Polar Electro G596-A User manual

Model:
G596-A/G597-A/G598-A/G599-A/G600-A/
DL914-A/DL915-A/DL916-A/DL917-A
Stainless Steel Counter
Refrigerators/Freezers
Instruction manual
G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 1 2017/8/2 14:29

2
AU Telephone Helpline: 1300225960
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required. Do not remove any
components or service panels on this product.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- Fire Precautions
- Wiring Regulations
- Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT use electrical appliances inside the appliance
(e.g. heaters, ice cream makers etc.)
• DO NOT stand or support yourself on the base, drawers or
doors.
• DO NOT allow oil or fat to come into contact with the plastic
components or door seal. Clean immediately if contact occurs.
• Bottles that contain a high percentage of alcohol must be
sealed and placed vertically in the refrigerator.
• Always carry, store and handle the appliance in a vertical
position and move by holding the base of the appliance.
• Always switch off and disconnect the power supply to the unit
before cleaning.
• Keep all packaging away from children. Dispose of the
packaging in accordance with the regulations of local
authorities.
• If the power cord is damaged, it must be replaced by a POLAR
agent or a recommended qualified technician in order to avoid
a hazard.
G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 2 2017/8/2 14:29

3
UKAUAU
Telephone Helpline: 1300225960
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience or knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Polar recommend that this appliance is PAT tested on an
annual basis to ensure the product remains safe.
Caution Risk of Fire
• Do not store explosive substances such as aerosol cans with a
flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of
obstruction. Unit should not be boxed in without
adequate ventilation.
• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance, unless they are the
type recommended by the manufacturer.
Product Description
G596-A - POLAR 282 litre 2 Door Counter Refrigerator
G597-A - POLAR 417 litre 3 Door Counter Refrigerator
G598-A - POLAR 563 litre 4 Door Counter Refrigerator
G599-A - POLAR 282 litre 2 Door Counter Freezer
G600-A - POLAR 417 litre 3 Door Counter Freezer
DL914-A - Polar Counter GN REFRIGERATOR - 2 Doors 700mm with upstand
DL915-A - Polar Counter GN REFRIGERATOR - 3 Doors 700mm with upstand
DL916-A - Polar Counter GN FREEZER - 2 Doors 700mm with upstand
DL917-A - Polar Counter GN FREEZER - 3 Doors 700mm with upstand
G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 3 2017/8/2 14:29

4
AU Telephone Helpline: 1300225960
Introduction
Please take a few moments to carefully read
through this manual. Correct maintenance and
operation of this machine will provide the best
possible performance from your POLAR product.
Pack Contents
The following is included:
• POLAR Refrigerator or Freezer
• Shelf guide (2 per door)
• Shelf (1 per door)
• Instruction manual
POLAR prides itself on quality and service, ensuring
that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit,
please contact your POLAR dealer immediately.
Installation
Note: If the unit has not been
stored or moved in an upright
position, let it stand upright for
approximately 12 hours before
operation. If in doubt allow to
stand.
1. Remove the appliance from the packaging.
Make sure that all protective plastic film and
coatings are thoroughly removed from all
surfaces.
2. Maintain a distance of 20cm (7 inches)
between the unit and walls or other objects for
ventilation. NEVER LOCATE NEXT TO OR
NEAR A HEAT SOURCE.
Note: Before using the appliance
for the first time, clean the
shelves and interior with soapy
water.
3. Set the brakes on the castors to keep the
appliance in position.
Fitting the Shelves & Floor Guards
1. Place one set of shelf guides on either side of
the cabinet at the desired height.
2. Slide the shelf into place.
3. Repeat for the remaining shelves.
4. Place the floor guards on the floor of the
cabinet, ensuring the flat side is clear of the
floor.
Note: This is vital for
ensuring correct drainage of
condensation.
Operation
Storing Food
To get the best results from your POLAR appliance,
follow these instructions:
• Only store foodstuffs in the appliance when it
has reached the correct operating temperature.
• Do not place uncovered hot food or liquid
inside the appliance.
• Wrap or cover food where possible.
• Do not obstruct the fans inside the appliance.
• Avoid opening the doors for prolonged periods
of time.
Turn On
1. Ensure the power switch is set to [O] and turn
on at the socket.
2. Switch on the Power [I]. The current
temperature within the appliance is displayed.
Control Panel
Set the Operating Temperature
1. Hold the SET button for 3 seconds. The value
of the current set point will be displayed.
2. Press the or buttons to display the
required temperature.
3. Press the SET button to store the temperature.
Manual Defrost
• The appliance will automatically run a defrost
cycle every six hours.
• To manually defrost the appliance: Press
and hold the defrost button "aux" for 2
seconds to begin a manual defrost. The defrost
light illuminates.
G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 4 2017/8/2 14:29

5
UKAUAU
Telephone Helpline: 1300225960
Cleaning, Care & Maintenance
Defrost appliance at least every 3 months, more often if required.
Switch off and disconnect from the power supply before cleaning.
• Clean the interior of the appliance as often as possible.
• Do not use abrasive cleaning agents. These can leave harmful residues.
• Clean the door seal with warm soapy water.
• Always wipe dry after cleaning.
• Do not allow water used in cleaning to run through the drain hole into the evaporation pan.
• Take care when cleaning the rear of the appliance. Sharp edges can cut.
• A POLAR agent or qualified technician must carry out repairs if required.
Stainless Steel Care
To maintain the stainless steel exterior of your Polar item, please consider the following information:
Never:
• Use abrasive Scourers or scrubbing pads, etc.
• Use Chlorinated or acidic detergents
• Allow anything e.g. food, dirt, cleaning chemicals to remain on the surface for longer than necessary,
clean them off right away.
• Allow the surface to remain wet.
Do:
• Clean often.
• Use soft Cloths or plastic Scourers.
• Rub with the grain of the metal, rather than across it.
• Use detergents and polish designed for cleaning Stainless Steel.
• Ensure that the cleaning products are washed off fully and that the steel is left dry.
Routine Maintenance
Condenser Cleaning
• The condenser is part of the refrigeration system. The condenser requires monthly cleaning.
• Always disconnect power supply before carrying out Routine Maintenance.
• Failure to clean the condenser will reduce the performance and life of your Polar unit and may
invalidate your warranty
• The condenser is located behind the service door on the right-hand side of the refrigeration cabinet.
• These models have a removable filter which can be cleaned with a vacuum cleaner.
G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 5 2017/8/2 14:29

6
AU Telephone Helpline: 1300225960
Troubleshooting
If your POLAR appliance develops a fault, please check the following table before making a call to the
Helpline or your POLAR dealer.
Fault Probable Cause Solution
The appliance is not
working
The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug and lead are damaged Call POLAR agent or qualified Technician
Fuse in the plug has blown Replace the fuse
Power supply Check power supply
Internal wiring fault Call POLAR agent or qualified Technician
The appliance turns on,
but the temperature is
too high/low
Too much ice on the evaporator Defrost the appliance
Condenser blocked with dust Clean the Condenser
Doors are not shut properly Check doors are shut and seals are not
damaged
Appliance is located near a
heat source or air flow to the
condenser is being interrupted
Move the refrigerator to a more suitable
location
Ambient temperature is too high Increase ventilation or move appliance to a
cooler position
Unsuitable foodstuffs are being
stored in the appliance
Remove any excessive hot foodstuffs or
blockages to the fan
Appliance is overloaded Reduce the amount of food stored in the
appliance
The appliance is
leaking water
The appliance is not properly
levelled
Adjust the screw feet to level the appliance
(if applicable)
The discharge outlet is blocked Clear the discharge outlet
Movement of water to the drain is
obstructed
Clear the floor of the appliance (if
applicable)
The water container is damaged Call POLAR agent or qualified Technician
The drip tray is overflowing Empty the drip tray (if applicable)
The appliance is
unusually loud
Loose nut/screw Check and tighten all nuts and screws
The appliance has not been
installed in a level or stable
position
Check installation position and change if
necessary
G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 6 2017/8/2 14:29

7
UKAUAU
Telephone Helpline: 1300225960
Technical Specifications
Model Voltage Power Current Temperature Range Capacity
(litres)
G596-A 230V 50Hz 350W 1.95A -2°C to 10°C 282
G597-A 230V 50Hz 350W 1.95A -2°C to 10°C 417
G598-A 230V 50Hz 350W 1.95A -2°C to 10°C 563
G599-A 230V 50Hz 750W 3.5A -10°C to -20°C 282
G600-A 230V 50Hz 750W 3.55A -10°C to -20°C 417
DL914-A 230V 50Hz 350W 1.95A -2°C to 10°C 282
DL915-A 230V 50Hz 350W 1.95A -2°C to 10°C 417
DL916-A 230V 50Hz 750W 3.5A -10°C to -20°C 282
DL917-A 230V 50Hz 750W 3.5A -10°C to -20°C 417
Model Refrigerant Dimensions
H x W x D mm
Weight
(kg)
G596-A R134a 230g 850 x 1360 x 700 98
G597-A R134a 230g 850 x 1790 x 700 134
G598-A R134a 250g 850 x 2230 x 700 153
G599-A R404a 300g 850 x 1360 x 700 98
G600-A R404a 300g 850 x 1790 x 700 136
DL914-A R134a 230g 960 x 1360 x 700 98
DL915-A R134a 230g 960 x 1795 x 700 134
DL916-A R404a 230g 960 x 1360 x 700 103
DL917-A R404a 230g 960 x 1795 x 700 136.5
G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 7 2017/8/2 14:29

8
AU Telephone Helpline: 1300225960
Electrical Wiring
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
The appliances must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Compliance
The WEEE logo on this product or its documentation indicates that the product must
not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and
environmentally safe recycling process. For further information on how to dispose of
this product correctly, contact the product supplier, or the local authority responsible for
waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to
change specifications without notice.
G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 8 2017/8/2 14:29

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 9 2017/8/2 14:29

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 10 2017/8/2 14:29

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 11 2017/8/2 14:29

G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802
http://www.polar-refrigerator.com/
G596-A_G600-A_DL914-A_DL917-A_A5_v5_170802.indb 12 2017/8/2 14:29