Napoleon Tourch GSST8N User manual

1
W415-0689 / A / 06.08.10
OUTDOOR
$10.00
INSTALLER: LEAVE THIS MANUAL WITH THE APPLIANCE.
CONSUMER: RETAIN THIS MANUAL FOR FUTURE REFERENCE.
INSTALLATION AND
OPERATING INSTRUCTIONS
1.2A
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON, L4M 4Y8 Canada /
103 Miller Drive, Crittenden, Kentucky, USA, 41030
Phone [phone] • Fax [phone] • www.napoleonfireplaces.com • [email protected]
SAFETY INFORMATION
!WARNING
If the information in these instructions are
not followed exactly, a fire or explosion
may result causing property damage,
personal injury or loss of life.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Immediately call your gas supplier from a
neighbour’s phone. Follow the gas supplier’s
instructions.
• If you cannot reach your gas supplier, call the
fire department.
- Installation and service must be performed by a
qualified installer, service agency or the supplier.
CERTIFIED FOR CANADA AND UNITED STATES USING ANSI/CSA METHODS.
GSST8N
NATURAL GAS
GSST8P
PROPANE
CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS: CR97-003 ●CAN-2.21-M85 ●IAS US. 4-96
WARNING: FOR OUTDOOR USE ONLY

2
W415-0689 / A / 06.08.10
NOTE: Changes, other than editorial, are denoted by a line in the margin.
TABLE OF CONTENTS
1.0 INSTALLATION OVERVIEW 3
2.0 INTRODUCTION 4
2.1 DIMENSIONS 5
2.2 GENERAL INSTRUCTIONS 5
2.3 GENERAL INFORMATION 6
2.4 RATING PLATE INFORMATION 7
3.0 INSTALLATION 8
3.1 INSTALLATION CLEARANCES 8
3.2 GAS INSTALLATION 9
3.3 COMBUSTION AND VENTILATION AIR 9
4.0 FRAMING 10
4.1 CLEARANCES TO COMBUSTIBLES 10
5.0 FINISHING 11
5.1 TMCSS MOUNTING CABINET INSTALLATION 11
5.2 RAIN TABS 12
5.3 DOOR REMOVAL 13
5.4 TFSSO FRAME INSTALLATION 14
5.5 LOGO PLACEMENT 14
5.6 GLASS MEDIA INSTALLATION 15
5.7 LK8 LIGHT INSTALLATION (OPTIONAL) 16
6.0 ELECTRICAL INFORMATION 17
7.0 OPERATION 18
8.0 ADJUSTMENTS 19
8.1 GAS PRESSURE ADJUSTMENT 19
8.2 VENTURI ADJUSTMENT 19
8.3 FLAME CHARACTERISTICS 19
9.0 MAINTENANCE 20
9.1 CARE OF GLASS 20
9.2 DOOR GLASS REPLACEMENT 21
9.3 CARE OF STAINLESS STEEL 21
10.0 REPLACEMENTS 22
11.0 TROUBLE SHOOTING 24
12.0 WARRANTY 26
13.0 SERVICE HISTORY 27

3
W415-0689 / A / 06.08.10
1.0 INSTALLATION OVERVIEW
Cabinet, see “MOUNTING
CABINET INSTALLATION”
section.
Door, see “DOOR
REMOVAL / INSTALLATION”
section.
Glass, see “GLASS
REMOVAL / INSTALLATION”
section.
Frame, see “FRAME /
FRONT INSTALLATION”
section.
Rating plate, see “RATING PLATE
INFORMATION” section.

4
W415-0689 / A / 06.08.10
3.14
!
WARNING
• THIS APPLIANCE IS HOT WHEN OPERATED AND CAN CAUSE SEVERE BURNS IF CONTACTED.
• Do not operate appliance before reading and understanding operating instructions. Failure to operate
appliance according to operating instructions could cause fire or injury.
• Any changes to this appliance or its controls can be dangerous and is prohibited.
• Risk of burns. The appliance should be turned off and cooled before servicing.
• Do not install damaged, incomplete or substitute components.
• Risk of cuts and abrasions. Wear protective gloves and safety glasses during installation. Sheet metal
edges may be sharp.
• Do not burn wood or other materials in this appliance.
• Provide adequate ventilation and combustion air. Provide adequate accessibility clearance for servicing
and operating the appliance. Never obstruct the front opening of the appliance.
• If appliance keeps shutting off, have it serviced. Keep burner and control compartment clean.
• Do not allow wind to blow directly into the appliance. Avoid any drafts that alter burner flame patterns.
• Young children should be carefully supervised when they are in the same room as the appliance. Tod-
dlers, young children and others may be susceptible to accidental contact burns. A physical barrier is
recommended if there are at risk individuals in the house. To restrict access to an appliance or stove,
install an adjustable safety gate to keep toddlers, young children and other at risk individuals out of the
room and away from hot surfaces.
• Clothing or other flammable material should not be placed on or near the appliance.
• Furniture or other objects must be kept a minimum of 4 feet away from the front of the appliance.
• Ensure you have incorporated adequate safety measures to protect infants/toddlers from touching hot
surfaces.
• Even after the appliance is out, the screen will remain hot for an extended period of time.
• Check with your local hearth specialty dealer for safety screens and hearth guards to protect children
from hot surfaces. These screens and guards must be fastened to the floor.
• Any safety screen or guard removed for servicing must be replaced prior to operating the appliance.
• It is imperative that the control compartments, burners and circulating blower and its passageway in the
appliance and venting system are kept clean. The appliance and its venting system should be inspected
before use and at least annually by a qualified service person. The appliance area must be kept clear
and free from combustible materials, gasoline and other flammable vapors and liquids.
• Under no circumstances should this appliance be modified.
• Do not use this appliance if any part has been under water. Immediately call a qualified service techni-
cian to inspect the appliance and to replace any part of the control system and any gas control which
has been under water.
• Keep the packaging material out of reach of children and dispose of the material in a safe manner. As
with all plastic bags, these are not toys and should be kept away from children and infants.
2.0 INTRODUCTION

5
W415-0689 / A / 06.08.10
2.1 DIMENSIONS
2.2 GENERAL INSTRUCTIONS
49 11/16”
GAS LINE
ACCESS
ELECTRICAL
ACCESS
6 Ǫ”
1 ½”
15”
13”
7 9/16”
ALWAYS LIGHT THE PILOT WHETHER FOR THE FIRST TIME OR IF THE GAS SUPPLY HAS RAN OUT,
WITH THE GLASS DOOR OPENED OR REMOVED.
NEVER OBSTRUCT THE FRONT OPENING OF THE APPLIANCE.
OBJECTS PLACED IN FRONT OF THE APPLIANCE MUST BE KEPT A MINIMUM OF 48” FROM THE
FRONT FACE OF THE APPLIANCE.
FIRE RISK. EXPLOSION HAZARD.
HIGH PRESSURE WILL DAMAGE VALVE. DISCONNECT GAS SUPPLY PIPING BEFORE PRESSURE
TESTING GAS LINE AT TEST PRESSURES ABOVE 1/2 PSIG. CLOSE THE MANUAL SHUT-OFF VALVE
BEFORE PRESSURE TESTING GAS LINE AT TEST PRESSURES EQUAL TO OR LESS THAN 1/2 PSIG.
USE ONLY WOLF STEEL APPROVED OPTIONAL ACCESSORIES AND REPLACEMENT PARTS WITH
THIS APPLIANCE. USING NON-LISTED ACCESSORIES (BLOWERS, DOORS, LOUVRES, TRIMS, GAS
COMPONENTS, VENTING COMPONENTS, ETC.) COULD RESULT IN A SAFETY HAZARD AND WILL
VOID THE WARRANTY AND CERTIFICATION.
THE APPLIANCE IS ONLY FOR USE WITH THE TYPE OF GAS INDICATED ON THE RATING PLATE.
THIS APPLIANCE IS NOT CONVERTIBLE FOR USE WITH OTHER GASES.
!
WARNING

6
W415-0689 / A / 06.08.10
RATES AND EFFICIENCIES
NATURAL GAS PROPANE GAS
Altitude 0 - 4,500* 0 - 4,500*
Maximum Input 6,000 6,000
Minimum Inlet Gas Supply Pressure 4.5” Water Column 11” Water Column
Maximum Inlet Gas Supply Pressure 7” Water Column 13” Water Column
Manifold Pressure Under Flow Conditions 3.5” Water Column 10” Water Column
4.3
THIS GAS APPLIANCE SHOULD BE INSTALLED AND SERVICED BY A QUALIFIED INSTALLER to
conform with local codes. Installation practices vary from region to region and it is important to know the
specifics that apply to your area, for example in Massachusetts State:
• The appliance damper must be removed or welded in the open position prior to installation of a appliance
insert or gas log.
• The appliance off valve must be a “T” handle gas cock.
• The flexible connector must not be longer than 36 inches.
• A Carbon Monoxide detector is required in all rooms containing gas fired appliances.
• The appliance is not approved for installation in a bedroom or bathroom unless the unit is a direct vent
sealed combustion product.
The installation must conform with local codes or, in
absence of local codes, the National Gas and Propane
Installation Code CSA B149.1 in Canada, or the National
Fuel Gas Code, ANSI Z223.1 / NFPA 54 in the United
States. Suitable for mobile home installation if installed in
accordance with the current standard CAN/CSA Z240MH
Series, for gas equipped mobile homes, in Canada or
ANSI Z223.1 and NFPA 54 in the United States.
We suggest that our gas
hearth products be installed
and serviced by professionals
who are certied in the U.S.
by the National Fireplace
Institute
® (NFI) as NFI Gas
Specialists
www.ncertied.org
2.3 GENERAL INFORMATION
FOR YOUR SATISFACTION, THIS APPLIANCE HAS BEEN TEST-FIRED TO ENSURE ITS OPERATION
AND QUALITY!
When the appliance is installed at elevations above 4,500ft, and in the absence of specific recommendations
from the local authority having jurisdiction, the certified high altitude input rating shall be reduced at the rate of
4% for each additional 1,000ft.
This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convert-
ible for use with other gases, unless a certified kit is used.
Expansion / contraction noises during heating up and cooling down cycles are normal and are to be expected.
Purge all gas lines with the glass door of the appliance removed. Ensure that a continuous gas flow is at the
burner before replacing the door.
Objects placed in front of the appliance must be kept a minimum of 48” from the front face of the unit.
Use only authorized accessories designed for and listed with the model.

7
W415-0689 / A / 06.08.10
2.4 RATING PLATE INFORMATION
RATING LABEL LOCATION: THE RATING LABEL IS LOCATED UNDER THE CONTROL PANEL AND IS
CHAINED TO THE APPLIANCE. DO NOT REMOVE.
CERTIFIED UNDER : CGA CR97-003 (July, 1997) CSA US Req. 4-96, 3rd Ed. OUTDOOR GAS FIREPLACE
IF APPLIANCE HAS BEEN SUPPLIED WITH A GAS PRESSURE REGULATOR, IT MUST BE USED. THE
GAS SUPPLY MUST BE TURNED OFFAT THE LP-GAS SUPPLY CYLINDER WHEN THISAPPLIANCE IS
NOT IN USE. DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORSAND LIQUIDS IN
THE VICINITY OF THIS ORANY OTHER APPLIANCE. IMPROPER INSTALLATION, ADJUSTMENT,
ALTERATION, SERVICE OR MAINTENANCE CAN CAUSE INJURY OR PROPERTY DAMAGE. REFER TO
THE OWNER’S MANUAL PROVIDED WITH THIS APPLIANCE. FOR ASSISTANCE OR ADDITIONAL
INFORMATION, CONSULT AQUALIFIED INSTALLER, SERVICE AGENCY OR GAS SUPPLIER. MUST
NOT BE USED FOR COOKING. FOR OUTDOOR USE ONLY. IF STORED INDOORS, DETACH AND
LEAVE CYLINDER OUTDOORS.
ALTITUDE
INPUT
ORIFICE
MANIFOLD PRESSURE: 3.5" WATER COLUMN
MINIMUM SUPPLY PRESSURE: 4.5" WATER COLUMN
MAXIMUM SUPPLY PRESSURE: 7.0" WATER COLUMN
MANIFOLD PRESSURE: 10" WATER COLUMN
MINIMUM SUPPLY PRESSURE: 11" WATER COLUMN
MAXIMUM SUPPLY PRESSURE: 13"WATERCOLUMN
0-4500FT(0-1370m)
6,000BTU/h
#69
0-4500FT(0-1370m)
6,000BTU/h
#56
CERTIFIED FOR CANADA AND USA
GSST8N
MODEL
GSST8P
MODEL
W385-0420 / C
GSST8
NOT FOR USE WITH SOLID FUEL. FOR USE WITH
GLASS DOOR. CERTIFIED WITH THIS UNIT ONLY.
WARNING: DO NOT ADD ANY MATERIAL TO THE
APPLIANCE, WHICH WILL COME IN CONTACT WITH THE
FLAMES, OTHER THAN THAT SUPPLIED BY THE
MANUFACTURER WITH THE APPLIANCE.
MINIMUM CLEARANCES TO COMBUSTIBLE MATERIALS
TOP 18” BACK 0”
SIDES 1” FLOOR 8”
MADEIN CANADA
WOLF STEEL LTD, BARRIE, ON, CANADA
SERIALNUMBER:
ELECTRICAL RATING: 115v 0.82AMP, 60HZ
REFERENCE
# W/N 16036
TOP, SIDES & BACK AS PER ABOVE. FOR FINISHING
MATERIAL, SEE OWNERS MANUAL.
(NATURAL GAS) (PROPANE)
THIS APPLIANCE IS ONLY FOR USE WITH THE TYPE
OF GAS INDICATED ON THE RATING PLATE. THIS
APPLIANCE IS NOT CONVERTIBLE FOR USE WITH
OTHER GASES, UNLESS A CERTIFIED KIT IS USED.
C
SAMPLE
. OUTDOOR GAOUTDOOR G
LATOR, IT MUST BELATOR, IT MUST B
LINDER WHEN THIS APPLINDER WHEN THIS APP
LAMMABLE VAPORS AND LIQ
MABLE VAPORS AND LIQ
PER INSTALLATION, ADJUSTMEALLATION, ADJUSTME
NJURY OR PROPERTY DAMAGEOPERTY DAMAG
NCE. FOR ASSISTANCE OR ADDNCE. FOR ASSISTANCE OR AD
SERVICEAGENCY OR GAS SUPERVICEAGENCY OR GAS SU
SE ONLY. IF STORED INDOORSNLY. IF STORED INDOOR
A
A
LL
TITUDETITUDE
LL
I
I
NN
P
P
U
T
O
RIFI
CEORIFIC
AA
TERT
AA
CO
L
U
M
COLUM
N
N
WW
AA
WWW
TERTER
AA
A
CO
L
U
M
COLUM
NN
7.0"0"
WW
AA
WWW
TERTER
AAA
CO
L
U
M
COLUM
NN
M
ANIFOL
DMANIFOLD
PP
MINIMUMMINIMU
S
MAXIMAXIM
CANADA AND USACANADA AND U
L
L
MM
OO
Y MATERIAL TO THERIAL TO THE
ME IN CONTACT WITH THEME IN CONTACT WITH THE
AT SUPPLIED BY THEAT SUPPLIED BY THE
THE APPLIANCE.HE APPLIANCE.
CES TO COMBUSTIBLE MATEO COMBUSTIBLE MATE
BACKCK
FLOORFLOOR
RICAL RATING: 115v 0.82AMP,
AL RATING: 115v 0.82AMP
& BACK AS PER ABOVE. FOR& BACK AS PER ABOVE. FO
L, SEE OWNERS MANUAL.
SEE OWNERS MANUAL.
SAMPLE
This illustration is for reference only. Refer to the rating plate on the appliance for accurate information.

8
W415-0689 / A / 06.08.10
3.0 INSTALLATION
3.1 INSTALLATION CLEARANCES
G
G
J
IK
A
C
DE
F
H
B
B
INSTALLATIONS
CANADA U.S.A.
A8 INCHES 8 INCHES Clearance above grade, veranda porch, deck or balcony.
B12 INCHES 9 INCHES Clearance to windows or doors that open.
C12 INCHES* 12 INCHES* Clearance to permanently closed windows.
D18 INCHES** 18 INCHES** Vertical clearance to ventilated soffit.
E12 INCHES** 12 INCHES** Vertical clearance to an unventilated soffit.
F1 INCH 1 INCH Clearance to an inside combustible corner wall or protruding
combustible obstructions. (vent chase, etc.)
G3 FEET 3 FEET*** Clearance to each side of the centre line extended above the metre/
regulator assembly to a maximum vertical distance of 15 ft.
H3 FEET 3 FEET*** Clearance to a service regulator vent outlet.
I12 INCHES 9 INCHES Clearance to a non-mechanical air supply inlet to the building or a
combustion air inlet to any other appliance.
J6 FEET 3 FEET**** Clearance to a mechanical air supply inlet.
K12 INCHES 12 INCHES*** Clearance under a veranda, porch, deck or balcony.
* Recommended to prevent condensation on windows and thermal breakage.
** It is recommended to use a heat shield and to maximize the distance to vinyl clad soffits.
*** This is a recommended distance. For additional requirements check local codes.
**** Three feet above if within 10 feet horizontally.

9
W415-0689 / A / 06.08.10
3.2 GAS INSTALLATION
3.2.1 The appliance is designed to accept a 1/2” gas
supply line. The appliance is equipped with a 1/2”
manual shut-off valve.
3.2.2 The access to the gas inlet is located in the bottom
of the cabinet.
3.2.3 The shut off valve / flex connector assembly must
always be contained within the cabinet.
3.2.4 When flexing any gas line, support the gas valve
so that the lines are not kinked.
3.2.5 Check for gas leaks by brushing on a soap and
water solution.
W385-0380
SHUT OFF
VALVE
FLEX
CONNECTOR
!
WARNING
ALL GAS CONNECTIONS MUST BE CONTAINED WITHIN THE APPLIANCE WHEN COMPLETE.
DO NOT USE OPEN FLAME.
This appliance is intended for installation on an outdoor patio or in your yard. It must never be installed inside
the warm air envelope of your structure.
It is highly recommended that this appliance be installed in a “sheltered” area. Direct wind will cause an erratic
flame and possible pilot or main burner outage. An erratic flame could also lead to excessive carboning (black
soot), this condition is not a safety issue but is visually undesirable.
Typical installation may include covered patio, screened porch, gazebo, or on an outside wall of a house.
3.3 COMBUSTION AND VENTILATION AIR
!
WARNING
ENSURE THE AREA HAS ADEQUATE VENTILATION.

10
W415-0689 / A / 06.08.10
YOUR APPLIANCE IS DESIGNED FOR OUTDOOR APPLICATION ONLY. THE APPLIANCE MUST BE IN-
STALLED IN THE CABINET PROVIDED. THE CABINET IS DESIGNED TO BE INSTALLED ON FINISHED
SURFACES.
YOUR APPLIANCE CAN BE RECESSED INTO A STRUCTURE A MAXIMUM OF 12” PROVIDED THAT
ALL CLEARANCES ARE MAINTAINED.
THE CABINET MAY BE INSTALLED DIRECTLY ONTO A COMBUSTIBLE SURFACE.
!
WARNING
4.0 FRAMING
MINIMUM CLEARANCES TO COMBUSTIBLES:
- 18” to top
- 1” to sides
- 8” to bottom
- 0” to rear
4.1 CLEARANCES TO COMBUSTIBLES
24”
MAX.
18”
MIN.
OUTDOOR
8”
MIN.
VENTILLATED
SOFFIT