NailFire D90-NF1 User manual

Strongfast Global Ltd
Richmond Court
128 Maidstone Road
Sidcup
Kent
DA15 5HS
0844 887 1401
0844 887 1401
[e-mail]
www.strongfastglobal.com

D90-NF1, SK464-NF2, SK464A-NF3
Gas Tools

!
3!
!
!
!
!
!"#$%&!'()*'!)#%+),-,$,.,!)*
*
!
It!is!the!employer’s!responsibility!to!assure!this!manual!is!read!and!understood!by!all!personnel!
assigned!to!use!the!tool.!!Keep!this!manual!available!for!future!reference.!
!
!
!
!
!
!
./-$!*%0*1%+.!+.)*
*
!
General!Safety!Warnings!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!4!
Tool!Safety!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!5!
Fuel!Cell!Safety!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!8!
Battery!Safety!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!9!
Charger!Safety!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!10!
Tool!Use!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!11!
Maintenance!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!15!
Troubleshooting!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!16!
Technical!Specification!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!18!!!
Noise!&!Vibration!Information!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!19!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!
Declaration!of!Conformity!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!20!
!
!
!
!
!
!
!
!
!
!

!
4!
)/0!.&*),2+)*
*
2343567*)6839:*;654<4=>*
!
!
Read!and!understand!the!tool!labels!and!manual.!!
Failure!to!follow!warnings!could!result!in!DEATH!
or!SERIOUS!INJURY.!
!
!
!
!
!
Use!safety!equipment.!!Always!wear!ANSI!Z87.1!
safety!glasses!with!permanently!attached!side!
shields,!dust!mask,!non-skid!safety!shoes,!hard!
hat!and!hearing!protection!must!be!used!for!
appropriate!conditions.!!Failure!to!do!so!could!
result!in!personal!injury.!
!
!
!
EXPLOSION!HAZARD!!Never!use!the!tool!in!an!
explosive!atmosphere!or!in!the!presence!of!
combustible!materials!such!as!flammable!liquids,!
gases!or!dust.!!Exhaust!or!sparks!from!the!tool!
may!ignite!atmosphere!gases,!dust!or!other!
combustible!materials.!!DO!NOT!smoke!whilst!
using!or!handling!the!tool!or!fuel!cell.!
!
!
!
EXTREMELY!FLAMMABLE!!The!fuel!cell!is!
liquefied!gas!under!pressure.!!Keep!away!from!all!
sources!of!ignition!such!as!flames,!sparks,!pilot!
lights,!static!discharge!and!hot!surfaces.!
Do!not!spray!contents,!puncture,!crush!or!
attempt!to!open!fuel!cell.!!Do!not!incinerate,!
recycle,!reclaim!or!re-use!fuel!cell!container.!
!
!
Do!not!expose!this!tool!or!fuel!cell!to!
temperatures!above!120°F!(50°C).!Do!not!store!in!
direct!sunlight.!!Overheating!the!tool!or!fuel!cell!
could!result!in!an!explosion,!fire!or!release!of!
flammable!gas.!
!
!
!
Use!and!store!the!tool!and!fuel!cells!in!well!
ventilated!areas!only.!!Do!not!inhale!gas,!exhaust!
or!fumes.!!Exposure!to!the!exhaust!which!
contains!carbon!monoxide!may!cause!nausea,!
dizziness,!unconsciousness!or!other!personal!
injury.!
!
!
!
Stay!alert,!watch!what!you!are!doing,!and!use!
common!sense!when!operating!a!power!tool.!!Do!
not!use!the!tool!whilst!tired!or!under!the!
influence!of!drugs,!alcohol!or!medication.!
A!moment!of!inattention!whilst!operating!power!
tools!may!result!in!serious!personal!injury.!

!
5!
)/0!.&*;/'+,+2)*
*
2343567*)6839:*;654<4=>*
*
!
!
Do!not!overreach.!!Keep!proper!footing!and!
balance!at!all!times.!!Proper!footing!and!balance!
enable!better!control!of!the!tool!in!unexpected!
situations.!
!
!
!
Always!keep!tools,!fuel!cells,!battery!and!battery!
chargers!out!of!reach!of!minors!and!other!
untrained!persons.!!Tools!are!dangerous!in!the!
hands!of!untrained!users.!
!
!
!
Dress!properly.!!Do!not!wear!loose!clothing!or!
jewellery.!!Contain!long!hair.!!Keep!your!hair,!
clothing!and!gloves!away!from!moving!parts.!!
Loose!clothing,!jewellery!or!long!hair!can!be!
caught!in!moving!parts.!
!
.??7*)6839:*;654<4=>*
*
!
!
Do!not!perform!any!emergency!repairs!without!
proper!tools!and!equipment.!
!
!
!
Always!assume!the!tool!contains!fasteners.!!Keep!
the!tool!pointed!away!from!yourself!and!others.!!
No!horseplay.!!Respect!the!tool!as!a!working!
implement.!
!
!
!
Drive!fasteners!into!appropriate!work!surface!
only.!!Never!into!materials!too!hard!to!penetrate.!!
Materials!too!soft!may!allow!a!fasteners!to!drive!
through!and!exit!the!material.!
!
!
!
!
!
!
!
!
!
!

!
6!
!
)/0!.&*;/'+,+2)*
*
.??7*)6839:*;654<4=>*
*
!
!
Do!not!drive!fasteners!close!to!the!edge!of!the!
work!surface.!!The!workpiece!is!likely!to!split!and!
the!fasteners!could!fly!free!or!ricochet!and!hit!
someone.!
!
!
!
Do!not!drive!fasteners!on!top!of!the!other!
fasteners!or!with!the!tool!positioned!at!too!steep!
an!angle.!!The!fasteners!can!ricochet!and!hurt!
someone.!
!
!
!
Do!not!force!the!tool.!!Let!the!tool!do!the!work.!!
Use!the!correct!tool!for!your!application.!!The!
correct!tool!will!do!the!job!better!and!safer!at!
the!rate!for!which!it!is!designed.!
!
!
!
Never!use!any!part!of!the!tool!(i.e;!the!cap!or!
main!body)!as!a!hammer.!!The!tool!may!activate!
or!become!damaged!and!result!in!an!unsafe!
condition.!
!
!
!
Keep!hands!and!other!body!parts!away!from!the!
safety!area!of!the!tool!to!avoid!possible!injury!
during!operation.!
!
!
!
!
!
When!using!the!tool,!care!should!be!taken!due!to!
the!possibility!of!the!tool!recoiling!after!a!
fastener!is!driven.!!If!the!tool!is!unintentionally!
allowed!to!re-contact!work!surface!following!a!
recoil,!an!unwanted!fastener!may!be!driven.!!
Therefore,!allow!the!tool!to!recoil!completely!off!
the!work!surface!after!a!fastener!is!driven!to!
avoid!this!occurring.!!Do!not!push!the!tool!on!to!
the!work!surface!until!a!second!fastener!is!fired.!
!
!
!
Remove!the!battery!and!fuel!cell!from!the!tool!
before!doing!any!tool!maintenance,!clearing!a!
jammed!fastener,!leaving!the!work!area,!moving!
the!tool!to!another!location!or!handing!the!tool!
to!another!person.!
!
!
!
!
!

!
7!
!
)/0!.&*;/'+,+2)*
*
.??7*)6839:*;654<4=>*
*
!
!
The!tool!may!eject!a!fastener!when!the!battery!
and!fuel!cell!are!inserted.!!Therefore,!remove!all!
fasteners!from!the!tool!before!inserting!the!
battery!and!fuel!cell.!
!
!
!
Never!use!the!tool!if!safety,!trigger!or!springs!
have!become!inoperable,!missing!or!damaged.!!
Do!not!tamper!with!or!remove!safety!element,!
trigger!or!springs.!
!
!
!
Make!sure!all!screws!and!caps!are!securely!
tightened!at!all!times.!!Make!daily!inspections!for!
free!movement!of!trigger!and!safety.!!Never!use!
the!tool!if!parts!are!missing!or!damaged.!
!
!
!
!
Use!only!parts,!fasteners!and!accessories!
recommended!or!sold!by!Nailfire.!!Do!not!modify!
the!tool!without!authorisation!from!Nailfire.!
!
!
!
Use!clamps!or!other!practical!ways!to!secure!and!
support!the!workpiece!to!a!stable!platform.!!
Holding!the!work!by!hand!or!against!your!body!is!
unstable!and!may!leas!to!loss!on!control!and!
personal!injury.!
!
!
!
Do!not!use!the!tool!without!a!Warning!label!on!
your!power!tool.!!If!the!label!is!missing,!damaged!
or!unreadable,!contact!your!Nailfire!
representative!to!obtain!a!new!label!at!no!cost.!
!
!
!
!
!
!
!
!
!
!

!
8!
!
)/0!.&*;/'+,+2)*
*
0@37*1377*)6839:*;654<4=>*
*
!
!
Read!the!Safety!Data!Sheet!(SDS)!for!more!
information!on!contents!of!the!fuel!cell.!!The!fuel!
cell!contains!flammable!gas!and!lubricant!for!the!
tool.!!Use!only!fuel!cells!that!are!recommended!
by!the!manufacturer!for!your!model.!
!
!
!
!
Do!not!incinerate,!reclaim!or!recycle!the!fuel!cell.!!
Dispose!of!empty!fuel!cells!in!accordance!with!
local!laws.!
!
!
!
!
Do!not!expose!this!tool!or!fuel!cell!to!
temperatures!above!120°F!(50°C).!!Do!not!store!
in!direct!sunlight.!!Overheating!the!tool!or!fuel!
cell!could!result!in!an!explosion,!fire!or!release!of!
flammable!gas.!
!
!
!
!
Use!and!store!the!tool!and!fuel!cells!in!well!
ventilated!areas!only.!!Do!not!inhale!the!gas,!
exhaust!or!fumes.!!Exposure!to!the!exhaust,!
which!contains!carbon!monoxide!may!cause!
nausea,!dizziness,!unconsciousness!or!other!
personal!injury.!
!!!
!
!
Do!not!puncture!or!attempt!to!open!the!fuel!cell.!!
Accessories!that!may!be!suitable!for!one!tool!
may!create!a!risk!of!injury!when!used!on!another!
tool.!!The!fuel!cell!contains!flammable!gas!even!if!
it!appears!empty.!
!
!
!
EXTREMELY!FLAMMABLE!!The!fuel!cell!is!
liquefied!gas!under!pressure.!!Keep!away!from!all!
sources!of!ignition!such!as!flames,!sparks,!pilot!
lights,!static!discharge!and!hot!surfaces.!!Do!not!
spray!contents,!puncture,!crush!or!attempt!to!
open!the!fuel!cell.!!Do!not!incinerate,!recycle,!
reclaim!or!re-use!the!fuel!cell!container.!
!
!
!
!
!
FIRST!AID!!For!exposure!to!fuel:!
Eyes!–!flush!with!plenty!of!water!
Skin!–!wash!with!soap!and!water!
Inhalation!–!move!patient!to!fresh!air,!provide!
artificial!respiration.!!Seek!medical!help!if!
symptoms!are!severe!or!persistent.!!If!necessary!
consult!Material!Safety!Data!Sheet!for!additional!
information.!

!
9!
!
!
)/0!.&*;/'+,+2)*
*
-69935:*)6839:*;654<4=>*
*
!
!
Use!only!batteries!that!are!recommended!by!the!
manufacturer!for!your!model.!!Accessories!that!
may!be!suitable!for!one!tool!may!create!a!risk!of!
injury!when!used!on!another!too.!
!
!
!
!
Do!not!incinerate!the!battery.!!Dispose!of,!or!
recycle!the!battery!in!accordance!with!local!laws.!
!
!
!
!
Do!not!puncture!or!attempt!to!open!the!battery!
case.!
!
!
!
!
Do!not!immerse!the!battery!in!water.!!Do!not!
expose!the!battery!to!water,!rain!or!snow.!
!
!
!
!
Do!not!charge!batteries!at!temperatures!below!
10°C!(50°F)!or!above!40°C!(104°F)!
!
!
!
Do!not!allow!metal!objects!to!come!into!contact!
with!the!battery!terminals.!
!
!
!
!
!
!
!
!
!
!
!
!

!
10!
!
!
)/0!.&*;/'+,+2)*
*
1A65=35*)6839:*;654<4=>*
*
!
!
EXPLOSION!HAZARD!!Never!use!the!battery!
charger!in!an!explosive!atmosphere!or!in!the!
presence!of!combustible!materials!such!as!
flammable!liquids,!gases!or!dust.!
!
!
!
!
Do!not!puncture!or!attempt!to!open!the!battery!
charger.!
!
!
!
!
Do!not!immerse!the!battery!charger!in!water.!!Do!
not!expose!the!battery!charger!to!water,!rain!or!
snow.!
!
!
!
!
Do!not!use!a!defective!battery!charger,!one!that!
overheats!and/or!smokes!when!plugged!in.!
!
!
!
!
Do!not!operate!the!charger!with!a!damaged!cord!
or!plug.!!If!damaged,!have!the!charger!replaced!
immediately!by!a!qualified!serviceman.!
!
!
!
Do!not!operate!the!charger!if!it!has!received!a!
sharp!blow,!been!dropped!or!otherwise!damaged!
in!any!way.!!Take!it!to!a!qualified!serviceman.!
!
!
!
!
!
!
!
!
!
!

!
11!
!
!
!
!
)/0!.&*;/'+,+2)*
*
1A65=35*)6839:*;654<4=>*
*
!
!
When!not!in!use,!unplug!the!charger!from!the!
outlet.!!To!reduce!the!risk!of!an!electric!shock,!
unplug!the!charger!from!the!outlet!by!the!wall!
mount!unit.!!Do!not!unplug!the!charger!by!pulling!
the!cord.!
!
!
!
!
Do!not!allow!anything!to!cover!the!charger.!
!
!
!
!
Do!not!attempt!to!use!a!step-up!transformer,!an!
engine!generator!or!DC!power!receptacle.!
!
.??7*B>3*
*
!
!
!
Read!section!titled:!!Safety!Warnings!before!
using!the!tool.!
!
!
!
Load!the!battery,!contacts!first!into!the!tool.!!
Push!the!battery!fully!forward!into!the!locked!
position.!!Use!only!Nailfire!batteries.!
!
!
!
Charging!the!battery!procedure:!
The!charger!LED!will!turn!red!when!a!discharged!
battery!is!plugged!into!the!charger.!!It!will!take!
approximately!two!hours!to!charge!the!battery.!
!
When!the!battery!is!recharged!and!ready!for!use!
the!LED!will!turn!to!green.!
!
!
!
!

!
12!
!
!
!
!
)/0!.&*;/'+,+2)*
*
.??7*B>3*
*
!
!
When!a!fully!charged!battery!is!inserted!into!the!
tool,!the!indicator!light!is!green.!!If!the!light!is!
red,!the!battery!need!charging.!
!
!
!
!
Remove!the!fuel!cell!cap.!Use!only!Nailfire!cells.!
!
!
!
Press!down!on!the!front!side!of!the!valve!(stem!
side)!until!is!seats.!
!
!
!
!
!
!
!
Press!down!on!the!rear!side!of!the!valve!until!it!
seats.!
!
!
!
!
!
The!valve!is!now!seated!on!the!fuel!cell!and!can!
be!inserted!into!the!tool.!
!
!
!
!
!
!
Open!the!fuel!cell!door!at!the!top!of!the!tool.!
!
!
!
With!the!metering!valve!stem!pointed!towards!
the!front!of!the!tool,!insert!the!fuel!cell/valve!
assembly.!
!
!
!
!
!

!
13!
!
)/0!.&*;/'+,+2)*
*
.??7*B>3*
*
!
!
!
When!inserting!the!Nailfire!fuel!cell,!make!sure!
the!valve!stem!is!properly!aligned!with!the!small!
orifice.!
!
!
!
Close!the!fuel!cell!cover.!
!
!
!
!
!
!
Insert!the!strip!of!nails!from!the!rear!into!the!
magazine.!
!
!
!
Pull!the!feeder!shoe!back!behind!the!strip!of!nails!
and!push!it!forward!again!together!with!the!nails.!
!
!
!
The!tool!has!a!safety!lock-out!feature,!which!
leaves!a!few!fasteners!in!the!magazine!and!will!
not!actuate.!
!
!
!
Push!the!safety!device!against!the!work!surface!
to!initiate!the!fuel!cell!valve!for!the!first!time.!!
The!fan!starts!simultaneously.!!Lift!off!the!device!
and!repeat!the!process.!!Note:!!Every!new!fuel!
cell!must!first!be!initiated.!
!
!
!
With!the!tool!against!the!work!surface,!squeeze!
the!trigger.!!A!spark!ignites!the!fuel/air!mixture.!!
The!combustion!powers!the!piston!assembly!and!
drives!the!fastener.!
!
!
!
!
!
!
!
!

!
14!
!
)/0!.&*;/'+,+2)*
*
.??7*B>3*
*
!
!
Lift!the!tool,!release!the!trigger!and!the!
combustion!chamber!will!open.!!Fan!exhausts!the!
hot!gas!and!cools!the!internal!parts.!
!
!
!
!
Before!attempting!to!remove!a!jammed!fastener,!
remove!the!fuel!cell!and!battery.!
!
!
!
!
With!your!finger!away!from!the!trigger,!remove!
the!nail!strip!from!the!magazine.!
!
!
!
!
Remove!the!jammed!nail!with!pliers.!
!
!
!
!
Reload!the!fuel!cell!and!battery.!
!
!
!
Reload!the!strip!of!nails.!
!
!
!
!
!
!
!
!
!
!

!
15!
)/0!.&*;/'+,+2)*
*
"6<493464C3*
*
!
!
Read!section!titled!Safety!Warnings!before!
maintaining!the!tool.!!The!fastener!driving!tool!
should!be!serviced!properly!and!at!regular!
intervals!in!accordance!with!the!manufacturers!
instructions.!
!
!
!
!
All!screws!should!be!kept!tight.!!Loose!screws!
result!in!unsafe!operation!and!parts!breakage.!
!
!
With!the!tool!unpowered,!make!daily!inspections!
to!ensure!free!movement!of!the!safety!element!
and!trigger.!!Do!not!use!the!tool!if!the!safety!
element!or!trigger!sticks!or!binds.!
!
!
!
Always!remove!the!battery!and!fuel!cell!at!the!
end!of!each!day!and!before!storing!the!tool!in!
the!tool!case.!!Always!store!and!transport!in!the!
original!Nailfire!tool!case.!
!
!
!
!
Wipe!the!tool!clean!daily!and!inspect!for!wear.!!
When!additional!cleaning!is!needed,!use!only!
non-flammable!cleaning!solutions.!
DO!NOT!SOAK!
Caution:!!Such!solutions!may!damage!O-rings!and!
other!tool!parts.!
!
!
!
!
!
NEVER!PERFORM!THIS!TEST!NEAR!AN!OPEN!
FLAME,!SPARKS!OR!WHILE!SMOKING!OR!WHERE!
FUEL!MAY!GET!IN!YOUR!EYES.!
To!determine!if!the!fuel!cell!has!any!fuel!inside,!
hold!in!an!upright!position!and!place!a!solid!
object!against!the!metering!stem.!!Gently!push!in!
three!to!four!times.!!A!small!amount!of!fuel!
should!be!released!each!time.!!If!no!fuel!is!
released,!dispose!of!the!fuel!cell!properly.!
!
!
!
!
!
Recommended!service!intervals!for!cleaning!of!
the!moving!part!of!the!combustion!chamber!is!
Fifty!thousand!cycles!unless!environmental!
conditions!are!particularly!dirty!or!dusty.!!In!this!
case,!cleaning!is!recommended!every!thirty!
thousand!cycles!or!less.!Replace!the!intake!filter!
at!every!service!interval,!or!more!often!as!
required.!It!is!recommended!that!the!tool!be!
returned!to!an!authorised!service!centre!for!
cleaning.!Use!of!non-flammable!cleaning!solution!

!
16!
!
.'%B-$!)D%%.,+2*
*
;/'+,+2*
Repairs!other!than!those!described!here!should!be!performed!only!by!trained,!qualified!personnel.!
!
'36E*>3C9<?4*9<973E*)6839:*;654<4=>*F38?53*G6<496<4<4=*9??7*
*
):GH9?GI*
Battery!does!not!accept!charge.!
!
)?7@9<?4I*
Monitor!charging!time!to!ensure!battery!has!adequate!time!for!recharging.!!Replace!battery.!!Replace!
charger.!
!
):GH9?GI*
Charger!gets!hot,!makes!loud!noise!or!smokes!during!charging.!
!
)?7@9<?4I*
Discontinue!use!immediately!and!unplug!from!power!source.!!Dispose!of!charger!and!replace.!
!
):GH9?GI*
Fan!does!not!run.!!Tool!indicator!light!is!red.!
!
)?7@9<?4I*
Charge!battery.!!Clean!battery!terminals!with!fine!emery!cloth.!
!
):GH9?GI*
Fan!does!not!run,!or!runs!slower!than!normal.!!Tool!indicator!light!is!red.!
!
)?7@9<?4I*
Charge!battery.!
!
):GH9?GI*
Tool!does!not!depress!fully.!!Tool!does!not!operate.!
!
)?7@9<?4I*
Check!tool,!if!unable!to!fire!up,!return!tool!to!the!authorised!Nailfire!dealer!for!service.!!Remove!and!
inspect!tool.!!Clean!and!lubricate!track!with!Nailfire!oil.!!Replace!safety.!!Position!follower!behind!
fasteners.!
!
):GH9?GI*
Tool!will!not!cycle!–!fan!runs.!
!
)?7@9<?4I*
Replace!fuel!cell.!!Remove!cap!and!check!spark!lead.!!Insert!spark!plug.!!Replace!cap.!
Clean!tool!cylinder!head!and!spark!plug.!!Return!tool!to!the!authorised!Nailfire!dealer!for!service.!!Be!
sure!tool!safety!is!completely!engaged.!!Be!sure!magazine!has!at!least!7!or!more!fasteners!to!ensure!
lockout!feature!is!not!preventing!actuation.!
!
!

!
17!
!
.'%B-$!)D%%.,+2*
*
):GH9?GI*
Tool!operates!properly!but!fasteners!do!not!drive!fully.!
!
)?7@9<?4I*
Check!fuel!cell!and!replace!as!required.!
!
):GH9?GI*
Tool!operates!properly!but!fasteners!are!sometimes!over!driven!and!sometimes!under!driven.!
!
)?7@9<?4I*
Use!only!fasteners!that!meet!Nailfire!specifications.!!Check!applications!section!for!fastener!types!
and!size!recommended.!!Position!feeder!shoe!behind!fastener!strip.!!Clear!jam.!
!
):GH9?GI*
Tool!operates!erratically!or!appears!to!be!losing!power.!
!
)?7@9<?4I*
Check!fuel!cell.!!Check!spark!plug!wire.!!Remove!filter!element!and!replace.!
Check!recommended!cleaning!schedule!and!service!if!required.!
Be!sure!safety!element!is!completely!engaged.!
!
):GH9?GI*
Tool!operates!and!drives!fasteners!but!driver!blade!does!not!return!to!the!up!position.!
!
)?7@9<?4I*
Take!care!that!the!safety!element!is!completely!engaged!when!driving!fasteners.!
Return!to!the!authorised!Nailfire!dealer!for!service.!
!
):GH9?GI*
Combustion!chamber!does!not!drop!after!tool!cycle.!
!
)?7@9<?4I*
Clear!or!replace!work!contacting!element.!
If!tool!will!not!operate!after!following!the!above!service!directives,!return!the!tool!to!the!authorised!
Nailfire!dealer!for!service.!
!
!
!
!
!
!
!
!

!
18!
.!1D+,1/$*)#!1,0,1/.,%+)*
*
.??7*+6G3*
JKLM+0NO*
)PQRQM+0S*
)PQRQ/M+0T*
!
!
!
!
Type!of!tool!
Linear!Combustion!
Linear!Combustion!
Linear!Combustion!
Tool!Size:!!Weight!
3.4!KG!
2.16!KG!
2.16!KG!
Tool!Size:!!Length!
374!MM!
320!MM!
320!MM!
Tool!Size:!!Height!
378!MM!
270!MM!
280!MM!
Tool!Size:!!Width!Main!
Body!
108!MM!
86!MM!
86!MM!
Magazine!Capacity!
60!
100!
100!
Average!Driver!per!
Battery!Charge!
4000!
4000!
4000!
Average!Drives!per!
Fuel!Cell!
1100!
1000!
1000!
Actuation!Mode!
Sequential!
Sequential!
Sequential!
Noisel:!!!!LpA!is!
!!!!!!!!!!!!!!!!LwA!Is!1M!
94.5!dB!
96.4!dB!
89.2!dBA!
94.6!dBA!
89.2!dBA!
94.6!dBA!
Vibration²!
3.39!m/s²!
1.96!m/s²!
2.19!m/s²!
Recommended!
Propellant!
Included!in!Lubricant!
Fuel!Cell!
Included!in!Lubricant!
Fuel!Cell!
Included!in!Lubricant!
Fuel!Cell!
!
* Tool is capable of driving 3.4 x 90 mm nails. But there is no guarantee the nails will be fully driven as this
will depend on the type of nail and the density of the wood. It is advisable to determine acceptability to the
application before purchasing this tool.

!
19!
NOISE AND VIBRATION INFORMATION
Noise Information
Noise values are tool related characteristic values and do not represent noise developed at the point of use.
Workplace design can also serve to reduce noise levels. Eg: placing the work piece on sound damping supports.
Vibration Information
Vibration values are a tool related characteristic value and do not represent the influence to the hand-arm system
when using the tool.
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!

!
20!
!
!
!
!
!
!
J!1$/'/.,%+*%0*1%+0%'",.&*
*
!
Strongfast!Global!Ltd!
Richmond!Court!
128!Maidstone!Road!
Sidcup!
Kent!
DA15!5HS!
!
Tel:!!+44!(0)844!887!1401!
!
Email:!![e-mail]!
!
!
Declare!under!our!sole!responsibility!!that!the!product!identified!below!to!which!this!declaration!
relates!is!in!conformity!with!the!following!standards!or!other!normative!documents:!
EN!12100:2100,!!EN!792-13:2000!+!A1:2008!!following!the!provisions!of!Directive!2006/42/EC!
!
Kent,!United!Kingdom!!01.09.2016!
!
!
!
Norman Shimwell
!
!
N!Shimwell!
!
!
!
!
!