Nokia Asha 230 User manual

Send feedback
Recommend Change in
KICS
Rate this page in KICS
E-mail
ca[email protected]
Service Manual for L1 and L2
Nokia Asha 230
Nokia Asha 230 Dual SIM
RM-986(DS), RM-987(SS
)
Key features

2.8" display with 320 x 240 resolution

1.3 Mpix camera

Quick photo sharing

Dual SIM support (RM-986 only)

Micro SD card support up to 32 GB
Version 1.0
CHECK THE REPAIR
POLICY BEFORE
PERFORMING ANY
MECHANICAL REPAIR ON
SERVICE LEVEL 1&2!
Exploded view Disassembly steps
Assembly hints Solder components Service devices
Product controls and interfaces Service concept
More More
More More More
More More
©2014 Nokia | Nokia Internal Use only | All Rights Reserved.
All manuals and user guides at all-guides.com
all-guides.com

Service Manual Level 1 an
d
2
Nokia Asha 230, Nokia Asha 230 Dual SI
M
RM-986(DS), RM-987(SS)
V
ersion 1.0
Version histor
y
Version Date Description
1.0 27.02.2014 First published version
©2014 Nokia | Nokia Internal Use only | All Rights Reserved.
All manuals and user guides at all-guides.com

Service Manual Level 1 and 2
Nokia Asha 230, Nokia Asha 230 Dual SIM
RM-986(DS), RM-987(SS)
Version 1.0
Exploded view
A-COVER
I0001
EARPIECE ADHESIVE
I0003
DISPLAY CONDUCTIVE TAPE
I0010
CAMERA
I0012
SIM LID
I0015
BATTERY COVER
I0020
BT ANTENNA
I0014
TOUCH IC GASKET
I0006
EARPIECE
I0004
RF SHIELDING LID
I0009
TOUCH PANEL
I0002
DISPLAY
I0005
TYPE LABEL
I0011
BB SHIELDING LID
I0008
LIGHT SWAP PWB
I0007
SPEAKER
I0017
D-COVER
I0016
SPEAKER MESH WITH GASKET
I0013
MAIN ANTENNA
I0018
SCREW TORX+
SIZE 6 RF1.6 x 4.5
I0019
D-COVER ASSEMBLY
(I0013 - I0016)
3
A-COVER ASSEMBLY
(I0001 - I0004)
1
LIGHT SWAP PACKAGE
(I0006 - I0011) 2
Only available
as assembly
Not reuseable
after removal
Repair/swap
only in level 3
©2014 Nokia | Nokia Internal Use only | All Rights Reserved.
All manuals and user guides at all-guides.com

Service Manual Level 1 and 2
Nokia Asha 230, Nokia Asha 230 Dual SIM
RM-986(DS), RM-987(SS)
Version 1.0
Disassembly steps
1) For disassembling you need the Nokia Standard toolkit version 2. You will also need the camera
removal tool SS-276.
2) Protect the TOUCH PANEL with protective film.
©2014 Nokia | Nokia Internal Use only | All Rights Reserved.
All manuals and user guides at all-guides.com

3) Pull from the shown corners and push from the middle of the BATTERY COVER to release it. Remove
the BATTERY COVER.
4) Unscrew the four Torx+ size 6 screws in the order shown.
©2014 Nokia | Nokia Internal Use only | All Rights Reserved.
All manuals and user guides at all-guides.com

5) Insert the SRT-6 to shown corner to release the shown clip holding the D-COVER.
6) Use the SRT-6 to release the two shown clips.
©2014 Nokia | Nokia Internal Use only | All Rights Reserved.
All manuals and user guides at all-guides.com
all-guides.com

7) Release also the clip on the bottom end of the device.
8) Release the two shown clips on the right side of the device.
©2014 Nokia | Nokia Internal Use only | All Rights Reserved.
All manuals and user guides at all-guides.com

9) The D-COVER can now be released.
10) Push from the shown place with the sharp end of the SS-93 to release the MAIN ANTENNA.
©2014 Nokia | Nokia Internal Use only | All Rights Reserved.
All manuals and user guides at all-guides.com

11) Push the SS-93 under the MAIN ANTENNA to release it. Remove the MAIN ANTENNA.
12) Clean the MAIN ANTENNA adhesive remains from the D-COVER. Do not use them again.
©2014 Nokia | Nokia Internal Use only | All Rights Reserved.
All manuals and user guides at all-guides.com

13) Release the SPEAKER with the dental tool.
Be careful not to injure yourself with the sharp end of the dental tool.
14) Release the SPEAKER MESH WITH GASKET with the dental tool. Remove it with tweezers. Discard it.
©2014 Nokia | Nokia Internal Use only | All Rights Reserved.
All manuals and user guides at all-guides.com