Plantcraft 160 litre dual batch composter User manual

160 Litre Dual Batch Composter

User Manual

[Revision 1.0 April 2017]

READ THIS MANUAL CAREFULLY BEFORE USE – FAILURE TO DO SO MAY RESULT IN INJURY,

PROPERTY DAMAGE AND MAY VOID WARRANTY. • KEEP THIS MANUAL FOR FUTURE REFERENCE. •

Products covered by this manual may vary in appearance, assembly, inclusions, specifications, description and

packaging.

A - Drum Side Panel (2)

B - Panel (7)

C - Hatch Panel (1)

D - Hatch (2 - may be pre-assembled)

E - Divider (1)

F - Small Screw / Nut (56)

G - Large Screw / Nut (2)

aa - Central Frame Tube (1)

bb - Side Frame Tube (2)

cc - Frame Foot (2)

dd - Frame Foot (2)

C / D

Parts Identification

PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT PLANT CRAFT

Assembly

Assemble the unit as follows in accordance with figure

1 to 10.

1. Attach the panel with the hatches to the drum end

panels first. Ensure that the arrows on all parts are

aligned, then secure them using 4 screws and nuts.

2. Install the next panel to the drum end panels and

also to the previously installed panel using 7 screws

and nuts.

3. Install the next 2 panels . There should be 4 panels

installed.

4. Insert the inner divider into the locating grooves in

the centre of the installed panels. Make sure that the

divider stayswithin the grooves in the middle of the

panels.

5. Install the remaining panels.

6. If required, slide the hatches into position.

7. When fully assembled, the drum is ready to be

attached to the frame.

8. Slide the frame central tube ("aa") through the drum.

9. Assemble frame tubes "bb", "cc" and "dd" together

as shown. At each joint there is a spring-loaded pin -

press the pin in when joining the tubes. When correctly

assembled the pin should pop out through the locating

hole in the other tube.

10. Place the central tube / drum assembly into position

on top of the frame. Attach the central tube to the frame

using the long screws ("G") and nuts.

Assembly is complete.

Setting-Up Your Composter

Ensure that the composter is placed on a flat surface and that there is sufficient

space around it so the drum to be rotated. If possible, select a location in direct

sunlight, to help "cook"the compost.

What to Compost

The composting process works best by mixing moist greens (nitrogen rich) with dry

browns (carbon rich) in approximately equal amounts. Not that actual ratios will vary

depending on your personal circumstances.

Greens:

- Kitchen scraps

- Grass clippings

- Garden & house plants

What NOT to Compost

- Meats/fats/bones

- Dairy products

-Rubbish/plastic

-Ashes

- Invasive plants/weeds (i.e. poison ivy)

Browns:

- Leaves

- Straw/hay

- Saw dust

- Twigs

Checking the Process

After 2 to 3 days, check the mix to see if it is getting hot. When the mix is hot, the

beneficial organisms are multiplying and decomposing materials. Turning the

composter 5 to 10 times every 2 or 3 days will mix the materials and keep the

process active. Squeeze a handful of compost to ensure the materials are not drying

out. If it feels like a damp sponge, the water level is fine –if it feels dry, add a little

water (be careful not to add too much) and turn the composter to mix well.

Depending on materials being composted, the compost should be ready in 4 to 8

weeks. Finished compost will contain fine and coarse material. For a fine blend, sift

the compost. Use the coarser compost as a fertiliser for outdoor plantings or till

directly into the garden.You may also use finished compost as a starter for the next

batch, or to heat up a batch that cooled too quickly.

To remove the finished compost, turn the barrel of the composter so the hatches are

facing the ground, then slide open the hatch for the chamber you want to empty.

Composting Tips

Three Rules of Composting

•Use good quality materials in a 1 to 1 ratio of greens (Nitrogen) to browns

(Carbon).

•Maintain consistent moisture - mix should feel like a damp sponge

•Maintain good air circulation –turn the composter every few days after the

batch heats up to help aerate mix and encourage decomposition.

Trouble Shooting

Compost not heat

ing:

·Mix is too wet –add dry browns

·Mix is too dry –add water

·Mix ratio is off –check green/brown ratio and adjust accordingly

Compost producing o

dour

•Ammonia smell means too much nitrogen (greens) –add dry browns.

•Putrid smell (like rotten eggs) means mix is too wet and/or not enough

oxygen –add dry browns to absorb excessive moisture and turn composter.

Problems with

ests/

nsects

·Rodents are attracted to meat and fatty foods –remove them.

·Flies/insects are attracted to uncovered waste, especially kitchen scraps –

mix or cover with brown materials or finished compos.

Some experts believe that the incorrect or prolonged use of almost any product may

cause seriousinjury or death. To help reduce your risk of seriousinjury or death, refer

to the information below. For more information, see www.datastreamserver.com/safety

Consult all documentation, packaging and product

labelling before use. Note that some products feature

documentation available online. It is recommended to

print and retain the documentation.

Before each use, check the product for loose/broken/

damaged/missing parts, wear or leaks (if applicable).

Never use a product with

loose/broken/damaged/missing parts, wear or leaks.

Products must be inspected and serviced (if

applicable) by a qualified technician every 6 months.

This is based on average residential use by persons of

average size and strength, and on a property of

average metropolitan size. Use beyond these

recommendations may require more frequent

inspections/servicing.

Ensure that all users of the product have completed a

suitable industry recognised training course before

being allowed access to the product.

If this product has been purchased in error when

considering the information presented here, contact

the retailer directly for details of their returns policy, if

required.

The product has been supplied by a general

merchandise retailer that may not be familiar with your

specific application or description of application. Be

sure to attain third-party approval from a qualified

specialist for your application before use, regardless of

any assurances from the retailer or its representatives.

This product is not intended for use where fail-safe

operation is required. As with any product (for

example, automobile, computer, toaster), there is the

possibility of technical issues that may require the

repair or replacement of parts, or the product itself. If

the possibility of such failure and the associated time it

may take to rectify could in any way inconvenience the

user, business or employee, or financially affect the

user, business or employee, then the product is not

suitable for your requirements. This product is not

intended for use where incorrect operation or a failure

of any kind, including but not limited to, a condition

requiring product return, replacement, parts

replacement or service by a technician may cause

financial loss, loss of employee time or an

inconvenience requiring compensation.

ideas, diagrams or images may be reproduced or transmitted in any form or by any means, electronic or

mechanical, including photocopying, scanning or recording, or any information storage and retrieval system,

without express permission or consent from the publisher.

Table of contents

Popular Lawn And Garden Equipment manuals by other brands

Graf

Graf PLATIN Series Installation and maintenance instructions

GÜDE

GÜDE GV 4000 B Translation of the original instructions

Stratco

Stratco MODULAR GARDEN BED LG-34498 install guide

G21

G21 GAH 884 installation manual

Grizzly

Grizzly AGS 108 Lion Original instructions for use

Levita

Levita S 1400 operating instructions

Holman

Holman 30091 installation guide

Makita

Makita SW400MP Original instruction manual

Hurricane

Hurricane HVL-S-1532 Translation from the original instruction manual

Sears

Sears Craftsman 316.794450 Operator's manual

Vente Unique

Vente Unique GARDENA Product description

Simplicity

Simplicity 1694543 Illustrated parts list

Simplicity

Simplicity 2438 Illustrated parts list

Gama Sonic

Gama Sonic GS-105PL880 instruction manual

GardenSkill

GardenSkill Mini Poly Tunnel instructions

hecht

hecht 220 Original instructions for use

Suncast

Suncast Free Standing Pergola Assembly instructions

GrowSpan

GrowSpan 105158F instruction manual

PLANTCRAFT 160 Litre Dual Batch Composter User manual

Popular Lawn And Garden Equipment manuals by other brands