MSA Ultima OPIR 5 User manual

Ultima® OPIR-5
Quick Guide
Because every life has a purpose...
Applications
• Oshore platforms
• FPSO’s
• Gas plants
• Around spherical tanks
• Down the length of several bullet tanks
• Compressor stations
• Fence line monitoring
• Rail and truck load outs
• Landlls
• Urban industrial settings

Things to Consider
• Use two people for alignment, one at Source and one at Receiver
• Automatic gain control compensates for dirty optics, rain, and fog
• Source and Receiver should not be mounted close to radio
sources or similar equipment
• Mount away from sources of excessive vibration and high
voltage/high current power lines
• If the path length is less than 20 meters (65 feet), a Source with
an attenuation plate is required
• A Long Range Alignment Kit is recommended for separations
of 60 meters or more
• If using adjacent detectors, install Receivers at opposite ends
to prevent light interference measurement errors
• Field calibration is not required and the sensitivity can be
checked by placing a test gas lm in front of the Receiver
Specication Ultima OPIR-5
RESPONSE TIME (T90, S) ≤3
REPEATABILITY <±5%
LINEARITY <±5% FS or ±10% Applied Gas
PATH LENGTH, MAX (M)
30 (short), 100 (standard)
OPERATING TEMPERATURE
RANGE ( °C)
-55 to +65
SOLAR BLIND All conditions
FOG IMMUNITY BASED ON FM 6325 95% blockage
COMBINED WEIGHT, RECEIVER
AND SOURCE (KG)
11 (SS only)
SUPPLY POWER, NOMINAL (W) 23
BIDIRECTIONAL COMMUNICATION HART, Modbus
EVENT LOGGING/AMS
DEVICE MANAGER
Available
TWO AVAILABLE SCALES
LIGHT HYDROCARBONS
HEAVY HYDROCARBONS
0-5000 ppm*m & 0-5 LEL*m
0-2000 ppm*m & 0-1 LEL*m
Typical AJ Values
Distance 20 m 50 m 100 m
STANDARD 5060 4050 2535
EXTENDED N/A 4555 3040
CLEAR • MEASURE • SOURCE • RECEIVER
• Ensure the path is CLEAR between the Source and Receiver.
•MEASURE the distance between the Source and Receiver
to get the best AJ Values
• Start the Alignment at the SOURCE
• Finalize the setup at the RECEIVER
04 12
AO (mA)
5 LEL•m5,000 ppm•m (0.1 LEL•m)
Methane Gas Concentration
(ppm•m)
Methane Gas Concentration
(LEL•m)
20
www.MSAgasdetection.com
Note: This bulletin contains only a general description of the products shown.
While uses and performance capabilities are described, under no circumstances
shall the products be used by untrained or unqualified individuals and not until
the product instructions including any warnings or cautions provided have
been thoroughly read and understood. Only they contain the
complete and detailed information concerning proper use and
care of these products.
ID 0782-010-MCe/ Mar 2017
© MSA 2015 Printed in U.S.A.
MSA – The Safety Company
1000 Cranberry Woods Drive,
Cranberry Township, PA 16066 USA
Phone [phone]
www.MSAsafety.com
U.S. Customer Service Center
Phone 1-800-MSA-2222
Fax [phone]
MSA Canada
Phone [phone]
Fax [phone]
MSA Mexico
Phone [phone]
Fax [phone]
MSA International
Phone [phone]
Toll Free 1-800-672-7777
Fax [phone]
Email [e-mail]
Source
Receiver
50 to 100m