Polar Electro UA001 User manual

Model • Modèle • Modell • Modello • Modelo • Malli:
UA001/UA002/UA003/UA004
Refrigerators/
Freezers
Instruction manual
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 1 2020/1/3 18:08

2
UK
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out
installation and any repairs if required.
• Consult Local and National Standards to comply with the
following:
- Health and Safety at Work Legislation
- BS EN Codes of Practice
- Fire Precautions
- IEE Wiring Regulations
- Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT use electrical appliances inside the appliance (e.g.
heaters, ice cream makers etc.).
• DO NOT allow oil or fat to come into contact with the plastic
components or door seal. Clean immediately if contact occurs.
• DO NOT store products on top of the appliance.
• Bottles that contain a high percentage of alcohol must be
sealed and placed vertically in the refrigerator.
• Always carry, store and handle the appliance in a vertical
position and move by holding the base of the appliance.
• Always switch off and disconnect the power supply to the
appliance when not in use.
• Keep all packaging away from children. Dispose of the
packaging in accordance to the regulations of local authorities.
• If the power cord is damaged, it must be replaced by a POLAR
agent or a recommended qualified technician in order to avoid
a hazard.
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 2 2020/1/3 18:08

3
UK
• This appliance is not intended for use by persons (including
children) with reduced physical, sensory or mental capabilities,
or lack of experience and knowledge, unless they have been
given supervision or instruction concerning the use of the
appliance by a person responsible for their safety.
• Children should be supervised to ensure that they do not play
with the appliance.
• Polar recommends that this appliance should be periodically
tested (at least annually) by a Competent Person. Testing
should include, but not be limited to: Visual Inspection,
Polarity Test, Earth Continuity, Insulation Continuity and
Functional Testing.
Warning: Risk of Fire / flammable materials
• Do not store explosive substances such as aerosol cans
with a flammable propellant in this appliance.
Warning: Keep all ventilation openings clear of
obstruction. Unit should not be boxed in without
adequate ventilation.
• Warning: Do not use mechanical devices or other means
to accelerate the defrosting process, other than those
recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food
storage compartments of the appliance, unless they are the
type recommended by the manufacturer.
Product Description
UA001 - Polar single door Refrigerator
UA002 - Polar single door Freezer
UA003 - Polar double door Refrigerator
UA004 - Polar double door Freezer
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 3 2020/1/3 18:08

4
UK
Introduction
Please take a few moments to carefully read
through this manual. Correct maintenance and
operation of this machine will provide the best
possible performance from your POLAR product.
Pack Contents
The following is included:
• POLAR Refrigerator / Freezer
• Keys
• Shelves
• Shelf support bars
• Top hinge and Bottom hinge (for UA001/UA002
only)
• Instruction Manual
POLAR prides itself on quality and service, ensuring
that at the time of packaging the contents are
supplied fully functional and free of damage.
Should you find any damage as a result of transit,
please contact your POLAR dealer immediately.
Installation
Note: If the appliance has
been stored or moved in a
non-vertical position, stand
it in an upright position for
approximately 12 hours before
operation. If in doubt allow to
stand.
1. Remove the appliance from the packaging and
remove the protective film from all surfaces.
2. When positioning, maintain a distance of 20cm
(7 inches) between the appliance and walls or
other objects for ventilation. NEVER LOCATE
NEXT TO OR NEAR A HEAT SOURCE.
Note: Before using the appliance
for the first time, clean the
shelves and interior with soapy
water.
3. Set the brakes on the castors to keep the
appliance in position.
Fitting the shelf support bars
• Place the support bar on the ladder at the
desired height. For installation, the closed end
shall be located at rear and open end at front.
1. Push the support bar backwards to let its rear
end hang on the rear ladder (Step 1).
2. Lift the front end slightly then buckle it onto
the front ladder (Step 2).
Support bar
Ladder
• Repeat for the remaining support bars.
• Slide the GN pans/shelves into place.
Reversing the door (for UA001/
UA002 only)
The door handle is on the left side by default.
If necessary to reverse the door, follow below
operations:
Caution: All the operations
under this section should be
carried out only by trained
personnel or professional
technicians.
1. Turn the fixing locks as arrowed to release the
control panel.
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 4 2020/1/3 18:08

5
UK
2. Lift the controller panel upward for about
15mm, then take it out.
3. Remove all inner and exterior screws to release
the top decoration plate.
4. Remove the bottom decoration plate.
5. Remove the right top hinge and bottom hinge
to release the door. Then remove the door
carefully.
6. Mount the left top hinge and bottom hinge with
screws. Keep the top hinge a little loose so that
the door can be inserted later easily.
7. Reverse the door and insert it into the holes
of both hinges. Then fix the door in place with
screws.
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 5 2020/1/3 18:08

6
UK
8. There are covers on the top and bottom
decoration plates, remove the left cover and
install on the right side.
9. Install back the top decoration plate, bottom
decoration plate, and controller panel with
screws. Then turn the fixing locks ahead to fix
the control panel in place.
Operation
Control Panel for refrigerators
(UA001/UA003)
Control Panel for Freezers
(UA002/UA004)
Turn On
1. Close the door/doors of the appliance.
2. Connect the appliance to the mains power
supply.
3. To switch system on or off, press and hold
for 3 seconds.
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 6 2020/1/3 18:08

7
UK
Adjusting the Temperature
1. Press for 3 seconds. The set temperature
on the display will flash.
2. Press or to change the set
temperature.
3. Wait 6 seconds for the set temperature to be
stored.
Manual Defrost
Automatic defrost:
The appliance features an
automatic defrost. However,
should the appliance require an
additional defrost period, carry
out below operations:
1. Press for 3 seconds to enter defrosting
mode. The symbol will appear on the
display.
2. Press for 3 seconds again to exit.
Short cut operations for
refrigerators only:
1. Press once to enter fish mode and display
the set temperature (Range: -1°C ~ 1°C).
2. Press once to enter meat mode and display
the set temperature (Range: -2°C ~ 2°C).
3. Press once to return to general mode and
display the set temperature (Range: 1°C ~
4°C).
Cleaning, Care &
Maintenance
Switch off and disconnect
from the power supply before
cleaning.
• Clean the interior of the appliance as often as
possible.
• Do not use abrasive cleaning agents. These
can leave harmful residues.
• Clean the door seals with warm soapy water.
• Always wipe dry after cleaning.
Cleaning the condenser
• The condenser is part of the
refrigeration system. The condenser
requires monthly cleaning.
• Always disconnect power supply before
carrying out routine maintenance.
• Failure to clean the condenser will
reduce the performance and life of your
unit and may invalidate your warranty.
1. The condenser is located above the refrigerator
cabinet at the top.
2. These models have a removable filter which
can be taken out directly. Clean with a vacuum
cleaner.
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 7 2020/1/3 18:08

8
UK
Troubleshooting
If the machine malfunctions due to causes other than those listed or the proposed corrective actions do
not solve the problem please call a Polar agent or qualified technician.
Fault Probable Cause Solution
The unit is not working The unit is not switched on Check the unit is plugged in correctly and
switched on
Plug and lead are damaged Call POLAR agent or qualified Technician
Fuse in the plug has blown Replace the fuse
Power supply Check power supply
Internal wiring fault Call POLAR agent or qualified Technician
The appliance is not
cooling
Coolant Leak Call POLAR agent or qualified technician
Fan Motor Failed Call POLAR agent or qualified technician
Airflow to the condenser
obstructed
Increase the gap between appliance and
obstacles/heat source
Condenser is clogged Cleaning the condenser
Loud noises Appliance is not level Adjust position to make it level
Appliance is too close to a wall or
other object
Move to a more suitable location
Odour from the unit Unit is not cleaned for long time Clean the unit thoroughly
Odour food not properly packed Seal and pack odour food properly
Error code/
indication
Probable Cause Solution
“ER1” and
alarm
The evaporator inlet probe is
faulty
Press any button to cease alarm. Call POLAR agent or
qualified Technician to replace the faulty probe
“ER2” and
alarm
The evaporator return gas
probe is faulty
Press any button to cease alarm. Call POLAR agent or
qualified Technician to replace the faulty probe
“ER3” and
alarm
The defrost probe (evaporator
temperature probe) is faulty.
Press any button to cease alarm. Call POLAR agent or
qualified Technician to replace the faulty probe
“ER4” and
alarm
Door not closed properly or
door switch is faulty
Press any button to cease alarm. Close the door/doors
properly or check the door switch
“ER5” and
alarm
Condenser probe is faulty Press any button to cease alarm. Call POLAR agent or
qualified Technician to replace the faulty probe
“SO” and
alarm
Cabinet temperature probe is
open-circuited
Press any button to cease alarm. Call POLAR agent or
qualified Technician to replace the faulty probe
“SC” and
alarm
Cabinet temperature probe is
short-circuited
Press any button to cease alarm. Call POLAR agent or
qualified Technician to replace the faulty probe
“HI” and alarm Condenser temperature
exceeding 60°C
Power off and re-start machine to cease alarm. Press
power button for 1 second to check the condenser
temperature on the screen. Clean the condenser filter
immediately, or Call POLAR agent or qualified technician
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 8 2020/1/3 18:08

9
UK
Technical Specifications
Model Voltage Power
(W) Temp. Range Refrigerant Dimensions H x W x D mm
Weight
(kg)
UA001 220-240V~ 50Hz 430 -2°C ~ +4°C R290 1980 x 737 x 815 122.10
UA002 220-240V~ 50Hz 650 -18°C ~ -22°C R290 1980 x 737 x 815 127.90
UA003 220-240V~ 50Hz 460 -2°C ~ +4°C R290 1980 x 1400 x 815 187.60
UA004 220-240V~ 50Hz 800 -18°C ~ -22°C R290 1980 x 1400 x 815 194.00
Electrical Wiring
POLAR appliances are supplied with a 3 pin BS1363 plug and lead.
The plug is to be connected to a suitable mains socket.
POLAR appliances are wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Disposal
EU regulations require refrigeration product to be disposed of by specialist companies who remove or
recycle all gasses, metal and plastic components.
Consult your local waste collection authority regarding disposal of your appliance. Local authorities are
not obliged to dispose of commercial refrigeration equipment but may be able to offer advice on how to
dispose of the equipment locally.
Alternatively call the POLAR helpline for details of national disposal companies within the EU.
Compliance
The WEEE logo on this product or its documentation indicates that the product must
not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and
environmentally safe recycling process. For further information on how to dispose of
this product correctly, contact the product supplier, or the local authority responsible for
waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic,
mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to
change specifications without notice.
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 9 2020/1/3 18:08

UK 0845 146 2887
NL 0800 – 29 1 29
040 – 2628080
FR 0800 - 29 2 29
01 60 34 28 80
DE 0800 – 1860806
IT N/A
ES 901-100 133
PT [email protected]
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 10 2020/1/3 18:08

DECLARATION OF CONFORMITY
• Conformiteitsverklaring • Déclaration de conformité • Konformitätserklärung • Dichiarazione di conformità •
• Declaración de conformidad • Declaração de conformidade
Equipment Type • Uitrustingstype • Type d'équipement • Gerätetyp •
Tipo di apparecchiatura • Tipo de equipo • Tipo de equipamento
U-series Premium Single Door Refrigerator
U series Premium Single Door Freezer
U-series Premium Double Door Refrigerator
U series Premium Double Door Freezer
Model • Modèle • Modell • Modello • Modelo • Malli
UA001
UA002
UA003
UA004
Application of Council Directives(s)
Toepassing van Europese Richtlijn(en) • Application de la/des
directive(s) du Conseil • Anwendbare EU-Richtlinie(n) • Applicazione
delle Direttive • Aplicación de la(s) directiva(s) del consejo • Aplicação
de directiva(s) do Conselho
Machinery Directive 2006/42/EC
EN 60335-1:2012 +A11:2014 +A13:2017
EN 60335-2-89:2010 +A1:2016
EN 62233:2008
Electro-Magnetic Compatibility (EMC) Directive
2014/30/EU
EN 55014-1:2017
EN 55014-2:2015
EN 61000-3-3:2013
EN 61000-3-2:2014
Restriction of Hazardous Substances Directive
(RoHS) 2015/863 amending Annex II to Directive
2011/65/EU
Producer Name • Naam fabrikant • Nom du producteur • Name des
Herstellers • Nome del produttore • Nombre del fabricante • Nome do
fabricante
Polar
Producer Address • Adres fabrikant • Adresse du producteur •
Anschrift des Herstellers • Indirizzo del produttore • Dirección del
fabricante • Morada do fabricante
Fourth Way,
Avonmouth,
Bristol,
BS11 8TB
United Kingdom
42 North Point Business
Park
New Mallow Road
Cork
Ireland
I, the undersigned, hereby declare that the equipment specified above conforms to the above Directive(s) and Standard(s).
Ik, de ondergetekende, verklaar hierbij dat de hierboven gespecificeerde uitrusting goedgekeurd is volgens de bovenstaande
Richtlijn(en) en Standaard(en).
Je soussigné, confirme la conformité de l'équipement cité dans la présente à la / aux Directive(s) et Norme(s) ci-dessus
Ich, der/die Unterzeichnende, erkläre hiermit, dass das oben angegebene Gerät der/den oben angeführten Richtlinie(n) und Norm(en)
entspricht.
Il sottoscritto dichiara che l'apparecchiatura di sopra specificata è conforme alle Direttive e agli Standard sopra riportati.
El abajo firmante declara por la presente que el equipo arriba especificado está en conformidad con la(s) directiva(s) y estándar(es)
arriba mencionadas.
Eu, o abaixo-assinado, declaro que o equipamento anteriormente especificado está em conformidade com a(s) anterior(es) Directiva(s)
e Norma(s)
Date • Data • Date • Datum • Data • Fecha • Data
6th December 2019
Signature • Handtekening • Signature • Unterschrift
Firma • Firma • Assinatura
Full Name • Volledige naam • Nom et prénom • Vollständiger Name •
Nome completo • Nombre completo • Nome por extenso
Ashley Hooper
Position • Functie • Fonction • Position • Qualifica • Posición • Função
Technical & Quality Manager
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 11 2020/1/3 18:08

UA001-UA002-UA003-UA004_UK_A5_v1_20200103
http://www.polar-refrigerator.com/
UA001-UA002-UA003-UA004_UK_A5_v1_20200103.indb 12 2020/1/3 18:08