Polaris Sync 3 User manual

1
Ford Sync 3 Camera Integraon
Installaon and User Manual
• Unit is tampered with, damaged or modied
• Any cables in the kit are cut or modied
• Reverse Camera is subjected to overvoltage
Warranty Terms
The Ford Integraon module is covered by warranty for 2 years and includes:
• Defecve Equipment • Defecve cables
Not covered under warranty:
• Abuse
• Improper installaon
• Alteraons to cables
• Accidents
• Water damage
• Improper use
• Labour
• Postage costs
Thank you for purchasing the Ford Camera Integraon Module.
Before installing be sure to read these instrucons.
Warranty for this product is 2 years from date of purchase, however warranty is void if:

2
 This module is to suit the Sync 3 Ford screens.
 The wiring and installaon of this unit requires special technical skill and experience. If you do
not feel condent installing this product or do not have the level of skill necessary, please
contact Polaris on 1300 555 514 so we can refer to a recommended installer.
 To avoid short circuit in the electrical system, ensure that the negave baery cable is
disconnected before installaon.
 To avoid possibility of shorng out the electrical circuit in the unit, never connect the baery
wire directly to the vehicle baery.
 Always secure all wirings with cable clamps or adhesive tape to prevent short circuit.
 Please make sure all wiring connecons are well insulated.
 When pulling the dash apart, please use quality trim tools to avoid damaging your dash.
 Please do NOT cut any plugs o of any Polaris cables. Doing so will void your warranty! If you
need to blend other brand cameras into our system, please call Polaris on 1300 555 514 so we
can refer you to a recommended dealer who has the skill and experience in performing this type
of work.
 Please do NOT cut any plugs o of any of your OEM Ford Cables as you will void your warranty
with Ford.
 If there is something you are not 100% sure about when installing this unit, please give our
experienced technicians a call on 1300 555 514.
Videos
How to pull the Ranger / Everest dash apart and install the module:
hp://y2u.be/I4dGAyTMh6A
Camera Acvaon for Ford Ranger 2016—2021
hp://y2u.be/EJgQS027tq0
Camera Acvaon for Ford Everest 2016—2021
hp://y2u.be/IgRAkEB_yZE
Installaon Notes

3
How to pull the dash apart to access OEM Head Unit & Screen—
Ford Ranger / Everest
This is the recommended order to pull the dash apart:
Please see individual photos below corresponding with their number above:
1. Pull out right hand
side small panel
2. Pull out le hand
side small panel
3. Put trim tool
underneath the long
panel aached to le of
OEM screen air vent and
pop out
3. Put trim tool under
le of OEM screen air
vent and pop out
3. Remove enre panel 4. Remove right of OEM screen air vent
1233
344

4
5. Place your hand on le side of
the long trim and loosen by
popping out carefully
5. Place your hand on the long
trim directly underneath the
monitor and loosen by popping
out carefully
5. You should now be able to
remove the enre panel with ease
This is the recommended order to pull the nal trim o:
Please see individual photos below corresponding with their number above:
1. Unscrew the top 2
screws
2. Unscrew the 2 middle
screws
3. Unscrew the 2
boom screws
4. Pull the 12 volt
socket panel out
555
1234

5
1. Remove the 2 screws underneath the air
condioning panel
2. Pull the trim o starng at the BOTTOM. Pull
gently as you will need to disconnect the plugs
from the back of the air condioning panel
3. Remove all plugs from the back of the air
condioning control panel, remove trim
and set aside
4. Remove 8 screws to access the back of the
monitor and head unit
5. On the back of the OEM monitor, remove linking
cable.
6. Keep this cable in case you ever want to revert
back to factory standard.

6
DipSw Sengs
The DipSw sengs are already pre-set for a Ford Ranger.
If you are ng into a another Ford vehicle, please make sure you refer to the DipSw
sengs and change accordingly

7
DipSw Sengs (Connued)
Ford Ranger with Sync 3: September 2016 – 2021
Ford Ranger with musical note on steering wheel control (See gure 1).
Ford Everest: September 2016 – 2021
For other Ford Vehicles please see Dip SW sengs on page 6 or on the module itself.
Dip SW 5678
Up X
Down XXX
Dip SW 5678
Up XXXX
Down
Dip SW 5678
Up XXX
Down X
Dip SW 12345678
Up See Below
Down XXXX
Figure 1. If your Ford Ranger has a musical note on the le hand side of your steering
wheel, please make sure 5,6,7 & 8 dip SW sengs are set to ON. See page 11 for
which steering wheel control acvates the camera).

8
7M EXT.
GENERIC CAM TO
POLARIS CAMERA
ADAPTOR
7M EXT.
CA05 RCA ADAPTOR
Camera Wiring
Polaris Caravan Camera Kit—All Polaris parts
Caravan Camera Kit—Converng A frame generic style plug to Polaris WOZA socket
Caravan Camera Kit—Using an adaptor to plug into A frame generic style plug (NO
WOZA setup)
Front Camera Setup—All Polaris parts
Don’t forget to cut the image control wire to turn the camera into forward facing.
If you want to remove guidelines, then also cut the guideline control wire

9
Programming
Caravan Camera or Front
Camera (one camera)
Hold in buon for 3
seconds
Interface Setup
Hold in buon for 10
seconds
(you will acvate the
caravan camera, keep
holding the buon in)
Back to your main head
unit
Short press buon
Front Camera Reverse Camera Parking Assist Side View
05
15 20
OEM
EXT AVM
ON ON
OFF OFF OFF
ON
Interface Setup Reset Exit
Version Factory Reset
Front Camera: Select 5 and select EXIT to save
Caravan Camera: Select EXT and select EXIT to save
Default sengs out of box: Front Camera 0 / Reverse Camera EXT
Camera Acvaon—Ford Ranger 2016-2021
(Other vehicles may dier—See page 11)

10
Caravan Camera & Front Camera (2 cameras)
Hold in buon for 3 seconds: Front Camera will appear rst.
Hold in buon for another 3 seconds and caravan camera will
appear.
Reverse Gear Combinaons
R
R
RD
Factory Screen Select reverse Factory camera
will appear
Hold buon
for 3
seconds
Van camera will
appear
Factory Screen Hold buon
for 3
seconds
Van camera will
appear Select Reverse Van camera will
stay on screen
Front Camera Select Reverse Factory camera
will appear
Select drive Front Camera
will come back
on
or
Front Camera Van Camera Short press
buon
Back to factory
screen

11
Camera Acvaon
Ford Ranger Sept 2016—2021
Ford Everest Sept 2016—2021
Ford Ranger with musical note on steering wheel control