National Products my junior jet 0450 User manual

IMPORTANT
READ THIS OWNER’S
MANUAL COMPLETELY
BEFORE OPERATING
THIS RIDE ON / REMOTE
CONTROL THE VEHICLE
OWNER’S MANUAL
AND ASSEMBLY INSTRUCTIONS
Please read this manual before assembling
and use four "AA" size & one 9V batteries
required (included)
Not recommended for children
under 24 months old.
Y
J
U
N
I
N
O
R
J
E
J
T
B
a
t
t
e
r
y
rr
O
p
e
r
a
r
t
e
d
R
a
d
i
d
o
C
o
n
t
r
o
r
l
R
i
d
e
O
n
M
MM
YY
Y
Y
Y
J
JJ
U
U
U
UU
N
N
N
NN
II
N
N
N
NN
I
I
I
O
O
N
N
I
I
O
O
O
R
R
R
RR
J
JJ
EE
J
J
J
E
E
E
TT
J
J
E
E
T
TT
B
B
B
a
a
a
a
a
t
t
t
t
t
t
t
t
t
t
ee
e
e
e
r
r
r
r
r
y
y
r
r
y
y
y
y
y
y
y
O
O
O
pp
OO
p
p
p
e
e
pp
e
e
e
r
r
r
r
r
a
a
r
r
r
a
a
a
t
t
r
r
a
a
a
t
t
t
e
e
e
e
e
d
d
d
d
d
R
R
R
a
a
a
a
a
d
d
d
d
d
i
i
d
d
d
d
i
i
i
oo
d
d
i
i
i
o
o
o
C
C
C
o
o
o
o
o
n
n
n
n
n
t
t
t
t
t
rr
t
t
t
t
r
r
r
o
o
rr
rr
tt
rr
r
o
o
o
l
l
r
o
o
o
l
l
l
R
R
R
i
i
i
i
i
d
d
d
d
d
e
e
d
e
e
e
e
e
O
O
O
nn
n
n
n
0-24M
Battery Operated Ride on for ages 2+ to 7 years.
Adult Assembly Required.
Item No. : 0450 / 0451
0452 / 0453

1
MANUAL INDEX
I
M
P
O
R
T
A
T
T
N
T
N
O
T
I
T
T
C
E
P
R
O
D
U
C
T
S
P
E
C
I
F
I
C
A
C
C
T
I
T
T
O
N
T
O
TT
O
L
N
E
E
E
D
E
E
E
D
E
E
/
C
O
M
P
O
N
E
N
E
T
L
I
S
T
S
A
S
S
F
E
F
F
T
Y
C
A
C
C
U
T
I
T
T
O
N
B
A
B
B
T
T
E
T
T
R
Y
I
N
F
O
R
M
A
M
M
T
I
T
T
O
N
A
S
S
E
M
B
L
Y
I
N
S
T
R
T
T
U
C
T
I
T
T
O
N
S
O
P
E
R
A
R
R
T
I
T
T
N
G
Y
O
YY
U
R
V
E
V
V
H
E
E
I
C
L
E
M
a
n
u
a
l
M
o
d
e
R
e
m
o
t
e
C
o
n
t
r
t
t
o
r
r
l
M
o
d
e
T
R
T
T
O
U
B
L
E
S
H
O
O
T
I
T
T
N
G
F
C
C
S
T
A
T
T
T
E
T
T
M
E
N
E
T
S
T
T
2
2
3
4
6
7
1
0
1
2
1
4
1
5

SPECIFICATION
2
IMPORTANT NOTICE
THE RECHARGE BATTERY HAS BEEN CHARGE FOR 24 HOURS
BEFORE FIRST USE.
Control Mode -- Manual Control
-- Remote Control <Full Function >
Battery -- 1 x Rechargeable 6- Volt battery 14Ah
-- 4 x AA (LR6) batteries.
-- 1 x 9-Volt (6LR61) battery. < For remote controller >
Max. loading 65lbs / 30kg
Product Size 80(L) x 77(W) x 52(H) cm /
31.5(L) x 30.25(W) x 20.5(H) inch
Speed High Speed -- approx. 2.1km/hr
Low Speed --- approx. 1.8 km/hr
Sound Effect Mute / Default / Forward / Reverse
Max. R/C range 20ft / 6M <remark>
R/C frequency 27 Mhz
Gross Weight 32.3Lbs / 14.7 kg
Adaptor 110V ~ 120VAC
For Age 2+ to 7 years
Remark:
The max. R/C range is limitation of playground environment.
Please see FCC statement for more information.
(After 12 - 14 hours of charging; can be used for 1 hour)

TOOL NEEDED (NOT INCLUDED)
COMPONENT LIST
1
PHILLIPS SCREWDRIVER
X1
4 5 67
X1 X1 X1 X1
8 9 10
X1 X1
3
X1
X1
2
3
MAIN BODY LEFT WING
( with traing flywheel )
RIGHT WING
( with traing flywheel )
RIGHT AILERON LEFT AILERON STEERING
WHEEL SEAT
ADAPTOR REMOTE
CONTROLLER RECHARGEABLE
BATTERY
X1

4
SAFETY CAUTON
1./ Adult supervision is required when a child is riding or child is remote control the vehicle.
2./ The car should be checked for damage every time before use.
3./Thetoyisintendedtobeassembledbyanadult.
4./ Teach the child how to operate the car before he/she starts to drive.
5./ Teach the child to release the accelerating pedal and ask for adult's help as the car
encounters an obstacle and stops.
6./ This vehicle is suitable for children ages 2+ to 7 years old.
7./ Do not overload the vehicle; the Ride on Car is designed for one child at a time that
weights 65lbs / 30kg or less.
8./ Children should always wear shoes while operating this vehicle.
9./Makesurethechildisseatedproperlyintheseatwhile.
10./ The vehicle should be cut-off power after using.
11./ The battery charger should be operated by an adult and kept out of reach of children.
12./ Do not ride the vehicle near a swimming pool, steps, streets, inclines, driveways.
13./ Do not drive the vehicle outdoor when bad weather situation such as raining ,snowing,etc.
14./ Keep the vehicle in dry area when not in use; moisture will cause the metal components
and electrical parts to corrode.
15./ To avoid accidental operation, remove battery pack when not in use for children from
driving themselves without adult's supervision.
16./ The charger adaptor is a not toy, when the vehicle is charging. Adult must make sure the
vehicle has come to full stop.
17./ The charger adaptor used with the toy has to be regularly examined for the damage to
the cord, plug, enclosure and other parts. In the event of such damage, a new charger
adaptor should replace the damaged.
18./ Please ensure the vehicle is placed in an adequately ventilated location during charging.
19./ Clean the vehicle with a dry cloth and please do not wash the vehicle with water.
20./ Please do not adding extra pull loading when the vehicle is moving.
21./ Please do not eating and drinking during drive the vehicle.
22./ Keep fingers, hair and loose clothing away from the tires and the wheel hobs while
thevehicleisanoperation.
23./ Do not pick up vehicle while in Motion.
Special safety precautions for remote control mode.
1./ Radio interference is caused by the presence of another radio-controlled vehicle operating
on the same time frequency as our vehicle.
2./ Radio interference can be caused by the operation of your vehicle near high voltage
electrical wires, large steel reinforced concrete buildings and passing trucks with CB radio.
3./ For best results, hold remote controller antenna up, not pointed down toward the R/C
vehicle. Too far away from the transmitter, your signal strength will become weak and
the vehicle will not function properly.

SAFETY CAUTON ( Contd. )
Rechargeable
Battery
LED
Low voltage detective function
The vehicle has low voltage auto detective function. This function can keep both ride on or remote
control the vehicle in safety situation by child if it is very low voltage level status. The LED is active for
battery voltage status either "AA" batteries and/or Rechargeable battery. It inform to user should replace
the 4 x "AA" batteries and/or Rechargeable battery should be recharge. This function is appear as following:
2./ If the "AA" batteries voltage level is too low:
-- Flash light is auto TURN OFF.
-- DISABLE the Remote Control function.
1./ If the rechargeable battery voltage level is too low:
-- The monitoring LED is TURN ON.
5
LED lighting

6
BATTERY INFORMATION
A./ ABOUT RECHARGE BATTERY TIPS
A.1 The battery has been charged fully before it's shipping out from the factory. Charge 24 hours before
your first use and make sure the battery charging line is connected with the charger.
A.2 Recharge 12-14 hours before use. Please keep min. TWO times of charge in every
month if vehicle non-use in long time period.
A.3 Recharge the Ride on Car battery immediately after use. Average charging time is 12-14 hours,
any time after this and the charger itself is comes warm to the touch.
A.4 Disconnect the battery terminal with the main wire set terminal if the product will not be used for long time.
A.5 Do not operates the product while recharging.
A.6 Only recharge adaptors of the same as attached or equivalent type are recommended to be use.
A.7 Non-rechargeable batteries cannot be recharged.
A.8 Warning! During charging, avoid explosive gases, flames and sparks.
A.9 If removable rechargeable batteries are used; they are only to be charge under adult supervision.
A.10 Rechargeable batteries are to be removed form the toy before they are charged.
A.11. Fuse : To protect the electrical system from over loading. To avoid poor recharging, the
electrical system is protected from continuous high current power surges.
A.13. Remove the car seat and check if the fuse
is blown. Relpace the fuse as necessary.
Check on the wires and make sure the wire
are connected properly as following graphic:
Good Fuse
Bad Fuse
ATTENTION:
The adaptor used with the Ride on Car is to be regularly examined for damage to the
cord plug, enclosure and other parts. In the event of such damage, the toy must not be
used with this adaptor until the damage has been required.
STEP 1 :
Remove the seat
STEP 2:
To charge the battery,
disconnected the plug of
the socket from vehicle.
STEP 3 :
Connect the charger plug into
the socket as shown.
SETP 4 :
After it is fully charged. The plug
must be reconnected into socket
AC

7
BATTERY INFORMATION ( Contd. )
B./ ABOUT 4 x 1.5VAASIZE ( LR 6 ) & 1x 9V ( 6LR 61 ) BATTERY TIPS:
B.1 Do not mix old and new batteries.
B.2 Do not mix different types of batteries: alkaline, standard (carbon-zinc) or rechargeable
(nickel - cadmium).
B.3 Remove the batteries during long periods of non-use. Always remove exhausted batteries
from the toy. Battery leakage and corrosion can damage this toy. Dispose of batteries safety.
B.4 Do not disposal of batteries in a fire. The batteries may explode or leak.
B.5 Never short-circuits the battery terminals.
B.6 Non-rechargeable batteries are not to be recharged.
B.7 Only batteries of the same or equivalent type as recommended in the " Battery Replacement "
instructions are to be used.
B.8 If removable rechargeable batteries are used; they are only to be charge under adult supervision.
B.9 Rechargeable batteries are to be removed from the toy before they are charged.
B.10 If you use a battery charger, it should be examined regularly for damage to the cord, plug,
enclosure and other parts. Do not use a damaged battery charger until it has been replaced.
KEEP THIS FOR REFERENCE SINCE CONTAINS IMPORTANT INFORMATION.
ASSEMBLY INSTRUCTIONS
STEP 1. Assembly the right wing into the main body
-- Put the right wing into body left wing slot.
-- Make sure the right wing insert in good position.
STEP 2. Assembly the left wing into the main body
-- Put the left wing into body left wing slot.
-- Make sure the left wing insert in good position.

8
ASSEMBLY INSTRUCTIONS
STEP 3. Assembly the right aileron
-- Put the right aileron on the main body.
STEP 4. Assembly the left aileron
-- Put the left aileron on the main body.
STEP 5. Insert the 6V recharge battery pack into the body.
-- Unscrew and open the left door of main body by Phillips screwdriver (see fig.a).
-- Press the limit pin. (see fig. b).
-- Insert the recharge battery from LEFT door. (see fig. c)
-- Please check the recharge battery is good installation in the body. Good installation should be lock
by limit pin.
-- Connect battery terminal into main wire set terminal. (see fig. d)
-- Close the left door and tighten screw.
a
b
d
c

9
ASSEMBLY INSTRUCTIONS
STEP6.Insertthe4x1.5VAAbatteriesinmainbody.
-- Unscrew the battery cover on rear side of body.
-- Open the cover and put FOUR " AA " size batteries inside
the compartment. Make sure the batteries are put in the
correct polar direction.
-- Replace the cover and tighten screw.
STEP 7. Assembly the seat
-- Make sure the seat pin is slot in the main body hole.
-- Put the seat on the main body.
STEP 8. Assembly the Steering wheel
-- Press the button on the shaft of steering wheel.
Let position pin to put it down
-- Make sure the shaft of steering wheel is insert to steering
hole lower position in main body.
-- Release the button of the steering wheel and then rotate
steering wheel to feel the position pin is locked.
1 1
2
2
STEP 9. Insert 9V battery in Remote Controller. < Remote Control only >
-- Unscrew the battery cover on rear side of remote controller.
-- Open the cover and put ONE " 9V " battery inside the
compartment. Make sure the battery is put in the correct
polar direction.
-- Replace the cover and tighten screw.