Numatic RSU150 NX User manual
NUMATIC RUCKSACK SANITISER UNIT
BATTERY POWERED
Original Instructions
CAUTION,
Read instructions before using the machine.
This machine is not suitable for
spraying / sanitising electrical items.
KEEP FOR FUTURE REFERENCE
numatic.com
RSU150 NX
Kit - Lance & Solution Tube
Assembly - Solution Tube to Machine
is running.
Assembly - Solution Tube to Lance
WARNING: Make sure the solution
tube is securely tted in place.
Do not remove whilst machine
is running.
A
B
To release the solution tube push the quick release
solution tube.
A
Chemical Dosage
WARNING:
dilution rates, could cause reduced cleaning strength or a
high concentration of sanitising mist.
chemical concentrated solution.
Remove the solution tank from the machine prior
to lling with cold water and chemical to avoid
spillage onto the machine. (See following page).
WARNING:
DO NOT USE WITH WATER ABOVE 20°C
TECcare Dosage
Note: Chemical dosage should be strictly adhered
to and only applies to Numatic supplied chemical.
sheet for dilution rates.
5
Fill the solution tank with the required amount
of COLD water.
See dosage table on
the previous page.
Chemical Dosage Machine Setup
Remove the solution tank to ll with cold water and chemicals, this is to avoid spilling liquid
on to the machine.
Fill the solution tank with the correct chemical
dosage.
3
Chemical Information
Note: Inappropriate selection of disinfectant solution may result in damage to unit including
corrosion, pump failure, reduction in mist performance etc. The RSU is fully compatible with
disinfection solutions based on Quaternary Ammonium Salts or Hypochlorous Acid using
appropriate dilution levels. Use of other chemical / disinfectant solutions may invalidate warranty.
Never spray into or towards face.
WARNING IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses,
if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention.
If medical advice is needed, have product container or label at hand.
Always refer to the MSDS (manufacturer’s safety data sheet) for safe usage and disposal.
Only use the chemicals / detergent solution provided. Replacements available from Numatic.
lenses, if present and easy to do.
Continue rinsing.
comfortable for breathing.
This chemical should be kept in the packaging/container
!!
CAS
CAS
Power
- On
User should not turn machine on / o without Solution tube & lance connected.
This machine is not suitable for spraying / sanitising electrical items.
Assembly - Battery Fitting
Using the machine
Adjusting harness height
Caution: The initial priming of the machine can take 1 to 2 minutes. Subsequent relling of the
solution tank will not require re-priming unless system has been de-pressurised.
During start up.
applied.
Ensure harness is straight
and level.
Adjust to t.
Lance Storage (in use)
NOTE*
It is advisable to t the lance to
the carabiner BEFORE tting the
machine to the user.
Lance Storage
Important - Always remove the battery from the machine after use.
being discharged.
De-pressurising the machine
tank from machine.
solution tank after each
use.
Note: wear appropriate
PPE whilst cleaning
machine.
3
The system must be de-pressurised before
disconnecting the solution tube.
3
Cleaning the machine
Male Tank feed O ring
and the machine and requires replacing
if found to be cracked or damaged.
Solution Tank lter
should be cleaned on a frequent basis.
Cleaning Spray Lance
reassemble.
Note: If there is constant dripping when spraying tighten both spray nozzle nuts.
3
Replacement parts
Chemical
Spares and Accessories
Battery
37 V Battery
Fast charger
Charging your battery
Operating time
charger original operating instructions.
Machine data
Schematic diagram
Model Hand / Arm
Vibration
Weight
(Ready to work)
Sound pressure (LpA)
Uncertainty (KpA)
Protection
class Dimensions
Class III
Fluid
Container
Flow
Rate Rated Power Pressure Rating Machine
Weight IP Rating
(GB) About your machine
Model
3
5Weight
7
3
5
7
Trouble shooting / Maintenance
Trouble shooting:
the solution tank and clean if dirty.
•
clean if dirty.
brush if dirty.
Maintenance:
•Clean nozzle face.
•
and replace immediately.
Failure to rectify the problem or in the event of a breakdown contact your Numatic dealer or the
Numatic Technical helpline +44 (0)1460 269268
PPE (Personal protective equipment) that may be required for certain operations.
NOTE: A risk assessment should be conducted to determine which PPE should be worn.
Hi-Vis Jacket Caution
ORIGINAL INSTRUCTIONS:- READ MANUAL BEFORE USE. !
Read the instruction manual before using the machine.
Operators shall be adequately instructed on the use of their machine.
render this equipment unsafe and the manufacturer can accept no responsibility in this respect.
the machine to another function.
This appliance is intended to be cleaned and maintained by an adult.
This machine is not a toy.
CAUTION
This machine should be stored indoors only.
This machine is intended for indoor use only.
any pipe connections.
• Charge the battery fully after use.
•
•
•
•
•
•
Information for Sanitising machines
Misuse during operation:
WARNING
Error Indications
Indication Error Action
pattern
Check nozzle for blockage
3 pulses
Check nozzle for blockage, cycle
3 pulses
connection issues
return machine to distributor
Battery Under Voltage
battery, if problem persists, return
machine to distributor
battery, if problem persists, return
machine to distributor
return machine to distributor
Lithium-Ion Battery Warranty
Warranty: Commercial Use
i. Serial number of the machine
ii. Battery date code
DEC-086 V3.0
EU, EC, EL, UE, ES:
Declaration of Conformity
Prohlášení o shodě
Konformitätserklärung
Overensstemmelseserklæring
Declaración de conformidad
Vastavusdeklaratsioon
Déclaration de conformité
Декларация за съответствие
Δήλωση συμμόρφωσης
Megfelelőségi nyilatkozat
Dichiarazione di conformità
Atitikties deklaracija
Conformiteitsverklaring
Samsvarserklæring
Declaração de conformidade
Deklaracja zgodności
Declaratie de conformitate
Декларация о соответствии
Försäkran om överensstämmelse
Izjava o skladnosti
Vaatimustenmukaisuusvakuutus
Manufacturer
:
/ Výrobce / Hersteller / Fabrikant / Fabricante /
Tootja
/ Fabricant / производитель / Κατασκευαστής / Gyártó / Fabbricante
/ Gamintojas / Fabrikant / Produsent / Fabricante / Producent /
Producător / производитель / Tillverkare / Proizvajalca / Valmistaja:
Numatic International Limited
Chard
Somerset
TA20 2GB
www.numatic.co.uk
Product
:
/ Produkt /
Produkt / Produkt /
Producto, Toode
t
, Produit
/
Πродукт / Προϊόν / Termék / Prodotto / Produktas / Artikel / Produkt
/ Produtos / Produkt / Produs / товар / Produkt / Izdelka / Tuote:
RSU
Description
:
/ Popis / Beschreibung / Beskrivelse / Descripción /
Kirjeldus / La description / Oписание / Περιγραφή / Leirás /
Descrizione / Apibudinimas / Omschrijving / Beskrivelse / Descrição /
Opis / Descriere / Oписание / Beskrivning / Opis / Kuvaus:
Battery Powered Spray/Sanitiser
-
Commercial
GB
We, Numatic hereby declare under our
sole responsibility, that the above-
mentioned product(s) is/are in conformity
with the following directives and standards.
CZ
My, Numatic prohlašujeme na svou
výlučnou odpovědnost, že výše uvedený
výrobek je ve shodě s následujícími
směrnicemi a normami.
DE
Wir, Numatic erklären in alleiniger
Verantwortung, dass das oben genannte
Produkt den folgenden Richtlinien und
Normen entspricht.
DK
Vi, Numatic erklærer hermed under
eget ansvar at ovennævnte produkt(er) er i
overensstemmelse med følgende direktiver
og standarder.
ES
Nosotros, Numatic declaramos bajo
nuestra única responsabilidad que el
producto antes mencionado está en
conformidad con las siguientes directivas y
normas
EE
Meie, Numatic Käesolevaga kinnitame ja
kanname ainuisikulist vastutust, et eespool
nimetatud toode on kooskõlas järgmiste
direktiivide ja
FR
Numatic déclare sous notre seule
responsabilité que le produit mentionné ci-
dessus est conforme aux directives et normes
suivantes.
BG
Ние, Numatic С настоящото
декларираме на своя лична отговорност,
че посочените по-горе продуктът е в
съответствие със следните директиви и
стандарти.
GR
Εμείς, Numatic δηλώνουμε με
αποκλειστική μας ευθύνη, ότι το
προαναφερόμενο προϊόν συμμορφώνεται
με τις ακόλουθες οδηγίες και πρότυπα.
HU
Mi, Numatic Kijelentjük, egyedüli
felelősséggel, hogy a fent említett termék
megfelel az alábbi irányelveknek és
szabványoknak
IT
Noi, Numatic dichiara sotto la propria
responsabilità, che il prodotto di cui sopra è
conforme alle seguenti direttive e norme.
LT
Mes, "Numatic pareiškiu vienašališkos
atsakomybės, kad pirmiau minėtas
produktas atitinka šias direktyvas ir
standartus
NL
We verklaren Numatic hierbij op eigen
verantwoordelijkheid, dat het
bovengenoemde product voldoet aan de
volgende richtlijnen en normen
NO
Vi, Numatic erklærer herved under
eget ansvar, at det ovennevnte produktet er
i samsvar med følgende direktiver og
standarder
PT
Nós, a Numatic declaramos, sob nossa
exclusiva responsabilidade, que o produto
acima mencionado está em conformidade
com as diretrizes e normas a seguir.
PL
My, Numatic Niniejszym oświadczamy z
pełną odpowiedzialnością, że wyżej
wymieniony produkt jest zgodny z
następującymi dyrektywami i normami.
RO
Noi, Numatic Prin prezenta declarăm
pe propria răspundere, că produsul mai sus
menționat este în conformitate cu
următoarele standarde și directive.
RU
Ми, Нилфиск овим изјављујем под
пуном одговорношћу, да наведеног
производ је у складу са следећим
директивама и стандардима.
SE
Vi Numatic förklarar härmed under
eget ansvar att ovan nämnda produkt
överensstämmer med följande direktiv och
normer.
SI
Mi, Numatic izjavljamo s polno
odgovornostjo, da je zgoraj omenjeni
izdelek v skladu z naslednjimi smernicami in
standardi.
FI
Me, Numatic täten vakuutamme omalla
vastuulla, että edellä mainittu tuote on
yhdenmukainen seuraavien direktiivien ja
standardien mukaisesti
2006/42/EC Machinery Directive EN60335-1:2012 + AC:2014 + A11:2014 + A13:2017
EN60335-2-68:2012
EN62233:2008
2014/30/EU EMC Directive EN55014-1:2006 + A1:2009 + A2:2011
EN55014-2:1997 + A1:2001 + A2:2008
2011/65/EU RoHS Directive
Authorised Signatory: Mr. Matthew Coles Position: Head of Technology
Numatic International Limited
Chard,
Signed: Date: 1
st
Dec 2021 Somerset, TA20 2GB, UK
DEC-086 V2.0
UKCA Declaration of Conformity
Manufacturer
:
Numatic International Limited
Chard
Somerset
TA20 2GB
www.numatic.co.uk
Product
:
RSU
Description
:
Battery
Powered Sprayer/Sanitiser
-
Commercial
We, Numatic hereby declare under our sole responsibility, that the above
-
mentioned product(s) is/are
in conformity with the following directives and standards.
S.I. 2008: 1597
Supply of
Machinery
Regulations
EN60335
-
1:2012 + AC:2014 + A11:2014
+ A13:2017
EN60335-2-68:2012
EN62233:2008
S.I. 2016: 1091
EMC
Regulations
EN55014
-
1:20
17 + A11:2020
EN55014-2:1997 + A1:2001 + A2:2008
S.I. 2012: 3032
RoHS
Regulations
Numatic International Limited,
Chard,
Somerset, TA20 2GB, UK
Position: Head of Technology
Signed: Date: 1
st
Dec 2021
Authorised Signatory: Mr. Matthew Coles
Specication subject to change without prior notice
www.numatic.co.uk © Numatic International Limited
Numatic International Limited.
Chard, Somerset TA20 2GB ENGLAND
Tel: 01460 68600 www.numatic.co.uk
Numatic International GmbH. Fränkische Straße 15–19
D-30455 Hannover, DEUTSCHLAND
Tel: 05 11 98 42 16 0 www.numatic.de
Numatic International SAS. 13 / 17 rue du Valengelier
EAE La Tuilerie – 77500 CHELLES, FRANCE
Tel: 01 64 72 61 61 www.numatic.fr
Numatic International BV
Vennootsweg 15, 2404 CG, Alphen aan den Rijn, NEDERLAND
Tel: 0172 467 999 www.numatic.nl
Numatic International (Pty.) Ltd.
16th & Pharmaceutical Roads, Midrand, Gauteng,
SOUTH AFRICA 1685
Tel: 0861 686 284 www.numatic.co.za
Numatic International Schweiz AG.
Sihlbruggstrasse 3A, 6340 Baar. SCHWEIZ
Tel: 0041 (0) 41 76 80 76 - 0 www.numatic.ch
Numatic International ULDA. Rua da Boa Viagem, 177
4470.210 Maia. PORTUGAL
Tel: +351 220 047 700 www.numatic.pt
Numatic International SLU. C/ La Forja, 41, 08840 Viladecans
(Barcelona), Spain
Tel: +34 93 647 22 22 www.numatic.es
Other manuals for RSU150 NX
1
Table of contents
Other Numatic Accessories manuals
Popular Accessories manuals by other brands
inventum
inventum HN197VB instruction manual
Garmin
Garmin LIDAR-LITE V4 LED Operation manual and technical data
Topgreener
Topgreener TDODS5-120 installation instructions
GP
GP H500 instruction manual
Orbit
Orbit OSLPIR360W manual
Revolution Lightning
Revolution Lightning RNET-OCC-HV-P-WS-J Specifications and installation
