Patton SmartNode 4660 Series User manual

SmartNode™ 4660 & 4670 Series
Multiport BRI/FXS/FXO VoIP
Gateway-Router, IAD
User Manual
Sales Office: [phone]
Technical Support: [phone]
E-mail: [e-mail]
www.patton.com
Part Number: 07MSN4660-SN4670, Rev. B
Revised: July 31, 2012
This is a Class B device and is intended for use in a light industrial (commercial) or residential environment. It is not intended for use in
a heavy industrial environment.
REGULATORY MODEL NUMBER: 13243D4-001

Patton Electronics Company, Inc.
7622 Rickenbacker Drive
Gaithersburg, MD 20879 USA
Tel: [phone]
Fax: [phone]
Support: [phone]
Web: www.patton.com
E-mail: [e-mail]
Trademark Statement
The term SmartNode is a trademark of Patton Electronics Company. All other trade-
marks presented in this document are the property of their respective owners.
Copyright © 2012, Patton Electronics Company. All rights reserved.
The information in this document is subject to change without notice. Patton Elec-
tronics assumes no liability for errors that may appear in this document.
Important Information
To use virtual private network (VPN) and/or AES/DES/3DES encryption capabilities
with the SmartNode 4660 and 4670, you may need to purchase additional licenses,
hardware, software, network connection, and/or service. Contact sal[email protected] or
[phone] for assistance.
Warranty Information
The software described in this document is furnished under a license and may be used
or copied only in accordance with the terms of such license. For information about the
license, see Appendix F, "End user license agreement" on page 54 or go to
www.patton.com.
Patton Electronics warrants all SmartNode 4660 and 4670 components to be free
from defects, and will—at our option—repair or replace the product should it fail
within one year from the first date of the shipment.
This warranty is limited to defects in workmanship or materials, and does not cover
customer damage, abuse or unauthorized modification. If the product fails to perform
as warranted, your sole recourse shall be repair or replacement as described above.
Under no condition shall Patton Electronics be liable for any damages incurred by the
use of this product. These damages include, but are not limited to, the following: lost
profits, lost savings and incidental or consequential damages arising from the use of or
inability to use this product. Patton Electronics specifically disclaims all other warran-
ties, expressed or implied, and the installation or use of this product shall be deemed
an acceptance of these terms by the user.

3
Summary Table of Contents
1General information...................................................................................................................................... 14
2Applications overview................................................................................................................................... 21
3SmartNode installation.................................................................................................................................. 23
4SmartNode initial configuration ................................................................................................................... 29
5Contacting Patton for assistance ................................................................................................................... 36
ACompliance information .............................................................................................................................. 39
BSpecifications ................................................................................................................................................ 41
CCabling ......................................................................................................................................................... 45
DPort pin-outs ................................................................................................................................................ 48
ESmartNode factory configuration ................................................................................................................. 52
FEnd user license agreement ........................................................................................................................... 54

4
Table of Contents
Summary Table of Contents ........................................................................................................................... 3
Table of Contents ........................................................................................................................................... 4
List of Figures ................................................................................................................................................. 7
List of Tables .................................................................................................................................................. 8
About this guide ............................................................................................................................................. 9
Audience................................................................................................................................................................. 9
Structure................................................................................................................................................................. 9
Precautions ........................................................................................................................................................... 10
Safety when working with electricity ...............................................................................................................11
General observations .......................................................................................................................................12
Typographical conventions used in this document................................................................................................ 13
General conventions .......................................................................................................................................13
1General information...................................................................................................................................... 14
Overview ...............................................................................................................................................................15
SmartNode 4660/4670 features ......................................................................................................................16
SmartNode 4660 Series model codes ..............................................................................................................16
SmartNode 4670 Series model codes ..............................................................................................................16
SmartNode 4660 Ports and LEDs .........................................................................................................................17
SmartNode 4660 rear panel ............................................................................................................................17
SmartNode 4660 front panel ..........................................................................................................................18
SmartNode 4670 Ports and LEDs .........................................................................................................................19
SmartNode 4670 rear panel ............................................................................................................................19
SmartNode 4670 front panel ..........................................................................................................................20
2Applications overview................................................................................................................................... 21
Typical application ................................................................................................................................................22
3SmartNode installation.................................................................................................................................. 23
Planning the installation........................................................................................................................................24
Site log ............................................................................................................................................................24
Network information ......................................................................................................................................24
Network Diagram ...........................................................................................................................................24
IP related information .....................................................................................................................................25
Software tools .................................................................................................................................................25
Power source ...................................................................................................................................................25
Location and mounting requirements .............................................................................................................25
Installing the SmartNode.......................................................................................................................................26
Placing the SmartNode ...................................................................................................................................26
Ground connection .........................................................................................................................................26
Installing cables ...............................................................................................................................................26
Installing an interface cable on the SmartNode’s FXS and FXO interface ports .........................................27

5
SmartNode 4660 & 4670 User Manual
Connecting ISDN terminals and NT to the SmartNode’s ISDN BRI ports ..............................................27
Connecting the SmartNode to the IP network ..........................................................................................27
Connecting the SmartNode’s DSL port (SN4670 series only) ...................................................................27
Connecting the SmartNode to the power supply .......................................................................................28
Using the ferrite clamp .......................................................................................................................28
External S-Bus power supply .....................................................................................................................28
4SmartNode initial configuration ................................................................................................................... 29
Introduction..........................................................................................................................................................30
Start the SmartNode Discovery Tool.....................................................................................................................30
Access the Web Browser (GUI) Interface...............................................................................................................31
Configuring your SmartNode................................................................................................................................33
Accessing the Internet .....................................................................................................................................33
Configuring the default gateway .....................................................................................................................35
5Contacting Patton for assistance ................................................................................................................... 36
Introduction..........................................................................................................................................................37
Contact information..............................................................................................................................................37
Patton support headquarters in the USA .........................................................................................................37
Alternate Patton support for Europe, Middle East, and Africa (EMEA) ..........................................................37
Warranty Service and Returned Merchandise Authorizations (RMAs)...................................................................37
Warranty coverage ..........................................................................................................................................37
Out-of-warranty service .............................................................................................................................38
Returns for credit ......................................................................................................................................38
Return for credit policy .............................................................................................................................38
RMA numbers ................................................................................................................................................38
Shipping instructions ................................................................................................................................38
ACompliance information .............................................................................................................................. 39
Compliance ...........................................................................................................................................................40
EMC Compliance ...........................................................................................................................................40
Low Voltage Directive (Safety) Compliance ....................................................................................................40
Radio and TV Interference ....................................................................................................................................40
CE Declaration of Conformity ..............................................................................................................................40
Authorized European Representative .....................................................................................................................40
BSpecifications ................................................................................................................................................ 41
DSP.......................................................................................................................................................................42
Voice connectivity .................................................................................................................................................42
Data connectivity ..................................................................................................................................................42
Voice processing (signaling dependent) .................................................................................................................42
Fax and modem support........................................................................................................................................42
Voice signalling .....................................................................................................................................................43
Voice routing—session router................................................................................................................................43
IP services..............................................................................................................................................................43
Management .........................................................................................................................................................44

6
SmartNode 4660 & 4670 User Manual
Broadband access (if applicable).............................................................................................................................44
Operating environment .........................................................................................................................................44
Operating temperature ....................................................................................................................................44
Operating humidity ........................................................................................................................................44
System...................................................................................................................................................................44
Dimensions ...........................................................................................................................................................44
Weight and power dissipation ...............................................................................................................................44
CCabling ......................................................................................................................................................... 45
Introduction..........................................................................................................................................................46
Ethernet ................................................................................................................................................................46
ISDN BRI.............................................................................................................................................................47
DPort pin-outs ................................................................................................................................................ 48
Console .................................................................................................................................................................49
Ethernet ................................................................................................................................................................49
ISDN BRI NT (Net).............................................................................................................................................50
ISDN BRI TE (User) ............................................................................................................................................50
FXS .......................................................................................................................................................................51
FXO......................................................................................................................................................................51
G.SHDSL .............................................................................................................................................................51
ADSL ....................................................................................................................................................................51
ESmartNode factory configuration ................................................................................................................. 52
Introduction..........................................................................................................................................................53
FEnd user license agreement ........................................................................................................................... 54
End User License Agreement.................................................................................................................................55
1. Definitions ..................................................................................................................................................55
2. Title ............................................................................................................................................................55
3. Term ...........................................................................................................................................................55
4. Grant of License ..........................................................................................................................................55
5. Warranty ....................................................................................................................................................55
6. Termination ................................................................................................................................................56
7. Other licenses .............................................................................................................................................56
8. SmartWare licenses .....................................................................................................................................56

7
List of Figures
1 SmartNode 4660 (left) and SmartNode 4670 (right) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
2 SmartNode 4660 rear panel (Model SN4661/4BIS4JS12V/EUI shown) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
3 SmartNode 4670 rear panel (Model SN4671/4BIS4JS8V2GS/EUI shown) . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
4 SN4660 application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
5 SN4670 application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
6 Connecting the FXS/FXO interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
7 Ferrite clamp installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
8 SmartNode Discovery Tool window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
9 SmartNode 4661 home page . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
10 Main GUI elements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
11 Ethernet Configuration page . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
12 Default Gateway Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
13 Typical Ethernet straight-through cable diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
14 Connecting an ISDN device . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
15 Console Port: EIA-561 (RJ-45 8-pin) port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

8
List of Tables
1 General conventions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
2 SmartNode 4660 Ports and Voice Channels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
3 SmartNode 4670 Ports and Voice Channels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
4 SN4660 rear panel ports . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
5 SmartNode 4660 LED definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
6 SN4670 rear panel ports . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
7 SmartNode 4670 LED definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
8 Sample site log entries . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
9 SmartNode weight and maximum power specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
10 Ethernet Port: RJ-45 socket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
11 ISDN BRI NT Port: RJ-45 socket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
12 ISDN BRI TE Port: RJ-45 socket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
13 FXS Port: RJ-11 socket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
14 FXO Port: RJ-11 socket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
15 G.SHDSL Port: RJ-45 connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
16 ADSL Port: RJ-45 connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51

9
About this guide
This guide describes the SmartNode 4660 and 4670 hardware, installation and basic configuration. For
detailed software configuration information refer to the SmartWare Software Configuration Guide and the avail-
able Configuration Notes available online at www.patton.com/smartnode.
Audience
This guide is intended for the following users:
•Operators
•Installers
•Maintenance technicians
Structure
This guide contains the following chapters and appendices:
•Chapter 1 on page 14 provides information about the SmartNode’s features and capabilities
•Chapter 2 on page 21 contains an overview describing the SmartNode’s operation and applications
•Chapter 3 on page 23 provides hardware installation procedures
•Chapter 4 on page 29 provides quick-start procedures for configuring the SmartNode 4660 and 4670
•Chapter 5 on page 36 contains information on contacting Patton technical support for assistance
•Appendix A on page 39 contains compliance information for the SmartNode 4660 and 4670
•Appendix B on page 41 contains specifications for the SmartNode 4660 and 4670
•Appendix C on page 45 provides cable recommendations
•Appendix D on page 48 describes the SmartNode’s ports and pin-outs
•Appendix E on page 52 lists the factory configuration settings for the SmartNode 4660 and 4670
•Appendix F on page 54 provides license information that describes acceptable usage of the software pro-
vided with the SmartNode 4660 and 4670
For best results, read the contents of this guide before you install the SmartNode.

10
SmartNode 4660 & 4670 User Manual About this guide
Precautions
Notes, cautions, and warnings, which have the following meanings, are used throughout this guide to help you
become aware of potential problems. Warnings are intended to prevent safety hazards that could result in per-
sonal injury. Cautions are intended to prevent situations that could result in property damage or
impaired functioning.
Note A note presents additional information or interesting sidelights.
The alert symbol and IMPORTANT heading calls attention to
important information.
Le symbole d'alerte et l'attention IMPORTANT rubrique appels à
des informations importantes.
The alert symbol and CAUTION heading indicate a potential haz-
ard. Strictly follow the instructions to avoid property damage.
Le symbole d'alerte et indiquent la position CAUTION un danger
potentiel. Suivre strictement les instructions afin d'éviter des dom-
mages matériels.
The shock hazard symbol and CAUTION heading indicate a
potential electric shock hazard. Strictly follow the instructions to
avoid property damage caused by electric shock.
Le symbole de danger de choc et la position CAUTION indique
un risque de choc électrique. Suivre strictement les instructions
pour éviter les dommages matériels causés par un choc élec-
trique.
The alert symbol and WARNING heading indicate a potential safety hazard.
Strictly follow the warning instructions to avoid personal injury.
Le symbole alerte et WARNING rubrique indiquer un danger potentiel pour la
sécurité. Suivre strictement les instructions d'avertissement pour éviter les
blessures.
The shock hazard symbol and WARNING heading indicate a potential electric
shock hazard. Strictly follow the warning instructions to avoid injury caused
by electric shock.
Le symbole de danger de choc et la position WARNING indique un risque de
choc électrique. Suivre strictement les instructions d'avertissement pour éviter
les blessures causées par un choc électrique.