Philips HTB5150D/12 User manual

TABLE OF CONTENTS
Page
Service Manual
. Mechanical and Dismantling Instructions…………........................3-1
. Software Upgrades ........................................................................4-1
. Trouble Shooting Chart……………………………………………….5-1
. Wiring Diagram………………………………………..………..….….6-1
. Electrical Diagrams and Print-layouts..….…………………....….…7-1
. Set Mechanical Exploded view & Part list.…………………..….…10-1
©Copyright 2011Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in aretrieval system or
transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise
without the prior permission of Philips.
CLASS 1
LASER PRODUCT
PHILIPS
GB
. DFU Instruction..............................................................................2-1
. Revision List.................................................................................11-1
Home Theater Soundbar
. Technical Specifications…………....………………………..............1-
3
. Safety Instruction, Warning & Notes….……………………....….....1-
7
. Location of PCB Boards ,Version Variation and Repair Scenario Matrix....1-2
Published by Arya & Stephen - 1234BU AVM Printed in The Netherlands Subject to modification
3141 785 38360
Version 1.1
Service
HTB5150D/12
. Votages and Waveforms for Connection Pins..….………………...8-1
. Pin Description & Block Diagrams of ICs..….………………..........9-1
. Pin Description & Block Diagrams of ICs..….………………..........9-1
. Votages and Waveforms for Connection Pins..….………………...8-1

VERSION VARIATIONS FOR SOUNDBAR
Type / Versions HTB5150D
Service Police
MAIN BOARD M +C
POWER BOARD M +C
AMPLIFER BOARD M +C
KEY BOARD M
LOADER M
VFD BOARD M
IN BOARD M
WIRELESS BOARD M
WIFI BOARD M
＊Tips：
Board in used
C -- Component Lever Repair
M -- Module Lever Repair
X -- Used
/12
PCB BOARD LOCATION OF SOUNDBAR:
MAIN BOARD
AMPLIFIER BOARD
LOADER
POWER BOARD
IN BOARD
1-2
KEY BOARD
VFD BOARD
WIRELESS
BOARD(UNDER
MAIN BOARD)
WIFI BOARD

Board in used
VERSION VARIATIONS FOR SUBWOOFER
Type / Versions HTB5150D
Service Police
POWER BOARD M
AMPLIFER BOARD M
WIRELESS BOARD M
WIFI BOARD M
＊Tips：
Board in used
C -- Component Lever Repair
M -- Module Lever Repair
X -- Used
/12
PCB BOARD LOCATION Of SUBWOOFER:
AMPLIFIER BOARD
POWER BOARD
1-2
WIRELESS BOARD
WIFI BOARD（UNDER
WIRELESS BOARD)

Product
specifications
Note
6SHFLÀFDWLRQVDQGGHVLJQDUHVXEMHFWWRFKDQJHZLWKRXW
notice.
Region codes
The type plate on the back or bottom of the
home theater shows which regions it supports.
Media formats
 AVCHD, BD, BD-R/ BD-RE, BD-Video,
DVD-Video, DVD+R/+RW, DVD-R/-RW,
DVD+R/-R DL, CD-R/CD-RW,Audio CD,
9LGHR&'69&'3LFWXUHÀOHV03PHGLD
WMA media, DivX Plus HD media, USB
storage device
Country DVD BD
Europe,
United Kingdom
Korea
Latin America
Australia,
New Zealand
Russia, India
China
AA
AA
CC
CC
Asia Pacific, Taiwan,
File formats
 Audio: .aac, .mka, .mp3, .wma, .wav, .mp4,
PDUDÁDFRJJ
 Video:
 .avi, .divx, .mp4, .m4v, .mov, .mkv, .m2ts,
DVIZPYPSJPSHJÁYJSJ
 .rmvb, .rm, .rv (Available only in Asia
3DFLÀFDQG&KLQD
 3LFWXUHMSJMSHJMSHMLIMÀIMÀJLISQJ
Audio formats
Your home theater supports the following
DXGLRÀOHV
Extension Con-
tainer
Audio
codec
Bit rate
.mp3 MP3 MP3 Upto 320 kbps
.wma ASF WMA Upto 192 kbps
WMA Pro Upto 768 kbps
.aac AAC AAC, HE-
AAC
Upto 192 kbps
.wav WAV PCM 27.648 Mbps
.m4a MKV AAC 192 kbps
.mka MKA PCM 27.648 Mbps
Dolby
Digital
640 kbps
DTS core 1.54 Mbps
MPEG 912 kbps
MP3 Upto 320 kbps
WMA Upto 192 kbps
WMA Pro Upto 768 kbps
AAC, HE-
AAC
Upto 192 kbps
.ra RM AAC, HE-
AAC
Upto 192 kbps
Cook 96469 bps
ÁDF FLAC FLAC Upto 24 bps
.ogg OGG Vorbis Variable bit rate,
maximum block
size 4096
FLAC Upto 24 bps
OGGPCM No limit
MP3 Upto 320 kbps
1-3

Video formats
,I\RXKDYHDKLJKGHÀQLWLRQ79\RXUKRPH
theater allows you to play your:
 YLGHRÀOHVZLWKDUHVROXWLRQRI[
1080 pixels (except DivX, which has a
resolution of 77220 x 576) and frame rate
of 6 ~ 30 frames per second.
 SKRWRÀOHVZLWKDUHVROXWLRQRI0SL[HOV
DYLÀOHVLQ$9,FRQWDLQHU
Audio
codec
Video codec Bit rate
PCM,
Dolby
Digital,
DTS core,
MP3,
WMA
DivX 3.11, DivX 4.x,
DivX 5.x, DivX 6.x
10 Mbps
max
MPEG 1, MPEG 2 40 Mbps
MPEG 4 SP / ASP 38.4
Mbps
H.264/AVC upto
[email protected]
25 Mbps
WMV9 45 Mbps
GLY[ÀOHVLQ$9,FRQWDLQHU
Audio codec Video codec Bit rate
PCM, Dolby
Digital, MP3,
WMA
DivX 3.11,
DivX 4.x, DivX 5.x,
DivX 6.x
10
Mbps
max
PSRUPYÀOHVLQ03FRQWDLQHU
Audio codec Video codec Bit rate
Dolby Digital,
MPEG, MP3,
AAC, HE-AAC,
DD+
MPEG 1,
MPEG 2
40 Mbps
MPEG 4 ASP 38.4
Mbps
H.264/AVC
[email protected]
25 Mbps
PRYÀOHVLQ029FRQWDLQHU
Audio codec Video codec Bit rate
Dolby Digital,
MPEG, MP3,
AAC, HE-AAC
MPEG 1, MPEG
2
40 Mbps
MPEG 4 ASP 38.4
Mbps
H.264/AVC
[email protected]
25 Mbps
PNYÀOHVLQ0.9FRQWDLQHU
Audio codec Video codec Bit rate
PCM, Dolby
Digital, DTS core,
MPEG, MP3,
WMA, AAC, HE-
AAC, DD+
DivX Plus HD 30 Mbps
MPEG 1, MPEG
2
40 Mbps
MPEG 4 ASP 38.4
Mbps
H.264/AVC
[email protected]
25 Mbps
WMV9 45 Mbps
PWVÀOHVLQ0.9FRQWDLQHU
Audio codec Video codec Bit rate
PCM, Dolby Digital,
DTS core, MPEG,
MP3,WMA, AAC,
HE-AAC, DD+
MPEG 1,
MPEG 2
40 Mbps
MPEG 4 ASP 38.4
Mbps
H.264/AVC
[email protected]
25 Mbps
WMV9 45 Mbps
DVIDQGZPYÀOHVLQ$6)FRQWDLQHU
Audio codec Video codec Bit rate
Dolby Digital,
MP3,WMA,
DD+
MPEG 4 ASP 38.4 Mbps
H.264/AVC
[email protected]
25 Mbps
1-4

Audio codec Video codec Bit rate
WMV9 45 Mbps
PSJDQGPSHJÀOHVLQ36FRQWDLQHU
Audio codec Video codec Bit rate
PCM, DTS core,
MPEG, MP3
MPEG 1,
MPEG 2
40
Mbps
ÁYÀOHVLQ)/9FRQWDLQHU
Audio
codec
Video codec Bit rate
MP3,
AAC
H.264/AVC upto
[email protected]
25 Mbps
H.263 38.4 Mbps
On2 VP6 40 Mbps
JSÀOHVLQ*3FRQWDLQHU
Audio
codec
Video codec Bit rate
AAC, HE-
AAC
MPEG 4 ASP 38.4 Mbps
H.264/AVC upto
[email protected]
25 Mbps
max
UPUYDQGUPYEÀOHVLQ50FRQWDLQHU
$YDLODEOHRQO\LQ$VLD3DFLÀFDQG&KLQD
Audio codec Video codec Bit rate
AAC, COOK RV30, RV40 40 Mbps
$PSOLÀHU
 Total output power:
 550W RMS (+/- 0.5 dB, 30% THD) /
440W RMS (+/- 0.5 dB, 10% THD)
 Frequency response: 20 Hz-20 kHz / ±3
dB
 Signal-to-noise ratio: > 65 dB (CCIR) /
(A-weighted)
 Input sensitivity:
 AUX: 2 V
 Music iLink: 300 mV
Video
 Signal system: PAL / NTSC
 HDMI output: 480i/576i, 480p/576p, 720p,
1080i, 1080p, 1080p24
Audio
 S/PDIF Digital audio input:
 Optical:TOSLINK
 Sampling frequency:
 MP3: 32 kHz, 44.1 kHz, 48 kHz
 WMA: 44.1 kHz, 48 kHz
 Constant bit rate:
 MP3: 32 kbps - 320 kbps
 WMA: 48 kbps - 192 kbps
Radio
 Tuning range:
 Europe/Russia/China: FM 87.5-108
MHz (50 kHz)
 $VLD3DFLÀF/DWLQ$PHULFD)0
MHz (50/100 kHz)
 Signal-to-noise ratio: FM 50 dB
 Frequency response: FM 180 Hz-12.5 kHz
/ ±3 dB
USB
 Compatibility: Hi-Speed USB (2.0)
 Class support: USB Mass Storage Class
(MSC)
 File system: FAT16, FAT32, NTFS
Main unit
 Power supply:
 Europe/China: 220-240 V~, 50 Hz
 /DWLQ$PHULFD$VLD3DFLÀF
V/220-240 V~, 50-60 Hz
 Russia/India: 220-240 V~, 50 Hz
 Satellite speakers: 4 x 2.5" speakers
 Power consumption: 60 W
 Standby power consumption: 0.5 W
 Dimensions (WxHxD): 1060 x 83.1 x
194.8 mm
1-5

 Weight: 4.9 KG
Subwoofer
 Impedance: 3 ohm
 Speaker drivers: 1 x 6.5" woofer
 Power consumption: 50 W
 Standby power consumption: 0.5 W
 Dimensions (WxHxD): 195 x 298 x 410
mm
 Weight: 7.2 KG
Remote control batteries
 2 x AAA-R03-1.5 V
Laser
 Laser Type (Diode): InGaN/AIGaN (BD),
AIGaInP (DVD/CD)
 Wave length: 405 +7 nm/-7 nm (BD), 655
+10 nm/-10 nm (DVD), 790 +10 nm/-20
nm (CD)
 Output power (Max. ratings): 20 mW
(BD), 6 mW (DVD), 7 mW (CD)
1-6

Safety instruction
1. General safety
Safety regulations require that during a repair:
. Connect the unit to the mains via an isolation transformer.
. Replace safety components indicated by the symbol ,
only by components identical to the original ones. Any
other component substitution (other than original type)
may increase risk of fire or electrical shock hazard.
Safety regulations require that after a repair, you must
return the unit in its original condition. Pay, in particular,
attention to the following points:
. Route the wires/cables correctly, and fix them with the
mounted cable clamps.
. Check the insulation of the mains lead for external
damage.
. Check the electrical DC resistance between the mains
plug and the secondary side:
1) Unplug the mains cord, and connect a wire between
the two pins of the mains plug.
2) Set the mains switch the “on” position (keep the
mains cord unplug).
3) Measure the resistance value between the mains
plug and the front panel, controls, and chassis
bottom.
4) Repair or correct unit when the resistance
measurement is less than 1M
¡
.
5) Verify this, before you return the unit to the
customer/user (ref. UL-standard no. 1492).
6) Switch the unit “off”, and remove the wire between
the two pins of the mains plug.
2.Laser safety
This unit employs a laser. Only qualified service personnel
may remove the cover, or attempt to service this device
(due to possible eye injury).
Laser device unit
Type :SemiconductorlaserGaAlAs
Wavelength : 650nm (DVD)
: 780nm (VCD/CD)
Output power : 7mW (DVD)
:10mW(DVD/CD)
Beam divergence: 60 degree
Note: Use of controls or adjustments or performance of
procedure other than those specified herein, may result in
hazardous radiation exposure. Avoid direct exposure to
beam.
Safet
y
instruction, Warnin
g
& Notes
1-7

Warning
1.General
. All ICs and many other semiconductors are susceptible to
electrostatic discharges (ESD). Careless handing during
repair can reduce life drastically. Make sure that, during
repair, you are at the same potential as the mass of the
set by a wristband with resistance. Keep components and
tools at this same potential. Available ESD protection
equipment:
1) Complete kit ESD3 (small tablemat, wristband,
connection box, extension cable and earth cable)
4822 310 10671.
2) Wristband tester 4822 344 13999.
. Be careful during measurements in the live voltage
section. The primary side of the power supply , including
the heat sink, carries live mains voltage when you
connect the player to the mains (even when the player is
“off”!). It is possible to touch copper tracks and/or
components in this unshielded primary area, when you
service the player. Service personnel must take
precautions to prevent touching this area or components
in this area. A “lighting stroke” and a stripe-marked
printing on the printed wiring board, indicate the primary
side of the power supply.
. Never replace modules, or components, while the unit is
“on”.
2. Laser
. The use of optical instruments with this product, will
increase eye hazard.
. Only qualified service personnel may remove the cover
or attempt to service this device, due to possible eye
injury.
. Repair handing should take place as much as possible
with a disc loaded inside the player.
. Text below is placed inside the unit, on the laser cover
shield:
Notes: Manufactured under licence from Dolby
Laboratories. The double-D symbol is trademarks of Dolby
Laboratories, Inc. All rights reserved.
CAUTION: VISIBLE AND INVISIBLE LASER
RADIATION WHEN OPEN, AVOID EXPOSURE
TO BEAM.
1-8

 6HUYLFH+LQWV
 &$87,21
&+$5*('&$3$&,7256217+(6(592%2$5'0$<'$0$*(7+('5,9(
(/(&7521,&6:+(1&211(&7,1*$1(:'5,9(7+$7¶6:+<%(6,'(67+(6$)(7<
0($685(6/,.(
  6:,7&+2))32:(56833/<
  (6'3527(&7,21
$'',7,21$/$&7,2160867%(7$.(1%<7+(5(3$,57(&+1,&,$1
 7KHIROORZLQJVWHSVKDYHWREHGRQHZKHQUHSODFLQJWKHGHIHFWLYHORDGHU

  'LVPDQWOLQJRIWKHORDGHUWRDFFHVVWKH(6'SURWHFWLRQSRLQWLIQHFHVVDU\
   6ROGHUWKH(6'SURWHFWLRQSRLQW    
  'LVFRQQHFWÀH[IRLOFDEOHIURPWKHGHIHFWLYHORDGHU
  3XWDSDSHUFOLSRQWKHÀH[IRLOWRVKRUWFLUFXLWWKHFRQWDFWV¿J
  5HSODFHWKHGHIHFWLYHORDGHUZLWKDQHZORDGHU
  5HPRYHSDSHUFOLSIURPWKHÀH[IRLODQGFRQQHFWLWWRWKHQHZORDGHU
  5HPRYHVROGHUMRLQWRQWKH(6'SURWHFWLRQSRLQW

$77(17,217KHODVHUGLRGHRIWKLVORDGHULVSURWHFWHGDJDLQVW(6'E\DVROGHUMRLQWZKLFKVKRUWFLUFXLWVWKHODVHUGLRGHWRJURXQG
)RUSURSHUIXQFWLRQDOLW\RIWKHORDGHUWKLVVROGHUMRLQWPXVWEHUHPRYHDIWHUFRQQHFWLRQORDGHUWRWKHVHW



 2QO\DSSOLFDEOHIRUGHIHFWLYHORDGHUQHHGHGWREHVHQWEDFNWRVXSSOLHUIRUIDLOXUHDQDO\VLVDQGWRVXSSRUWEDFNFKDUJLQJ 
 HYLGHQFH
 7KLVLVDOVRDSSOLFDEOHIRUDOOSDUWQHUVKLSZRUNVKRSV
(6'SURWHFWLRQSRLQWLVDFFHVVLEOHIURPWRSRIORDGHU
SolderJoint
1-9