Overview and Product Dimensions
Pleasereview the Installation Checkliston Page 4 forgeneral information
onpreparingforasuccessfulinstallationofyourreplace.
TheH-SeriesVOreplacemaybeinstalledinanylocationthatmaintains
properclearancestoairconditioningducts,electricalwiringandplumbing.
Safety,aswellasefciencyofoperation,shouldbeconsideredwhen
selectingthereplacelocation.Trytoselectalocationthatdoesnot
interfere with room trafc, has adequate ventilation and offers an
accessiblepathforDirectVentinstallation.
G
H
Top View
F
F
E
J
B
B
D
I
C
D
D
A
A
Front View
G
Side View
P”
N”
Q”
N”
M”
O”
1" clearance
to corners only
Exterior Wall
**Optiona l Drain Pan:
available for all models.
H34VO Part No. OD34123
H38VO Part No. OD38123
H42VO Part No. OD42123
Insulation material
vapor barrier
(exterior wall).
1” Clearance to
combustibles to sides
ot Unit
Figure 1. Fireplace dimensions, (ALL Models, shown in Table on Page 3).
The replace dimensions are shown below:
Unit Dimensions
A B C D E F G H I J
H34VON 33⅞"34⅞" 31⅜" 1¼" 22¾" 5¼" 19¾"24" 1" 18"
H38VON 37⅞" 37⅜" 35¼"1¼" 25" 5¼" 201/16"25" 1" 18"
H42VON 42" 41¼"39½" 1¼"28¾" 5¼"21⅝" 28" 1" 18"