Nodka TPC6000-A152 User manual

TPC6000‐A152UserManual
1



UserManualVer1.0
TPC6000‐A152
IndustrialPanelPC

TPC6000‐A152UserManual
2
COPYRIGHT
COPYRIGHTNOTICE
Theinformationinthisdocumentissubjecttochangewithoutpriornoticeinorderto
improvereliability,designandfunctionanddoesn’trepresentacommitmentonthepartof
manufacturer.
Innoeventwillthemanufacturerbeliablefordirect,indirect,special,incidental,or
consequentialdamagearisingoutoftheuseorinabilitytousetheproductor
documentation,evenifadvisedofpossibilityofsuchdamages.
Thisdocumentcontainsproprietaryinformationprotectedbycopyright.Allrightsare
reserved.Nopartofthismanualmaybereproducedbyanymechanical,electronic,orother
meansinanyformwithoutpriorwrittenpermissionofmanufacturer.

TRADEMARKS
Allregisteredtrademarksandproductnamesmentionedhereinareusedfor
identificationpurposesonlyandmaybetrademarksand/orregistertrademarksoftheir
respectiveowners.

AMIisatrademarkofAmericanMegatrends,Inc.
Intel&BaytrailaretrademarksofIntelCorporation
IBM,PC/AT,PS/2&VGAaretrademarksofInternationalBusinessMachinesCorporation
MicrosoftWindowsisatrademarkofMicrosoftCorp.
RTListrademarkofRealtekSemiconductorCo.,Ltd.

DECLARATIONOFCONFORMITY
Thisrestrictionissubjecttoprovideprotectionforsystemoperationinbusiness
environment,whichwillproduce,useandtransmitradiofrequencyenergy.Withoutnotice
oftheinstructionsofthecorrectinstallationanduse,itmaycauseharmfulinterferenceto
radiocommunication.Theinterferencepreventioncannotbeguaranteedevenwithproper
installationaccordingtothemanual.Ifthedevicegetsbadaffectonthesignalofradio/TV.
Usercouldinsurebyturndeviceon/off.
Whenthisdeviceproducessomeharmfulinterference,usercanusethefollowing
measuretosolveinterferenceproblem:
Settingthereceivingantenna’sdirectionorlocation
Increasethedistancebetweenthisdeviceandreceiver.

TPC6000‐A152UserManual
3
Pluginthisdevice’spowerconnectorintodifferentcircuitsofthepoweroutletwith
receiver
Ifyouneedtechnicalsupport,pleaseinformthedealerorexperiencedradio/TV
technicalpersonnel.
Warning:
Ifuserchangesthesettingunauthorizedorrepairsthedevicewithoutanyapprovalofthe
relevantauthority,thenuser’srightsofcontrollingthisdevicewillbecanceled.

ORDERINGINFORMATION

TypeDescription
TPC6000‐A152‐T15’’XGATFTLED/2.0GHzCPU/1xSODIMM/2xGLAN/4xUSB/5x
RS232(COM1optionalsettoRS485)/HDMI/VGA
TPC6000‐A152‐TA
15’’XGATFTLED/2.0GHzCPU/1xSODIMM/2xGLAN/4xUSB/5x
RS232(COM1optionalsettoRS485)/1xRS485(withmodule)/HDMI/
VGA
TPC6000‐A152‐TB
15’’XGATFTLED/2.0GHzCPU/1xSODIMM/2xGLAN/4xUSB/5x
RS232(COM1optionalsettoRS485)/2xRS485(withmodule)/HDMI/
VGA

TECHNICALSUPPORTANDSERVICE
Pleasevisit:en.nodka.comtogetthedetails.
Usershouldcollecttheproductinformationfollowing:
‐Productnameandserialnumber.
‐Attacheddevice’sdescription
‐User’ssoftware’sdescription(operationalsystem,vision,applicationsoftwareandso
on)
‐Fulldescriptionoftheproduct’sproblem
‐Fulldetailsofeveryerrorinformation

Warning:
1.DC12Vinputpower;
2.Package:becareful,pleasetakethedevicebytwohands;
3.Maintenance:pleasecleanandmaintainthesurfacebycorrectways,onlycanusethe
certificatedordryproducttocleanup.


TPC6000‐A152UserManual
4
SAFETYINTRODUCTION
1.Pleasereadthesafetyoperatingintroductionverycarefully.
2.Pleasestorethismanualsothatrefersitagain.
3.Beforecleanupthedevicebywetcloth,pleaseconfirmthatpowerconnectoris
outofoutlet,DONOTuseanyliquidordecontaminationspraytocleanitup!
4.Theremustbeaeasytouchedpoweroutlet.
5.Pleaseconfirmthatthedeviceisbeputonastableplatformbeforeinstallation,
accidentfallmaycausedamagesofdevice.
6.Pleaseconfirmthatthevoltagewhichiscomefrompoweroutletisfitonthe
requirement,beforeyouconnectthedevicetooutlet.
7.Pleasearrangethepowercableinahidingplaceanddonotcoveranythingonthe
cable.
8.Pleasebecautiousofthewarningsandnoticesonthedevice.
9.Ifthedeviceisnotusedforalongtime,shutoffthepowertoavoidthedamagesby
transientovervoltage.
10.DONOTallowanyliquidflowintothedevicesothatcausefireorshortcircuit.
11.DONOTpullthedeviceupbyyourself,pleaseletanycertificatedengineertodo
thatforyoursafety.
Ifyoumeetthefollowingsituations,pleaserepairitbyprofessionalperson:
Powercableorconnectorisbroken;
Liquidflowintothedevice.
Devicedoesn’tworkproperly.Oryoucan’tmakeitworkthroughtheusermanual.
Thisdevicefallsoranydamage;
Someobviousdamage;
12.DONOTstorethedeviceinoutofthetemperaturerangewhatwesuggested,NOT
lessthen‐30°Corhigherthan70°C,ormaydamagethedevice.


TPC6000‐A152UserManual
5
Contents
CHAPTER1OVERVIEW
1.1INTRODUCTIONS....................................................................................................9
1.2FEATURES...............................................................................................................9
1.3EXTERNALOVERVIEW...........................................................................................10
1.3.1FRONTPANEL.................................................................................................................10
1.3.2REARPANEL...................................................................................................................11
1.4INTERNALOVERVIEW...........................................................................................11
1.5SPECIFICATIONS....................................................................................................12
1.6DIMENSIONS........................................................................................................14
CHAPTER2INSTALLATION
2.1UNPACKTHEFLATPANELPC......................................................................................16
2.2PACKINGLIST:............................................................................................................17
2.3HARDDRIVEINSTALLATION.......................................................................................18
2.4SSDINSTALLATIONBYUSINGMSATA.........................................................................18
2.5MEMORYINSTALLATION............................................................................................19
2.6MOUNTINGSYSTEM...................................................................................................19
2.6.1MONITORSTAND............................................................................................................20
2.6.2ARMMOUNTING.............................................................................................................20
2.6.3WALLMOUNTING...........................................................................................................21
2.6.4PANELMOUNTING...........................................................................................................22
2.7BOTTOMPANELCONNECTORS...................................................................................24
2.7.1LANCONNECTION...........................................................................................................24
2.7.2SERIALDEVICECONNECTION..............................................................................................25
2.7.3USBCONNECTION...........................................................................................................26
2.7.4VGAMONITORCONNECTION............................................................................................26
2.8POWERCONNECTOR..................................................................................................27
2.9CONNECTORSDEFINITION..........................................................................................28

TPC6000‐A152UserManual
6
2.10DRIVERINSTALLATION.............................................................................................32
2.10.1CHIPSETDRIVER............................................................................................................33
2.10.2GRAPHICSDRIVER..........................................................................................................37
2.10.3AUDIODRIVER..............................................................................................................41
2.10.4LANDRIVER.................................................................................................................44
2.10.5TOUCHSCREENDRIVER...................................................................................................49
2.10.6INTELTXEINSTALLATION................................................................................................52
CHAPTER3BIOSSETTING
3.1INTRODUCTION....................................................................................................57
3.1.1STARTINGSETUP.............................................................................................................57
3.1.2USINGSETUP..................................................................................................................57
3.1.3GETTINGHELP................................................................................................................58
3.1.4UNABLETOREBOOTAFTERCONFIGURATIONCHANGES..........................................................58
3.1.5BIOSMENUBAR.............................................................................................................58
3.2MAIN....................................................................................................................58
3.2.1SYSTEMTIME/SYSTEMDATE...........................................................................................59
3.3ADVANCEDBIOSFEATURESSETUP.......................................................................59
3.3.1PCISUBSYSTEMSETTING..................................................................................................60
3.3.2ACPISETTING................................................................................................................62
3.3.3CPUCONFIGURATIONSETTING.........................................................................................63
3.3.4SATACONFIGURATION.................................................................................................64
3.3.5USBCONFIGURATION..................................................................................................65
3.3.6SUPERI/OCONFIGURATION.............................................................................................66
3.3.7PCHEALTHSTATUS......................................................................................................67
3.3.8PPMCONFIGURATION..................................................................................................68
3.4CHIPSETSETTINGS/HOSTBRIDGE........................................................................69
3.4.1INTELGRAPHICCONFIGURATION........................................................................................70
3.5CHIPSETSETTINGS/SOUTHBRIDGE.....................................................................72
3.5.1NM10CHIPCONFIGURATION........................................................................................73
3.5.2POWERONCONFIGURATION..........................................................................................74
3.5.3BOOTCONFIGURATION................................................................................................75
3.6SECURITYSETTINGS..............................................................................................77
3.7EXITOPTION.........................................................................................................78

TPC6000‐A152UserManual
7
3.7.1SAVECHANGESANDEXIT.................................................................................................78
3.7.2DISCARDCHANGESANDEXIT.........................................................................................78
3.7.3LOADOPTIMIZEDDEFAULTS..........................................................................................79
CHAPTER4SYSTEMMAINTENANCE
4.1SYSTEMMAINTENANCEINTRODUCTION..............................................................81
4.2MOTHERBOARDREPLACEMENT............................................................................81
4.3COVERREMOVAL.................................................................................................81
APPENDIX
A.1SAFETYPRECAUTIONS...............................................................................................83
A.1.1GENERALSAFETYPRECAUTIONS........................................................................................83
A.1.2ANTI‐STATICPRECAUTIONS...............................................................................................83
A.1.3PRODUCTDISPOSAL........................................................................................................84
A.2MAINTENANCEANDCLEANINGPRECAUTIONS..........................................................84
A.2.1MAINTENANCEANDCLEANING.........................................................................................85
A.2.2CLEANINGTOOLS............................................................................................................85
B.1ALC662DIGITALMICROPHONECONFIGURATION.......................................................87
D.1HAZARDOUSMATERIALSDISCLOSURETABLEFORIPBPRODUCTSCERTIFIEDASROHS
COMPLIANTUNDER2002/95/ECWITHOUTMERCURY.....................................................94


TPC6000‐A152UserManual
8
Chapter1
OVERVIEW


TPC6000‐A152UserManual
9
1.1Introductions


Figure1‐1:TPC6000‐A152‐T

TPC6000‐A152‐Tislow‐powerconsumptionfanlesspanelPC,itequippedwiththelatest
IntelBaytrailJ1900processoranditalsohasexcellentcomputationalperformanceand
low‐consumption,DatastoragesupportsmSATAand2.5inchSSDorHDD;Ithasbeen
designedwithvariousofcommunicationinterfaceand2x1000MbpsEthernetport,3xUSB
2.0ports,1xUSB3.0ports,6xRS232(COM1,COM5,COM6optionalRS485);Powerinput
12VDC.
Usingsealedboxstructure,preventdustfromfloatingintothedevice,largeareaof
aluminumfinheatsink,Itcandistributestheinternaldevice’sheatquicklyandeffectively,
makesurethatthePC’sreliabilityandlongerservicelife.TPC6000‐A152‐Tcanbeusedina
long‐termrunningandindustrialfieldinharshenvironment,iswidelyusedinintelligent
traffic,machinevision,medicalequipment,textilemachine,railwayandindustrial
automationetc.
TPC6000‐A152‐TcompatiblewithWindows7,Windows8,Windows10,Androidand
Linuxoperatingsystemandotherembeddedoperatingsystem.

1.2Features
AluminumMagnesiumalloydie‐casting,IP65enabledinfrontpanel;
Hightemperature5‐wiresanalogresistivetypetouchscreen;

TPC6000‐A152UserManual
10
Support2.5’’SSDormSATA.
IntelBaytrailJ19002.0GHzquad‐coreprocessor;
2xRealtekRTL8111F10/100/1000MbpsEthernetinterface;
6xRS‐232serialport(COM1,COM5,COM6canbesettoRS‐485optional),with
magnetic‐couplingisolationandsurgeprotection;
Interfaces:VGA/HDMI/2xGLAN/4xUSB/6xCOM;

1.3ExternalOverview
TheTPC6000‐A152‐Tconsistsofascreenandarearpanelthatcoverstheback,sideand
top.Therearpanelcontainsasmalleraccesspanel,allthecableconnectionsandmounting
holes.

1.3.1Frontpanel
ThefrontsideoftheTPC6000‐A152‐TisflatpanelLCDscreensurroundedbyan
aluminummagnesiumalloydie‐castframe.


Figure1‐2:Frontpanel


TPC6000‐A152UserManual
11
1.3.2Rearpanel

A:COM6G:COM3
B:COM5H:COM4
C:ATXI:LAN
D:DCINJ:USB2.0*3/USB3.0*1
E:COM1K:VGA
F:COM2L:HDMI

Figure1‐3:Rearpanel

1.4Internaloverview
Allcomponentsarecontainedundertherearpanel.Theinternalcomponentsinclude
thetouchpanelmoduleandthemotherboard.Themotherboardhasmemory,awireless
moduleandaharddrive.Optionally,anHSDPAmodulecanbeinstalledinanyofthe
models.


TPC6000‐A152UserManual
12
1.5Specifications

TypeTPC6000‐A152‐T
Hardware
ProcessorOnboardIntelBaytrailJ1900quad‐coreprocessor(TDP10W)
CPUclockspeed2.0GHz
2ndCache2MB
RAMSupportDDR3L1333MHz,1*SO‐DIMMSlot,Upto8GB
HarddriveSupportmSATA,SATA2.5“SSD,HDD
GraphicsIntel®HDGraphics
Ethernetport2xRealtekRTL8111F1000MbpsRJ‐45Ethernetportwithsurge,
lighting,15KVESDprotections
Wirelessnetwork1xMini‐PCIeslot,expandable3G,WIFIwirelessnetworkcard
USB3xUSB2.0,1xUSB3.0portswith8KVelectrostaticprotection
Serialport
6xRS‐232/RS‐485serialports(COM1,COM5,COM6selectable)
withmagnetic‐couplingisolationandsurgeprotection,RS485
supportsdatatransferdirectioncontrol
Watchdog1~255secondprogrammablesetting
InterfacesVGA/HDMI/2xGLAN/4xUSB2.0/6xCOM
LCDandtouchpanel
Size15’’XGATFTLCD
Max.resolution1024x768
Displayarea304.128x228.096mm
BacklightLED
BacklightMTBF(Hours)30,000
Luminance450cd/m2
Touchscreen
Touchscreenstyle5‐wiresanalogresistivetype
Touchlifetime250g/35,000,000times
Strokelifetime250g/5,000,000times
LuminousnessMorethan81%
Structure
FrontpanelAluminummagnesiumalloydie‐castingpanelframe,PETpaton

TPC6000‐A152UserManual
13
surface,compliantwithNEMAIP65
StructureSteelbox,hightemperaturepainting,largeareaoffinnedheat
sinksonbackshell.
MountingmethodSupportdesktopandPanel‐mounting,fixitbyhooks;Or
VESA‐mountingwithracks.
InterfacecolorSilver
Totaldimension393x313x82mm(WxHxD)
Cutdimension376x300mm(WxH)
Structuredimension373x297x76mm(WxHxD)
Netweight4.83kg
Environment
Worktemperature0‐50℃(SSD‐Free)
Storagetemperature‐30‐70℃
PowersupplyDC12V
Powerconsumption22W
Constanttemperature/
wettest40℃95%RH/1000hrs
Hightemperaturetest60℃/1000hrs
Relativehumidity10‐95%(Non‐condensing)
Vibration50‐500Hz,1.5G,0.19mmpeak‐peakvalue
Shock10G/peak(11msduration)
Table1‐1:Specification

TPC6000‐A152UserManual
14
1.6Dimensions


 
Figure1‐5:TPC6000‐A152‐Tdimensions

TPC6000‐A152UserManual
15
Chapter2
INSTALLATIONS


TPC6000‐A152UserManual
16
Warning:
WheninstallingtheTPC6000‐A152‐T,makesureto:
Turnthepoweroff:chanceofelectrocution.Turnoffthemonitorandunplugitfrom
thepowersupply.
Onlyletcertifiedengineerchangethehardwaresettings:Incorrectsettingscancause
irreparabledamagetotheproduct.
Installthemonitorwithassistance:Theproductisveryheavyandmaybedamageby
dropsandbumps.TwoormorepeopleshouldinstallthepanelPC.
Takeanti‐staticprecautions:Electrostaticdischargecandestroyelectricalcomponents
andinjuretheuser.Usersmustgroundthemselvesusingananti‐staticwristbandor
similardevice.

Theinstallationstepsbelowshouldbefollowedinorder:
Step1:UnpacktheflatpanelPC;
Step2:Checkalltherequiredpartsareincluded;
Step3:Installtheharddrive;
Step4:Installthecompactflashcard;
Step5:MounttheflatpanelPC;
Step6:ConnectperipheraldevicestothebottompaneloftheflatpanelPC;
Step7:Connectthepowercable;
Step8:configurethesystem;

2.1UnpacktheflatpanelPC
UnpacktheflatpanelPC,followthestepbelow:
Step1:Carefullycutthetapestealingtheoutsidebox.Onlycutdeepenoughtobreakthe
tape.
Step2:Opentheoutsidebox.
Step3:Carefullycutthetapestealingtheinsidebox.Onlycutdeepenoughtobreakthe
tape.
Step4:Opentheinsidebox.
Step5:Liftthemonitoroutthebox.
Step6:Removetheperipheralboxfromthemainbox.


TPC6000‐A152UserManual
17

2.2Packinglist:
Pleasecheckoutallitemsbyfollowinglistwhenyouopenthepackage:
ItemImageQuantity
TPC6000‐A152‐T

1
Touchscreenpen1
UtilityCD

1
Powercord

1
Poweradapter1
MountingClamps4
Table2‐1:Packinglist

Ifanyitemsaremissingordamaged,contactthedistributororsalesrepresentative
immediately.


TPC6000‐A152UserManual
18

2.3Harddriveinstallation
ThissectionoutlinestheinstallationoftheharddriveintheTPC6000‐A152‐T.Toinstallthe
harddrive,pleasefollowthestepsbelow:
Step1:Flipoverthisdeviceandyoucanseeitsback.
Step2:Unfastenthe4silverretentionscrewsontheleftandrightside.(Figure2‐1)
Step3:Liftthecovertoremove.
Step4:LocatetheHDDbracket.
Step5:InserttheSATAconnectorattheendoftheHDDintothebrackettoconnectthe
motherboardSATAconnectortotheharddriveSATAconnectorasshowninthe
figurebelow.
Step6:PlantthescrewontheHDDbracket.
Step7:Replacethecoversandscrews.



2.4SSDinstallationbyusingmSATA
TheinstallationforaSSDisdescribedinthissection.
Step1:RemovetheHDDbracketjustlikementionedonthe“Harddriveinstallationsteps”.
Step2:InsertthemSATASSDintothemSATAslotasshownintheFigure2‐4below:


TPC6000‐A152UserManual
19

Figure2‐4:mSATASSDinstallation

Step3:ReplacetheHDDbracket,coverandscrews.

2.5Memoryinstallation
ThissectionoutlinestheinstallationofthememoryintheTPC6000‐A152‐T.Toinstallthe
memory,pleasefollowthestepsbelow:
Step1:Flipoverthisdeviceandyoucanseeitsback.
Step2:Unfastenthe4silverretentionscrewsontheleftandrightside.(Figure2‐5)
Step4:Liftthecovertoremove.
Step5:Locatethememorybracket.
Step6:PlugtheDDR3LmemorybarintotheDDR3Lslotintheangleof45degreesthenpush
lightlydowntillthetwometalclipsvisethememorybarwithasound“pa”,and
donesafety.
Step7:Plantthecoveronbackofthedevice.

2.6Mountingsystem
Warning:
ThepanelPCisveryheavy,twoormorepeopleshouldmountthepanelPC.Droppingor
bumpingthepanelPCduringinstallationcancauseseriousorirreparabledamagetothe
panelPC
Thefollowinginstallationoptionsareavailable:

TPC6000‐A152UserManual
20
2.6.1Monitorstand
Themonitorstandallowsthemonitortobeusedonadeskortable.Forinstructionson
installingthemonitorstand,pleaserefertothemanualthatcomewiththestand.


Figure2‐6:Monitorstand

2.6.2Armmounting
TheTPC6000‐A152‐TcanbeinstalledonanyarmthatsupportsthestandardVESAmounting
interface.Anexamplewallarmisshownbelow:


Figure2‐7:Wallarm