Polar Electro GH218-A User manual

Model:
GH218-A/GH219-A
Display Glass Door
Fridge
Instruction manual
GH218-A_GH219-A_A5_v1_20210816.indb 1GH218-A_GH219-A_A5_v1_20210816.indb 1 2021/8/16 10:532021/8/16 10:53

2
AU Telephone Helpline: 1300225960
Safety Instructions
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components or service panels on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT stand or support yourself on the base, drawers or
doors.
• DO NOT allow oil or fat to come into contact with the plastic
components or door seal. Clean immediately if contact occurs.
• Bottles that contain a high percentage of alcohol must be
sealed and placed vertically in the refrigerator.
• Always carry, store and handle the appliance in a vertical
position and move by holding the base of the appliance.
• Always switch off and disconnect the power supply to the unit
before cleaning.
• Keep all packaging away from children. Dispose of the
packaging in accordance with the regulations of local
authorities.
• If the power cord is damaged, it must be replaced by a POLAR
agent or a recommended qualified technician in order to avoid
a hazard.
GH218-A_GH219-A_A5_v1_20210816.indb 2GH218-A_GH219-A_A5_v1_20210816.indb 2 2021/8/16 10:532021/8/16 10:53

3
AUAU
Telephone Helpline: 1300225960
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have
been given supervision or instruction concerning use of the
appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play
with the appliance.
• Polar recommend that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity, Insulation Continuity and
Functional Testing.
Caution Risk of Fire
• Do not store explosive substances such as aerosol cans with a
flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of
obstruction. Unit should not be boxed in without
adequate ventilation.
• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance, unless they are the
type recommended by the manufacturer.
Product Description
GH218-A - Polar Gastro Display Fridge - Glass Door - 600Ltr
GH219-A - Polar Gastro Display Fridge - Glass Door - 1200Ltr
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your POLAR product.
GH218-A_GH219-A_A5_v1_20210816.indb 3GH218-A_GH219-A_A5_v1_20210816.indb 3 2021/8/16 10:532021/8/16 10:53

4
AU Telephone Helpline: 1300225960
Pack Contents
The following is included:
• POLAR Refrigerator or Freezer
• Keys
• Shelf guides
• Shelves
• Instruction manual
POLAR prides itself on quality and service, ensuring
that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit,
please contact your POLAR dealer immediately.
Installation
Note: If the unit has not been
stored or moved in an upright
position, let it stand upright for
approximately 12 hours before
operation. If in doubt allow to
stand.
1. Remove the appliance from the packaging.
Make sure that all protective plastic film and
coatings are thoroughly removed from all
surfaces.
2. To optimize performance and longevity, ensure
a minimum clearance of 2.5cm is maintained
between the unit and walls and other objects,
with a minimum 5cm clearance on the top.
NEVER LOCATE NEXT TO A HEAT SOURCE.
Note: Before using the appliance
for the first time, clean the
shelves and interior with soapy
water.
3. Set the brakes on the castors to keep the
appliance in position.
Removing the Compressor Safety
Band
• The compressor is located on the top of the
appliance, and sits on rubber washers. Under
normal operating conditions the compressor is
allowed to vibrate.
• To avoid damage through excessive motion
during transit, a stainless steel safety band is
placed over the compressor and screwed into
the top of the appliance.
• This safety band and the two screws fixing it
to the appliance must be removed before the
appliance is turned on.
Compressor
Safety Band
Compressor
Screws
Lock/Unlock the Doors
A lock is fitted to the doors to ensure foodstuffs
are kept secure within your POLAR appliance.
Use the keys provided to lock/unlock the doors.
Fitting the Shelves
1. Place one set of shelf guides on either side of
the cabinet at the desired height.
2. Slide the shelf into place.
3. Repeat for the remaining shelves.
GH218-A_GH219-A_A5_v1_20210816.indb 4GH218-A_GH219-A_A5_v1_20210816.indb 4 2021/8/16 10:532021/8/16 10:53

5
AUAU
Telephone Helpline: 1300225960
Operation
Storing Food
To get the best results from your POLAR appliance,
follow these instructions:
• Only store foodstuffs in the appliance when it
has reached the correct operating temperature.
• Do not place uncovered hot food or liquid
inside the appliance.
• Wrap or cover food where possible.
• Do not obstruct the fans inside the appliance.
• Avoid opening the doors for prolonged periods
of time.
Turn On
1. Close the door(s) of the appliance.
2. Ensure the power switch is set to [O] and turn
on at the socket.
3. Switch on the Power [I]. The current
temperature within the appliance is displayed.
Control Panel
A BC
A - Power Switch
B - Lamp Switch
C - Controller
To See the Setpoint
Push and immediately release the SET key: the
display will show the Setpoint value.
Changing the Setpoint
1. Push the SET key for more than 2 seconds to
change the Setpoint value.
2. The value of the set point will be displayed and
the COMPRESSOR LED starts blinking.
3. To change the Set value push and
buttons within 10 seconds.
4. To store the new Setpoint push the SET key or
wait 10 seconds.
Manual Defrost
The appliance will automatically run a defrost cycle
every six hours.
Note: The cycle starts from the
time the appliance is initially
powered up.
To manually defrost the appliance:
1. Press and hold the aux button for more then 2
seconds.
2. The defrost cycle will start immediately and the
Defrost LED illuminates.
Note: Starting a manual defrost
also resets the automatic
defrost timer.
3. The next automatic defrost will start six hours
after the manual defrost has finished.
Cleaning, Care &
Maintenance
Defrost appliance at least
every 3 months, more often if
required.
Switch off and disconnect
from the power supply before
cleaning.
• Clean the interior of the appliance as often as
possible.
• Do not use abrasive cleaning agents. These
can leave harmful residues.
• Clean the door seal with warm soapy water.
• Always wipe dry after cleaning.
• Do not allow water used in cleaning to run
through the drain hole into the evaporation
pan.
• Take care when cleaning the rear of the
appliance. Sharp edges can cut.
• A POLAR agent or qualified technician must
carry out repairs if required.
GH218-A_GH219-A_A5_v1_20210816.indb 5GH218-A_GH219-A_A5_v1_20210816.indb 5 2021/8/16 10:532021/8/16 10:53

6
AU Telephone Helpline: 1300225960
Stainless Steel Care
To maintain the stainless steel exterior of your Polar item, please consider the following information:
Never:
• Use abrasive Scourers or scrubbing pads, etc.
• Use Chlorinated or acidic detergents.
• Allow anything e.g. food, dirt, cleaning chemicals to remain on the surface for longer than necessary,
clean them off right away.
• Allow the surface to remain wet.
Do:
• Clean often.
• Use soft Cloths or plastic Scourers.
• Rub with the grain of the metal, rather than across it.
• Use detergents and polish designed for cleaning Stainless Steel.
• Ensure that the cleaning products are washed off fully and that the steel is left dry.
Cleaning the Condenser
• The condenser is part of the refrigeration
system. The condenser requires monthly
cleaning.
• Always disconnect power supply before
carrying out Routine Maintenance.
• Failure to clean the condenser will reduce the
performance and life of your Polar unit and
may invalidate your warranty.
• The condenser is located above the
refrigeration cabinet. These models have a
removable filter which can be cleaned with a
vacuum cleaner.
Troubleshooting
If your POLAR appliance develops a fault, please check the following table before making a call to the
Helpline or your POLAR dealer.
Fault Probable Cause Solution
The appliance is not
working
The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug or lead is damaged Call POLAR agent or qualified Technician
Power supply Check power supply
GH218-A_GH219-A_A5_v1_20210816.indb 6GH218-A_GH219-A_A5_v1_20210816.indb 6 2021/8/16 10:532021/8/16 10:53

7
AUAU
Telephone Helpline: 1300225960
Fault Probable Cause Solution
The appliance turns on,
but the temperature is
too high/low
Too much ice on the evaporator Defrost the appliance
Condenser blocked with dust Clean condenser with hose attachment of
vacuum
Doors are not shut properly Check doors are shut and seals are not
damaged
Appliance is located near a
heat source or air flow to the
condenser is being interrupted
Move the refrigerator to a more suitable
location
Ambient temperature is too high Increase ventilation or move appliance to a
cooler position
Unsuitable foodstuffs are being
stored in the appliance
Remove any excessive hot foodstuffs or
blockages to the fan
Appliance is overloaded Reduce the amount of food stored in the
appliance
The appliance is
leaking water
The appliance is not properly
levelled
Adjust the screw feet to level the appliance
(if applicable)
The discharge outlet is blocked Clear the discharge outlet
Movement of water to the drain is
obstructed
Clear the floor of the appliance
(if applicable)
The water container is damaged Call POLAR agent or qualified Technician
The drip tray is overflowing Empty the drip tray (if applicable)
The appliance is
unusually loud
The safety band has not been
removed
Remove the safety band
Loose nut/screw Check and tighten all nuts and screws
The appliance has not been
installed in a level or stable
position
Check installation position and change if
necessary
Technical Specifications
Model Voltage Power Current Temp.
Range
Net
Capacity
(Ltr)
Refrigerant
Dimensions
H x W x D
mm
Weight
(kg)
GH218-A 220-240V
50Hz
255W 2.0A +2°C ~ +8°C 369 R290 90g 2000 x 680 x
810
145
GH219-A 220-240V
50Hz
410W 3.0A +2°C ~ +8°C 754 R290 130g 2000 x 1340
x 810
195
GH218-A_GH219-A_A5_v1_20210816.indb 7GH218-A_GH219-A_A5_v1_20210816.indb 7 2021/8/16 10:532021/8/16 10:53

8
AU Telephone Helpline: 1300225960
Electrical Wiring
The plug is to be connected to a suitable mains socket.
POLAR appliances are wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and environmentally safe
recycling process. For further information on how to dispose of this product correctly, contact the product
supplier, or the local authority responsible for waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to
change specifications without notice.
GH218-A_GH219-A_A5_v1_20210816.indb 8GH218-A_GH219-A_A5_v1_20210816.indb 8 2021/8/16 10:532021/8/16 10:53

DECLARATION OF CONFORMITY
• Conformiteitsverklaring • Déclaration de conformité • Konformitätserklärung • Dichiarazione di conformità •
• Declaración de conformidad • Declaração de conformidade
Equipment Type • Uitrustingstype • Type d'équipement • Gerätetyp
• Tipo di apparecchiatura • Tipo de equipo • Tipo de equipamento
Model • Modèle • Modell • Modello
• Modelo • Malli
G-Series Gastro Display Fridge 600L
G-Series Gastro Display Fridge 1200L
GH218-A
GH219-A
Application of Territory Legislation &
Council Directives(s)
Toepassing van Europese Richtlijn(en) •
Application de la/des directive(s) du
Conseil • Anwendbare EU-Richtlinie(n) •
Applicazione delle Direttive
• Aplicación de la(s) directiva(s) del
consejo • Aplicação de directiva(s) do
Conselho
Electrical safety
AS/NZS 60335.1:2011 +A1:2012 +A2:2014 +A3:2015 +A4:2017
AS/NZS 60335.2.89:2010 +A1:2013 +A2:2016
Electro-Magnetic Compatibility
EN 55014-1:2017
EN 55014-2:2015
EN 61000-3-2:2014
EN 61000-3-3:2013
Producer Name • Naam fabrikant • Nom du producteur • Name des Herstellers
• Nome del produttore • Nombre del fabricante • Nome do fabricante
Polar
I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s)
and Standard(s).
Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande
Richtlijn(en) en Standaard(en).
Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus
Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und
Norm(en) entspricht.
Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati.
El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y
estándar(es) arriba mencionadas.
Eu, o abaixo-assinado, declaro que o equipamento anteriormente especificado está em conformidade com a(s) anterior(es)
Directiva(s) e Norma(s)
Date • Data • Date • Datum • Data •
Fecha • Data
10th August 2021
Signature • Handtekening • Signature
• Unterschrift Firma • Firma •
Assinatura
Full Name • Volledige naam • Nom et
prénom • Vollständiger Name • Nome
completo • Nombre completo • Nome
por extenso
Ashley Hooper
Nerida Pearse
Position • Functie • Fonction • Position
• Qualifica • Posición • Função
Technical & Quality Manager
Commercial Manager/ Responsible
Supplier
Producer Address • Adres fabrikant •
Adresse du producteur • Anschrift des
Herstellers • Indirizzo del produttore •
Dirección del fabricante • Morada do
fabricante
Fourth Way,
Avonmouth,
Bristol,
BS11 8TB
United Kingdom
15 Bagdally Road,
Campbelltown
NSW 2560
DocuSign Envelope ID: D9AE9490-0D1D-4214-8035-944271F1C08E
GH218-A_GH219-A_A5_v1_20210816.indb 9GH218-A_GH219-A_A5_v1_20210816.indb 9 2021/8/16 10:532021/8/16 10:53

GH218-A_GH219-A_A5_v1_20210816.indb 10GH218-A_GH219-A_A5_v1_20210816.indb 10 2021/8/16 10:532021/8/16 10:53

GH218-A_GH219-A_A5_v1_20210816.indb 11GH218-A_GH219-A_A5_v1_20210816.indb 11 2021/8/16 10:532021/8/16 10:53

GH218-A_GH219-A_A5_v1_20210816
http://www.polar-refrigerator.com/
GH218-A_GH219-A_A5_v1_20210816.indb 12GH218-A_GH219-A_A5_v1_20210816.indb 12 2021/8/16 10:532021/8/16 10:53