Polar Electro GC870-A User manual

Display Chiller
Instruction manual
Model
GC870-A / GC871-A

1
Safety Tips
• Position on a flat, stable surface.
• A service agent/qualified technician should carry out installation and any repairs if required. Do not
remove any components or service panels on this product.
• Consult Local and National Standards to comply with the following:
• Health and Safety at Work Legislation
• BS EN Codes of Practice
• Fire Precautions
• IEE Wiring Regulations
• Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT use electrical appliances inside the appliance (e.g. heaters, ice-cream makers etc.).
• DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean
immediately if contact occurs.
• DO NOT store products on top of the appliance.
• Bottles that contain a high percentage of alcohol must be sealed and placed vertically in the
refrigerator.
• Always carry, store and handle the appliance in a vertical position and move by holding the base of the
appliance.
• Always switch off and disconnect the power supply to the unit before cleaning.
• Keep all packaging away from children. Dispose of the packaging in accordance with the regulations of
local authorities.
• If the power cord is damaged, it must be replaced by a POLAR agent or a recommended qualified
technician in order to avoid a hazard.
• This appliance is not intended for use by persons (including children) with reduced physical, sensory
or mental capabilites, or lack of experience and knowledge, unless they have been given supervision
or instruction concerning use of the appliance by a person responsible for their safety
• Children should be supervised to ensure that they do not play wth the appliance
Product Description
•GC870-A - 68 litre White Display Chiller
•GC871-A - 98 litre White Display Chiller
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of
this machine will provide the best possible performance from your POLAR product.

2
Telephone Helpline:1300225960
Pack Contents
The following is included:
POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are supplied
fully functional and free of damage.
Should you find any damage as a result of transit, please contact your POLAR dealer immediately.
Installation
1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are
thoroughly removed from all surfaces.
2. Maintain a distance of 20cm (7 inches) between the unit and walls or other objects for ventilation.
Increase this distance if the obstacle is a heat source.
Fitting the Shelves
1. Place the shelf guides on either side of the cabinet at the desired height.
2. Lower the shelf into place, slotting the rear of the shelf into the corresponding holes. Ensure the
shelves are level.
3. Repeat for the remaining shelves.
Operation
Tu r n O n (
1. Close the door of the appliance.
2. Connect the appliance to a mains power supply.
3. Press the button to turn the light On and Off as required
Setting the Operating Temperature
1. Press the button. The display will flash.
2. Press the or buttons to display the required temperature
3. Press the button to store the temperature
Note: If the appliance has been stored or moved in a non-vertical position, stand it in an
upright position for approximately 12 hours before operation. If in doubt allow to stand.
Note: Before using the appliance for the first time, clean the shelves and interior with
soapy water.
• POLAR Display Chiller
• Instruction manual
•Shelves
4

3
Manual Defrost
Press and hold the button foir 6 seconds to begin automatic defrost. The defrost light illuminates
Storing Food
To get the best results from your POLAR appliance, follow these instructions:
• Only store foodstuffs in the appliance when it has reached the correct operating temperature.
• Do not place uncovered hot food or liquid inside the appliance.
• Wrap or cover food where possible.
• Do not obstruct the fans inside the appliance.
• Avoid opening the doors for prolonged periods of time.
Cleaning, Care & Maintenance
• Switch off and disconnect from the power supply before cleaning.
• Clean the interior of the appliance as often as possible.
• Do not use abrasive cleaning agents. These can leave harmful residues.
• Clean the door seal with water only.
• Always wipe dry after cleaning.
• Do not allow water used in cleaning to run through the drain hole into the evaporation pan.
• A POLAR agent or qualified technician must carry out repairs if required.
Cleaning the Condenser
Periodically cleaning the condenser can extend the life of the appliance.
POLAR recommend that a POLAR agent or qualified technician clean the condenser.

4
Telephone Helpline:1300225960
Tro u b l e s h o o t i n g
If your POLAR appliance develops a fault, please check the following table before making a call to the
Helpline.
Fault Probable Cause Action
The appliance is not
working
The unit is not switched on Check the unit is plugged in correctly and switched on
Plug and lead are damaged Call POLAR agent or qualified Technician
Fuse in the plug has blown Replace the fuse
Power supply Check power supply
Internal wiring fault Call POLAR agent or qualified Technician
The appliance turns
on, but the
temperature is too
high/low
Too much ice on the evaporator Defrost the appliance
Condenser blocked with dust Call POLAR agent or qualified Technician
Doors are not shut properly Check doors are shut and seals are not damaged
Appliance is located near a
heat source or air flow to the
condenser is being interrupted
Move the refrigerator to a more suitable location
Ambient temperature is too
high
Increase ventilation or move appliance to a cooler position
Unsuitable foodstuffs are being
stored in the appliance
Remove any excessive hot foodstuffs or blockages to the fan
The appliance turns
on, but the
temperature is too
high/low
Appliance is overloaded Reduce the amount of food stored in the appliance
The appliance is
leaking water
The appliance is not properly
levelled
Adjust the screw feet to level the appliance (if applicable)
The appliance is
unusually loud
The frame has become loose Check and tighten all nuts and screws
The appliance has not been
installed in a level or stable
position
Check installation position and change if necessary
The Display Lamp
does not
illuminate
Lamp Needs Replacing Call POLAR agent or qualified technician
Light not turned on Ensure Light button has been pressed properly
Door does not
shut
Dirt / obstacle in runners Clean runners

5
Electrical Wiring
The plug is to be connected to a suitable mains socket.
POLAR appliances are wired as follows:
• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E
All POLAR appliances must be earthed, using a dedicated earthing circuit.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency
disconnection being required they must be readily accessible.
Technical Specifications
Compliance
The WEEE logo on this product or its documentation indicates that the product must
not be disposed of as household waste. To help prevent possible harm to human
health and/or the environment, the product must be disposed of in an approved and
environmentally safe recycling process. For further information on how to dispose of
this product correctly, contact the product supplier, or the local authority responsible
for waste disposal in your area.
POLAR parts have undergone strict product testing in order to comply with regulatory
standards and specifications set by international, independent, and federal
authorities.
POLAR products have been approved to carry the following symbol:
All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means,
electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR.
Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right
to change specifications without notice.
Model Voltage Power Current Temperature
Range
Capacity
(litres) Refrigerant Dimensions H x W x D (mm)
Weight
(kg)
GC870
-A
230V
50Hz
164W 0.7A 3°C to 8°C 68 R134a 130g 925 x 428 x 386 32.5
GC871
-A
230V
50Hz
200W 1A 3°C to 8°C 98 R134a 130g 1150 x 428 x 429 81

DECLARATION OF CONFORMITY
I, the undersigned, hereby declare that the equipment specified above
conforms to the above Legislation and Standard(s).
Equipment Type Refrigerator / Freezer
Model GC870-A, GC871-A
Legislation C-Tick
AS/NZ 3820 Essential Safety Requirements for Low Voltage
Electrical Equipment
Standards EN 55014-1:2006, EN 55014-2:1997+A1
EN 61000-3-2:2006,
EN 61000-3-3:1995+A1+A2,
EN 61000-3-11:2000,
EN 55015:2006, EN 61547:1995+A1
AS/NZS 60335.2.89:2002+A1:2003+A2:2005+A3:2007 with:
AS/NZS 60335.1:2002+A1:2004+A2:2007+A3:2007
Producer Name POLAR
Producer Address 15 Badgally Road,
Campbelltown,
NSW 2560
Date 24/03/11
Signature
Full Name Richard Cromwell
Position Marketing Director

GC870-A_GC871_A_v2